RoadVitals

2001 Chevrolet G30 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Aug 16, 2004
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
5
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2001 Chevrolet G30, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes233.3%
  • Engine116.7%
  • Steering116.7%
  • Suspension116.7%
  • Transmission116.7%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

2
reports

From owner reports, verbatim

POWER ASSIST BRAKES AND STEERING FAILURE. REPAIRED BY DEALER (EA04012). *AK

NHTSA ID 10086961 · filed Aug 16, 2004

LEAKING REAR WHEEL BEARING SEAL DISCOVERED WHEN CHANGING TIRES AT 36000 MILES. OPPOSITE REAR WHEEL BEARING SEAL FAILURE AT 47000 MILES. 8/16/04 GREASE LEAKS ONTO BRAKE PADS AND DRUM RENDERING REAR BRAKES INEFFECTIVE. *AK 1ST FAILED SEAL REPLACED - OLD PART UNAVAILABLE - 2ND FAILED SEAL REPAIR PENDING WILL SAVE PART

NHTSA ID 10086955 · filed Aug 16, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

1
report

From owner reports, verbatim

CONSUMER HAS SIX 1997 B7 WITH 20000 MILES OR LESS AND THEY ARE ALL HAVING THE SAME PROBLEM. THE PROBLEM IS WITH THE DESIGN OF THE SEAL FOR THE EXHAUST BETWEEN THE MANIFOLD AND THE PIPES. THE DESIGN WAS CHANGED FROM CONSTANT TENSION TO A SOLID COLLAR WHICH IS CAUSING THE EXHAUST TO LEAK. *JG THE CONSUMER PURCHASED TWO 2001 G30 CHEVROLET MINI BUSES WITH 5.7 LITER ENGINES ONLY TO FIND OUT THAT THEY HAVE THE SAME DEFECT AT ONLY 4000 MILES.

NHTSA ID 566044 · filed Jun 10, 2002

Too few reports in this category for a page of its own — they appear in the full complaint list.

Steering

Reports naming the steering system — racks, columns, power-steering assist and steering linkage.

1
report

From owner reports, verbatim

POWER ASSIST BRAKES AND STEERING FAILURE. REPAIRED BY DEALER (EA04012). *AK

NHTSA ID 10086961 · filed Aug 16, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Suspension

Reports naming suspension components — springs, struts, shocks, control arms and related hardware.

1
report

From owner reports, verbatim

LEAKING REAR WHEEL BEARING SEAL DISCOVERED WHEN CHANGING TIRES AT 36000 MILES. OPPOSITE REAR WHEEL BEARING SEAL FAILURE AT 47000 MILES. 8/16/04 GREASE LEAKS ONTO BRAKE PADS AND DRUM RENDERING REAR BRAKES INEFFECTIVE. *AK 1ST FAILED SEAL REPLACED - OLD PART UNAVAILABLE - 2ND FAILED SEAL REPAIR PENDING WILL SAVE PART

NHTSA ID 10086955 · filed Aug 16, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Transmission

Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.

1
report

From owner reports, verbatim

THE VAN WAS PARKED ON AN INCLINE AND THE ENGINE TURNED OFF. THE DRIVER LEFT THE VEHICLE AND WAS IN A RESIDENCE. APPROXIMATELY 10 MINUTES AFTER LEAVING THE VEHICLE HE HEARD A CRASH. HE WENT OUT SIDE TO FIND THE VAN ROLLED DOWN THE DRIVEWAY AND INTO A SMALL WOODS. BOTH THE DRIVER AND THE CUSTOMER CHECKED THE STEERING COLUMN AND THE VEHICLE WAS IN PARK. 2ND INCIDENT - THE DRIVER WAS PARKED IN A DRIVEWAY, WITH THE MOTOR RUNNING. HE FELT THE VEHICLE START TO ROLL BACKWARD AND THEN "IT CAUGHT ITSELF" BEFORE HE APPLIED THE BRAKE.*AK

NHTSA ID 750144 · filed Aug 9, 2001

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .