2008 Chevrolet Express Cutaway Van Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2008 Chevrolet Express Cutaway Van, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure266.7%
- Brakes133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE PAINT IS PEELING OFF IN SHEETS ON THE HOOD OF MY VEHICLE, DIRECTLY OVER THE ENGINE.
VAN HAS ALWAYS BEEN USED FOR RESIDENTIAL ELECTRICAL WORK. NOTHING HAS EVER BEEN HUNG ON THE SIDE DOORS, HOWEVER, THE HINGES ARE SAGGING TO THE POINT THAT THE DOORS ARE OVERLAPPING AND ARE NEARLY UNUSABLE. WE KNOW OF ANOTHER CHEVY EXPRESS VAN THAT IS DOING THE SAME THING. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
THIS IS A 2008 CHEVROLET 3500 CUTAWAY SCHOOL BUS WITH 24,926 MILES ON. THE DRIVER WAS COMING TO A STOP TRAVELING APPROXIMATELY 15 MPH. HE APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. THE BUS THEN REAR ENDED A ANOTHER VAN WHICH THEN HIT THE REAR OF A POSTAL TRUCK. THE DRIVERS OF THE TWO OTHER VEHICLES WERE TAKEN AWAY BY AMBULANCE COMPLAINING OF BACK INJURIES. THE BUS WAS EXAMINED AT THE SCENE OF THE ACCIDENT BY TWO PENNDOT CLASS 7 INSPECTION MECHANICS VERIFYING THAT THE BRAKE PEDAL WENT TO THE FLOOR. THE TOW TRUCK DRIVER (THIRD PARTY TOWER) ALSO CHECKED THE BRAKES AND OPENED THE MASTER CYLINDER TO SEE IF THE FLUID WAS DOWN OR EMPTY AND STATED THAT IT WAS FULL. THE BUS WAS TOWED TO OUR GARAGE WHERE WE MOVED THE BUS AND THEN HAD A BRAKE PEDAL. THERE WERE TWO LIGHTS ON THE DASH, THE ABS LIGHT AND THE "BRAKE LIGHT" (PICTURES TAKEN). WE READ THE CODES (OBD II) AND HAD C0035 - LEFT FRONT WHEEL SENSOR CIRCUIT MALFUNCTION, AND C0040 - LEFT FRONT WHEEL SPEED SENSOR CIRCUIT MALFUNCTION (PICTURES TAKEN). THE BUS WAS DRIVEN AROUND AND DID HAVE BRAKES. THIS SAME BUS WAS AT THE LOCAL CHEVROLET DEALER NOVEMBER 09,2010 TO HAVE BOTH FRONT ABS SENSORS REPLACED (DEALER WORK ORDER AVAILABLE). IT WAS TAKEN TO THE DEALER BECAUSE OF CONTINUED COMPLAINTS OF THE BRAKES FAILING TO STOP THE BUS. AS THE DRIVERS DESCRIBED THE PROBLEM - " IT WAS LIKE TRYING TO STOP ON ICE". THE SENSORS WERE REPLACED AND THE BUS WAS PUT BACK IN SERVICE. THIS IS A VERY UNSAFE CONDITION, PARTICULARLY SINCE THIS IS A SCHOOL BUS! *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .