Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
10
Latest Feb 24, 2025
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Jul 23, 2011
What this page shows
Our database holds 10 NHTSA owner-reported complaints for the 2009 Chevrolet Express. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Complaints, most recent first
Showing 1–10 of 10
Powertrain (other)
Filed Feb 24, 2025
The contact owns a 2009 Chevrolet Express. The contact stated that upon starting the vehicle, the contact became aware that the check engine warning light was illuminated. The contact took the vehicle to a local dealer, where it was diagnosed, and the contact was informed that the transmission was faulty and needed to be replaced. The transmission was replaced, and the contact continued to drive the vehicle normally. The contact stated that while driving 50 MPH, the vehicle started to vibrate abnormally. There was no warning light illuminated. The contact pulled over to the side of the road and the vehicle was towed to a local dealer to be diagnosed. The contact was informed that the transmission and the driveshaft had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 30,000.
NHTSA ID
11644633
Incident
Feb 21, 2024
Mileage
30,000 mi
Driver assistance
Filed Oct 13, 2020
TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS. THE CONTACT STATED THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING WHILE STOPPED AT A TRAFFIC LIGHT. THE CONTACT TURNED THE VEHICLE OFF FOR SEVERAL SECONDS AND THEN RESTARTED THE VEHICLE AND DROVE TO HIS RESIDENCE. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER TO BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 61,000. *BF CONSUMER STATED SAME THNG HAPPENED THE SECOND TIME 7 MONTHS LATER.*JB
NHTSA ID
11364173
Incident
Oct 8, 2020
Mileage
61,000 mi
Electrical
Filed Jun 25, 2019
TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 14V614000 (ELECTRICAL SYSTEM); HOWEVER, THE VEHICLE EXHIBITED THE SAME FAILURE AS THE RECALL CAMPAIGN. HAWTHORNE CHEVROLET (1180 GOFFLE RD, HAWTHORNE, NJ 07506, (973) 453-2564) WAS CONTACTED AND DID NOT ASSIST. THE VEHICLE WAS NOT SCHEDULED FOR A REPAIR APPOINTMENT. AN INDEPENDENT CERTIFIED MECHANIC DIAGNOSED THAT THERE WAS AN ELECTRICAL SHORT DUE TO CONTAMINATION ON THE CHASSIS ELECTRONIC CONTROL MODULE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, INDICATED THAT THE VEHICLE WAS EXCLUDED FROM MANUFACTURER RECALL NUMBER: 14515, AND PROVIDED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
NHTSA ID
11222451
Incident
Jun 10, 2019
Mileage
160,000 mi
Body & structure
Filed Feb 20, 2016
WHITE 2009 CHEVROLET EQUINOX PAINT IS PEELING OFF OF CAR. IT STARTED ON THE DRIVER'S SIDE ABOVE THE WINDOWS FIRST AND WITHIN A FEW DAYS, THE PASSENGER SIDE IS DOING THE EXACT SAME THING. WE NOTICED SOME "DIMPLING" IN THE PAINT ON THE LIFT GATE AS WELL. WE HAVE CONTACTED GM (CHEVROLET) AND HAVE BEEN TOLD TO TAKE IT TO A LOCAL DEALER FOR A "DIAGNOSTIC" EVALUATION. MY CAR HAS ONLY BEEN EXPOSED TO NATURAL ELEMENTS AND THIS SHOULD NOT BE OCCURRING IN ONLY 6 YEARS.
NHTSA ID
10837304
Incident
Feb 12, 2016
Airbags
Filed Nov 13, 2014
Crash reported2 injuries reported
TL* THE CONTACT OWNED A 2009 CHEVROLET EXPRESS. WHILE DRIVING APPROXIMATELY 62 MPH, THE CONTACT'S VEHICLE CRASHED INTO THE DRIVER SIDE DOOR OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A FEW CUTS ON THE KNEE THAT DID NOT REQUIRE MEDICAL ATTENTION. THE PASSENGER FROM THE OTHER VEHICLE SUSTAINED A BROKEN COLLAR BONE AND A HEAD INJURY, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 229,000.
NHTSA ID
10654755
Incident
Oct 16, 2014
Mileage
229,000 mi
Airbags
Filed Aug 11, 2014
TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS. WHILE DRIVING APPROXIMATELY 35 MPH, THE AIR BAGS DEPLOYED WITHOUT WARNING. THE DEALER COULD NOT DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.
NHTSA ID
10621426
Incident
Jul 9, 2014
Mileage
51,000 mi
Other / unspecified
Filed Mar 19, 2013
WHILE DRIVING ON THE HIGHWAY THE TIRE SIDE WALL FAILED, CAUSING BLOW-OUT. NEW TIRES WERE PURCHASED ON07/6/2012. BLOW OUT HAPPENED WITH LESS THAN 13,000 MILES. *TR
NHTSA ID
10503643
Incident
Dec 17, 2012
Mileage
126,116 mi
Tires & wheels
Filed Dec 15, 2012
DRIVING 55 MPH OR SO TIRE LIGHT CAME STOPPED TO CHECK AND VALVE STEM BLEW OUT OF TIRE,THIS IS THE SECOND TIME THIS HAS HAPPENED AND POSES A GREAT DANGER TO ME AND MY PASSENGERS AND OTHERS. *TR
NHTSA ID
10488861
Incident
Dec 14, 2012
Mileage
51,000 mi
Airbags
Filed Feb 10, 2012
BOTH FRONT AIR BAGS DEPLOYED IN PARKING LOT!VAN WAS LOCKED! *TR
NHTSA ID
10447384
Incident
Jan 26, 2012
Mileage
44,790 mi
Tires & wheels
Filed Jul 23, 2011
WHILE CHECKING TIRE PRESSURE TPMS BROKE - FILED BY JIFFY LUBE. *TR
NHTSA ID
10414830
Incident
May 10, 2011
Mileage
30,400 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.