RoadVitals

1997 Chevrolet G30 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Jan 15, 2004
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
4
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
2

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1997 Chevrolet G30, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Airbags240.0%
  • Brakes120.0%
  • Fuel system120.0%
  • Visibility120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Airbags

Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.

2
reports

From owner reports, verbatim

WHEN I WAS IN AN AUTO ACCIDENT IN OCTOBER 1999 THE AIRBAG DIDN'T WORK IN THE VEHICLE I WAS DRIVING. ANOTHER VEHICLE STRUCK ME FROM BEHIND AND PUSHED ME INTO THE VEHICLE AHEAD. THE AIRBAG DID NOT WORK BECAUSE MY HEAD STRUCK THE STEERING WHEEL VERY HARD.IT LEFT ME BLEEDING IN MY BRAIN.

NHTSA ID 10070795 · filed Jan 15, 2004

ACCIDENT DUE TO BRAKE FAILURE, AIR BAGS DID NOT DEPLOY. VEHICLE WAS TOTALED. VEHICLE HAD BEEN BROUGHT IN FOR BRAKE PROBLEMS 4 TIMES PRIOR TO THE INCIDENT. *AK *ML

NHTSA ID 862763 · filed May 31, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

ACCIDENT DUE TO BRAKE FAILURE, AIR BAGS DID NOT DEPLOY. VEHICLE WAS TOTALED. VEHICLE HAD BEEN BROUGHT IN FOR BRAKE PROBLEMS 4 TIMES PRIOR TO THE INCIDENT. *AK *ML

NHTSA ID 862763 · filed May 31, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

1
report

From owner reports, verbatim

1997 CHEVROLET VAN STALLS WHEN IDLING OR DRIVING. ACTS AS IF FUEL SYSTEM SHUTS OFF - THERE IS NO WARNING OR UNUSUAL NOISE. AFTER STALLING, WILL NOT START IMMEDIATELY. BUT, WILL START IF ALLOWED TO COOL 5-30 MINUTES. PROBLEM HAS OCCURRED 6 TIMES BETWEEN MARCH 2001 AND JULY 3, 2001 -- FOUR TIMES WHILE IDLING, ONCE WHILE ON INTERSTATE HIGHWAY, AND ONCE ON A US HIGHWAY. HAVE TAKEN TO 3 DIFFERENT CHEVY DEALERS, BUT NONE HAVE FOUND ANY PROBLEM -- THERE ARE NO COMPUTER ERROR CODES OR OTHER SYMPTOMS THAT CAN BE FOUND BY DEALERS. ONE DEALER REPLACED FUEL PUMP AND REGULATOR IN EARLY MAY 2001 AND STATED THIS FIXED PROBLEM. BUT, SAME FAILURE OCCURRED ON JUNE 25, 2001. MOST RECENT FAILURE WAS ON JULY 3, 2001. VAN RUNS FINE EXPECT WHEN THIS INTERMITTENT FAILURE OCCURS. DEALERS STATE THAT THERE ARE NO MAINTENANCE BULLETINS DESCRIBING THIS PROBLEM. THIS PROBLEM IS SIMILAR TO NHTSA ODI ID 822086. ALSO, 5 DAYS BEFORE WE PURCHASED OUR VAN, WE HAD BOUGHT A GMC VAN OF SAME MODEL. IT FAILED THE SAME WAY (I.E., FUEL SYSTEM FAILURE) THE FIRST NIGHT WE DROVE IT, SO WE RETURNED IT TO DEALER AND GOT OUR MONEY BACK. THIS IS A SERIOUS SAFETY PROBLEM -- WE DARE NOT DRIVE ON INTERSTATE HIGHWAY BECAUSE WE MIGHT NOT BE ABLE TO MANUEVER VAN OFF THE ROAD WHEN IT STALLS, OR WE COULD BE HIT BY A VEHICLE (E.G., SEMI) BEHIND US BECAUSE WE SLOW DOWN ABRUPTLY. *AK

NHTSA ID 747804 · filed Jul 4, 2001

Too few reports in this category for a page of its own — they appear in the full complaint list.

Visibility

Reports naming windshields, glass, wipers, defrosters and mirrors.

1
report

From owner reports, verbatim

WHILE DRIVING WITH THE SIDE WINDOWS DOWN, OBJECTS (ROCKS, BUGS, BIRDS, ETC.)STRIKE EXTERIOR MIRRORS AND THEN BOUNCE OFF INTO VEHICLE, STRIKING DRIVER/PASSENGERS.

NHTSA ID 524323 · filed Nov 5, 1997

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .