Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
13
+1 complaint in 30 days
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
2
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
2
Reports on file since Jan 12, 2013
What this page shows
Our database holds 13 NHTSA owner-reported complaints for the 2012 Chevrolet Express. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Complaints, most recent first
Showing 1–13 of 13
BrakesElectrical
Filed Aug 6, 2026
ABS Valve Body / Pump Harness chafed through brake hydraulic line near transmission crossmember. This resulted in a hydraulic leak and loss of brake pedal feel / partial loss of brakes. Fortunately failure occurred in the driveway--I had 4500 Lbs of sailboat trailer hitched to the van and was about to go on a long trip. Design issue. Wiring harness should not be located so as to chafe on hydraulic lines. This is not the first chafe related failure on this vehicle.
NHTSA ID
11755204
Incident
Aug 4, 2026
Airbags
Filed Dec 14, 2025
Crash reported2 injuries reported
About 6:45 in the morning on November 10th, the vehicle was in a high-speed. Front end collision with adult cow elk at 70 miles an hour on the freeway, and the airbags failed to deploy in the Van on both front seats and the vehicle was severely damaged. Injuries were sustained.
NHTSA ID
11704917
Incident
Nov 10, 2025
Fuel system
Filed Apr 23, 2025
Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a re hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem.
NHTSA ID
11656226
Incident
Apr 22, 2025
Fuel system
Filed Mar 21, 2025
Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a fire hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem before any failure. Failed fuel tank straps on this were repaired by GM Dealer (Faulkner GMC, 705 Auto Park Blvd, West Chester, PA 19382) (Invoice #677658 - Invoice Date Feb 25 2025).
NHTSA ID
11649646
Incident
Feb 18, 2025
Driver assistanceSteering
Filed Aug 13, 2023
Crash reported2 deaths reported
UNKNOWN...THE VEHICLE VEARED OFF ROAD AN INTO ON COMING TRAFFIC. Did not seam like steering was working properly. The final out come there were 2 deceased operators. In 2 different vehicles. I'm not sure if the recalls were ever repaired.
NHTSA ID
11538233
Incident
Apr 24, 2023
Filed May 30, 2019
VEHICLE ROLLS WHILE IN PARK
NHTSA ID
11216933
Incident
May 28, 2019
Mileage
85,000 mi
Brakes
Filed Apr 5, 2017
I MANAGE A FLEET OF 53 SCHOOL BUSES, MODEL YEARS RANGING FROM 2008 TO 2015. I HAVE NOTICED A TREND WITH THE HYDRO BOOSTERS AND MASTER CYLINDERS, THEY TEND TO LEAK INTERNALLY ON THESE GM VEHICLES SOME HAVE BEGUN TO LEAK AS EARLY AS 30,000 MILES. I EXPECT TO HAVE TO REPLACE ALL OF THESE COMPONENTS, ON EVERY BUS IN THE NEAR FUTURE. AS THE FLEET AGES THE TREND IS GETTING INCREASINGLY WORSE. I BELIEVE THIS IS A DANGEROUS SITUATION BECAUSE I AM VIGILANT WITH KEEPING UP ON THIS ISSUE, HOWEVER I AM NOT SURE THAT THE GENERAL PUBLIC WILL HAVE THE SAME UNDERSTANDING ABOUT THE DANGER OF THIS DESIGN FLAW. I HAVE HAD BUSES COME IN BLEEDING BRAKE FLUID OR HYDRAULIC FLUID.
NHTSA ID
10970667
Incident
Apr 4, 2017
Mileage
30,000 mi
EnginePowertrain (other)
Filed Sep 29, 2015
THE ENGINE WILL GO TO LOW POWER AND NOT GO MORE THAN 30 MPH WITHOUT WARNING. THIS IS AN AMBULANCE CHASSIS AND IS A KNOW PROBLEM GM HAS NOT ADDRESSED YET IN THE 2012 AND 2013 CHASSIS. IT CAN DO THIS ON HWYS WITH SPEED LIMITS OF 55, 65, 70 MPH SUDDENLY WHICH COULD CAUSE AN ACCIDENT AS NO STOP LIGHTS GIVE ANY WARNING AND YOU CAN'T SPEED UP ANYTIME IN POOR VISIBILITY OR AT ANYTIME. NOT ONLY IS IT BAD FOR THE INJURED OR ILL PATIENT IT COULD CAUSE AN ACCIDENT AND INJURY OTHERS. GM HAS FIXED THIS ON THE 2014 AND NEWER MODELS BUT NOT 12 &13. THIS IS NOT JUST OUR ONE UNIT THIS IS 2012 AND 2013 CHEVY DIESELS AMBULANCE ALL OVER THE US. WE HAVE FOUR UNITS THAT IT CAN HAPPEN TO AND TWO THAT IS HAS WITH PATIENTS. I HAVE CONTACTED THE EPA, GM, AND OUR INDIANA STATE SENATORS TRYING TO GET THIS DANGEROUS SITUATION TAKEN CARE OF IN THE LAST FEW DAYS. I AM ASKING ANYONE WHO WILL LISTEN TO HELP PUSH GM FOR A FIX.
NHTSA ID
10778557
Incident
Sep 1, 2015
Mileage
100,000 mi
Electrical
Filed Sep 12, 2015
ENGINE WAS AT IDLE HAD PULLED INTO GAS STATION . ALARMS WENT OFF CHECK ENGINE LIGHT CAME ON, STABLE TRACK ERROR, MULTIPLE TONES. AFTER 20 SECONDS ENGINE STALLED. WOULD NOT CRANK. AFTER TALKING TO PEOPLE AND COUPLE TRIES FIX TOOK TO DEALERSHIP AS IT WAS DIAGNOSED TO BE THE ENGINE CONTROL MODULE SHORTED. I HAD GONE THRU RAIN EARLIER AND A COUPLE STORMS PASSED THRU WHILE AT STATION AND EATING. DEALER REPLACED ENGINE CONTROL MODULE AND PROGRAMMED IT. THIS COULD OF HAPPENED WHILE DRIVING AND WOULD OF LOST ENGINE POWER AND POWER STEERING. SINCE JUST MODULE REPLACED AND BEN TOLD IT IS KNOW TO SHORT OUT WHEN WET IT COULD HAPPEN AGAIN.
NHTSA ID
10763324
Incident
Jun 26, 2015
Mileage
212,000 mi
ElectricalSteering
Filed Jun 17, 2015
TL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS. WHEN THE BRAKES WERE DEPRESSED AND RELEASED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT MENTIONED THAT THE STABILITRAK ACTIVATED INDEPENDENTLY AFTER BEING TURNED OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.
NHTSA ID
10725751
Incident
Aug 7, 2014
Mileage
47,000 mi
Seat belts
Filed Oct 21, 2014
DRIVER'S SEAT BELT REEL SEIZED WHILE THE VEHICLE WAS PARKED SO THE BELT COULD NOT BE EXTENDED AND BUCKLED. THE OPERATOR WAS NOT ABLE TO WEAR THE SEAT BELT AS REQUIRED BY LAW. VEHICLE WAS BROUGHT TO THE CHEVROLET DEALER AND REPAIRED UNDER TSB 05-09-40-002G TODAY, A SECOND VEHICLE OF THE SAME MAKE/MODEL 2014 MODEL YEAR EXPERIENCED THE SAME PROBLEM.
NHTSA ID
10649163
Incident
Sep 5, 2013
Mileage
4,750 mi
Body & structureBrakesSuspension
Filed Apr 22, 2013
PARKING BRAKE CABLE FOUND RUBBING ON THE HYDRAULIC SERVICE BRAKE LINE, FORWARD OF THE REAR AXLE ON DRIVERS SIDE OF CHASSIS. WEAR IS EVIDENT ON HYDRAULIC SERVICE BRAKE LINE AND PARKING CABLE, ALONG WITH COMPONENT PARKING BRAKE ASSEMBLY WAS STUCK UNDER. *TR
NHTSA ID
10509029
Incident
Apr 20, 2013
Mileage
14,500 mi
Brakes
Filed Jan 12, 2013
VIOLENT SHAKING WHILE APPLYING BRAKES. *TR
NHTSA ID
10492330
Incident
Sep 22, 2012
Mileage
200 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.