2022 Chevrolet Malibu Engine Problems

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the message “Engine Power Reduced” was displayed. The failure was a persistent failure. The vehicle was taken to the dealer where it was diagnosed with turbocharger failure. The contact was informed that the turbocharger needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 82,950.

NHTSA ID

11753711

Incident

Jun 3, 2026

Mileage

82,950 mi

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving approximately 62 MPH, the vehicle lost motive power with the message "Reduced Engine Power" displayed, and the check engine warning light intermittently illuminated. The vehicle was taken to an independent mechanic, where a diagnostic scan retrieved DTC: P0299, indicating a failure with the turbo charger. The vehicle was then taken to the local dealer, who confirmed that the vehicle was not eligible for the GM Special Coverage: N252508360. The manufacturer was not notified of the failure. The failure mileage was approximately 82,010.

NHTSA ID

11752008

Incident

May 31, 2026

Mileage

82,010 mi

Component: Air Conditioning – A/C Hose Assembly / Refrigerant Discharge Line The air conditioning refrigerant discharge line (A/C hose assembly) appears to have been improperly designed and/or installed during manufacturing. The rubber A/C hose was routed in a manner that caused it to rest against or press against the side of the engine. Over time, the engine heat and constant contact burned a hole through the hose, causing a rapid loss of refrigerant (Freon). As a result of the refrigerant leak, the air conditioning system stopped blowing cold air, and the HVAC system no longer functioned properly. This failure was not caused by normal wear and tear, but by the improper routing and placement of the A/C hose against the engine. The issue was confirmed by Meineke Service Center through a diagnostic inspection and UV dye leak test, which identified the damaged refrigerant discharge line as the source of the leak. A significant safety concern is that simply replacing the hose does not permanently correct the problem if the replacement hose is routed in the same location. Without a manufacturer-provided redesign or long-term repair solution that prevents the hose from contacting the engine, the replacement part is at risk of failing in the same manner. There were no warning lights, dashboard messages, or other indications before the failure occurred. The air conditioning stopped blowing cold air after the refrigerant escaped through the damaged hose. I believe this is a manufacturing and/or design defect that could affect other vehicles with the same hose routing configuration. I am requesting that NHTSA investigate this issue and determine whether a safety recall or manufacturer corrective action is warranted.

NHTSA ID

11750741

Incident

Jul 9, 2026

My 2022 Chevrolet Malibu LT repeatedly and unpredictably enters a "Reduced Engine Power" state, causing sudden, dangerous drops in speed while driving in traffic. This intermittent loss of power happens constantly on and off, creating an ongoing and severe safety hazard. A diagnostic scan reveals codes P0299 (Turbocharger Underboost), P1101, and P2227. General Motors has an active Special Coverage Program (N252508360) covering this exact turbocharger failure for 2022 Malibus with the 1.5L engine. However, GM and the local dealership refuse to cover the repair, claiming my specific VIN is excluded from their automated list. I have already replaced the MAF and MAP sensors to eliminate electrical faults, had all hoses examined for leaks, and I've replaced the air filter under the hood and in the cabin twice, proving this is a chronic mechanical failure of the turbocharger system. GM is using arbitrary VIN boundaries to avoid repairing a known, widespread manufacturing defect that continually compromises vehicle safety.

NHTSA ID

11750044

Incident

Jul 13, 2026

Transmission misfiring.

NHTSA ID

11749174

Incident

Jul 8, 2026

CHECK ENGINE LIGHT CAME ON AND VEHICLE WAS SLOW TO ACCELERATE INTERMITTENTLY. OFTEN SLOW TO TAKE OFF AT A STOP LIGHT. SAFETY CONCERNS OF BEING REAR END DUE TO SLOW TAKE OFF. TOOK VEHICLE TO CHEVY DEALER FOR REVIEW AND THEY INDICATED AND SHOW A PICTURE OF THE TURBO BOOSTER BEING BROKEN. PER DEALER THIS CAUSED THE VEHICLE TO LOOSE POWER AND NOT ACCELERATE PROPERLY. DEALER STATED I WAS 5k MILES OVER WARRANTY AND EXISTING SERVICE SPECIAL COVERAGE NOTICE N252508360 FOR 2022 MALIBU DID NOT COVER MY VIN.

NHTSA ID

11747026

Incident

Feb 25, 2026

I have a problem with parking, the warning comes on,”Shift Into Park” knowing that I’m in park, so it’s not registering. Have to move the shifter a couple of times before it comes off. My check engine light stays on and then comes off a week or two later and then comes back on and no code comes up, so I’ll clear it or let it clear itself.

NHTSA ID

11746599

Incident

Mar 2, 2026

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the front driver's side tire was replaced several times due to air loss. The vehicle was taken to the dealer, who replaced an unknown filter. The failure recurred. The vehicle was taken to an independent mechanic, who determined that the unknown filter needed to be replaced a second time. The vehicle was taken back to the dealer, who confirmed that the unknown filter and other unknown parts needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ID

11741485

Incident

Oct 1, 2025

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly entered limp mode with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the turbocharger had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer referred the contact to the NHTSA hotline for further assistance. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

NHTSA ID

11740153

Incident

May 26, 2026

Mileage

70,000 mi

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at 70 MPH, the reduced power mode message was displayed. The contact linked the failure to TSB 22-NA-224. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, who confirmed there was no coverage. The failure mileage was approximately 76,000.

NHTSA ID

11738611

Incident

May 1, 2026

Mileage

76,000 mi

My cars check engine light keeps coming on and the first time it came on with an engine under boost failure and I took it to a 3rd party shop to get fixed and they had to replace the turbo charger. I paid $2500.00 for that. 2 weeks later the same light came on and they had to replace it again. Well now the light came on again after a month for the same thing and I am taking it back into the shop again. That will be 3 times.

NHTSA ID

11737070

Incident

May 11, 2026

failing turbo charger - GM website issued special coverage bulletin

NHTSA ID

11734921

Incident

Apr 1, 2026

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended, and the vehicle was driving sluggishly, with the check engine warning light illuminated and the message “Engine Power Reduced” displayed. The vehicle was taken to the dealer, where it was diagnosed with turbocharger failure. The contact was informed that the turbocharger needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 67,506.

NHTSA ID

11733586

Incident

Apr 24, 2026

Mileage

67,506 mi

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at various speeds on several occasions, the check engine warning light illuminated, and the message "Reduced Engine Power" was displayed. The accelerator pedal was depressed, but the vehicle failed to respond and lost automotive power. The contact was able to pull over to the side of the road, and the vehicle was towed to the residence on several occasions. The contact stated that the failure was intermittent. The vehicle was driven to an independent mechanic, where it was diagnosed with turbocharger failure. The vehicle was not repaired because the mechanic lacked confidence in performing the required repair. The mechanic referred the contact to the dealer for the repair. Several dealers were contacted and informed that the vehicle was not under warranty or recall coverage. The contact stated that the turbocharger was previously replaced by a dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 31,000.

NHTSA ID

11731848

Incident

Aug 17, 2023

Mileage

31,000 mi

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at various speeds, the vehicle suddenly decelerated and went into LIMP Mode. The contact continued driving until being able to safely stop. Once the vehicle was stopped, it was turned off and restarted after a while. The failure occurred while the contact was attempting to accelerate and had become more persistent. The check engine warning light was illuminated with the message “Reduce Engine Power” displayed. The vehicle was taken to the dealer, who diagnosed that there was a failure with the turbocharger. The vehicle was being repaired. The manufacturer was informed of the failure. The manufacturer informed the contact that there was no recall for the issue. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 128,000.

NHTSA ID

11731296

Incident

Mar 1, 2026

Mileage

128,000 mi

Component/System Failure: The turbocharger system failed, specifically the wastegate arm, resulting in loss of boost and reduced engine performance. The failed component should be available for inspection upon request through the servicing dealership. Safety Risk: The failure caused a sudden loss of engine power while driving, placing me and others at risk, especially in traffic situations where acceleration is required (such as merging, crossing intersections, or maintaining speed). This created a hazardous driving condition. Confirmation of Issue: The problem was diagnosed and confirmed by an authorized dealership. The diagnosis stated: “turbocharger wastegate arm damaged causing loss of boost and DTC,” which matches known issues described in GM’s Special Coverage. Inspection History: The vehicle has been inspected by the dealership service department. It has not yet been inspected directly by the manufacturer, police, or insurance representatives. Warning Signs Prior to Failure: Yes. The vehicle displayed a check engine light and reduced engine power message prior to the failure. These symptoms began shortly before the vehicle experienced noticeable loss of acceleration and performance. Additional Information: This failure is consistent with a known issue acknowledged by General Motors under Special Coverage for similar vehicles experiencing turbocharger-related defects. Despite having the same failure and symptoms, my vehicle was excluded based on lot number, not condition or diagnosis.

NHTSA ID

11727076

Incident

Feb 14, 2026

The contact owns a 2022 Chevrolet Malibu. The contact stated that while her husband was driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with turbocharger failure. The dealer informed the contact that the vehicle was under recall. The vehicle was repaired; however, after the vehicle was serviced, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed and determined that the charger air cooler had failed and needed to be replaced. The contact was informed that the vehicle was not under recall. The vehicle was not repaired due to the cost. The vehicle was picked up and then taken to Auto Zone for a diagnostic test. The diagnostic test retrieved DTC: P0234 (Turbocharger/Supercharger "A" Over Boost Condition (Engine and Engine Cooling). The manufacturer was not made aware of the failure. The failure mileage was 77,157.

NHTSA ID

11725932

Incident

Feb 10, 2026

Mileage

77,157 mi

Two months after purchasing my used Chevy 2022 Malibu my engine light came on and also a notification stating Engine Power Reduced and the car was not performing well. I went to advanced auto to get a diagnostic and the results that were generated was the code P0299 along with several other codes. I have been dealing with this same issue over 6 months even after taking it to Chevrolet and them fixing everything but the actual problem. Now my light is on, blinking, along with the engine shaking roughly and also making a ticking sound. Dates: Purchased April 2025 Engine Light Appearance June 2025- Present

NHTSA ID

11718860

Incident

Jun 23, 2025

The car will cut off while driving and across the dashboard it’ll say “press brake to start engine”.

NHTSA ID

11717468

Incident

Apr 1, 2024

Turbo waste gate failed at under 66,000 miles, that’s just was soon after warranty expired at 60,000-5years GM recalled a select group for turbos for this year. This turbo on the 1.5L cars, falls and should be replaced on all models.

NHTSA ID

11716766

Incident

Jan 17, 2025

The Chevy Malibu turbo is malfunctioning and making a loud noise when driving also bringing up the engine light with codes

NHTSA ID

11716723

Incident

Feb 6, 2026

so ive been having issue's with my 2022 chevy malibu the check engine light has been on and i got it looked at twice both saying its my turbo i looked up online and in detail recalls and other websites on chevy's and the 2018 and 2022 malibu's are recalled for there turbo chargers and says GM has a recall im at like 66k miles and it says reduced engine power and my light is staying on please help me with this i dont have the money im pay check to pay check and 2,200 is alot i would very much appricate it and i would tell a friend and give great reviews i dont know if i can make it happen alone again thank you have a good one

NHTSA ID

11716234

Incident

Jan 28, 2026

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly decelerated and failed to exceed 40 MPH, with the check engine warning light illuminated. The vehicle unexpectedly went into LIMP Mode. The vehicle was towed to an independent mechanic, where it was diagnosed with turbocharger failure. The contact was informed that the turbocharger needed to be replaced. The vehicle was not repaired. The vehicle was then towed to the dealer, but was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 110,022.

NHTSA ID

11715967

Incident

Jan 28, 2026

Mileage

110,022 mi

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at 45 MPH, the message “Engine Power Reduced” was displayed, and the vehicle decelerated unexpectedly. The driver pulled over and was informed to turn off the vehicle and restart the vehicle with the assistance of a Police Officer. The vehicle was restarted but failed to exceed 10 MPH while driving. The vehicle was towed to the local dealer, where it was diagnosed with turbocharger failure. The vehicle was not repaired. The manufacturer was contacted and confirmed there was no coverage for the repair and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 62,000.

NHTSA ID

11714125

Incident

Jan 24, 2026

Mileage

62,000 mi

Check engine light came on. Took car to Autozone and O'Reilly's to be given the same P0299 code which is a failed turbocharger. Reduced engine power, car goes into limp mode. GM has issued a special coverage program for 2022 Chevy Malibu as of Nov 2025 but for some reason my car is not covered!!

NHTSA ID

11707527

Incident

Aug 10, 2025