2005 Chevrolet Malibu Classic Problems

IGNITION SWITCH PROOBLEMS

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU CLASSIC. WHILE ATTEMPTING TO START THE VEHICLE, THE ANTI-THEFT INDICATOR ILLUMINATED AND THE ENGINE WOULD NOT START. MIDWAY CHEVROLET(381 12TH ST, PLAINWELL, MI) WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 190,000.

driving the car it just shuts off which results in no power no steering and no brakes possibly an ignition switch problem.

I CAN'T USE POWER STEERING FLUID IN MY CAR BECAUSE I'VE BEEN TOLD IT'S ELECTRICAL. I WAS PULLING OUT OF MY APARTMENT BUILDING AND I CAME UP TO A RED LIGHT UP THE ROAD TO TURN LEFT. I STOPPED AT THE LIGHT FOR A MINUTE, AS THE LIGHT TURNED GREEN I CONTINUED AN THATS WHEN THE PROBLEM OCCURRED. I COULDN'T BARELY TURN MY STEERING WHEEL AND ITS HARD AN THATS WHEN "POWER STEERING" POPPED UP ON MY DASH. MY STEERING WHEEL SHAKES UNCONTROLLABLY AND I'M SCARED TO DRIVE IT AND ITS MY ONLY TRANSPORTATION TO AND FROM MY JOB.

While driving on the interstate while using the cruise control, the vehicle started increasing speed and rpm’s. I could not turn off cruise by braking or using the off button on steering wheel. I had to put it in neutral which caused the engine to redline in rpm’s, so I could use brakes to safely stop on the side of the interstate highway. I turned off the engine and opened the hood to look inside. I turned ignition back on and immediately the engine revved to redline rpm’s again.

driving the car it just shuts off which results in no power no steering and no brakes possibly an ignition switch problem.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE ANTI-THEFT SYSTEM WARNING INDICATOR FLASHED AND THE VEHICLE COULD NOT BE STARTED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP WAS DEFECTIVE. THE FUEL PUMP WAS REPLACED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 36,000.

MAY BE FUEL PUMP. CAR WILL TURN OVER BUT WON'T START.

THE THEFT SYSTEM KEEPS GOING OFF FOR NO REASON LEAVING ME STRANDED FOR 10-15 MINUTES. IT HAPPENED TO TURN OFF WHILE DRIVING ON THE HIGHWAY 3 TIMES IN THE PAST THE WHOLE DASH BOARD LIT UP AND THE THEFT SYSTEM LIGHT WAS BLINKING. IT ALSO HAPPENS WHILE I INITIALLY START THE CAR UP.

I CAN'T USE POWER STEERING FLUID IN MY CAR BECAUSE I'VE BEEN TOLD IT'S ELECTRICAL. I WAS PULLING OUT OF MY APARTMENT BUILDING AND I CAME UP TO A RED LIGHT UP THE ROAD TO TURN LEFT. I STOPPED AT THE LIGHT FOR A MINUTE, AS THE LIGHT TURNED GREEN I CONTINUED AN THATS WHEN THE PROBLEM OCCURRED. I COULDN'T BARELY TURN MY STEERING WHEEL AND ITS HARD AN THATS WHEN "POWER STEERING" POPPED UP ON MY DASH. MY STEERING WHEEL SHAKES UNCONTROLLABLY AND I'M SCARED TO DRIVE IT AND ITS MY ONLY TRANSPORTATION TO AND FROM MY JOB.

WE BOUGHT A 2005 CHEVY MALIBU CLASSIC BASE MODEL FROM A REPUTABLE DEALER. EVERYTHING WAS WORKING FINE UNTIL MY SON FLIPPED THE SWITCH ON THE TURN SIGNAL INDICATOR FOR THE LIGHTS FROM "AUTO" TO FULL LIGHTS AT NIGHT. THE DASH CLUSTER ILLUMINATION WENT OUT ALONG WITH THE RADIO BACK LIGHTING, HVAC BACK LIGHTING, DOOR LOCK AND WINDOW SWITCH LIGHTING. THE DOME LIGHT STOPPED WORKING. THE DOME LIGHT HAD BURNED WIRES AND THE PLASTIC FIXTURE WAS BURNED. REPLACED IT BACK TO THE HARNESS. FUSES KEPT BLOWING. HAVE SINCE TRIED REPLACING THE TURN INDICATOR/LIGHTS/WIPER MODULE, THE DIMMER SWITCH, AND DASH CLUSTER, UPON INSPECTING THE BODY CONTROL MODULE I FOUND CORRODED MODULE CONNECTORS THAT WERE CORRODED AND BURNED. NOW THE CAR WON'T START AND THE SUSPECT IS THE ANTI-THEFT SYSTEM. THIS IS CLEARLY AN ELECTRICAL MALFUNCTION FROM THE ASSEMBLY LINE AND THOUSANDS OF DOLLARS IN WASTE BY MYSELF MY SON AND OTHERS REPORTING ACROSS THE INTERNET WITH THE SAME PROBLEMS AS OURSELVES. *TR

I PURCHASED THIS VEHICLE VERY USED AT 143XXX MILES, FROM A "REPUTABLE" DEALER. I GOT A TUNE UP AS WELL AS AN OIL CHANGE, STANDARD USED CAR PURCHASE PROCEDURE. MY DAD INITIALLY BROUGHT TO MY ATTENTION THAT WHILE DRIVING MY FUEL GAUGE DROPPED DOWN TO E, THE LOW GAS LIGHT LIT UP AND THE CHECK ENGINE LIGHT CAME ON. A LOCAL AUTO PARTS STORE SAID I SHOULD USE A FUEL INJECTION KIT FOR THE CHECK ENGINE LIGHT. NOW I HAVE 146XXX MILES AND IT HAPPENS EVERY SINGLE TIME I GET GAS. IT'S NERVE RACKING BECAUSE I DO DRIVE FREQUENTLY AND MY MAIN CONCERN IS HOW MUCH GAS DO I HAVE? I CAME ACROSS A GUY THAT WORKS AT A DIFFERENT AUTO STORE AND HE SAID IT'S PROBABLY MY SENDER UNIT FOR MY GAS TANK, WHICH SHOULD COST ABOUT $300 TO FIX DEPENDING ON WHERE I TAKE IT. MY NEXT SET OF ISSUES IS MY HORN, I WAS UNAWARE THAT IT DIDN'T WORK UPON PURCHASING UNTIL I WENT TO HONK IT AND NOTHING HAPPENED. I TOOK IT TO MIDAS AND THEY REPLACED THE FUSE. AFTER DRIVING IT HOME THE HORN STOPPED WORKING AGAIN. I HEARD IT'S JUST SOME WIRES TOUCHING BUT NOBODY DOES ELECTRICAL WORK. TODAY, A FRIEND ASKED IF MY TURN SIGNALS WERE WORKING. I SAID THEY DID AND HE SAID THEY WERE BURNT UP, PLASTIC AND ALL. I LOOKED AND SURE ENOUGH THEY WERE MELTED AND THE LIGHT ITSELF WAS BLACK ON THE INSIDE AND IT LOOKED LIKE IT'S ON THE VERGE OF SHATTERING. HE ASKED IF THERE WERE RECALLS ON ANYTHING WITH THIS CAR, I TOLD HIM I CALLED A LOCAL CHEVY DEALER AND THE GUY INSISTED OTHERWISE. NOW, I CHECKED THIS WEBSITE AND BOTH THE GAS AND LIGHTS ARE ON A LIST OF RECALLS. APPARENTLY, NOT ALL DEALERS KNOW HALF THE INFORMATION THEY SHOULD FOR CONCERNED DRIVERS. *TR

WHILE CHECKING OUT MY DAUGHTERS 2005 MALIBU CLASSIC FOR COMPLAINTS ABOUT INTERMITTENT AIRBAG LIGHT I HAPPENED TO SLIGHTLY TUG ON HER KEYCHAIN WHILE DRIVING ABOUT 50 MPH ON THE HIGHWAY. THE ENGINE SHUT OFF. I LOST POWER STEERING. I LOST POWER BRAKES. I COULD NOT RESTART THE CAR WHILE IT WAS MOVING. LUCKILY I WAS ABLE TO PULL IT OVER TO THE SIDE OF THE ROAD. IT WOULD NOT RESTART UNTIL I PUT THE SHIFT LEVER INTO PARK. I INVESTIGATED THIS ON THE INTERNET AND FOUND OTHER GM VEHICLES BEING RECALLED BUT NOT THIS ONE. I CALLED GM'S RECALL LINE. THEY SAID TO CONTACT MY DEALER. I ASKED THE DEALER TO MAKE SOME KEYS WITH A CENTER HOLE RATHER THAN A SLOT (AT MY EXPENSE) TO PREVENT THE IGNITION SWITCH FROM ROTATING TO ENGINE OFF WHEN A KEYCHAIN IS ATTACHED. THEY SAID THEY COULD NOT DO IT WITHOUT GM AUTHORIZATION. I AM CONCERNED ABOUT MY FAMILY MEMBERS USING THIS VEHICLE. LUCKILY NO ONE WAS HURT. *TR

THIS CAR HAS HAD THE CALIPERS REPLACED 2 TIMES NOW. THE FIRST IS RECORDED HERE AND THE SECOND OCCURRED ON JAN. 15, 2014. BOTH TIMES THE CAR LOST FLUID DUE TO CALIPER LEAKAGE. HAD DIFFICULTY STOPPING THE CAR THE SECOND TIME AROUND BUT WAS ABLE TO BRING IT TO A STOP WITHOUT INCIDENT. I HAVE A LICENSED MECHANIC TELLING ME THIS IS NOT NORMAL WEAR AND TEAR. THE FIRST INCIDENT PAID FOR WAS $285 AND THE SECOND WAS IN EXCESS $600. THIS IS NOT PART OF A RECALL BUT AM CERTAIN THAT THIS SHOULD NOT BE OCCURRING. SHOULD THIS RESULT IN A DETERMINATION OF FACTORY ERROR, IT WOULD BE GOOD TO GET REIMBURSED FOR THE HEAVY OUT OF POCKET EXPENSE. *JS

driving the car it just shuts off which results in no power no steering and no brakes possibly an ignition switch problem.

TAKATA RECALL ON 01/10/2012 , I WAS IN A CRASH ,, INVOLVING A AIR BAG DEPOLYMENT IN WHICH , THE AIR BAR DEPLOYED DURRING A CRASH , , I REAR ENDED A CAR AFTER IT HAD STOPPED SUDDENDLY AFTER A PEDIESTRAIN HAD CROSSED THE STREET , UNEXPECTALLY , ,, AFTER THE SUDDEN DEPLOYMENT OF THE AIR BAG , SO MUCH MATERAIL HAD BLOWEN OUT OF THE AIR BAG , HITTING MY HAND , MOST OF THE INJURY WAS ON MY FACE AREA MOUTH WAS BLEEDING AS THE MATERAIL HAD STRUCK MY MOUTH AREA , ,, I THOUGHT THE CAR WAS ON FIRE , FROM THE SMOKE AND MATERAIL EXPLOIDED OUT OF IT , I HAD A HARD TIME SLEEPING AND WAS VERY DISTRUBED BY IT , THE CAR WAS TOWED TO THE JUNK YARD , AS THE INSURANCE COMPANY TOOK THE CAR , AS IT WAS JUNKED , CAN PROVIDE POLICE REPORT AND INSURANCE DOCUMENTS , JUST NEED SOME TIME TO RETRIVE THEM ,

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT IT WAS DIFFICULT TO REMOVE THE KEY FROM THE IGNITION DUE TO THE GEAR SHIFTER NOT BEING IN THE PARK POSITION, ALTHOUGH THE SHIFT INDICATOR DISPLAYED PARK. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. MAGEE AUTOPLEX CHEVROLET (2127 WASHINGTON ST, FRANKLINTON, LA 70438, (866) 551-5128) WAS CONTACTED AND AN APPOINTMENT WAS MADE TO HAVE THE VEHICLE REPAIRED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,596.

THE KNOB YOU CHANGE GEARS WITH HAS A PIN IT AND THE PIN HAS BROKEN. IT GOT TO BE A PROBLEM WHEN I WHEN TO THE JUNK YARD TO BUY A KNOB ALL OF THEM WAS BROKEN IT IS VERY HARD TO FIND IN THE JUNK YARD . WILL YOU PLEASE HELP ME FIND ONE I AM 75 YEARS OLD AND I DON'T KNOW WHAT TO DO SOME TIME WHEN I TRY TO PUT THE CAR IN GEAR IT WILL NOT MOVE. ONE AUTO REPAIRMAN SAY I WILL HAVE TO REPLACE THE WHOLE DRIVE CONSOLE. PLEASE HELP ME!!! *TR

I CAN'T USE POWER STEERING FLUID IN MY CAR BECAUSE I'VE BEEN TOLD IT'S ELECTRICAL. I WAS PULLING OUT OF MY APARTMENT BUILDING AND I CAME UP TO A RED LIGHT UP THE ROAD TO TURN LEFT. I STOPPED AT THE LIGHT FOR A MINUTE, AS THE LIGHT TURNED GREEN I CONTINUED AN THATS WHEN THE PROBLEM OCCURRED. I COULDN'T BARELY TURN MY STEERING WHEEL AND ITS HARD AN THATS WHEN "POWER STEERING" POPPED UP ON MY DASH. MY STEERING WHEEL SHAKES UNCONTROLLABLY AND I'M SCARED TO DRIVE IT AND ITS MY ONLY TRANSPORTATION TO AND FROM MY JOB.

I PURCHASED A 2005 CHEVY MALIBU CLASSIC. THE ANTI THEFT SYSTEM COMES ON AS THE OPERATOR DRIVES THE CAR. I HAVE BEEN DRIVING SEVERAL TIMES AND THE VEHICLE JUST LOST ALL ACCELERATION. EVERY WEEK I HAVE PROBLEMS GETTING THE VEHICLE TO START BECAUSE THE ANTI THEFT SYSTEM COMES AS THE OPERATOR TURNS THE IGNITION ON. THIS IS A VERY SERIOUS AND DANGEROUS PROBLEM. I STRONGLY FEEL THAT THIS CARS SHOULD AND NEEDS TO BE RECALLED. *TR

METAL ON METAL RATTLING SOUNDS COMING FROM THE FRONT END OF THE CAR. THE NOISE IS LOUD. SOUNDS UNSAFE LIKE SOMETHING IS GOING TO FALL OFF OR FREEZE UP. TOOK THE CAR TO MY REPAIR GUY AND THEY COULD NOT FIND ANYTHING WRONG. WE THE(REPAIR) GUY AND I TOOK IT FOR A TEST DRIVE. THEY SAID IT'S SOUNDS BAD BUT, DIDN'T FIND ANYTHING WRONG. HE SAID THEY COULD START REPLACING PARTS BUT WILL NOT GUARANTEE UNTIL THE ACTUAL PART (S) ARE FOUND IF ANY. *TR

ON 4-28-06 I WAS BACKING OUT OF MY DRIVE WAY AND TURNED THE STEERING WHEEL AND HEARD A CLICKING AND A POPPING NOISE. AS I PROCEEDED TO DRIVE GETTING UP SPEED TO ABOUT 45 MPH, OUR ROAD HAS SLIGHT BUMPS IN IT, I HEARD THE SAME NOISE. THIS PROBLEM HAS CONTINUED BUT IS NOW LOUDER, IT IS IN THE FRONT END. I HAVE ONLY HAD THE CAR THREE MONTHS AS OF TODAY 6-24-06. SO THE FIRST WEEK OF MAY '06 I TOOK THE CAR BACK TO THE DEALERSHIP WHERE I GOT IT THEY KEPT THE CAR FOR THREE DAYS AND SAID THERE IS NOTHING WRONG I DROVE THE MECHANIC IN MY CAR AND HE HEARD THE SAME NOISE SAID KEEP DRIVING IT. I AM A MECHANIC MYSELF AND KNOW SOMETHING IS WRONG I THOUGHT CV JOINTS SO I LEFT. SO I CALLED THE CHEVROLET DEALER IN MY TOWN AND ASK IF THEY WOULD LOOK AT IT AND THEY HAVE AND SAID THEY DIDN'T THINK ANYTHING MAJOR WAS GOING ON AND ONE MECHANIC SAID HE THOUGHT IT WAS A STEERING PROBLEM AND HE WOULD HAVE TO TAKE THE STEERING WHEEL OUT AND GREASE SOMETHING, BUT THEY WILL LOOK TO EASE MY MIND. NOW YESTERDAY I RAN INTO A MAN WHO BOUGHT A '05 FOR HIS WIFE AND I ASK IF HE HAS HAD PROBLEMS WITH HIS CAR CLICKING AND POPPING IN THE FRONT END AND HE SAID YES AND TOOK HIS TO THE SAME PLACES I HAVE AND TOLD HIM THE SAME THING AND IF I FIND ANY THING WRONG OUT TO LET HIM KNOW AND HE WILL ALSO COMPLAIN. I DON'T FEEL SAFE AT ALL AND ESPECIALLY WITH MY FAMILY IN THERE ALSO. *NM

I PUT DOWN THE BACK WINDOWS AND NOW THEY WON'T GO BACK UP. I HAVE AN '05 MALIBU AND RARELY USE THE WINDOWS. THE MOTOR SHOULD NOT HAVE WENT (IF THAT IS IN FACT THE PROBLEM). I WILL NOT BE ABLE TO PUT MY INFANT IN THE CAR IN THE WINTER IF THIS PROBLEM ISN'T FIXED? *TR

MY WINDSHIELD WIPERS WILL WORK SOMETIMES AND NOT OTHERS, I REPLACED THE FUSE. IN THE RAIN WIPERS WILL BE WORKING FINE, THEN QUIT ALL OF A SUDDEN. MY MECHANIC COULD FIND NOTHING WRONG. IF YOU DO NOT TAKE THE FUSE OUT NOW, THE WIPERS WILL STAY ON CONSTANTLY. IF YOU WANT TO USE THEM NOW YOU HAVE TO PUT THE FUSE BACK IN TO MAKE THEM WORK. YOU HAVE TO HOPE YOU CAN PULL OVER SAFELY ONCE THE RAIN STARTS. I AM CONSTANTLY USING RAIN X WHEN IT LOOKS LIKE RAIN. THIS IS THE 2ND ELECTRICAL PROBLEM I HAVE HAD WITH MY 2005 CHEVY MALIBU. *TR

NO INCIDENT,CRASH AND NO INJURY. MY CHEVROLET MALIBU-CLASSIC 2005 HAS THE PROBLEM WITH - AC CONTROL HEAD -FP # 22718118 ,DESCRIPTION CONTROL 9.273, UNIT PRICE $206 ,TOTAL PRICE$ 345.12 THATS MY WEEKLY CHECK,AND I THINK THAT IS THE MANUFACTURERS PROBLEM-DEFECTS FOR RECALLS. *TR

DT*: THE CONSUMER STATED THE ENGINE STALLED WITHOUT PRIOR WARNING. WHEN THIS OCCURRED THERE WAS A LOSS OF ALL POWER AND NO WARNING LIGHTS ILLUMINATED. THE CONSUMER WAS DRIVING AROUND A SHARP CURVE WHEN THE ENGINE STALLED AND LOST CONTROL OF THE VEHICLE. ALTHOUGH THERE WAS A CRASH, THERE WERE NO INJURIES OR DAMAGE TO THE VEHICLE. THE POLICE WERE NOT CONTACTED. THE VEHICLE WAS SEEN BY A DEALER, BUT THE SERVICE DEPARTMENT WAS UNABLE TO DUPLICATE THE PROBLEM. IN ADDITION TO THE STALLING PROBLEM, THE TRUNK LID LEAKED ALLOWING RAIN TO ENTER THE TRUNK COMPARTMENT. THE TRUNK CARPETING WAS REPLACED, BUT THE TRUNK LID CONTINUES TO LEAK. PRIOR TO THE PROBLEMS, THE VEHICLE WAS EXPOSED TO A HURRICANE BUT DID NOT HAVE ANY FLOOD DAMAGE. *JB

FRONT DRIVER SEAT WELD BROKEN. SEAT LEANS TO SIDE. UNCOMFORTABLE DRIVING AND UNSAFE.