1996 Chevrolet Sierra Pu Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Chevrolet Sierra Pu, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags120.0%
- Fuel system120.0%
- Seat belts120.0%
- Steering120.0%
- Tires & wheels120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
PULLED OUT OF PARKING LOT ONTO THE HIGHWAY 29 IN LIBERTY HILL AND WENT OVER A OIL SPILL ABOUT A GALLON OF OIL.AFTER GOING OVER IT, THE VEHICLE LOST TOTAL CONTROL OF STEERING AND WENT TO THE LEFT SIDE OF THE ROAD .THE STEERING SHOT TO THE RIGHT, AND COULN'T MOVE THE WHEEL. VEHICLE RAN INTO THE DITCH AND HIT A TREE. DRIVER'S SIDE AIRBAG DIDN'T DEPLOY. DRIVING SPEED 40 TO 45MPH EVEN ROAD.TOOK THE VEHICLE 4 TIMES TO THE DEALER FOR THE SAME PROBLEM, AND HAS NOT BEEN FIXED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
THE FUEL PUMP ASSEMBLY MELTED AND BURNED THE INSIDE OF THE GAS TANK. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
RIGHT FRONT PASSENGER'S SEAT BELT SUCKS BACK IN AFTER IT'S LOCKED IN BUCKLE. KEEPS TIGHTENING IF A BUMP IS HIT OR A PERSON MOVES. TOOK TO DEALER & WAS INFORMED IT'S FOR A CHILD RESTRAINT. CAN PULL OUT BELT, BUT IT KEEPS TIGHTENING. HAS CONTACTED THE MANUFACTURER. *AK *ML
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
PULLED OUT OF PARKING LOT ONTO THE HIGHWAY 29 IN LIBERTY HILL AND WENT OVER A OIL SPILL ABOUT A GALLON OF OIL.AFTER GOING OVER IT, THE VEHICLE LOST TOTAL CONTROL OF STEERING AND WENT TO THE LEFT SIDE OF THE ROAD .THE STEERING SHOT TO THE RIGHT, AND COULN'T MOVE THE WHEEL. VEHICLE RAN INTO THE DITCH AND HIT A TREE. DRIVER'S SIDE AIRBAG DIDN'T DEPLOY. DRIVING SPEED 40 TO 45MPH EVEN ROAD.TOOK THE VEHICLE 4 TIMES TO THE DEALER FOR THE SAME PROBLEM, AND HAS NOT BEEN FIXED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TWO TIRES WENT FLAT DUE TO PUNCTURE OF THE TREAD SIDE OF TIRE (WRANGLER 265/7R16 TIRES).
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .