1999 Chevrolet Malibu Tires & wheels Problems

VEHICLE WAS UNABLE TO PASS INSPECTION DUE TO TIRE (TREAD) SEPARATION ON ALL 4 BRIDGESTONE POTENZA 'S INSPECTOR POINTED OUT THAT ALL 4 TIRES WERE CRACKED THROUGHOUT THE ENTIRE CIRCUMFERENCE ON ALL 4 TIRES AND DANGEROUS/HAZARDOUS TO DRIVE ON. HAD TO PURCHASE NEW TIRES IN ORDER TO PASS INSPECTION... HAVE TAKEN PHOTOS OF ALL THE TIRES... TIRES WERE PURCHASED IN OCT, 2010 AND REPLACED IN NOV, 2015 -- TIRE HAD A TOTAL OF 24,183 MILES ON IT... AND STILL HAS PLENTY OF TREAD LEFT.

NHTSA ID

10807168

Incident

Nov 10, 2015

Mileage

179,311 mi

ON 6 AUGUST 2010, I PURCHASED 3 TIRES FROM RAY'S TIRE & SERVICE IN ST. AUGUSTINE, FL 32084, HAVING A GOODYEAR LOGO TOUTED ON THEIR INVOICE AND A HUGE GOODYEAR SIGN ON THEIR BUILDINGS, THEREFORE, ONE WOULD ASSUME THAT TIRES BEING BOUGHT AND INSTALLED ARE GOODYEAR... WELL THAT'S NO SO... WHILE DRIVING TO CLEVELAND, OHIO SUBURB LAST MONDAY (20 SEPT 10), MY LEFT FRONT TIRE SEPARATED ON I-75 RUNNING AT APPROX 74 MPH HEADING NORTH IN LONDON, KY. HAD IT BEEN A WOMAN DRIVER WITH LESSER DRIVING SKILLS, LORD ONLY KNOWS THE HORRORS. UPON RETURNING TO TOWN AND VISITING RAY'S TIRE FOR A REBATE, I WAS TOLD IT WAS NOT RESPONSIBLE AND THAT TIRE INSTALLED WAS A KUMO TIRE... NOT A GOODYEAR... THUS, I ASK THOSE OF YOUR OVERSEEING HIGHWAY SAFETY, IS THIS ACCEPTABLE AS A "TRUTH-IN-ADVERTISING" ISSUE? THUS I ASK OF YOU OVERSEEING HIGHWAY SAFETY, IS THIS ACCEPTABLE TO GOODYEAR CORPORATE BOARD OF DIRECTOR STEWARDSHIP? THUS I ASK, IS THIS ACCEPTABLE FROM A HIGHWAY SAFETY STANDPOINT AND TRUSTWORTHY, THE AVERAGE CONSUMER CAN FEEL COMFORTABLE WITH? THIS 84 YEAR OLD WW II OVERSEAS VETERAN CONSUMER DOES NOT BELIEVE SO AND FEELS STRONGLY YOU SHOULDN'T EITHER. *TR

NHTSA ID

10357452

Incident

Sep 20, 2010

Mileage

141,960 mi

ON JUNE 18, 2010 I HAD AN ACCIDENT THAT I BELIEVE WAS CAUSED BY A TIRE FAILURE. NO OTHER VEHICLES WERE INVOLVED IN THIS ACCIDENT AND THERE WERE NO INJURIES. THE VEHICLE WAS DECLARED A TOTAL LOSS BY MY INSURANCE COMPANY. ON JUNE 18, 2010 AT APPROXIMATELY 6:00PM I WAS DRIVING ON THE PENNSYLVANIA TURNPIKE. MY VEHICLE WAS HEADED WEST SOMEWHERE BETWEEN THE DONEGAL EXIT AND THE NEW STANTON EXIT OF THE TURNPIKE. THE WEATHER CONDITIONS WERE WHAT I CONSIDER IDEAL DRIVING CONDITIONS. I WAS IN THE RIGHT LANE OF THE TWO LANE ROADWAY AND AS I WAS APPROACHING A MODERATE CURVE IN THE ROADWAY MY VEHICLE PULLED SEVERELY TO THE LEFT, I ATTEMPTED TO CONTROL THE VEHICLE BY USING THE STEERING WHEEL AND MODERATE PRESSURE ON THE BRAKES. NO AMOUNT OF CONTROL I TRIED TO EXERT WAS OF ANY VALUE AND WITHIN SECONDS MY VEHICLE HAD STRUCK THE JERSEY BARRIER ON THE LEFT SIDE OF THE HIGHWAY AND SPUN INTO A POSITION AGAINST THE RIGHT JERSEY BARRIER FACING TRAFFIC. I WOULD LIKE TO ADD HERE THAT I HAD OWNED AND DRIVEN THIS VEHICLE FOR OVER 10 YEARS AND APPROACHING 75,000 MILES, I WAS COMPLETELY ACCUSTOMED TO MAINTAINING CONTROL OF THIS VEHICLE EVEN WHILE DRIVING UNDER THE WORST OF CONDITIONS AT HIGHWAY SPEEDS. AT THE TIME OF THE ACCIDENT MY VEHICLE WAS EQUIPPED WITH FOUR P215/60R15 93T YOKAHAMA AVID TOUR S S319 BW SERIAL NO. M6ORPLHR1410 TIRES. THESE TIRES WERE PURCHASED AND MOUNTED ON JUNE 15, 2010 AND HAD APPROXIMATELY 150 MILES ON THEM. THE IMMEDIATE AND SEVERE LOSS OF THE CONTROL I EXPERIENCED IS THE BASIS FOR MY OPINION THAT ONE OF THESE TIRES FAILED CATASTROPHICALLY TO CAUSE THIS ACCIDENT. MY AUTO INSURANCE COMPANY HAS RESEARCHED THE MATTER AND FOUND THAT THERE WERE NO MANUFACTURER RECALLS, INVESTIGATIONS, OR TECHNICAL SERVICE BULLETINS RELATING TO THE CONDITIONS DESCRIBED. I URGED THEM TO MAKE A PHYSICAL INSPECTION OF THE VEHICLE TO DETERMINE IF THE TIRES OR ANY OTHER DEFECT OF THE VEHICLE COULD HAVE CAUSED THE LOSS OF CONTROL, BUT THEY WERE UNWILLING TO DO SO. UPDATED IVOQ 09/22/10 *TR UPDATED 10/2811

NHTSA ID

10349637

Incident

Jun 18, 2010

Mileage

90,380 mi

ROTOR REPLACEMENT X 3. SUSPENSION - FRONT REPLACED. CALIPERS X3. TIRE WEAR AND LEAKS - REPLACED ANNUALLY. RADIO - BAD WIRING. A/C IN DASH WIRING REPLACED TWICE. REAR LIGHT ASSEMBLY REPLACED TWICE. LEAKING IN REAR LIGHT ASSEMBLY AND TRUNK. COOLANT LEAK - 8/06 AT 74000 MILES. MECHANIC BELIEVES IT IS THE WATER PUMP. A/C SENSOR REPLACED. *NM

NHTSA ID

10166043

Incident

Aug 18, 2006

Mileage

5,000 mi

I'VE HAD 2 TIRES MANUFACTURED BY COOPER TIRE FAIL DUE TO FAULTY CONSTRUCTION. BOTH TIRES HAVE FAILED WITHIN THE PAST YEAR. THEY ARE 215/60R15 AVENGER GT RWL TIRES MANUFACTURED BY COOPER TIRES AND I PURCHASED THEM AT KAUFFMAN TIRES. SERIAL #U9MWFF6032. *NM

NHTSA ID

10161400

Incident

Jul 1, 2006

THE CONSUMER SMELLED FUEL WHILE DRIVING. SHE THEN OBSERVED FUEL DRIPPING ONTO THE GROUND WHILE PARKED, THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. IT WAS DETERMINED THAT THE FUEL LINE WAS LEAKING AT THE FUEL FILTER CONNECTOR DUE TO CORROSION. THE CONSUMER FEELS THE MANUFACTURER SHOULD BE 100% RESPONSIBLE FOR REPLACING THE FUEL LINE. THE CONSUMER HAS HAD OTHER COMPONENTS FAIL ON THE VEHICLE. ALL FOUR TIRES WERE REPLACED DUE TO CENTER TREAD WEAR. THE FRONT BRAKE PADS WERE REPLACED AT 20000 MILES AND AGAIN AT 41313. THE DRIVER'S SIDE SUNVISOR BROKE. BOTH FRONT WHEEL HUB ASSEMBLIES WERE REPLACED DUE TO BEARING FAILURE AT 41313 MILES. BOTH FRONT BRAKE ROTORS WERE REPLACED AT 41313 MILES. *JB *NM

NHTSA ID

10074219

Incident

May 21, 2004

Mileage

41,695 mi

WHILE DRIVING ON THE HIGHWAY, THE RIGHT FRONT TIRE BLEW OUT AND HAD COME APART. ALSO, THE LEFT TIRE BLEW OUT AND SEPARATED UPON PULLING INTO A REPAIR SHOP TO FILL THE TIRE WITH AIR BECAUSE AIR WAS SEEPING OUT. THE CAUSE OF THE BOTH TIRE BLOWOUTS WAS NOT DETERMINED. *AK *SC *JB

NHTSA ID

10063396

Incident

Apr 3, 2003

Mileage

50,000 mi

AIR CONDITIONING CONTROL PROBLEMS DEALER INSISTED NOTHING WRONG NEVER REPAIRED TIRES; WORN OUT AT 16000 DEALER INSISTED THAT THAT WAS NORMAL FOUGHT TO GET THEM TO REPLACE ONLY 2 TIRES ENGINE: INTAKE MANIFOLD GASKET WENT OUT NEVER EXPERIENCED THE PROBLEM IN ALL THE CARS I EVER OWNED 978.00 LATER. ENGINE 3 MONTHS LATER PRESENTLY ENGINE HAS SERIOUS INTERNAL ENGINE RATTLE, LOSE OF POWER DON'T KNOW WHAT IS WRONG YET THERE WAS NO INDICATION OF PROBLEM OIL WAS CLEAN NO TEMP PROBLEM JUST BLEW LAST WEEK TOWED TO THE HOUSE BRAKES; HAD TO CHANGE BOTH FRONT CALIPERS COULD NOT RE USE THEM NEEDED NEW ONES WHEN DOING BRAKE JOB WOULD NEVER BUY A CHEVY PRODUCT EVER AGAIN!!!!

NHTSA ID

10069757

Incident

Apr 15, 2003

Mileage

16,000 mi

SINCE I'VE HAD THE CAR, THE BRAKES HAVE BEEN REPLACED TWICE, ROTORS REPLACED (ALSO CLEANED AND OTHER THINGS-TO THE POINT THEY ASKED ME TO SEE IF THERE WAS A RECALL ON BRAKES AND ROTORS). THE RIGHT FRONT PASSENGER WINDOW WILL NOT WORK FROM THE DRIVER SIDE TO ROLL DOWN BUT CAN STILL ROLL IT UP FROM THERE. THE AIR CONDITIONER BUTTON(RESISTOR) NEEDED REPLACING AND THEN THE VENT BUTTON(RESISTOR) NEEDED REPLACING. ALSO, HAD TO REPLACE TIE ROD END AND WHEEL BEARING . NOT TO MENTION A WATER PUMP. WE BOUGHT THE CAR USED FROM SAWYER CHEVROLET WITH 38,000 MILES ON IT. IT NOW HAS 76,000. BUT WITHIN A YEAR AND A HALF OF OWNING IT, THIS IS ALL THE WORK WE HAD TO PUT INTO IT. I'VE NEVER HAD A CAR THAT NEEDED ALL THAT REPAIRING DONE BEFORE IT REACHED 100,000 MILES. PLUS WE HAD TO GET NEW TIRES BECAUSE THEY HAD FIRESTONE TIRES ON THEM THAT WERE WARPING, ETC. BUT SAWYERS REFUSED TO REPLACE THEM AND FIRESTONE DID NOT GET BACK TO US IN TIME BEFORE OUR VACATION. SO WE PUT NEW TIRES ON OURSELVES.

NHTSA ID

10052894

Incident

Jan 2, 2004

THIS 1999 CHEVROLET MALIBU WAS PURCHASED IN JULY 2001 IN HAD A WATER LEAKING PROBLEM TOOK 3 TRIES BEFORE THEY FOUND IT NEEDED THERMOSTAT GASKET DIDN'T EVEN HAVE ONE IN IT THEY SOLD IT TO ME .THIS WAY WITH A PROMISE IT HAD BEEN FIXED. WITHIN THE FIRST YEAR I HAD THE CAR THEY HAD TO REPLACE BOTH FRONT WHEEL BEARINGS & STRUT BUSHINGS. THEN THE ALTERNATOR WENT OUT & IT CAUSE MY BATTERY TO GO BAD OVERCHARGED IT THEY REPLACED ALTERNATOR BUT REFUSED TO RE-EMBURSE ME FOR THE BATTERY. THEN IGNITION SWITCH CAUSED PROBLEM WITH ANTI-THEFT SYSTEM WOULD NOT START. HAD THAT REPLACED IN MARCH 2002. THEN ANTI-LOCK BRAKE SYSTEM WENT OUT HAD TO HAVE IT REPLACED WINDOW SWITCH VERY SLOW HAD TO BE CLEANED ANOTHER ONE NOT WORKING AT ALL NOW, NOT COVERED UNDER WARRANTY, AT THIS TIME ALSO HAD TO HAVE ANTI THEFT SYSTEM FIXED AGAIN LIGHT ON ALL THE TIME ANOTHER BAD IGNITION SWITCH. ALSO HAD BLOWER MOTOR & RELAY SWITCH FOR HEATER TO GO OUT OVER THE SUMMER MOST OF THE INTERIOR LIGHTS HAVE LONG AGO BURNT OUT & HAD TO BE REPLACED LOCK OUT FOR TRUNK LID ALSO BROKE NOT COVERED ON WARRANTY. HUB CAPS HAVE LUG NUTS MADE IN THEM THAT SCREW ONTO YOUR LUG BOLTS STRIPPED OUT WHEN TOOK FOR REPAIRS BY DEALER REFUSED TO REPLACE THEM BECAUSE THEY COST $500.00 FOR A NEW SET. SO I PURCHASED THE LUG NUT PART & REPALCED IT MYSELF AT A DEALERSHIP FOR $10.00 SET OF 5. NOVEMBER OF 2002 BRAKES & ROTORS WERE REPLACED IN JAN. 2003 BRAKE PADS REPLACED AGAIN IN MARCH 2003 PADS REPLACED AGAIN IN JULY 2003 PADS REPLACED ONCE AGAIN THEN IN SEPT. 2003 MASTER CYLINDER REPLACED IN OCT. 2003 MASTER CYLINDER REPLACED AGAIN NOW IT'S NOV 2003 & MASTER CYLINDER BEING REPLACED AGAIN TOMORROW.THESE CARS HAVE A REAL BRAKE PROBLEM THAT NEEDS TO BE FIXED IT'S COSTING A FORTUNE.*AK

NHTSA ID

10045462

Incident

Nov 4, 2003

Mileage

70,000 mi

THE CONSUMER STATED THE TECHNICIAN NOTICED ALL FOUR TIRES HAD TREAD SEPARATION. *AK THERE WERE CRACKS AROUND THE TREAD. (FOUND DURING THE STATE INSPECTION) *SCC *JB

NHTSA ID

10029992

Incident

Jul 23, 1993

Mileage

7,043 mi

WHILE BACKING INTO A PARKING LOT FRONT SUSPENSION COIL BROKE, AND CAUSED FRONT TIRES TO BURN. *AK

NHTSA ID

10033672

Incident

Aug 9, 2003

WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING HEARD A POPPING NOISE. THE RIGHT FRONT TIRE TREAD SEPARATED FROM THE WHEEL.THE TIRE WAS A FIRESTONE P20585R15. DEALER WAS AWARE OF THE PROBLEM.*AK *TS *JB

NHTSA ID

10021975

Incident

May 30, 2003

THE RIGHT FRONT TIRE EXPERIENCED TREAD SEPARATION. *JB THE VEHICLE HAD BECOME HARD TO HANDLE AND GET OFF OF THE ROAD. ALSO, THE TIRE HAD SPLIT FROM THE RIM TO TREAD. (TIRE MODEL/TOURING) SCC

NHTSA ID

10011528

Incident

Mar 12, 2003

ALL FOUR TIRES WERE CUPPED BADLY DUE TO TIRE MALFUNCTION. *JG

NHTSA ID

10004027

Mileage

23,350 mi

CONSUMER STATED THE BRAKE AND ABS LIGHT WOUL COME ON IMTERMITTENLY. IT WAS SAID TO BE A COMMUNICATION PROBLEM (SINCE NEW). THE BRAKES HAVE BEEN IN THE SHOP(DEALER) MANY TIMES. NOW THE BRAKES RELEASE AND COAST AT SLOW SPEED, AND ALMOST CAUSED TWO ACCIDENTS WHERE THE VEHICLE WOULD HAVE REAR ENDED ANOTHER. THERE ARE ALSO COMPLAINTS WITH THE TIRES (INCOMPLETE INFO). SCC *JB

NHTSA ID

10001978

THE LEFT REAR BRAKE MAKES NOISE AND THE BRAKE CYLINDER WAS REPLACED. ALSO, WARPED ROTORS WERE REPLACED AND TURNED AS WELL. *YH

NHTSA ID

567802

ALL 4 TIRES BEGAN TO CUP AT JUST OVER 23,O00 MILES AND WHILE DRIVING THERE WAS A ROARING SOUND. IT WAS LATER DETERMINED THAT THE BELTS BROKE (FIRESTONE AFFINITY, P215/60R15 93T M-5, DOT NUMBER UNKNOWN). *TT *NLM

NHTSA ID

567127

CONSUMER STATES THE FIRESTONE AFFINITY, P215/60R15 TIRES ARE CRACKING IN BETWEEN THE TREAD.(STATE FARM MUTUAL AUTOMOBILE INSURANCE COMPANY).*JB

NHTSA ID

566530

THE FIRESTONE AFFINITY TIRES P21560R15 ARE CRACKING IN BETWEEN THE TREAD.(STATE FARM MUTUAL AUTOMOBILE INSURANCE COMPANY)*JB

NHTSA ID

566529

CONSUMER STATES THE FIRESTONE AFFININTY TIRES, P215/60R15 ARE CRACKING IN BETWEEN THE TREAD.(STATE FARM MUTUAL AUTOMOBILE INSURANCE COMPANY).*JB

NHTSA ID

566527

TIRES WERE CRACKING BETWEEN THE TREAD (FIRESTONE AFFINITY P215/60R15). NLM

NHTSA ID

566526

FIRESTONE AFFINITY TIRES P215/60R15 ARE CRACKING IN BETWEEN TREAD. *YH

NHTSA ID

566525

TIRE IS CRACKING BETWEEM THE TREAD (FIRESTONE AFFINITY P215/60R15). NLM

NHTSA ID

566524

CONSUMER STATES THAT ALL FOUR ORIGINAL TIRES ARE EXPERIENCING CRACKING IN BETWEEN THE TREAD, FIRESTONE AFFINITY, P215/60R15. *SLC

NHTSA ID

566523