2005 Chevrolet Malibu Steering Problems

The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. There was no warning light illuminated. The contact stated that the failure was related to the U-joint in the steering column, which made the vehicle difficult to control. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.

NHTSA ID

11723407

Incident

Mar 10, 2026

Mileage

37,000 mi

Power steering failing. As I was driving down the road I got a power steering message and chime. No dash light came on and I lost all ability to turn my vehicles steering wheel. I went to add power steering fluid just to learn that my 2005 Chevy Malibu maxx LS comes equipped with EPS(electric power steering). Then I check on NHTSA for safety recalls and there is a safety recall for the Chevy Malibu maxx including the 2005 Chevy Malibu maxx. I was pulling safely out of store parking lot into traffic and I had to hit the ditch luckily I didn't get T-boned. Thanks to my reaction time being fast I made it safely outta the road. I am available to have car inspected if needed. It just started on 11/23/2025 I bought the car used a year prior in Nov. 2024.

NHTSA ID

11704639

Incident

Nov 23, 2025

The steering locked up when the brakes were pressed and the steering wheel was turned to avoid crashing with another car. The result is the crash happened and damage to both cars. Thankfully traffic was only going around 10 mph. If this had happened at high speed my son may have been seriously injured or even killed. The mechanic is working on it now and has reported the power steering module and power steering motor has to be replaced.

NHTSA ID

11700534

Incident

Nov 13, 2025

The car has a recall for power steering the recall covers the torque sensor in the steering assembly I had the recall done about 6-8 weeks ago & now I’m dealing with another power steering issue I took the car to Chevy & the whole power steering motor has failed they say it is not covered under the recall although it should be other Malibu models are this is very frustrating & unacceptable as I just got a recall for steering done & now I can’t even drive my car

NHTSA ID

11678786

Incident

Aug 4, 2025

The EPS began sporadically and severely jerking the steering very powerfully while driving and stationary and draining the battery at an accelerated rate necessitating multiple replacements of and charging 2 batteries to get to and from my job and anywhere else making everyday life very difficult beginning in early 2024. A couple months before this issue became a daily and constant occurrence in in February 2024 between the 6th and 13th I had a stabilizer link and control arm on the right side replaced and an alignment done at Firestone, on the document for the alignment it states no manufacturers recommended services necessary on suspension. The mechanic who replaced the parts told me that the EPS issue is a likely cause for the steering system damage as a vehicle is not meant to remain stationary while the wheels are forcibly turned as is the case when the EPS takes over and jerks the wheel often to the extremes of its function. I have video of this on multiple occasions and it can be inspected still occuring. I took it to Hendrick Chevrolet Shawnee Mission in April 2024 and explained the services done recently and the mechanics opinion on the EPS. They held my vehicle for 3 days not saying it would take so long, during which I had to use a truck I had just bought and was not ready to be driven to get to work, it's transmission blew and has sat since. They called me to come pick it up and only once there told me they had refused to replace the recalled EPS unit "due to loose steering" as quoted from the document Given to me. I asked them to reconsider since this was the only vehicle I had running and charging batteries and being nearly forced off of the road or into other cars daily was very concerning, they simply told me to take it to another dealership for "a second opinion" I stated I didn't have time for another dealer to hold my car for days because my truck had just gone OOC, they held their position and I drove it until forced to buy a new car in 03/2025

NHTSA ID

11678257

Incident

Jan 1, 2024

POWER STEERING WENT OUT AND WATER PUMP

NHTSA ID

11675929

Incident

Jul 24, 2025

The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving at 60-70 MPH, the steering wheel turned to left and to the right independently. The traction control warning light was illuminated. An unknown local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 220,000.

NHTSA ID

11672661

Incident

Jun 11, 2025

Mileage

220,000 mi

The electric power steering has failed on me numerous times. From being completely locked and having to restart the car 5 times just to free it up, to it locking up while i'm going 70 down the freeway multiple times. one of those times was while i was merging lanes and my wheel got locked slightly left and it sent me into the median wall, luckily no more damage than some missing paint and scratches but this is a problem that needs fixed. I searched my vin and there is no recall but it is the exact same make and model and has the exact same EPS issues the other 05 malibus do. what are my options before i get into a really bad accident because of this?

NHTSA ID

11661092

Incident

May 12, 2025

The contact owns a 2005 Chevrolet Malibu. The contact stated that while his daughter was driving at an undisclosed speed and attempting to complete a turn, he became aware that the electronic power steering was not functioning properly, requiring an increased effort to maneuver the vehicle. The message "Service Electronic Power Steering" was displayed. The vehicle returned to normal functionality, but the failure became a regular occurrence. The electronic power steering warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V153000 (Steering); but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 103,000.

NHTSA ID

11633659

Incident

Jan 2, 2025

Mileage

103,000 mi

STEERING WHEEL SHAKES VIOLENTLY WHEN THE CAR IS STARTED. AFTER AWHILE IT GOES OUT COMPLETELY MAKING IT EXTREMEMLY DANGEROUS TO STEER OR TURN WHILE DRIVING. TOOK IT TO A DEALER IN NORFOLK, NE, NORFOLK GM SERVICE CENTER, AND THEY SAID RECALL WAS FIXED BACK IN 2014 AT A SHOP IN HARTINGTON, NE. SAME ISSUE IMMEDIAITLY HAPPENED AGAIN. ISSUE IS NOT FIXED AND CAR REMAINS UNSAFE FOR TRAVEL.

NHTSA ID

11584209

Incident

Apr 19, 2024

The car was allegedly previously repaired under Product Safety Recall Bulletin No.: 14116 back in 2014. The vehicle was 10 years old at that time. Now in 2024, 10 years later, the power steering issue is back. As the vehicle is operated, a sound rings from the computer system and a message warning about Power Steering appears on the center console screen. The electronic power steering then stops working entirely and steering becomes incredibly difficult. In July 2010, GM issued Service Bulletin No.: 10183. The Subject of the Bulletin was "Special Coverage Adjustment - Power Steering Assist." The Condition described in the bulletin is the same as the problem described above. GM extended coverage of this issue to 10 years and 100,000 miles. In May of 2012, GM issued Service Bulletin No.: 10183A, which extended coverage to 150,000 miles. In September 2014, NHTSA stepped in and forced GM to issue Recall Bulletin No.: 14116 with the subject "Power Steering Assist." GM knows that some vehicles on the road have had this repair performed 3 times, based on their decision to extend their own service bulletins. Clearly they have decided to use the same faulty part repeatedly. NHTSA needs to step in and tell them to continue repairing the defective part until all of these vehicles are off the road.

NHTSA ID

11582784

Incident

Apr 12, 2024

Car is getting hard has been happening for a while but is getting worse There's is a recall on similar Chevy models but not for this specific one

NHTSA ID

11579961

Incident

Mar 28, 2024

I was tightening the battery and there was a spark and it’s been difficult to steer ever since

NHTSA ID

11570954

Incident

Feb 8, 2024

The contact owns a 2005 Chevrolet Malibu. The contact stated that after his daughter started the vehicle, she became aware that the electronic power steering was not functioning properly. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V153000 (Steering) but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 85,000.

NHTSA ID

11559475

Incident

Dec 8, 2023

Mileage

85,000 mi

Issue started at ~80K while driving 60-65 mph, the steering wheel would unexpectedly shake violently. After hitting brakes, the steering system would return to normal. Had car evaluated by mechanic specializing in steering/suspension and could not recreate the issue. This issue has been returning intermittently for the past year (99,800 mileage now). Now the engine light is on indicating “POWER STEERING “ on dashboard and loss of power steering. I’m issuing this report because my vin number shows no outstanding recalls but there’s a known issue (14V15300) against this vehicle.

NHTSA ID

11558450

Incident

Nov 26, 2023

No accedents. Trying to be a head of it!

NHTSA ID

11558334

Incident

Nov 22, 2023

The contact owns a 2005 Chevrolet Malibu. The contact stated that he received recall notification of the NHTSA Campaign Number: 14V153000 (Steering). The vehicle was taken to the dealer where the recall was completed however, the contact stated that while driving at an undisclosed speed, the steering wheel became stiff and difficult to maneuver. The contact stated that he had to turn off and restart the vehicle. The power steering assist warning light intermittently illuminated. The vehicle was taken to the dealer where it was diagnosed that the torque sensor assembly or the EPS motor controller unit needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 140,000.

NHTSA ID

11549150

Incident

Oct 10, 2022

Mileage

140,000 mi

The contact's wife owns a 2005 Chevrolet Malibu. The contact stated while driving 30 MPH, the vehicle emitted a chime and the message "Steering" was displayed. The contact stated that the vehicle did not experience any mechanical failure and he was able to continue driving. The contact stated that the failure had been reoccurring. The vehicle was taken to an independent mechanic where it was diagnosed that the steering torque sensor needed to be reprogrammed. The independent mechanic referred the contact to the dealer for assistance. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as the vehicle was previously repaired under NHTSA Campaign Number: 14V153000 (Steering) on February 09, 2015. The failure mileage was approximately 106,200.

NHTSA ID

11492135

Incident

Oct 31, 2022

Mileage

106,200 mi

In January 2022, I started to lose the power steering my 2005 Chevy Malibu. After much research, I have learned that Chevrolet installed EPS systems on the 2004-2007 Malibus. I found there has been a recall on the failure of this system. I contacted our local Chevrolet dealership in April 2022 to learn there is a mileage stipulation on the recall. Presently this is my only mode of transportation, which loses the power steering ability while driving. I am a Disabled Senior on a fixed income, therefore, leaving me with a crippled vehicle. I purchased this pre-owned vehicle in 2012, with the intention of not buying another one. I would like assistance with the repair on my Malibu.

NHTSA ID

11466753

Incident

Jan 10, 2022

Power Steering goes in & out. Wheel sometimes shakes side to side with & without touching wheel

NHTSA ID

11461536

Incident

Mar 17, 2022

I was making a right turn onto a busy highway when my front end made a loud thunk, as if something had broken, then my steering wheel threw itself and locked up on me.

NHTSA ID

11450346

Incident

Jan 28, 2022

The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving at 65 MPH and making a turn, the steering wheel inadvertently lost power steering assist functionality. There were no warning lights illuminated. The contact was able to continue to drive the vehicle with the extra effort needed to steer the vehicle. The contact stated that as she arrived at her destination, turned off the vehicle, and restarted it, the steering wheel regained power steering functionality. The contact notified an independent mechanic who advised her that the failure was related to NHTSA Campaign Number: 14V153000 (Steering). The contact stated that the failure had been reoccurring while driving and the steering wheel was increasingly more difficult to maneuver. The dealer and the manufacturer were notified of the failure and informed the contact that they could not assist because NHTSA Campaign Number: 14V153000 (Steering) had expired. The vehicle was not diagnosed or repaired. The approximate failure mileage was 183,000.

NHTSA ID

11444477

Incident

Dec 6, 2021

Mileage

183,000 mi

Starting feeling a clunking in steering wheel while driving. 5 days later cars dic said power steering while driving 60 down the highway. Car was hard to handle and turn.

NHTSA ID

11432635

Incident

Sep 3, 2021

loss of steering. couldn't steer the car. no power steering message came up on display screen only warning alarm sounded. This has happened when trying to park in a parking spot as well as two separate times on the freeway.

NHTSA ID

11428936

Incident

Aug 9, 2021

loss of steering. couldn't steer the car. no power steering message came up on display screen

NHTSA ID

11424339

Incident

Jul 10, 2021