RoadVitals

2004 Chevrolet Kodiak Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
5
Latest Jun 19, 2006
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
7
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Chevrolet Kodiak, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes114.3%
  • Engine114.3%
  • Powertrain (other)114.3%
  • Steering114.3%
  • Suspension114.3%
  • Tires & wheels114.3%
  • Transmission114.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

BRAKE WARNING LIGHT FOR SERVICE BRAKES CAME ON. SOFT BRAKE PEDAL. FURTHER INVESTIGATION REVEALED LOSS OF BRAKE FLUID AND BRAKE FLUID SPRAYED ALL OVER LEFT FRONT WHEEL, CHASSIS, AND FRAME. OUTSIDE BRAKE LINE FROM THE BRAKE PRESSURE MODULATOR HAD A HOLE LEAKING BRAKE FLUID. CAUSE OF WORN BRAKE LINE WAS FROM THE POWER STEERING HOSE COMING FROM THE HYDRAULIC PUMP TO THE INLET SIDE OF THE STEERING GEAR BOX. THE POWER STEERING HOSE WAS RUBBING AGAINST THE BRAKE LINE. POWER STEERING HOSE WAS REPLACED AND BRAKE LINE REPAIRED. DEFECTIVE BRAKE LINE IS AVAILABLE FOR INSPECTION. *JB

NHTSA ID 10157798 · filed May 18, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

1
report

From owner reports, verbatim

DT: THE CONTACT EXPERIENCE A PROBLEM WITH THE DIESEL ENGINE DYING WHILE THE VEHICLE WAS DRIVE. THE VEHICLE DID NOT STALL, BUT SIMPLY DIED AT ONCE WITHOUT WARNING. THE CHECK ENGINE LIGHT ILLUMINATED AS A WARNING, AND THE ENGINE SHUT OFF . THE VEHICLE WAS USED AS A HAULER THAT PULLED A TRAILER DELIVERING BOATS. WHEN THE ENGINE DIED THERE WAS A LOSS OF POWER, RESULTING IN A LOSS OF POWER STEERING AND THE BRAKES. THE ONLY WAY TO STOP THE VEHICLE WAS BY USING THE IN CAB CONTROLLER TO ACTIVATE THE ELECTRIC BRAKES ON THE TRAILER WHICH ULTIMATELY SLOWED AND STOPPED THE VEHICLE. THE VEHICLE HAS BEEN TO 18 DEALERSHIPS ACROSS THE COUNTRY IN AN ATTEMPT TO REPAIR THIS PROBLEM. THE DEALERS WERE CAUSE OF THE UNABLE TO DETERMINE THE PROBLEM. THE VEHICLE DID NOT PRODUCE ANY TYPE OF DIAGNOSTIC CODE. THEREFORE, NO REPAIRS OR CORRECTIONS WERE MADE. THE LATEST INCIDENT RESULTED IN A JACKKNIFE CRASH ON THE HIGHWAY. THERE WAS AN INJURY, AND A POLICE REPORT WAS TAKEN. THE VEHICLE WAS NOT BEING DRIVEN DUE TO THE RISK OF THIS PROBLEM OCCURRING AGAIN. *AK

NHTSA ID 10140314 · filed Oct 20, 2005

Too few reports in this category for a page of its own — they appear in the full complaint list.

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

1
report

From owner reports, verbatim

CONSUMER IS UNABLE TO KEEP VEHICLE STRAYED OUT OF THE LANE. FRONT END HAD BEEN DONE EIGHT TIMES. THE REAR AXLE WAS MOUNTED WRONGLY ON THE VEHICLE. *AK

NHTSA ID 10095131 · filed Oct 5, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Steering

Reports naming the steering system — racks, columns, power-steering assist and steering linkage.

1
report

From owner reports, verbatim

BRAKE WARNING LIGHT FOR SERVICE BRAKES CAME ON. SOFT BRAKE PEDAL. FURTHER INVESTIGATION REVEALED LOSS OF BRAKE FLUID AND BRAKE FLUID SPRAYED ALL OVER LEFT FRONT WHEEL, CHASSIS, AND FRAME. OUTSIDE BRAKE LINE FROM THE BRAKE PRESSURE MODULATOR HAD A HOLE LEAKING BRAKE FLUID. CAUSE OF WORN BRAKE LINE WAS FROM THE POWER STEERING HOSE COMING FROM THE HYDRAULIC PUMP TO THE INLET SIDE OF THE STEERING GEAR BOX. THE POWER STEERING HOSE WAS RUBBING AGAINST THE BRAKE LINE. POWER STEERING HOSE WAS REPLACED AND BRAKE LINE REPAIRED. DEFECTIVE BRAKE LINE IS AVAILABLE FOR INSPECTION. *JB

NHTSA ID 10157798 · filed May 18, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Suspension

Reports naming suspension components — springs, struts, shocks, control arms and related hardware.

1
report

From owner reports, verbatim

DT*: THE CONTACT STATED THE FRONT END OF THE VEHICLE SHOOK AT ANY SPEED. THIS CAUSED ABNORMAL WEAR TO THE FRONT TIRES, THE TIRES MUST BE REPLACED EVERY 10,000 MILES. THE DEALERSHIP WAS UNABLE TO DETERMINE A PROBLEM WITH THE VEHICLE, BUT DETERMINED THE TIRES ARE NOT RATED TO CARRY THE LOAD OF THE VEHICLE.

NHTSA ID 10150504 · filed Feb 17, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Tires & wheels

Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.

1
report

From owner reports, verbatim

DT*: THE CONTACT STATED THE FRONT END OF THE VEHICLE SHOOK AT ANY SPEED. THIS CAUSED ABNORMAL WEAR TO THE FRONT TIRES, THE TIRES MUST BE REPLACED EVERY 10,000 MILES. THE DEALERSHIP WAS UNABLE TO DETERMINE A PROBLEM WITH THE VEHICLE, BUT DETERMINED THE TIRES ARE NOT RATED TO CARRY THE LOAD OF THE VEHICLE.

NHTSA ID 10150504 · filed Feb 17, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Transmission

Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.

1
report

From owner reports, verbatim

DT*: THE CONTACT STATED THERE WERE NUMEROUS PROBLEMS WITH THE VEHICLE. AT 20,000 MILES, THE LEFT WHEEL BEARING BACKED OUT AND AT 87,000 MILES, THE DRAG LINK FAILED. WHILE DRIVING 80 MPH, THE VEHICLE SUDDENLY DOWN SHIFTED TO 20 MPH WITH NO EFFORT FROM THE CONTACT. WHILE STARTING THE VEHICLE, THE RPM WILL NOT GO BEYOND 2000. THE VEHICLE HAS BEEN TAKEN TO THE DEALER ON NUMEROUS OCCASIONS AND THEY CAN NOT DETERMINE THE PROBLEM. THIS OCCURRED REGARDLESS OF THE TRAFFIC CONDITIONS, SPEED OR TERRAIN.*AK

NHTSA ID 10160174 · filed Jun 19, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .