2004 Chevrolet Express Problems

This vehicle was sold for use over US highways, as "repairable condition". After going to a mechanic shop, I was advised, because of sever rust the rear leaf spring hangers were completely rusted thru, the rear axle assembly could come off or the frame could break in half, by just going over say, a railroad crossing. The mechanic said they would not repair this vehicle for use to drive on roads. I am requesting a local representative to help evaluate if this vehicle is safe to travel on Oklahoma roads.

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHILE DRIVING 5 MPH AND DEPRESSING THE BRAKE PEDAL, THE ABS SYSTEM PREVENTED THE VEHICLE FROM BRAKING PROPERLY AND THE ABS WARNING LIGHT ILLUMINATED. IN ONE OCCASION, THE VEHICLE FAILED TO STOP AND PROCEEDED THROUGH THE INTERSECTION DURING A RED LIGHT. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE SENSORS AND THE ABS MAIN CONTROL SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

NHTSA Campaign Number: 12V388000. I have this problem. A leaking fuel line due to corrosion. I drive in the Cascade MT's of Washington state. my line now leaks excessively on fill up.

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS STATIONARY, FUEL SPILLED ONTO THE GROUND. IT WAS DIAGNOSED THAT THE FILLER NECK WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 148,000. UPDATED 04/11/2017*JS

TWO REAR BUCKET SEAT BELT CABLES HAVE BROKEN WITHOUT IMPACT.

DT*: THE CONTACT STATED THE SEAT BELT BUCKLE DID NOT RELEASE THE SEAT BELT PROPERLY. INTERMITTENTLY, THE SEAT BELT BECAME STUCK IN THE BUCKLE. THE NOTICE FOR NHTSA RECALL #05V558000, PERTAINING TO THE SEAT BELTS, WAS RECEIVED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER DENIED A FREE REMEDY DUE TO THE PROBLEM ONLY BEING INTERMITTENT. THE MANUFACTURER WAS NOTIFIED, WHO STATED THE BUCKLE ASSEMBLY WOULD ONLY BE REPLACED IF THE PROBLEM COULD BE REPLICATED AT THE DEALERSHIP.

VEHICLE HAS CONTINUED TO EVIDENCE PROBLEMS SIMILAR TO WHAT'S DESCRIBED BY NHTSA CAMPAIGN ID NO. 04V452000. POWER STEERING PUMP AND BELTS HAVE BEEN REPLACED AND GM DEALER PERFORMED HYDRO BOOST INSPECTION TEST AND IT PASSED; SAID NO FURTHER ACTION REQUIRED. BUS HAS AGAIN LOST POWER STEERING AND BRAKES TO CAUSE A DANGEROUS CONDITION. DEALER SAYS IT IS NOT A VEHICLE THAT RECALL APPLIES TO. *JS

LEFT FRONT WHEEL DISENGAGED FROM VAN AT 55 MILES PER HOUR ON THE INTERSTATE DUE TO A NUT FALLING OFF OF THE SPINDLE. THIS WAS A VERY DANGEROUS AND COSTLY SITUATION.

THE VAN WAS PARKED IN MY DRIVEWAY STATIONARY. IT CAUGHT FIRE AND PROCEEDED TO BURN COMPLETELY FOR UNKNOWN REASONS. THE WEBSITE STATES THIS VIN NUMBER IS NOT INCLUDED IN ANY RECALLS BUT THE VEHICLE TYPE HAS A RECALL LISTED THAT STATES IT COULD BE A FIRE HAZARD.

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS G1500. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE DOUBLE DOOR HINGES FAILED AND THE DOORS COULD NOT BE OPENED. THE DEALER ADVISED THAT THE DOOR HINGES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000 AND THE APPROXIMATE FAILURE MILEAGE WAS 110,00.

ENGINE EXHAUST MANIFOLD BROKEN BOLTS,HAS 3 AT THIS POINT AND TIME. THIS CAUSES THE EXHAUST TO LEAK INTO DRIVERS COMPARTMENT. *TR

DT: THE VEHICLE IS A 2004 CHEVROLET EXPRESS 2500 VAN. ON 7-11-05 THE VEHICLE WAS MAKING INTERMITTENT KNOCKING NOISES. THE VEHICLE WAS STILL ABLE TO GO AT THIS POINT. THIS HAD BEEN GOING ON FOR A COUPLE OF DAYS. THE PROBLEM HAD BECAME WORSE, SO THE CONSUMER TOOK THE VEHICLE TO MIDAS. THE MECHANIC TOLD THE CONSUMER THAT THE FLY WHEEL HAD FAILED. THE CONSUMER HAD TO REPLACE THE WATER PUMP, BATTERY AND THE ALTERNATOR . *JB

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS PARKED THE REAR DRIVER'S SIDE WINDOW FELL OUT OF PLACE. THE CONTACT STATED THAT ALL THE WINDOWS ON THE VEHICLE WERE LOOSE. THERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 33,000. UPDATED 01/31/17*LJ CONSUMER STATED DRIVERS SIDE REAR SEAT LOWER WINDOW BROKE. GLUE CAME OFF MANUFACTURED WINDOW MADE BY C.R. LAURENCE CO, INC. WINDOW WAS REPLACED 11/08/16. UPDATED 6/22/18*JB

DT: THE VEHICLE IS A 2004 CHEVROLET EXPRESS 2500 VAN. ON 7-11-05 THE VEHICLE WAS MAKING INTERMITTENT KNOCKING NOISES. THE VEHICLE WAS STILL ABLE TO GO AT THIS POINT. THIS HAD BEEN GOING ON FOR A COUPLE OF DAYS. THE PROBLEM HAD BECAME WORSE, SO THE CONSUMER TOOK THE VEHICLE TO MIDAS. THE MECHANIC TOLD THE CONSUMER THAT THE FLY WHEEL HAD FAILED. THE CONSUMER HAD TO REPLACE THE WATER PUMP, BATTERY AND THE ALTERNATOR . *JB

This vehicle was sold for use over US highways, as "repairable condition". After going to a mechanic shop, I was advised, because of sever rust the rear leaf spring hangers were completely rusted thru, the rear axle assembly could come off or the frame could break in half, by just going over say, a railroad crossing. The mechanic said they would not repair this vehicle for use to drive on roads. I am requesting a local representative to help evaluate if this vehicle is safe to travel on Oklahoma roads.

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHILE ATTEMPTING TO SHIFT INTO PARK, THE LINKAGE POPPED OFF PREVENTING THE VEHICLE FROM BEING SHIFTED INTO PARK. THE EMERGENCY BRAKE WAS ENGAGED IN ORDER TO PREVENT THE VEHICLE FROM MOVING. THE VEHICLE WAS DIAGNOSED WITH A FAILED CABLE ASSEMBLY THAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 136,000.

AIR BAGS FAILED ON CRASH. *NM