1985 Chevrolet G20 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1985 Chevrolet G20, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes116.7%
- Engine116.7%
- Fuel system116.7%
- Interior & seats116.7%
- Suspension116.7%
- Tires & wheels116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WHEN APPLYING BRAKES, THE FRONT BRAKES WOULD LOCK UP. HAD BRAKES REPAIRED DUE TO STRESS ON THE FRONT BRAKES FROM THE BACK BRAKES NOT SELF ADJUSTING. THEY SUPPOSE TO BE SELF ADJUSTING. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
ENGINE FIRE. (OHIO STATE POLICE REPORT)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
VAN WAS REAR ENDED AND DAMAGE GAS TANK, VAN BURNED. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
CAN NOT GET OUT OF VEHICLE WHEN LOCKED UNLESS YOU ROLL DOWN WINDOW AND OPEN DOOR FROM OUTSIDE. PLEASE DESCRIBE DETAILS. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
VAN PULLS TO THE LEFT WHEN DRIVING AND WHEN PUTTING ON THE BRAKES. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TL*THE CONTACT OWNS A 1985 CHEVROLET G20, WITH COOPER WEATHER- MASTER ST STEEL P225/75/R15 TIRES. WHILE DRIVING 75 MPH THE DRIVER-SIDE FRONT TIRE TREAD SEPARATED. HE REPLACED THE FAILED TIRE WITH THE SPARE TIRE; HOWEVER, 15 MILES LATER, THE DRIVER-SIDE REAR TIRE BLEW OUT AND CAUSED THE VEHICLE TO ROLL OVER AND CRASH. THE POLICE AND EMS WERE NOTIFIED. HE SUSTAINED INJURIES TO THE HEAD AND EXTENSIVE BRUISING ON HIS ENTIRE BODY. A POLICE OFFICER CONCLUDED THAT BECAUSE THE SIDE-WALLS WERE SPLIT, THE TIRES WERE DEFECTIVE. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 140,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .