Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 3 NHTSA owner-reported complaints for the 2002 Chevrolet Express 3500. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–3 of 3
2002 CHEVROLET EXPRESS 3500. CONSUMER WRITES IN REGARDS TO BROKEN DRIVERS SIDE SPRING LEAF. *LD THE CONSUMER STATED AFTER A POTHOLE BROKE THE SPRING LEAVE, IT WAS DISCOVERED THAT SPRING LEAF WAS INCORRECTLY INSTALLED BY THE FACTORY. *JS
TL* THE CONTACT OWNS A 2002 CHEVROLET EXPRESS CUTAWAY G3500. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO COAST ONTO THE SHOULDER AND RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE A DIAGNOSTIC WAS PERFORMED AND LOCATED THE FAILURE AT THE CRANK SHAFT POSITION SENSOR. THE LOCAL MECHANIC REPLACED THE CRANK SHAFT POSITION SENSOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 69,196 AND THE APPROXIMATE CURRENT MILEAGE WAS 71,000.
2002 EXPRESS 3500 6.5 DIESEL VAN HAS STARTED INTERMITTENT STALLING AT HIGHWAY SPEEDS 60 MPH MID 09/2006. NO TROUBLE CODES LOCKED IN MEMORY. TWO CHEVY DLRS AND GM CUSTOMER SERVICE MADE AWARE OF PMD HEAT PROBLEM, BUT ALL THREE SOURCES CLAIM CAN'T REPAIR UNTIL MAJOR FAILURE. WHEN ENGINE STALLS AT SPEED, YOU LOOSE ALL POWER STEERING AND BRAKES. *NM
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .