RoadVitals

1997 Chevrolet S10 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
8
Newest May 11, 2009
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
4 investigations on file

Recall campaigns

8 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

09E025000

EXTERIOR LIGHTING:HEADLIGHTS

May 11, 2009
42,540 units potentially affected
The defect: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
DOPE, INC.View on NHTSA.gov
07E021000

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Mar 12, 2007
742 units potentially affected
The defect: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
The risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
The remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
DELPHIView on NHTSA.gov
03V159000

VISIBILITY:WINDSHIELD WIPER/WASHER

Apr 28, 2003
1,755,876 units potentially affected
The defect: ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
The risk: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
The remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
GENERAL MOTORS CORP.Manufacturer number 03023View on NHTSA.gov
00V159000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Jun 16, 2000
306 units potentially affected
The defect: VEHICLE DESCRIPTION: ELECTRIC PICKUP TRUCKS. A CONDITION IN WHICH THE FUEL-FIRED HEATER FILL PIPE GROUND STRAP CONTACTS THE REAR PASSENGER SIDE BRAKE PIPE.
The risk: THIS COULD WEAR OFF THE CORROSION PROTECTION ON THE BRAKE PIPE, LEADING TO PREMATURE CORROSION AND EVENTUAL LOSS OF BRAKE PIPE INTEGRITY. WHEN BRAKE PIPE INTEGRITY IS LOST, BRAKE FLUID LEAKAGE CAN OCCUR.
The remedy: DEALERS WILL RELOCATE THE GROUND STRAP ATTACHMENT, INSPECT THE BRAKE PIPE FOR WEAR, AND REPLACE THE BRAKE PIPE IF NECESSARY.
GENERAL MOTORS CORP.Manufacturer number 00050View on NHTSA.gov
00V069200

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Mar 3, 2000
576 units potentially affected
The defect: VEHICLE DESCRIPTION: GENERATION 1 ELECTRIC LIGHT DUTY PICKUP TRUCKS. THESE VEHICLES WERE BUILT WITH A CHARGE PORT ASSEMBLY THAT COULD FAIL DURING A CHARGING EVENT.
The risk: HEAT COULD BUILD UP WITHIN THE CHARGE PORT AND A FIRE COULD RESULT.
The remedy: DEALERS WILL REPLACE THE CHARGE PORT ASSEMBLY WITH A REDESIGNED CHARGE PORT ASSEMBLY.
GENERAL MOTORS CORP.Manufacturer number 00025View on NHTSA.gov
98V177000

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Aug 4, 1998
354 units potentially affected
The defect: VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH ELECTRIC DRIVE. RAPID FOGGING OF THE INTERIOR GLASS CAN OCCUR WITHIN TWO MINUTES AFTER THE HEAT IS TURNED ON IF (1) THE OUTSIDE TEMPERATURE IS BETWEEN 35 AND 76 DEGREES FAHRENHEIT AND (2) WATER HAS COLLECTED ON THE HEAT EXCHANGER DURING PREVIOUS OPERATION OF THE AIR CONDITIONING.
The risk: IF RAPID FOGGING WERE TO OCCUR DURING DRIVING, IT COULD OBSTRUCT THE DRIVER'S VISION INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: OWNERS ARE BEING PROVIDED WITH A CAUTION LABEL AND SUPPLEMENTAL INSERT FOR THEIR OWNER'S MANUAL ADVISING THEM TO FOLLOW A "STOP AND WAIT" PROCEDURE TO HELP AVOID WINDOW FOGGING WHILE DRIVING.
GENERAL MOTORS CORP.View on NHTSA.gov
97V146001

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Sep 11, 1997
146,167 units potentially affected
The defect: VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
The risk: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
The remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
GENERAL MOTORS CORP.View on NHTSA.gov
97V096001

SEAT BELTS

Jun 12, 1997
586,058 units potentially affected
The defect: VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
The risk: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
The remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
GENERAL MOTORS CORP.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

RQ04002ClosedRecall Query

DRIVER'S SEAT BELT BUCKLE ASSEMBLY

Opened Feb 18, 2004
Closed May 27, 2004

ON FEBRUARY 18, 2004, ODI OPENED THIS RECALL QUERY (RQ) BASED ON TWO FATALITY REPORTS INVOLVING MY 1997 GM S-10 PICKUP TRUCKS.EACH REPORT ALLEGED THAT THE BELTED DRIVER OCCUPANT WAS EJECTED IN A MULTIPLE-ROTATION ROLLOVER CRASH.THE MY 1997 S/T SERIES PICKUPS USE AN ENERGY-ABSORBING LOOP IN THE DRIVER SEAT BELT THAT ALLOWS THE WEBBING TO ELONGATE UP TO 10 INCHES (TO MITIGATE DRIVER INJURY IN FRONTAL CRASHES).GM ALSO USED THIS ENERGY-ABSORBING LOOP SEAT BELT DESIGN IN MY1997 S/T SERIES UTILITY VEHICLES (CHEVROLET BLAZER, GMC JIMMY AND OLDSMOBILE BRAVADA).GM CONDUCTED A SAFETY RECALL CAMPAIGN (03V-117) TO REPLACE THE DRIVER SEAT BELT IN THESE UTILITY VEHILCES BASED ON A HIGHER FATALITY RATE OF EJECTED BELTED DRIVERS IN ROLLOVER CRASHES.BOTH FATAL CRASHES ARE SEVERE ROLLOVER CRASHES (MULTIPLE-ROTATION ROLLOVER) AND BOTH VEHICLES SUSTAINED DAMAGE TO THE ROOF STRUCTURE.ODI REVIEWED THE FIELD DATA PERFORMANCE OF THE SUBJECT VEHICLES AND COMPARED THEM TO PEER VEHICLES USING NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE FARS DATA DID NOT INDICATE A FIELD PERFORMANCE TREND FOR THE SUBJECT VEHICLE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

SEAT BELTS:FRONT
EA97004ClosedEngineering Analysis

SEAT BELT WEBBING SEPARATION

Opened Feb 28, 1997
Closed Aug 5, 1997

NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.

SEAT BELTS:FRONT:WEBBINGLed to recall 97V096001
PE96061ClosedPreliminary Evaluation

SEAT BELT WEBBING SEPARATION

Opened Oct 25, 1996
Closed Feb 28, 1997

ON 9/9/96 NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) PERFORMED A 35 MPH BARRIER CRASH TEST WITH A 1997 CHEVROLET S10 EXTENDED CAB PICKUP.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.

SEAT BELTS:FRONT:WEBBING
EA94038ClosedEngineering Analysis

ABS BRAKING SYSTEM

Opened Oct 31, 1994
Closed Feb 28, 2000

THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.

SERVICE BRAKES, HYDRAULICLed to recall 99I006000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .