2003 Chevrolet Express Problems

DRIVING ON INTERSTATE AT 65 MPH, THE ABS WARNING LIGHT CAME ON, AND THE SPEEDOMETER STARTED JUMPING ERRATICALLY FROM ACTUAL SPEED TO LOWER SPEEDS 45, 25 + OTHERS AS LOW AS 8 (EIGHT) MPH. THIS CAUSED THE TRANSMISSION TO DOWNSHIFT UNPREDICTABLY, OVER-REVVING THE ENGINE SPEED. IT HAPPENED REPEATEDLY SO I DOCUMENTED THE ODOMETER ERRATIC MOVEMENT ON MY CELL PHONE AS A VIDEO, SHOWING ROAD MOVEMENT + ALL GAUGES + AUDIO EVENTS LIKE ENGINE OVER-REVVING AT SAME TIME. THE VIDEO IS OF HIGH QUALITY AND THE EVENTS TAKING PLACE ARE DOCUMENTED WITH THE VIDEO. RURAL AREA WITH FEW CARS ON ROAD AT THE TIME. IF IT TOOK PLACE IN A CITY INTERSTATE ENVIRONMENT (ESPECIALLY IN THE WINTER MONTHS) IT MIGHT HAVE CAUSED A MULTIPLE CAR COLLISION WITH SUDDEN UNEXPECTED DOWNSHIFTING THAT WAS OUT OF MY CONTROL. ENGINE RPM ALSO HUNTS ERRATICALLY AND OUT OF MY CONTROL. PREDICTABLE IN WHAT IT DOES, IT BEGINS APPROXIMATELY WITHIN A RANGE OF 4-8 MILES AFTER LEAVING HOME DAILY. WHEN ENGINE TURNED OFF AND PARKED AT A LOCAL STORE AS AN EXAMPLE, IT WILL CLEAR IT'S PROBLEM AS IF A CPU IS "RE-BOOTED", AND REPEAT THE CYCLE OF ERRATIC BEHAVIOR FROM THAT NEW STARTING POINT. WHEN I BOUGHT + INSTALLED ACTRON BRAND OBD-II CODE READER WHICH FEATURES ABILITY TO REVEAL ABS BRAKE CODES, IT NEVER SHOWS ANY OTHER STORED CODES EXCEPT A SINGLE PO446 WHICH IS AN EMISSIONS RELATED CODE. THIS VAN WAS ORIGINALLY SENT NEW BY THE SELLING NH CHEVROLET DEALER TO THE PENNSYLVANIA BASED QUIGLEY CONVERSION FACILITY, SO IN FEBRUARY 2004 WAS MODIFIED FROM RWD TO A 4WD BY EXCHANGING STOCK MODEL 2500 FRONT END FOR A 4 WD PICKUP TRUCK NEW FACTORY FRONT END WITH 4WDL, NEUTRAL, 2WDH 4WDH FLOOR CONTROL LEVER. THE DRIVER'S DOOR JAM HAS AN 8600 LB GVW CERTIFICATION WHICH IS APPROPRIATELY QUIGLEY'S. MY VERY LOW ODOMETER AT 16,614 MILES IS ACCURATE, AS I ALSO HAVE OTHER VEHICLES TO USE, AND WORK AT HOME. *TR

DRIVER A NOTICED LACK OF PRESSURE IN BRAKE PEDAL. THE BRAKE PEDAL WENT FULLY TO THE FLOOR AND RESULTED IN LESS BRAKING THAN EXPECTED. DRIVER REDUCED SPEED BY DOWNSHIFTING TO LOWER GEARS (AUTOMATIC TRANSMISSION) AND PULLED INTO FIRST AVAILABLE PARKING AREA. BY PUMPING THE BRAKES AND PULLING INTO AN UPHILL PARKING SPOT, DRIVER ACHIEVED ENOUGH BRAKING TO COME TO A FULL STOP WITHOUT USING THE EMERGENCY BRAKE. INSPECTION SHOWED A NEARLY FULL BRAKE RESERVOIR AND NO LEAKAGE FROM WHEEL CYLINDERS. FURTHER INSPECTION SHOWED LEAKING FLUID FROM BRAKE LINE ON LEFT SIDE UNDER THE DRIVERS SEAT AND ABOVE THE VEHICLE FRAME. IT SQUIRTED OUT FROM A CRACK IN A BRAKE LINE WHEN BRAKE PEDAL WAS PUMPED. THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE VEHICLE WAS TOWED FOR REPAIR. *TR

I RECEIVED A NOTICE FROM GM ( DOC ID #32202443, #12167 FUEL FILLER PIPE CORROSION) STATING THAT THERE WAS A RECALL ON MY VEHICLE FOR LEAKING GASOLINE. I BROUGHT IT TO SIGHN CHEVROLET IN RIVERSIDE CA AND THE SERVICE MANAGER TOLD ME THAT CA VEHICLES DO NOT QUALIFY. I CONTACTED CUSTOMER COMPLAINTS CASE # [XXX] AND ALL THEY DID WAS CALL THE SAME SERVICE MANAGER AND GOT BACK TO ME SAYING THEY WON'T FIX IT. I BELIEVE I AM DRIVING AROUND WITH A VEHICLE LEAKING GAS ON THE ROAD CREATING AN EXTREMELY DANGEROUS SITUATION FOR MY FAMILY WITH A DIRE FIRE HAZARD. MY CONTENTION IS, WHY WOULD THEY SEND ME A RECALL NOTICE AND THEN TELL ME I DON'T QUALIFY? I DID RECEIVE THE NOTICE AND IT SAID IT HAD TO BE ACTED ON BEFORE 12/31/12 BUT IT WAS NOT LEAKING THEN. I DON'T CARE WHEN IT EXPIRES. IT IS A ADMITTED DEFECT AND GM SHOULD STAND BEHIND THEIR DANGEROUS ERRORS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THERE WAS A FUEL LEAK COMING FROM THE VEHICLE. THE CONTACT INDICATED THAT AFTER REFUELING, FUEL PUDDLE UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE FILLER NECK NEEDED TO BE REPLACED AND THE METAL FUEL FILLER PIPE WAS CORRODED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V388000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,500.

Odometer Fraud. The contact purchased a 2003 Chevrolet Express. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was approximately 156,000. It was later discovered that the mileage on July 2, 2024, was 258,051.

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS CONVERSION VAN. THE CONTACTED STATED THAT WHILE DRIVING 45 MPH, ALL OF THE GAUGES AND ELECTRICAL FEATURES FAILED HOWEVER, THE LIGHT FUNCTIONS REMAINED OPERABLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. NO REPAIRS WERE PERFORMED TO THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 84,000. UPDATED 5/22/14*CN

MY SPEEDOMETER QUICKLY JUMPS FROM ONE INDICATED SPEED TO ANOTHER SPEED THAT IS CLEARLY INACCURATE, DOWN AS LOW AS -0- WHILE DRIVING, ACCOMPANIED BY THE TRANSMISSION ATTEMPTING TO DOWNSHIFT ON IT'S OWN, WHICH CAUSES A SEVERE ENGINE OVER-REV CONDITION OR GOING INTO A NEUTRAL MOMENTARILY WITH NO INPUT FROM ME AS THE DRIVER. THERE ARE NO SPECIFIC ACTIONS I CAN TAKE TO TRIGGER THE ERRATIC SYMPTOM, NOR ANY SPECIFIC ACTION I CAN TAKE TO CAUSE NORMAL OPERATION. WITH SNOW AND ICE ON THE ROADS AT THIS TIME OF THE YEAR THIS IS EXTREMELY DANGEROUS AS IT COULD CAUSE THE VAN TO LOCK UP THE REAR WHEELS ON SLIPPERY PAVEMENT CAUSING LACK OF CONTROL. THIS CONDITION CAN OCCUR REGARDLESS OF WHETHER OR NOT CRUISE CONTROL IS SELECTED, REGARDLESS OF THE GEAR I MANUALLY SELECT, AND REGARDLESS OF THE TRAILER MODE BEING SELECTED OR NOT. SIMULTANEOUSLY THE "CHECK ENGINE" LIGHT GOES ON, THE "ABS LIGHT" AND "BRAKES" LIGHTS ARE LIT ON THE DASHBOARD ALTHOUGH NO BRAKING ABNORMALITIES ARE NOTED. I REPORTED A LESS SEVERE CASE OF THIS SEVERAL MONTHS AGO, BUT RECEIVED NO REPLY FROM THE NHTSA. DOING INTERNET RESEARCH I FIND THAT IT MAY BE A DEFECTIVE SPEEDOMETER DASHBOARD ASSEMBLY THAT WOULD NEED TO BE SENT AWAY FOR REPAIR/EXCHANGE. THEY REQUIRE A LARGE DEPOSIT IN ORDER TO GO THRU THE VERIFICATION PROCESS THAT THE ODOMETER READING I REPORT IS THE SAME AS THE UNIT I SEND IN. PART COST WITH DEPOSIT IS CLOSE TO $600, AND THEY SHOW AN ONLINE INTERNET VIDEO OF HOW TO REMOVE THE DASHBOARD UNIT WHICH TAKES LESS THAN 3 MINUTES. I'VE READ THIS IS A COMMON PROBLEM WITH THIS VEHICLE MAKE, MODEL AND YEAR. I AM THE ORIGINAL OWNER SINCE NEW, AND IT HAS LESS THAN 17,000 ACTUAL MILES ON IT. *TR

THIS VEHICLE WAS BOUGHT BRAND NEW BUT UNBEKNOWNST TO ME WAS MADE IN CANADA (SOMETHING WHICH WOULD NOT HAVE BEEN ACCEPTABLE TO ME HAD I BEEN TOLD). UPON POSSESSION THE WINDSHIELD MOLDING CAME OFF ON THE RIDE HOME. THE DRIVER SIDE TIEROD END WENT AT 12,000 MILES AND AGAIN AT 24,000 MILES BECAUSE UPON INSPECTION THE BALL JOINTS WERE NEVER PROPERLY TIGHTENED. THE BOLTS ON THE TRANSMISSION WERE FOUND BY THE DEALER TO HAVE BEEN NEVER PROPERLY TIGHTENED. THE SIDEDOOR HINGE HAD TO BE REPLACED AT A COST OF $600 BECAUSE IT FROZE UP AND COULD NOT BE OPENED. THE POWER STEERING UNIT RUSTED OUT AT 12,000 MILES AND STARTED LEAKING FLUID AND, WHAT I FIND MOST IMPORTANT, I AM NOT SURE IF I HAVE AIRBAGS BECAUSE THE AIRBAG LIGHT STAYS ON BUT IS NOTED TO GO OFF WHEN THE KEY IS PARTIALLY TURNED HOWEVER THE KEY CANNOT STAY IN THIS POSITION AND MUST BE TURNED TO START THE VEHICLE. FUEL EXPECTATION WAS NEVER NEAR WHAT I WAS TOLD IT WOULD BE AND TAILPIPE CONSISTENTLY SHOWED EVIDENCE OF BEING BLACKENED DUE TO INSUFFICIENT FUEL BURNING. THE POOR BACKDOOR DESIGN MAKES IT DIFFICULT TO SEE OUT THE BACK WINDOW AND IT IS CLEARLY EVIDENT BY ALMOST EVERY VAN OF THIS TYPE HAVING A DENTED BUMPER DUE TO THIS BLINDSPOT IN DESIGN. I HAVE NOT BEGUN TO LIST ALL THE THINGS NOT RIGHT WITH THIS VEHICLE BUT I WILL CHALK THEM UP TO DOWNRIGHT LYING AND JUST INFERIOR PARTS AND CRAFTSMENSHIP. THIS VEHICLE HAS BEEN A NIGHTMARE. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE CABLE THAT HELD THE SEAT BELTS TOGETHER, LOCATED IN THE REAR MIDDLE ROW, SNAPPED WITHOUT WARNING. AS A RESULT, THE CONTACT WAS CONCERNED THAT, IN THE EVENT OF A CRASH, THE SEAT BELTS WOULD NOT SECURE PROPERLY AND CAUSE AN INJURY. THE CONTACT ALSO STATED THAT THE REAR DRIVER AND PASSENGER SIDE DOOR HINGES FRACTURED. THE CONTACT STATED THAT THE DOORS WERE GLUED SHUT. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 228,000. UPDATED 10/17*LJ UPDATED 10/4/18*JB

THIS VEHICLE WAS BOUGHT BRAND NEW BUT UNBEKNOWNST TO ME WAS MADE IN CANADA (SOMETHING WHICH WOULD NOT HAVE BEEN ACCEPTABLE TO ME HAD I BEEN TOLD). UPON POSSESSION THE WINDSHIELD MOLDING CAME OFF ON THE RIDE HOME. THE DRIVER SIDE TIEROD END WENT AT 12,000 MILES AND AGAIN AT 24,000 MILES BECAUSE UPON INSPECTION THE BALL JOINTS WERE NEVER PROPERLY TIGHTENED. THE BOLTS ON THE TRANSMISSION WERE FOUND BY THE DEALER TO HAVE BEEN NEVER PROPERLY TIGHTENED. THE SIDEDOOR HINGE HAD TO BE REPLACED AT A COST OF $600 BECAUSE IT FROZE UP AND COULD NOT BE OPENED. THE POWER STEERING UNIT RUSTED OUT AT 12,000 MILES AND STARTED LEAKING FLUID AND, WHAT I FIND MOST IMPORTANT, I AM NOT SURE IF I HAVE AIRBAGS BECAUSE THE AIRBAG LIGHT STAYS ON BUT IS NOTED TO GO OFF WHEN THE KEY IS PARTIALLY TURNED HOWEVER THE KEY CANNOT STAY IN THIS POSITION AND MUST BE TURNED TO START THE VEHICLE. FUEL EXPECTATION WAS NEVER NEAR WHAT I WAS TOLD IT WOULD BE AND TAILPIPE CONSISTENTLY SHOWED EVIDENCE OF BEING BLACKENED DUE TO INSUFFICIENT FUEL BURNING. THE POOR BACKDOOR DESIGN MAKES IT DIFFICULT TO SEE OUT THE BACK WINDOW AND IT IS CLEARLY EVIDENT BY ALMOST EVERY VAN OF THIS TYPE HAVING A DENTED BUMPER DUE TO THIS BLINDSPOT IN DESIGN. I HAVE NOT BEGUN TO LIST ALL THE THINGS NOT RIGHT WITH THIS VEHICLE BUT I WILL CHALK THEM UP TO DOWNRIGHT LYING AND JUST INFERIOR PARTS AND CRAFTSMENSHIP. THIS VEHICLE HAS BEEN A NIGHTMARE. *TR

THIS VEHICLE WAS BOUGHT BRAND NEW BUT UNBEKNOWNST TO ME WAS MADE IN CANADA (SOMETHING WHICH WOULD NOT HAVE BEEN ACCEPTABLE TO ME HAD I BEEN TOLD). UPON POSSESSION THE WINDSHIELD MOLDING CAME OFF ON THE RIDE HOME. THE DRIVER SIDE TIEROD END WENT AT 12,000 MILES AND AGAIN AT 24,000 MILES BECAUSE UPON INSPECTION THE BALL JOINTS WERE NEVER PROPERLY TIGHTENED. THE BOLTS ON THE TRANSMISSION WERE FOUND BY THE DEALER TO HAVE BEEN NEVER PROPERLY TIGHTENED. THE SIDEDOOR HINGE HAD TO BE REPLACED AT A COST OF $600 BECAUSE IT FROZE UP AND COULD NOT BE OPENED. THE POWER STEERING UNIT RUSTED OUT AT 12,000 MILES AND STARTED LEAKING FLUID AND, WHAT I FIND MOST IMPORTANT, I AM NOT SURE IF I HAVE AIRBAGS BECAUSE THE AIRBAG LIGHT STAYS ON BUT IS NOTED TO GO OFF WHEN THE KEY IS PARTIALLY TURNED HOWEVER THE KEY CANNOT STAY IN THIS POSITION AND MUST BE TURNED TO START THE VEHICLE. FUEL EXPECTATION WAS NEVER NEAR WHAT I WAS TOLD IT WOULD BE AND TAILPIPE CONSISTENTLY SHOWED EVIDENCE OF BEING BLACKENED DUE TO INSUFFICIENT FUEL BURNING. THE POOR BACKDOOR DESIGN MAKES IT DIFFICULT TO SEE OUT THE BACK WINDOW AND IT IS CLEARLY EVIDENT BY ALMOST EVERY VAN OF THIS TYPE HAVING A DENTED BUMPER DUE TO THIS BLINDSPOT IN DESIGN. I HAVE NOT BEGUN TO LIST ALL THE THINGS NOT RIGHT WITH THIS VEHICLE BUT I WILL CHALK THEM UP TO DOWNRIGHT LYING AND JUST INFERIOR PARTS AND CRAFTSMENSHIP. THIS VEHICLE HAS BEEN A NIGHTMARE. *TR

VEHICLE WAS PARKED IN OUR COMPANY PARKING LOT, VEHICLE WAS NOT RUNNING AND THE KEY WAS NOT IN THE IGNITION. EMPLOYEE WAS LOADING TOOLS AND EQUIPMENT INTO REAR OF VEHICLE AFTER COMPLETING A JOB. SIDE SLIDING DOOR WAS OPEN. PASSENGER AIR BAG ONLY DEPLOYED. VEHICLE HAD NOT BEEN A WRECK. *TR

MY SPEEDOMETER QUICKLY JUMPS FROM ONE INDICATED SPEED TO ANOTHER SPEED THAT IS CLEARLY INACCURATE, DOWN AS LOW AS -0- WHILE DRIVING, ACCOMPANIED BY THE TRANSMISSION ATTEMPTING TO DOWNSHIFT ON IT'S OWN, WHICH CAUSES A SEVERE ENGINE OVER-REV CONDITION OR GOING INTO A NEUTRAL MOMENTARILY WITH NO INPUT FROM ME AS THE DRIVER. THERE ARE NO SPECIFIC ACTIONS I CAN TAKE TO TRIGGER THE ERRATIC SYMPTOM, NOR ANY SPECIFIC ACTION I CAN TAKE TO CAUSE NORMAL OPERATION. WITH SNOW AND ICE ON THE ROADS AT THIS TIME OF THE YEAR THIS IS EXTREMELY DANGEROUS AS IT COULD CAUSE THE VAN TO LOCK UP THE REAR WHEELS ON SLIPPERY PAVEMENT CAUSING LACK OF CONTROL. THIS CONDITION CAN OCCUR REGARDLESS OF WHETHER OR NOT CRUISE CONTROL IS SELECTED, REGARDLESS OF THE GEAR I MANUALLY SELECT, AND REGARDLESS OF THE TRAILER MODE BEING SELECTED OR NOT. SIMULTANEOUSLY THE "CHECK ENGINE" LIGHT GOES ON, THE "ABS LIGHT" AND "BRAKES" LIGHTS ARE LIT ON THE DASHBOARD ALTHOUGH NO BRAKING ABNORMALITIES ARE NOTED. I REPORTED A LESS SEVERE CASE OF THIS SEVERAL MONTHS AGO, BUT RECEIVED NO REPLY FROM THE NHTSA. DOING INTERNET RESEARCH I FIND THAT IT MAY BE A DEFECTIVE SPEEDOMETER DASHBOARD ASSEMBLY THAT WOULD NEED TO BE SENT AWAY FOR REPAIR/EXCHANGE. THEY REQUIRE A LARGE DEPOSIT IN ORDER TO GO THRU THE VERIFICATION PROCESS THAT THE ODOMETER READING I REPORT IS THE SAME AS THE UNIT I SEND IN. PART COST WITH DEPOSIT IS CLOSE TO $600, AND THEY SHOW AN ONLINE INTERNET VIDEO OF HOW TO REMOVE THE DASHBOARD UNIT WHICH TAKES LESS THAN 3 MINUTES. I'VE READ THIS IS A COMMON PROBLEM WITH THIS VEHICLE MAKE, MODEL AND YEAR. I AM THE ORIGINAL OWNER SINCE NEW, AND IT HAS LESS THAN 17,000 ACTUAL MILES ON IT. *TR

DRIVING ON INTERSTATE AT 65 MPH, THE ABS WARNING LIGHT CAME ON, AND THE SPEEDOMETER STARTED JUMPING ERRATICALLY FROM ACTUAL SPEED TO LOWER SPEEDS 45, 25 + OTHERS AS LOW AS 8 (EIGHT) MPH. THIS CAUSED THE TRANSMISSION TO DOWNSHIFT UNPREDICTABLY, OVER-REVVING THE ENGINE SPEED. IT HAPPENED REPEATEDLY SO I DOCUMENTED THE ODOMETER ERRATIC MOVEMENT ON MY CELL PHONE AS A VIDEO, SHOWING ROAD MOVEMENT + ALL GAUGES + AUDIO EVENTS LIKE ENGINE OVER-REVVING AT SAME TIME. THE VIDEO IS OF HIGH QUALITY AND THE EVENTS TAKING PLACE ARE DOCUMENTED WITH THE VIDEO. RURAL AREA WITH FEW CARS ON ROAD AT THE TIME. IF IT TOOK PLACE IN A CITY INTERSTATE ENVIRONMENT (ESPECIALLY IN THE WINTER MONTHS) IT MIGHT HAVE CAUSED A MULTIPLE CAR COLLISION WITH SUDDEN UNEXPECTED DOWNSHIFTING THAT WAS OUT OF MY CONTROL. ENGINE RPM ALSO HUNTS ERRATICALLY AND OUT OF MY CONTROL. PREDICTABLE IN WHAT IT DOES, IT BEGINS APPROXIMATELY WITHIN A RANGE OF 4-8 MILES AFTER LEAVING HOME DAILY. WHEN ENGINE TURNED OFF AND PARKED AT A LOCAL STORE AS AN EXAMPLE, IT WILL CLEAR IT'S PROBLEM AS IF A CPU IS "RE-BOOTED", AND REPEAT THE CYCLE OF ERRATIC BEHAVIOR FROM THAT NEW STARTING POINT. WHEN I BOUGHT + INSTALLED ACTRON BRAND OBD-II CODE READER WHICH FEATURES ABILITY TO REVEAL ABS BRAKE CODES, IT NEVER SHOWS ANY OTHER STORED CODES EXCEPT A SINGLE PO446 WHICH IS AN EMISSIONS RELATED CODE. THIS VAN WAS ORIGINALLY SENT NEW BY THE SELLING NH CHEVROLET DEALER TO THE PENNSYLVANIA BASED QUIGLEY CONVERSION FACILITY, SO IN FEBRUARY 2004 WAS MODIFIED FROM RWD TO A 4WD BY EXCHANGING STOCK MODEL 2500 FRONT END FOR A 4 WD PICKUP TRUCK NEW FACTORY FRONT END WITH 4WDL, NEUTRAL, 2WDH 4WDH FLOOR CONTROL LEVER. THE DRIVER'S DOOR JAM HAS AN 8600 LB GVW CERTIFICATION WHICH IS APPROPRIATELY QUIGLEY'S. MY VERY LOW ODOMETER AT 16,614 MILES IS ACCURATE, AS I ALSO HAVE OTHER VEHICLES TO USE, AND WORK AT HOME. *TR

I OWN A 2003 CHEVROLET EXPRESS VAN. I AM UNABLE TO OPEN THE REAR DOORS ON THE DRIVER AND PASSENGER SIDES. I HAVE BEEN TOLD BY A LOCAL BODY SHOP THAT THE PROBLEM IS THE PINS THAT WERE USED IN THE HINGES. THEY ARE RUSTING FROM THE INSIDE CAUSING THE DOORS NOT TO OPEN. THIS BODY SHOP SAID THEY HAVE BEEN GIVEN INFORMATION ON HOW TO FIX THE PROBLEM AT A COST OF $1500.00 PER SIDE. BUT I CANNOT FIND ANY INFORMATION ABOUT A RECALL FROM GENERAL MOTORS. I DO NOT HAVE AN EXTENDED WARRANTY ON THIS VEHICLE BUT I DON'T THINK THESE REPAIRS SHOULD BE MADE AT MY EXPENSE. THIS VEHICLE IS USED MOSTLY WHEN I GO CAMPING. I HAVE TWO YOUNG CHILDREN WHO RIDE IN THIS VEHICLE. I TRIED TRADING THIS VEHICLE IN NUMEROUS TIMES BEFORE THE REAR DOORS BECAME TOTALLY INOPERABLE. BUT EVERY DEALERSHIP I GO TO GOES FOR THE REAR DOORS AND TRIES TO OPEN THEM. WHICH LEADS ME TO BELIEVE THAT THEY KNOW THAT A PROBLEM EXISTS. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 2500 VAN. WHILE THE VEHICLE WAS PARKED IT CAUGHT ON FIRE AND BOTH AIR BAGS DEPLOYED. THE CONTACT STATED THAT THE CAUSE OF FIRE WAS THE SAME AS MENTIONED IN RECALL # 05V104000 ELECTRICAL SYSTEM: WIRING:INTERIOR/UNDER THE DASH BOARD). THE FIRE DEPARTMENT EXTINGUISHED THE FIRE, AND THE VEHICLE WAS TOWED TO THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 74,000.*AK

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE CABLE THAT HELD THE SEAT BELTS TOGETHER, LOCATED IN THE REAR MIDDLE ROW, SNAPPED WITHOUT WARNING. AS A RESULT, THE CONTACT WAS CONCERNED THAT, IN THE EVENT OF A CRASH, THE SEAT BELTS WOULD NOT SECURE PROPERLY AND CAUSE AN INJURY. THE CONTACT ALSO STATED THAT THE REAR DRIVER AND PASSENGER SIDE DOOR HINGES FRACTURED. THE CONTACT STATED THAT THE DOORS WERE GLUED SHUT. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 228,000. UPDATED 10/17*LJ UPDATED 10/4/18*JB

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE SEAT BELT BUCKLE ASSEMBLY BROKE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE SEAT BELT WAS WORKING UP TO SPECIFICATIONS. THE DEALER STATED THAT THERE WAS A RECALL NHTSA CAMPAIGN ID NUMBER: 03V050000 COMPONENT: SEAT BELTS:FRONT:BUCKLE ASSEMBLY. BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 65,000. THE VIN WAS NOT AVAILABLE.

WHEN DRIVING IN A HORRIBLE RAINSTORM, THE DRIVER'S SIDE WINDSHIELD WIPER STOPPED MOVING AND THEN ON THE NEXT ROTATION, SWUNG ITSELF AROUND AND GOT LODGED BY THE SIDE VIEW MIRROR. AN ACCIDENT WAS AVOIDED, BUT IT OCCURRED 3 MORE TIMES RANDOMLY THAT SAME DAY, AND THEN TODAY. IT WAS A MIRACLE THROUGH THE HEAVY RAIN THAT WE DIDN'T WRECK. LUCKILY THE PASSENGER SIDE WIPER KEPT WORKING AND WITH SOME LUCK, WE EXITED TO SAFETY. *TR

I DRIVE A 2003 CHEVROLET EXPRESS VAN. I BELIEVE THERE IS AN ISSUE WITH THE WINDSHIELD WIPERS. MANY TIMES, WHEN TRAVELING AT SPEEDS ABOVE 50 THE WIPERS DO VERY LITTLE TO KEEP THE WINDSHIELD CLEAR. EVEN AFTER INSTALLING NEW BLADES. THIS HAPPENS DURING ALL TYPES OF INCLEMENT WEATHER, BUT IS ESPECIALLY BAD IN THE WINTER. THE WIPER BLADES ALLOW ICE TO COLLECT ON THEM, AND THE DEFROSTER IS NOT ENOUGH TO KEEP THEM CLEAR. I MUST STOP AND MANUALLY CLEAR THE WIPERS IF I MUST USE THE WIPERS, THEY JUST SCRAPE ACROSS THE WINDSHIELD BUT DO VERY LITTLE TO ACTUALLY CLEAR THE WINDSHIELD. IF TRAFFIC PASSING BY, THROWS SLUSH AND SUCH ON THE WINDSHIELD. THE WIPERS CAN NOT CLEAR IT PROPERLY. IN ADDITION TO THIS, THE WINDSHIELD WASHER SPRAY HOSES ARE ATTACHED TO THE WIPER ARMS AND TEND TO PLUG OR FREEZE AND COMPOUNDS THE PROBLEM. I HAVE DRIVEN THIS VEHICLE FOR 3 YEARS AND ITS THE SAME THING EVERY YEAR. IT PRESENTS QUITE A PROBLEM SINCE MANY TIMES, I AM OPERATING THE VEHICLE AT HIGHWAY SPEEDS, WITH LIMITED VISION. UNTIL I STOP AND CLEAR IT OFF. I DON'T KNOW IF ITS BECAUSE THE WIPERS LIFT OFF THE WINDSHIELD AT HIGH SPEEDS OR IF THE JUST SHRINK DUE TO THE COLD. I DO KNOW THAT IT HAS BECOME A SAFETY ISSUE. *JB

DRIVING ON INTERSTATE AT 65 MPH, THE ABS WARNING LIGHT CAME ON, AND THE SPEEDOMETER STARTED JUMPING ERRATICALLY FROM ACTUAL SPEED TO LOWER SPEEDS 45, 25 + OTHERS AS LOW AS 8 (EIGHT) MPH. THIS CAUSED THE TRANSMISSION TO DOWNSHIFT UNPREDICTABLY, OVER-REVVING THE ENGINE SPEED. IT HAPPENED REPEATEDLY SO I DOCUMENTED THE ODOMETER ERRATIC MOVEMENT ON MY CELL PHONE AS A VIDEO, SHOWING ROAD MOVEMENT + ALL GAUGES + AUDIO EVENTS LIKE ENGINE OVER-REVVING AT SAME TIME. THE VIDEO IS OF HIGH QUALITY AND THE EVENTS TAKING PLACE ARE DOCUMENTED WITH THE VIDEO. RURAL AREA WITH FEW CARS ON ROAD AT THE TIME. IF IT TOOK PLACE IN A CITY INTERSTATE ENVIRONMENT (ESPECIALLY IN THE WINTER MONTHS) IT MIGHT HAVE CAUSED A MULTIPLE CAR COLLISION WITH SUDDEN UNEXPECTED DOWNSHIFTING THAT WAS OUT OF MY CONTROL. ENGINE RPM ALSO HUNTS ERRATICALLY AND OUT OF MY CONTROL. PREDICTABLE IN WHAT IT DOES, IT BEGINS APPROXIMATELY WITHIN A RANGE OF 4-8 MILES AFTER LEAVING HOME DAILY. WHEN ENGINE TURNED OFF AND PARKED AT A LOCAL STORE AS AN EXAMPLE, IT WILL CLEAR IT'S PROBLEM AS IF A CPU IS "RE-BOOTED", AND REPEAT THE CYCLE OF ERRATIC BEHAVIOR FROM THAT NEW STARTING POINT. WHEN I BOUGHT + INSTALLED ACTRON BRAND OBD-II CODE READER WHICH FEATURES ABILITY TO REVEAL ABS BRAKE CODES, IT NEVER SHOWS ANY OTHER STORED CODES EXCEPT A SINGLE PO446 WHICH IS AN EMISSIONS RELATED CODE. THIS VAN WAS ORIGINALLY SENT NEW BY THE SELLING NH CHEVROLET DEALER TO THE PENNSYLVANIA BASED QUIGLEY CONVERSION FACILITY, SO IN FEBRUARY 2004 WAS MODIFIED FROM RWD TO A 4WD BY EXCHANGING STOCK MODEL 2500 FRONT END FOR A 4 WD PICKUP TRUCK NEW FACTORY FRONT END WITH 4WDL, NEUTRAL, 2WDH 4WDH FLOOR CONTROL LEVER. THE DRIVER'S DOOR JAM HAS AN 8600 LB GVW CERTIFICATION WHICH IS APPROPRIATELY QUIGLEY'S. MY VERY LOW ODOMETER AT 16,614 MILES IS ACCURATE, AS I ALSO HAVE OTHER VEHICLES TO USE, AND WORK AT HOME. *TR

THE RACK AND PINION UNIT HAS LOTS OF PLAY IN THE CENTER. (APPROX 50K) THE TRANSMISSION SLIPS IN REVERSE FROM DAY ONE. THE GAS PEDAL SHIFT FROM LEFT TO RIGHT ABOUT 3 INCHES. (APPROX 40K) THIS VAN HAS ABOUT 50 REPAIRS UNDER WARRANTY. THIS VAN IS USED BY MY WIFE AND 4 KIDS. *NM

THIS VEHICLE WAS BOUGHT BRAND NEW BUT UNBEKNOWNST TO ME WAS MADE IN CANADA (SOMETHING WHICH WOULD NOT HAVE BEEN ACCEPTABLE TO ME HAD I BEEN TOLD). UPON POSSESSION THE WINDSHIELD MOLDING CAME OFF ON THE RIDE HOME. THE DRIVER SIDE TIEROD END WENT AT 12,000 MILES AND AGAIN AT 24,000 MILES BECAUSE UPON INSPECTION THE BALL JOINTS WERE NEVER PROPERLY TIGHTENED. THE BOLTS ON THE TRANSMISSION WERE FOUND BY THE DEALER TO HAVE BEEN NEVER PROPERLY TIGHTENED. THE SIDEDOOR HINGE HAD TO BE REPLACED AT A COST OF $600 BECAUSE IT FROZE UP AND COULD NOT BE OPENED. THE POWER STEERING UNIT RUSTED OUT AT 12,000 MILES AND STARTED LEAKING FLUID AND, WHAT I FIND MOST IMPORTANT, I AM NOT SURE IF I HAVE AIRBAGS BECAUSE THE AIRBAG LIGHT STAYS ON BUT IS NOTED TO GO OFF WHEN THE KEY IS PARTIALLY TURNED HOWEVER THE KEY CANNOT STAY IN THIS POSITION AND MUST BE TURNED TO START THE VEHICLE. FUEL EXPECTATION WAS NEVER NEAR WHAT I WAS TOLD IT WOULD BE AND TAILPIPE CONSISTENTLY SHOWED EVIDENCE OF BEING BLACKENED DUE TO INSUFFICIENT FUEL BURNING. THE POOR BACKDOOR DESIGN MAKES IT DIFFICULT TO SEE OUT THE BACK WINDOW AND IT IS CLEARLY EVIDENT BY ALMOST EVERY VAN OF THIS TYPE HAVING A DENTED BUMPER DUE TO THIS BLINDSPOT IN DESIGN. I HAVE NOT BEGUN TO LIST ALL THE THINGS NOT RIGHT WITH THIS VEHICLE BUT I WILL CHALK THEM UP TO DOWNRIGHT LYING AND JUST INFERIOR PARTS AND CRAFTSMENSHIP. THIS VEHICLE HAS BEEN A NIGHTMARE. *TR

THE RACK AND PINION UNIT HAS LOTS OF PLAY IN THE CENTER. (APPROX 50K) THE TRANSMISSION SLIPS IN REVERSE FROM DAY ONE. THE GAS PEDAL SHIFT FROM LEFT TO RIGHT ABOUT 3 INCHES. (APPROX 40K) THIS VAN HAS ABOUT 50 REPAIRS UNDER WARRANTY. THIS VAN IS USED BY MY WIFE AND 4 KIDS. *NM

TAIL LIGHTS LIGHT BULBS HAVE TO BE CHANGE EVRY WEEK OR EVERY OTHER WEEK. *NM

WHILE DRIVING CONSUMER SMELLED A BURNING ODOR. WITHIN SECONDS THE CABIN WAS IN SMOKE, THEN FLAMES. UPON INSPECTION OF THE VEHICLE BY THE CONSUMER THE FIRE STARTED FROM THE REAR OF THE VAN. CONSUMER FELT IT WAS DUE TO THE REAR LICENSE PLATE LAMP SOCKET, RECALL 03V217000, BUT WAS NOT SURE. THE VAN WILL BE INSPECTED BY A CHEVROLET INSPECTOR.*AK

THE RACK AND PINION UNIT HAS LOTS OF PLAY IN THE CENTER. (APPROX 50K) THE TRANSMISSION SLIPS IN REVERSE FROM DAY ONE. THE GAS PEDAL SHIFT FROM LEFT TO RIGHT ABOUT 3 INCHES. (APPROX 40K) THIS VAN HAS ABOUT 50 REPAIRS UNDER WARRANTY. THIS VAN IS USED BY MY WIFE AND 4 KIDS. *NM

DT: CONTACT OWNS 2003 CHEVROLET EXPRESS G3500 PASSENGER VAN. THE VAN WILL ACCELERATE ON ITS OWN SPORADICALLY. THIS STARTED AROUND 7-20-05. IT DOES IT WHILE STOPPING AT STOP LIGHT AND IT WILL ALSO DO IT WHILE DRIVING ON THE HIGHWAY. THE IDLE SPEED CONTROL MOTOR, THROTTLE POSITION SENSOR, COOLING SENSOR, ECM, AND THE PROM HAVE ALL BEEN CHANGED WITHIN 5-6 WEEKS. HE SAYS IT DID IT AT ANY SPEED SPORADICALLY. HE MADE AN APPOINTMENT TO BRING THE CAR IN AGAIN FOR A POSSIBLE REPAIR. THE CHECK ENGINE LIGHT WILL USUALLY COME ON AFTER AN INCIDENT. *AK

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE FRONT OF THE VEHICLE VIBRATED WHENEVER THE VEHICLE WAS BEING DRIVEN OVER 30 MPH OVER A BUMP. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CONTROL ARMS, THE PITMAN ARM, THE TIRES AND THE HUBS WERE REPLACED, BUT THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 109,000. THE VIN WAS NOT AVAILABLE. ....UPDATED 07/22/15 *BF UPDATED 10/4/2017*CN

2003 CHEVROLET EXPRESS LOST CONTROL OF VEHICLE STRIKING THE MEDIAN BARRIER. *BF ACCORDING TO THE POLICE REPORT, THE REAR TIRES HAD VERY LITTLE TREAD. ON THE INSIDE OF THE TIRES, THERE WAS NO TREAD. (OHIO TRAFFIC CRASH REPORT # 10-0234-91)*JB UPDATED 07/22/10 *BF

I HAVE A 2003 CHEVROLET 2500 EXPRESS VAN (PURCHASED NEW AND WELL MAINTAINED) THAT I USE FOR FIRE INVESTIGATIONS. ON THE DATE OF THE INCIDENT, THE ODOMETER READING WAS 50628 MILES. ON MY RETURN TRAVEL, I WAS ON I-75 NORTH BOUND THROUGH DAYTON, OHIO (SPEEDS EST @ 65-70 MPH) WHEN THE VIBRATION THROUGH THE STEERING WHEEL INCREASED. APPROXIMATELY SEVEN MILES SOUTH OF PIQUA, OHIO, I EXPERIENCED A CATASTROPHIC FAILURE OF THE LEFT FRONT WHEEL (DIDN'T KNOW WHAT TYPE OF FAILURE AT THIS TIME) WHICH CAUSED THE VEHICLE TO SUDDENLY "JERK" TO THE LEFT. TRAVELING IN THE CENTER NORTH BOUND LANE OF I-75 AND IN HEAVY TRAFFIC, I USED BOTH HANDS TO STEERING MY VAN TO THE RIGHT HAND LANE NARROWING MISSING A SEMI TRACTOR-TRAILER. I CONTINUED ONTO THE BERM WITH THE END OF THE VAN SLIDING SIDEWAYS TO THE RIGHT. AS THE VAN SLOWED AND NOW ALMOST PERPENDICULAR TO TRAFFIC, THE LEFT SIDE OF THE VAN BEGAN TO LIFT WITH BOTH LEFT SIDE WHEELS OFF THE GROUND. LUCKILY, THE VAN CAME TO A STOP AND THE LEFT SIDE DROPPED TO THE GROUND. TRAFFIC ON I-75 WAS IN CHAOS TRYING TO AVOID MY VAN DURING THE WHOLE EPISODE. I BELIEVE THE LONG WHEEL BASE OF THE VAN CONTRIBUTE TO PREVENTING THE VAN FROM ROLLING. AAA TOWED THE MY VAN TOWED TO DEFIANCE (OHIO) CHEVROLET DEALER IN PREPARATION FOR REPAIRS BECKMAN CHEVROLET DEALER SERVICE DEPARTMENT INSPECTED THE VAN ON THE NEXT DAY AN FOUND COMPLETE FAILURE OF THE LEFT FRONT WHEEL BEARING WITH ONLY THE FRONT BRAKE SYSTEM KEEPING THE WHEEL ON THE SPINDLE. THE VEHICLE WAS REPAIRED WITH THE INSTALLATION OF A NEW WHEEL AND BEARING ASSEMBLY(SOLD AS ONE UNIT). I HAD TO PAY $300 AS A "WARRANTY DEDUCTIBLE" WITH THE DEFECTIVE PARTS RETURNED TO THE MANUFACTURER GM . IN MY OPINION THIS WHEEL AND BEARING ASSEMBLY SHOULD NOT HAVE FAILED WITH ONLY 50,000 MILES AND IT APPEARS THERE WAS A MATERIAL OR INSTALLATION FAILURE IN SOME MANNER. AAA IS OUT ABOUT $300 FOR THE TOW BILL. I REMAIN, BOB MARIHUGH, DEFIANCE, OHIO. *JB