1991 Chevrolet Pickup Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1991 Chevrolet Pickup, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Tires & wheels531.3%
- Brakes318.8%
- Steering212.5%
- Exterior lighting16.3%
- Transmission16.3%
- Body & structure16.3%
- Visibility16.3%
- Driver assistance16.3%
- Engine16.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
LEFT FRONT TIRE LOST THREAD, TORE UP LEFT FRONT QUARTER, TORE UP DOWN UNDER BUMPER RUINED THE WHEEL, REPLACED TWO TIRE.
I WAS ON I-75 BY TOLEDO,OHIO WHEN THE TIRE JUST BLEW OUT ON THE RIGHTSIDE REAR. THIS WAS ON A CURVE . I WAS IN THE CENTER LANE AND I WAS FIGHTING TO CONTROL IT AND JUST MISSED A SEMI. ALL THREE LANES STOPPED AND THE TRUCK PULLED HARD TO THE RIGHT AND CAME TO A STOP BY THE GUARD RAIL.NORTHWOOD POLICE CAME BY AND ASKED ME IF I NEEDED HELP .WHICH TIME HE LEJFT. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
BRAKES ARE NOT STRONG, NO PROBLEMS FOUND. *MJS
BRAKES ONLY WORK WHEN TRAVELING SLOW. IF TRAVELING AT 40 MPH CAN STAND UP ON BRAKE PEDAL AND THE VEHICLE WILL NOT STOP. DEALER WAS CONTACTED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
VAN HAD COMPLETE STEERING FAILURE AFTER HEARING A THUMP WHILE TURNING AT 15 MPH. OWNER WAS ABOUT TO TAKE THE VAN IN FOR DIAGNOSIS FROM DEALERSHIP. OWNER IS VERY CONCERNED DUE TO NO WARNING GIVEN, AT ALL. STEERING WHEEL CAN TURN BUT THE WHEELS ARE NON-RESPONSIVE. PLEASE DESCRIBE DETAILS.AK
STEERING COLUMN IS LOOSE AND MOVES WITH STEERING. SEVERAL OF THE PARTS STORES IN THIS AREA HAVE NOT BEEN ABLE TO OBTAIN A STEERING COLUMN THEY SUGGESTED THAT THIS USUALLY OCCURRS WHEN THERE HAS BEEN A MAJOR PROBLEM WITH A VEHICLE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
GIVES POOR LIGHTING. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
TRANSMISSION FAILED, CAUSING FIRE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
PAINT CHIPPING FROM VEHICLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WIPERS FAILED DURING RAIN STORM. WIPERS RUN FOR APPROX. 5 MINUTES THEN QUIT. MUST TURN TRUCK OFF FOR 10 MINUTES BEFORE WIPERS WILL OPERATE FOR 5 MINUTES. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
GAS PEDAL STUCK, CAUSING ACCIDENT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
EXHAUST GASKET ON THE MANIFOLD WARPED, CAUSING THE MAINFOLD TO CRACK.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .