1996 Chevrolet G10 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Chevrolet G10, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes220.0%
- Electrical110.0%
- Fuel system110.0%
- Interior & seats110.0%
- Powertrain (other)110.0%
- Steering110.0%
- Transmission110.0%
- Body & structure110.0%
- Visibility110.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
BRAKE FAIL ON OCCASIONS, BATTERY FAILED.
BRAKE PEDAL GOES TO FLOOR.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
BRAKE FAIL ON OCCASIONS, BATTERY FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL*THE CONTACT OWNS A 1996 CHEVROLET G10. THE INTAKE MANIFOLD BEGAN LEAKING, BECAME WORSE OVER TIME. AS OF MAY 23, 2008, THE MECHANIC REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 98,000 AND CURRENT MILEAGE WAS UNAVAILABLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
THE DRIVER'S SIDE SEAT BROKE OFF THE TRACKS AND ANCHOR, CAUSING THE SEAT TO ROCK BACKWARDS, IT WAS REPLACED ONCE, AND THIS INCIDENT HAS OCCURRED AGAIN. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
WE HAVE REPLACED 3 DIFFERENT REAR AXLES/GEARS. BEFORE REPLACING WE DIDNT HAVE ANY PROBLEM WITH BACKLASH. WE HAVE HAD THE VAN LOOKED AT & THE DEALERSHIP STATES THEY DIDNT NEED TO LOOK AT THE VAN THAT THEY HAD A BULLETIN STATING THIS WAS NORMAL BACKLASH & USUALLY FOUND IN TRUCKS. WE HAVE HAD ONE FIRE WITH THE REAR AXLE BURNING BUT NOW WE CAN TELL IF THE REAR AXLE IS BLOWING. WE HAVE SPOKE TO SEVERAL OTHER OWNERS OF THESE VANS & THEY SEEM TO BE HAVING A HOWLING IN THE ENGINE/ PAINT BURNING OFF THE HOUSING UNIT & THEY WERE TOLD THIS WAS NORMAL. THE OTHER OWNER HAS STATED HE HAS REPLACED 2 REAR AXLES. PLEASE CONTACT ME TO WHETHER OR NOT AN INVESTIGATION IS BEING PERFORMED OR HOW THE THREE OF US WHO ARE HAVING THE SAME TYPE OF PROBLEMS (REAR AXLE) BUT GM KEEPS STATING THIS IS NORMAL. SOMEONE COULD HAVE BEEN KILLED IF WE DIDNT HAVE AN EXTINGUISER TO PUT THE FIRE OUT BEFORE THE FIRE DEPT ARRIVED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
STEERING FAILURE, CAR WANDERS ALL OVER ROA.D
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
CONSUMER STATES THAT TRANSMISSION IS SLIPPING. DELAER NOTIFIED.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE PANEL ON THE INSIDE OF THE DOOR IS COMING LOOSE, AND CAUSING THE DOOR TO STICK AND JAM SO THAT THE PASSENGERS CAN'T GET OUT. DEALER HAD REPAIRED DOOR PANEL, BUT PROBLEM REOCCURRED FOR THE 3RD TIME. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
STEERING FAILURE, CAR WANDERS ALL OVER ROA.D
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .