2024 Chevrolet Express 3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2024 Chevrolet Express 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical125.0%
- Other / unspecified125.0%
- Steering125.0%
- Suspension125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The contact owns a 2024 Chevrolet Express 3500. The contact stated while the vehicle was parked, the contact noticed a huge black puddle of liquid on the ground on the front driver's side. The contact stated that upon inspection, it was determined that the unknown liquid was from the propane tank. In addition, the contact stated that the unknown liquid had a strong foul odor. The vehicle was towed to the dealer where it was diagnosed with oil leaking from the generator. The contact was informed that the bottom of the generator needed to be cleaned. The vehicle was repaired. In addition, the contact stated that the vehicle was at the dealer for three months for the repairs that were covered under warranty. The contact stated that the repairs included an alignment, repair to the AC unit, and the cleaning of the generator. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 541.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The vehicle shakes at speeds starting at 68 mph and is extreme at 73 mph. I have taken it in for repairs at the Chevrolet dealership twice and to a tire shop. I fear this could be the start of the term known as the "Death Wobble". Chevrolet is aware of this issue and have issued Technical Service Bulletins relating to shake and vibration complaints. This is a brand new 2025 vehicle. Because this vibration/shake occurs it highway speeds a mechanical failure could cause serious injury or death. I have contacted the manufacturer and they do not wish to address the issues with this vehicle.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
The vehicle shakes at speeds starting at 68 mph and is extreme at 73 mph. I have taken it in for repairs at the Chevrolet dealership twice and to a tire shop. I fear this could be the start of the term known as the "Death Wobble". Chevrolet is aware of this issue and have issued Technical Service Bulletins relating to shake and vibration complaints. This is a brand new 2025 vehicle. Because this vibration/shake occurs it highway speeds a mechanical failure could cause serious injury or death. I have contacted the manufacturer and they do not wish to address the issues with this vehicle.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
The vehicle shakes at speeds starting at 68 mph and is extreme at 73 mph. I have taken it in for repairs at the Chevrolet dealership twice and to a tire shop. I fear this could be the start of the term known as the "Death Wobble". Chevrolet is aware of this issue and have issued Technical Service Bulletins relating to shake and vibration complaints. This is a brand new 2025 vehicle. Because this vibration/shake occurs it highway speeds a mechanical failure could cause serious injury or death. I have contacted the manufacturer and they do not wish to address the issues with this vehicle.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .