RoadVitals

2004 Chevrolet Express 2500 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
8
Latest Oct 5, 2016
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
6
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Chevrolet Express 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes330.0%
  • Engine220.0%
  • Powertrain (other)220.0%
  • Electrical110.0%
  • Other / unspecified110.0%
  • Transmission110.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

3
reports

From owner reports, verbatim

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 2500. THE CONTACT STATED THAT WHEN THE BRAKES WERE APPLIED, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BRAKE PADS AND ROTORS WERE REPLACED; HOWEVER, THE FAILURE CONTINUED. THE CONTACT HAD TO APPLY EXTREME FORCE TO THE BRAKE PEDAL TO ENSURE THAT THE VEHICLE CAME TO A COMPLETE STOP. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 05V043000 (SERVICE BRAKES, HYDRAULIC) AND 04V045000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

NHTSA ID 10913946 · filed Oct 5, 2016

I OWN A 2004 SILVERADO 2500 HD WITH 26,500 MILES ON IT. I HAD MY TRUCK SERVICED FOR SPEEDOMETER THAT WAS NOT WORKING AND WAS TOLD BY KARL CHEVY HERE IN ANKENY, IA THAT ALL OF MY ROTORS AND BRAKE PADS NEEDED TO BE REPLACED BECAUSE OF RUST. GM OUGHT TO FIX MY BRAKES FOR FREE, THEY NEED TO RECALL. I AM 61 AND HAVE OWNED A FEW AUTOMOBILES AND HAVE NEVER HAD TO REPLACE ROTORS WITH SUCH LOW MILEAGE. THE MAJORITY OF MILES ARE HIGHWAY. I HAVE BEEN IN A RIDESHARE POOL USING A METRO VAN PROVIDED TO OUR POOL FOR THE LAST FOUR YEARS AS THE MAIN DRIVER. *TR

NHTSA ID 10299911 · filed Jan 15, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

2
reports

From owner reports, verbatim

AS I ATTEMPTED TO SPEED UP IN TRAFFIC, I HEARD A NOISE AND THE VEHICLE SUDDENLY SLOWED DOWN. I WAS ABLE TO GET IT OFF THE HIGHWAY ON TO A SIDE ROAD. ONCE THERE, IT WOULD NOT START. ON CLOSER INSPECTION, I SAW THAT THE BELT HAD COME APART AND OFF THE PULLEY'S. I HAD THE VAN TOWED TO MY HOME AND SUBSEQUENTLY, FIXED/REPLACED THE BELT. SINCE THAT TIME, I BEGAN TO HEAR A LOW KNOCKING, MORE SO WHEN I TURNED ON THE AIR CONDITIONING. WHEN IT BECAME LOUDER ON ALL GEARS AND WHILE PARKED, I TOOK IT TO HOLLER DRIVERS MART, IN WINTER PARK, FL. ON 01/19/2012, I WAS TOLD THAT THE FLYWHEEL HAD SHEARED AROUND THE AREA WHERE IT WAS BOLTED ONTO THE TRANSMISSION AND CONNECTED TO THE ENGINE. IT ALSO HAD FRACTURES IN AND AROUND THE SAME AREA OF THE SHEARING. TECH INFORMED ME THAT I HAD CAUGHT THE PROBLEM BEFORE A SERIOUS INCIDENT MAY HAVE OCCURRED. I HAVE THE FLY WHEEL AND WILL SEND PHOTOS. CONSUMER SENT IN PHOTOS. 02/07/12 UPDATED 02/07/12 *BF STATUS UPDATE 02/23/12

NHTSA ID 10447592 · filed Feb 6, 2012

MYSTERIOUS COOLANT LEAK. RESERVOIR IS LOW AND NEEDS REFILLING OFTEN. MECHANIC HAS PERFORMED PRESSURE TEST TO NO AVAIL. NO COOLANT ON GROUND AT ANY POINT. NO VISIBLE SIGNS OF LEAK. THIS BEGAN RIGHT AFTER 2ND CRACKED FLYWHEEL WAS REPLACED. AT THE SAME TIME A LIFTER KNOCK BEGAN AS WELL. 1ST FLYWHEEL WAS REPLACED AT 103K (3K OUTSIDE OF EXTENDED WARRANTY). 2ND FLYWHEEL REPLACED AT 143K. VAN IS KEPT IN MINT CONDITION, OIL CHANGED EVERY 3K W/O FAIL. VEHICLE SEEMS TO BE IN OTHERWISE TERRIFIC CONDITION. 1ST AND ONLY OWNER. DATE REFERRED TO IS DATE OF 2ND FLYWHEEL CRACK. *TR

NHTSA ID 10336168 · filed Jun 14, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

2
reports

From owner reports, verbatim

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 2500. THE CONTACT STATED WHENEVER AT AN IDLE A LOUD METAL TO METAL NOISE WOULD EMIT CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON TWO SEPARATE OCCASIONS WHERE THE CRACKED FLYWHEEL WAS REPLACED EACH TIME. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.

NHTSA ID 10533187 · filed Aug 2, 2013

MYSTERIOUS COOLANT LEAK. RESERVOIR IS LOW AND NEEDS REFILLING OFTEN. MECHANIC HAS PERFORMED PRESSURE TEST TO NO AVAIL. NO COOLANT ON GROUND AT ANY POINT. NO VISIBLE SIGNS OF LEAK. THIS BEGAN RIGHT AFTER 2ND CRACKED FLYWHEEL WAS REPLACED. AT THE SAME TIME A LIFTER KNOCK BEGAN AS WELL. 1ST FLYWHEEL WAS REPLACED AT 103K (3K OUTSIDE OF EXTENDED WARRANTY). 2ND FLYWHEEL REPLACED AT 143K. VAN IS KEPT IN MINT CONDITION, OIL CHANGED EVERY 3K W/O FAIL. VEHICLE SEEMS TO BE IN OTHERWISE TERRIFIC CONDITION. 1ST AND ONLY OWNER. DATE REFERRED TO IS DATE OF 2ND FLYWHEEL CRACK. *TR

NHTSA ID 10336168 · filed Jun 14, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

I OWN A 2004 SILVERADO 2500 HD WITH 26,500 MILES ON IT. I HAD MY TRUCK SERVICED FOR SPEEDOMETER THAT WAS NOT WORKING AND WAS TOLD BY KARL CHEVY HERE IN ANKENY, IA THAT ALL OF MY ROTORS AND BRAKE PADS NEEDED TO BE REPLACED BECAUSE OF RUST. GM OUGHT TO FIX MY BRAKES FOR FREE, THEY NEED TO RECALL. I AM 61 AND HAVE OWNED A FEW AUTOMOBILES AND HAVE NEVER HAD TO REPLACE ROTORS WITH SUCH LOW MILEAGE. THE MAJORITY OF MILES ARE HIGHWAY. I HAVE BEEN IN A RIDESHARE POOL USING A METRO VAN PROVIDED TO OUR POOL FOR THE LAST FOUR YEARS AS THE MAIN DRIVER. *TR

NHTSA ID 10299911 · filed Jan 15, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Other / unspecified

Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.

1
report

From owner reports, verbatim

DT*: THE CONTACT STATED THE ELECTRICAL MODULE THAT CONTROLS THE AUDIO WARNING SYSTEM IS LOCATED IN THE ORIGINAL RADIO. THE CONTACT SWITCHED THE RADIO AND LOST ALL OF THE AUDIO WARNING SYSTEMS. THE DEALER AND MANUFACTURER WAS ALERTED AND DETERMINED THE MODULE WAS IN THE ORIGINAL RADIO AND IT SHOULD BE PUT BACK IN THE VEHICLE.

NHTSA ID 10159219 · filed Jun 7, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Transmission

Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.

1
report

From owner reports, verbatim

REPEATED CRACKED FLYWHEEL. ORIGINAL CRACKED JUST OVER 100K MILES. REPLACEMENT NOW CRACKED 40K MILES LATER. *TR

NHTSA ID 10325828 · filed Apr 15, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .