RoadVitals

1986 Chevrolet G20 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Oct 22, 2007
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
5
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1986 Chevrolet G20, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes120.0%
  • Interior & seats120.0%
  • Powertrain (other)120.0%
  • Seat belts120.0%
  • Steering120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

BRAKE PADS FAILED.

NHTSA ID 516961 · filed May 6, 1997

Too few reports in this category for a page of its own — they appear in the full complaint list.

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

WHILE DRIVING THE DRIVER'S AND ALL PASSENGERS' SEATS UNEXPECTEDLY RELEASE TO THE RECLNING POSITION. CAUSE UNKNOWN. PLESASE GIVE ANY FURTHER DETAILS. *AK

NHTSA ID 827029 · filed Aug 20, 1998

Too few reports in this category for a page of its own — they appear in the full complaint list.

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

1
report

From owner reports, verbatim

I HAD ZANESVILLE JOINT AND CLUTCH MAKE ME A NEW DRIVESHAFT FOR MY 1986 CHEVY G-20 VAN, BECAUSE MY OLD DRIVESHAFT WAS CREATING A VIBRATION. THIS NEW ONE PIECE DRIVESHAFT WAS APROX. 65.5" IN LENGTH FROM CENTER TO CENTER OF U-JOINT, USING 2.75" O.D. BY .065" WALL THICKNESS SEAMED TUBING. I INSTALLED THE NEW DRIVESHAFT THEN WENT FOR A DRIVE TO CHECK FOR ANY VIBRATIONS. THE ORIGINAL VIBRATIONS OCCURRED AT 55MPH WITH THE OLD DRIVESHAFT, AS I HAD EXPLAINED ALL OF THIS TO ZANESVILLE JOINT AND CLUTCH PRIOR TO THEM MAKING ME A NEW DRIVESHAFT. SO I GOT ON THE HIGHWAY TO TEST FOR VIBRATIONS AT 55MPH WITH THE NEW DRIVESHAFT. TO MY SURPRISE I NOTICED A VIOLENT VIBRATION FOLLOWED BY A CONSTANT BANGING, AS I THEN TRIED TO GUIDE THE VEHICLE TO THE BURM OF THE HIGHWAY. I GOT OUT OF THE VEHICLE TO FIND OUT THE CAUSE OF THE PROBLEM. TO MY SURPRISE THERE WAS ONLY HALF OF THE NEW DRIVESHAFT STILL ATTACHED TO MY VEHICLE. AS I LOOKED DOWN THE HIGHWAY IN TOTAL DISBELIEF I SAW THE OTHER HALF OF MY DRIVESHAFT. IT WAS THEN THAT I REALIZED I HAD NOT EVEN TRAVELED HALF OF A MILE ON THE HIGHWAY AT 55MPH. VISUALLY MY NEW DRIVESHAFT WAS DESTROYED ALONG WITH FLOOR BOARDS AND EXHAUST. IT WAS LATER AFTERI INSTALLED MY OLD ORIGINAL DRIVESHAFT THAT I FOUND MORE DAMAGES INCLUDING TRANSMISSION AND REAR DIFFERENTIAL. I CONTACTED ZANESVILLE JOINT AND CLUTCH AND WAS TOLD IT WAS THE OPERATORS FAULT AND THEY DID NOTHING TO CORRECT THE FAILURE. I CONTACTED THE OHIO ATTORNEY GENERAL AND THE OHIO BBB, AFTER ABOUT 2 YEARS OF REBUTTAL, TO RESOLVE MY ISSUE I GAVE A LIST OF DAMAGES AND PRICES OF NEW PARTS, BUT WAS REFUSED AND ONLY OFFERED A REFUND FOR MY DRIVESHAFT. WHICH I DID NOT EXCEPT. *TR

NHTSA ID 10206580 · filed Oct 22, 2007

Too few reports in this category for a page of its own — they appear in the full complaint list.

Seat belts

Reports naming seat belts, buckles, retractors and pretensioners.

1
report

From owner reports, verbatim

SEAT BELTS ON CONVERSION VAN ARE TOO SHORT, SEAT BELT WILL NOT HOLD CHILD SEAT, SEAT BELTS WERE PUT IN BY U.S. CONVERSION, DEALER SAID SEAT BELT ARE WRONG SIZE

NHTSA ID 980734 · filed Mar 14, 1996

Too few reports in this category for a page of its own — they appear in the full complaint list.

Steering

Reports naming the steering system — racks, columns, power-steering assist and steering linkage.

1
report

From owner reports, verbatim

BRAKE PADS FAILED.

NHTSA ID 516961 · filed May 6, 1997

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .