Owner-reported complaints naming the engine system, filed with NHTSA
Data refreshed
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components. Every record below is an owner-reported complaint about the 2001 Chevrolet Silverado 1500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 28 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 28, in the owner's own words
The contact owns a 2001 Chevrolet Silverado 1500. The contact stated that the check engine warning light, low fuel warning light, and the ABS warning light were illuminated. The vehicle was not diagnosed nor repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.
TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED AND THE SECURITY WARNING INDICATOR ILLUMINATED. THE CONTACT WAITED A FEW MINUTES AND THE VEHICLE RESTARTED NORMALLY. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED APPROXIMATELY TEN TIMES IN THE PAST EIGHT YEARS. THE VEHICLE WAS TAKEN TO NIX AUTO CENTER INC. (700 S GEORGE NIGH EXPY, MCALESTER, OK 74501) IN JULY OF 2015 TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 8-4865333314. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 138,000.
I AM THE ORIGINAL OWNER OF THIS VERY WELL MAINTAINED SILVERADO. AT JUST 100000 MILES I NOTICED MULTIPLE EXHAUST MANIFOLD BOLTS BROKEN, I HAD NOTICED A TICKING SOUND FOR AT LEAST 10000 MILES BUT COULD NOT LOCATE THE SOUND, AS IT TURNS OUT IT WAS THE BROKEN EXHAUST BOLTS. THESE BOLTS BREAK OFF AT VARYING LENGTHS INCLUDING BELOW FLUSH WHICH IS EXTREMELY COSTLY TO HAVE REPLACED. AFTER A BRIEF INTERNET SEARCH I HAVE REALIZED THIS IS A MAJOR ISSUE WITH A MAJORITY OF THESE VEHICLES. THIS IS DEFINITELY AN EPA CONCERN BEING THE RAW GASSES ARE FLOWING OUT OF THE VEHICLE BYPASSING THE CATALYTIC CONVERTER AND BY NOT ALLOWING THESE VEHICLES TO PASS REGULATORY SMOG CERTIFICATIONS. THIS DEFECT COULD ALSO BE CONSIDERED A SAFETY CONCERN WITH THE POTENTIAL FOR THE EXHAUST GASSES TO GET INTO THE PASSENGER COMPARTMENT. I TRULY HOPE THAT YOU CAN INVESTIGATE THESE DEFECTIVE BOLTS AND AT THE VERY LEAST GET CHEVROLET TO ACKNOWLEDGE THE ISSUE AND HELP WITH A PORTION OF THE COST TO REPAIR.
EVAPORATED SYSTEM.
TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. WHILE DRIVING 70 MPH, THE VEHICLE LOST POWER. THE CONTACT HAD TO ROLL THE VEHICLE A MILE DOWN THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DISTRIBUTOR WAS FULL OF WATER, WHICH BURNED THE COIL AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED NUMEROUS TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 7,000.
TRANNY, ABS, COOLING SYSTEM, TAILGATE, ETC. I BOUGHT THE TRUCK 2003 DIDN'T EXCHANGE TITLE UNTIL LATER RECALL WHEN I FIRST BOUGHT IT UNDER 50,000 MILE WARRANTY. I FILE AN COMPLAIN RECALL REPAIR STILL HAVING SAME PROBLEM. SAD THING MY FATHER IS AN RETIRED EMPLOYEE IN DALLAS LOCATION. RESEARCHED THE RECALLS FROM PREVIOUSLY AND PRESENT SAME RESULTS. THEY HAVE UNTIL 2 DAYS TO CONTACT ME @ [XXX] IN GOING TO THE WAREHOUSE AND RETURN THE VEHICLE TO THE OWNER, CFO, CEO WHOMEVER AND ASK FOR A FULL REFUND OR I'M FILING AN COMPLAINT AND SMALL CLAMS FOR 30 YRS WORTH. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE VEHICLE STALLED ON SEVERAL OCCASION WITHOUT WARNING. THE CONTACT ALSO STATED THAT AFTER NUMEROUS OCCASIONS THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.
THE VEHICLE WOULD EITHER STALL WHILE DRIVING VARIOUS SPEEDS OR FAIL TO START. I WAS DRIVING APPROXIMATELY 55 MPH WHEN HE NOTICED THAT THE FUEL GAUGE DISPLAYED EMPTY WHICH WAS INACCURATE; HOWEVER, THE VEHICLE SUDDENLY STALLED, COASTED TO THE SHOULDER. CAR WOULD NOT CRANK AT FIRST BUT THEN STARTED, THIS HAPPENED SEVERAL TIMES, THE VEHICLE WOULD SPORADICALLY BECOME HESITANT TO START. THE VEHICLE WOULD ALSO STALL PERIODICALLY WITHOUT WARNING. THE OTHER COMPONENTS, SUCH AS THE RADIO, WERE STILL OPERABLE. THE VEHICLE WOULD SPORADICALLY BECOME HESITANT TO START. THE VEHICLE WOULD ALSO STALL PERIODICALLY WITHOUT WARNING. AUTORIDE SUSPENSION, NOT WORKING. HARSH RIDE WITHOUT SHOCK DAMPERING. FRONT PASSENGER SEATBELT FREQUENTLY LOCKS UP AND WILL NOT EXTEND ENOUGH TO SECURE A PERSON. SEAT BELT OFTEN LOCKS UP WHEN PASSENGER IS BELTED IN AND PASSENGER CANNOT MOVE. *TR
WENT TO CHANGE EXHAUST MANIFOLD AND GASKET WHEN NUMBER ONE CYLINDER MANIFOLD BOLT BROKE OFF UNDER MINIMAL PRESSURE. BOLT BROKE OFF FLUSH/RECESSED TO GASKET SURFACE OF CYLINDER HEAD. INSPECTED BOLT AND CAME TO THE CONCLUSION THAT THE BOLT WAS FRACTURED WHEN IT WAS INSTALLED DURING VEHICLE ASSEMBLY. SPOKE WITH DEALERSHIP AND REPRESENTATIVE PULLED UP VIN HISTORY IN COMPUTER. HISTORY SHOWED AN ERROR WITH NUMBER ONE CYLINDER DURING VEHICLE ASSEMBLY AND DEALER SERVICE REPRESENTATIVE STATED "THAT MOTOR SHOULD HAVE NEVER MADE IT OUT OF THE ASSEMBLY PLANT." NO HELP FROM DEALERSHIP TO REMOVE BROKEN BOLT SO EXHAUST LEAK CAN BE REPAIRED. DEALERSHIP ALSO NOTICED THAT THE NUMBER ONE SPARK PLUG ON THE SAME CYLINDER WAS STICKING OUT FURTHER THAN THE OTHER PLUGS. COME TO FIND OUT THAT THE SPARK PLUG HOLE HAD NOT BEEN THREADED ALL THE WAY INTO THE CYLINDER. NO HELP FROM GM ON THAT ONE EITHER. HAD TO BUY A TAP AND FINISH THREADING THE HOLE MYSELF AT HOME. RESEARCHED BROKEN BOLT EXTRACTION FOR SILVERADO EXHAUST MANIFOLD AND HAVE FOUND THAT THIS IS AN EPIDEMIC AND THERE ARE MULTIPLE VIDEOS ON YOUTUBE ABOUT THIS ISSUE. *JS
TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 190,000 AND THE CURRENT MILEAGE WAS 198,000.
LOSS OF COOLANT NO VISIBLE LEAK, COOLANT IS SEEPING INTO HEADS DUE TO FAULTY CASTECH HEADS USED BY GM IN THE MANUFACTURING OF THESE TRUCKS. *TR
TWO OF THE FACTORY EXHAUST MANIFOLD BOLTS ARE BROKEN ON THE DRIVERS SIDE OF THE ENGINE, THE BACK TWO NEAREST THE FIRE WALL. THERE IS AN EXHAUST LEAK DUE TO THE FACTORY EXHAUST MANIFOLD BOLTS BREAKING OFF, AND THE MANIFOLD IS LEAKING EXHAUST WHICH IS VERY CLOSE TO THE FIREWALL MATERIAL WHICH I AM WORRIED THAT MIGHT CATCH ON FIRE. GM SHOULD HAVE A RECALL ON THESE EXHAUST MANIFOLD BOLTS ON SILVERADOS TO FIX AND REPAIR THEM. *TR
THIS TRUCK HAS SEVERAL EXHAUST HEADER BOLTS THAT ARE BREAKING OFF. THIS IS A MAJOR DEFECT AND SHOULD BE A RECALL TO REPLACE THE EXHAUST HEADER BOLTS THEY SHOULD NOT BE BREAKING OFF AND THEY ARE CAUSING EMISSION ERRORS AND NEEDING MAJOR REPAIRS. *JS
EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS GM IS NOT STANDING BEHIND THIS ISSUE. THIS IS CAUSING CO RELEASE, HIGH HEAT IN THE ENGINE COMPARTMENT, NOISE, AND AN EXPENSE THAT I SHOULD NOT PAY FOR. SOME STATES ARE NOT ACCEPTING THESE VEHICLES NOW FOR NOT MEETING THE EMISSION STANDARDS PLEASE LOOK IN TO THIS. IT IS A SAFETY HAZARD. *TR
NORMAL DRIVING LESS THAN 10 MILES. THE FAILURES ARE MANY AND OFTEN. TRANSMISSION FAILURES EVERY FEW THOUSAND MILES. ALWAYS LEAKS TRANS FLDS ALL OVER STREETS AND DRIVEWAYS. SERVICE ENGINE LIGHT ON. CHEVROLET DEALER ERASED FAILURE AND DIAGNOSTIC CODES TO GOUGE CONSUMER, MANY TIMES. PARKING BRAKE CABLE SNAPPED IN TWO ON DRIVEWAY. ABS FAILURES AT LOW SPEEDS AND ENGINE KLACKS LOUD WHEN STARTING. I AM ORIGINAL OWNER OF A DEFECTIVE 2001 CHEVROLET SILVERADO. THE LAST TIME GMPP WITH GM DEALER REPAIR THE UNDERWARRANTY REPAIRS TOOK 6 WEEKS THERE ARE ONLY 26.000 MILES ON THIS TRUCK. OBVIOUSLY THIS IS A DEFECT IN ITS DESIGN AND APPLICATION. (SEE PTIOR COMPLAINTS) TIRES FLEW OFF, ALTERING OF SERVICE CONTRACTS ON AND ON. *TR
ON CERTAIN MODELS OF THE SILVERADO THERE IN A ENGINE NOISE DUE TO FAILURE OF POSITION SKIRTS AND WILL EVENTUALLY CAUSE LOSS OF POWER MORE EMISSIONS AND GM WILL DO NOTHING ABOUT THIS PROBLEM. *TR
TL*THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. WHILE DRIVING AT ANY SPEED OR WHILE MAKING A TURN, THE VEHICLE STALLS INTERMITTENTLY AND HAS TO BE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES, BUT THEY CANNOT DUPLICATE THE FAILURE. THERE WERE NO RECALLS AVAILABLE. THE CURRENT MILEAGE WAS 86,000 AND FAILURE MILEAGE WAS 15,000. UPDATED 02-19-08 *BF UPDATED 02/14/08 *TR
THE CONSUMER REQUESTED ASSISTANCE FOR 15 FAILURES AND OR PROBLEMS WITH GM 2001 CHEVY TRUCK. *BF THE STEERING ROD ASSEMBLY WOULD POP WHEN THE STEERING WHEEL WAS TURNED, THE SHIFTER BOOT RIPPED IMMEDIATELY, THE TAILGATE STRAPS BROKE AND BENT THE TAILGATE, THE PCV VALVE WAS USING 4 QUARTS OF OIL AND THE DEALER WAS UNABLE TO FIND THE PROBLEM, THE BATTERY EXPLODED AT 40K MILES, THE RIGHT REAR BRAKE ON THE INSIDE HAD WORN DOWN THE METAL, THE LIGHTS ON THE STEREO BURNED OUT, THE LIGHTS HAD BURNED OUT, THE VALVE COVER WERE LEAKING OIL BEFORE 100K MILES, THE FUR WHEEL DRIVE SWITCH HAD BROKEN AT 50K MILES, THE TRANSMISSION DID NOT SHIFT AT 1K MILES AND THE DEALERS WERE UNABLE TO FIND THE PROBLEM, THE ENGINE EXPERIENCED A PRE-IGNITION KNOCK AND THE DEALER WAS UNABLE TO FIND THE PROBLEM, THE DRIVER'S SEAT CONTROLS RIPPED AT 60K MILES, THE TRANSMISSION HAD COMPLETE GONE OUT AT 118K MILES AND THE SEAT BELTS LATCH SYSTEM HAD BECOME DEFECTIVE. *SC
PARKING BRAKE, DAY TIME RUNNING LIGHTS, O2 SENSOR, UEL GAUGE . *AK
PARKING BRAKE HASN'T WORKED SINCE AROUND 20000 MILES, BRAKE WILL DEPRESS, BUT WON'T KEEP TRUCK FROM ROLLING. LOUD PISTON SLAP, KNOCKING FROM ENGINE MOSTLY WHEN ENGINE IS COLD, GOES AWAY AFTER WARMED UP. THIS IS A Z71 AND THE 4 WHEEL DRIVE BUTTONS DO NOT WORK ALL THE TIME WHEN TRYING TO PUT INTO 4 WHEEL DRIVE. POWER MIRRORS DON'T WORK A LOT OF THE TIME. AT LEAST ONE OF THE FRONT RUNNING LIGHTS STAY BURNED OUT MOST OF THE TIME. TRUCK IS OUT OF WARRANTY NOW BUT THESE PROBLEMS HAVE EXISTED FOR A LONG TIME. A LOT OF OTHER TRUCKS OF THIS SAME MODEL HAVE ALL THE SAME PROBLEMS. GM SHOULD ADDRESS THESE PROBLEMS AND MAKE THEM RIGHT AT NO COST TO THE CONSUMER.*AK
NOTHING BUT PROBLEMS WITH TRUCK. FIRST WAS THE SLIP YOKE IN THE DRIVE SHAFT, FELT LIKE TRANNY WAS SLIPPING FROM TAKE OFF AT START POSITION. REPLACED UNDER WARRANTY.*AK ANTI-LOCK BRAKES WOULD COME ON WITH EVERY STOP. USUALLY AT VERY SLOW SPEEDS, CAUSING TRUCK TO EXCEED 5-10 FT FURTHER THAN IT SHOULD HAVE. HAD FRONT WHEEL BEARING REPLACED, FIXED FOR SOME TIME DOING IT AGAIN. ALSO IN THE MEAN TIME, HAD TO HAVE ALL BRAKES AND ROTORS REPLACED. BRAKE SYSTEM IS AWFUL. THIS COULD CAUSE ACCIDENTS. ALSO, HAS COLD ENGINE KNOCK, VERY LOUD KNOCK, NOT A NORMAL KNOCK. SOMETHING ISNT RIGHT WITH THIS. DONE THIS SINCE A LITTLE OVER 20,000 MILES, WORSE WHEN TEMPERATURES OUTSIDE ARE LOW. HAD TO HAVE 4X4 SWITCH ON DASH REPLACED. KEPT GETTING SERVICE 4WD UNIT. OUT OF WARRANTY AT THIS TIME. I KNOW OF AT LEAST 4 OTHER WITH ALL SAME PROBLEMS. STILL NOTHING DONE WITH GM, SOMETHING SHOULD BE DONE. ESPECIALLY WITH THE BRAKE SYSTEM. SAFETY HAZARD.
WHILE PROCEEDING TO ENTER THE HIGHWAY DRIVER ACCELERATED AND WITHOUT WARNING THE VEHICLE STALLED REPEATEDLY. CONSUMER HAD TO PULL OFF THE EXIT RAMP. *AK ENGINE PINGING SINCE PURCHASE OF VEHICLE BUT WAS TOLD THIS WAS NORMAL. HOWEVER WHEN DRIVING 30-40 MPH ENGINE WILL PING LOUDLY THEN STALL. *TT
PISTON SLAP, THIS IS A LOW END KNOCK THAT MOSTLY OCCURS DURING COLD START UP AND GOES AWAY WITHIN THE FIST COUPLE OF MINUTES. THIS IS A CONTINUING PROBLEM. THE TICK / KNOCK THAT IS NOT NORMAL.*JB
THE VEHICLE HAD BEEN DRIVEN FOR ABOUT 15 MINUTES, CONSUMER SHUT OFF ENGINE. NEXT CONSUMER WAS CALLED BY A NEIGHBOR STATING VEHICLE HAD CAUGHT FIRE. FIRE TOTALED THE VEHICLE. FIRE DEPARTMENT STATED FIRE STARTED BEHIND STEERING COLUMN. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
ENGINE HAS UNKNOWN KNOCKING/RATTLING WHEN FIRST STARTING VEHICLE, AND COULD BE HEARD THROUGHOUT NORMAL DRIVING DURING DAYTIME. DEALERSHIP HAS LOOKED AT TRUCK, AND DETERMINED IT TO BE PISTON SLAP, AND GAVE CONSUMER LITERATURE. PLEASE DESCRIBE DETAILS. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .