2006 Chevrolet Silverado 1500 Owner Complaints

I was driving down the highway at 65 mph and went to slow down and I had no brakes. Resulting in me having to go into the ditch to avoid a collision. After I was able to get the truck to slow down and to a stop I inspected my braking system to find all of my brake lines were rusted out and I had ruptured my brake lines. Since the incident I have had to replace all my brake lines and both of my brake cylinders on the rear of my truck. Now I have minimal brakes after bleeding them and they are slowly coming back. The truck has almost 400,000 miles on the chassis but a new motor. During this event I was getting a grinding coming from the rear differential, after inspection, I found that my gov lock was bad and needed new spider gears which I have since replaced the rear differential with a posi differential and have had minimal problems since.

NHTSA ID

11702927

Incident

Apr 10, 2025

On [XXX], at or around midnight, I was traveling [XXX] at approximately 60 mph. The traffic was very light, with few vehicles on the road. It was raining, and I was in the number 1 lane. Two additional lanes were to my left, reserved for toll road traffic. I did not see any other vehicles on [XXX], nor did I see any vehicles to my left in the toll lanes. There was a physical separation between [XXX] and the toll road, consisting of 36-inch plastic candlestick dividers with approximately 10-foot separations. As I was traveling, I suddenly felt a lurch, and the right rear of my 2006 Chevrolet Silverado (Vin# [XXX] ) dropped. My pickup truck immediately began to spin to my left, forcing me into the toll lanes and into the concrete center divider. When my vehicle came to rest, I was facing eastbound in the westbound lanes of the toll road. My lights were no longer except a single amber light flashing, which gave limited warning to approaching vehicles. The California Highway Patrol arrived (unknown why no traffic collision report was taken), my vehicle was removed from the roadway, the right rear wheel and tire had separated from the vehicle and rolled to the right shoulder of [XXX] 150 yards from where my pickup came to rest. The vehicle was towed to the tow yard, where a vehicle inspection was conducted on March 19, 2025. The right rear wheel and tire for some reason were not recovered from the collision scene. The inspection revealed the cause of the collision was a broken/severed axle, not related to driver error. Photographs of the broken axle were taken and are available for review. The axle clearly had a manufacturing defect, poor casting or forging. The defect appeared to be an ongoing problem and separated from the vehicle at the time of the collision for no apparent reason. Depending on the time of day, traffic conditions, and the number of passengers, the collision had the potential to be much worse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11649348

Incident

Feb 7, 2025

The auxiliary transmission fuel pump system is prone to failure. This makes it so the start/stop feature will not work, as the vehicle will stall when stopped (causing an unsafe situation), and it cannot pass state inspection. The part is entirely unavailable from Chevy, and results in the vehicle being scrapped. There is no way to permanently bypass this system.

NHTSA ID

11632021

Incident

Dec 1, 2024

hi the power steering hose failed and caused a fire and total loss

NHTSA ID

11629501

Incident

Nov 23, 2024

The contact owns a 2006 Chevrolet Silverado 1500. The contact stated that upon a vehicle inspection performed by an independent mechanic, it was discovered that the brake line and the fuel line were severely corroded. Upon further inspection, the contact stated that the brake lines had blown out. The contact was informed that the vehicle was unsafe to drive and that the lines needed to be replaced. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was repaired. The failure mileage was approximately 187,000.

NHTSA ID

11581206

Incident

Mar 28, 2024

Mileage

187,000 mi

A LITTLE WHILD AFTER TURNING THE TRUCK OFF I NOTICED SMOKE COMING FROM INSIDE THE TRUCK. AFTER PUTTING OUT THE FIRE, I INSPECTED THE WIRES TO FIND THAT THE BLOWER MOTOR HAD SHORTED OUT AND CAUGHT FIRE. I HAVE HAD A SIMILIAR ISSUE WITH MY 2003 AS WELL BUT WAS ABLE TO CATCH THE ISSUE BEFORE ANY FIRE BROKE OUT. THERE NEEDS TO BE A RECALL ON THIS PART. THANKFULLY NOONE WAS HURT BUT THIS IS A DEFINITE SAFETY ISSUE.

NHTSA ID

11565150

Incident

Jan 12, 2024

Service Engine Soon light came on while driving. Code P0327 - Knock Sensor 1, Circuit Low Input (Bank 1) shown on code reader. Took vehicle to local service station and had both knock sensors and wiring harness replaced. Mechanic said that the rear knock sensor was corroded due to water getting to the sensor. Drove vehicle for about 2 weeks and service engine light came back on. Took vehicle back to service station where knock sensors were replaced again. Mechanic again stated that the rear sensor was corroded due to water getting to the sensor. Drove vehicle for about 1 week and the Service Engine light has come back on for the third time with the same P0327 code showing.

NHTSA ID

11543556

Incident

May 9, 2023

My air bag singnol is on

NHTSA ID

11434468

Incident

Sep 27, 2021

The Frame has excessive rust especially the crossmembers that are in-between the two main lateral frame beams. In this vehicle they have rotted all the way through and there is nothing left of them and they look like swiss cheese. This particular vehicle also has only 130,000 miles on it which I personally feel is very excessive for them milage. I do understand it is a little older at this point but I have a dodge van and a Chevy sedan both having over 200,000 miles on them. Both also have been driven in West Virginia all winter long with salt exposure that do not show this amount of rust in the frame components. I feel this is a flaw in the manufacturing I have been looking online and it seems to beyond a common problem with this make and model of vehicle.

NHTSA ID

11434280

Incident

Sep 24, 2021

EXHAUST MANIFOLD BOLTS BROKE OFF AND IS NOW LEAKING EXHAUST FUMES IN SIDE THE TRUCK ALSO EMISSIONS IS EFFECTED FOR OSHA OR EMISSION TEST THIS IS A PROBLEM OF SAFETY I HAVE SEEN ALOT OF PEOPLE WITH SAME PROBLEM AND YET NO RECALL ,IT IS A PROBLEM IN ALL PHASES OF OPERATION OF THE TRUCK ONLY HAS 49,000 MILES DON'T HAVE A PHOTO BUT SURELY YOU ARE REALLY FAMILIAR WITH THIS PROBLEM USUALLY ITS THE FRONT AND REAR BOLTS CAUSE IS INFERIOR MATERIALS AND WORKMANSHIP ALSO CAN CAUSE CATALYTIC CONVERTER FAILURE THE COST OF THIS REPAIR SHOULD BE ON GM AS IT CAN RUN 1000S TO FIX

NHTSA ID

11399892

Incident

Sep 7, 2017

Mileage

48,000 mi

THE INTERIOR LIGHTS ON THE GAUGES ALL TURN OFF MAKING IT HARD TO SEE THE SPEED LIMITS. BRAKES SOUND AS IF GRINDING BUT CANT TELL IF ITS BRAKES OR DIFFERENTIAL AND U JOINTS. NOISE GETS LOUDER IN THE CABIN OF THE TRUCK AS I DRIVE ON THE ROAD. 3. SIGNAL LIGHTS TURN ON BRIGHT WHILE ON LEFT HAND TURN SIGNAL. AND CIGARETTE LIGHTER AND OTHER COMPONENTS WONT WORK

NHTSA ID

11385029

Incident

Dec 24, 2020

Mileage

175,000 mi

THE PASSLOCK LIGHT COMES ON AND THE TRUCK WON'T START. THE INTERIOR LIGHTS GETS BRIGHT THEN DIM. BACK AND FORTH. WHEN THE PASSLOCK COMES ON IT WILL KEEP THE TRUCK FROM STARTING FOR DAYS AT A TIME. I'M AFRAID TO DRIVE THE TRUCK ANYWHERE

NHTSA ID

11378501

Incident

Jun 1, 2020

TRUCK DRIVING TRANSFER CASE GO IN NEUTRAL, THEN NEED TO PARK AND PUT THE TRANSMISSION IN PARK AND IN NEUTRAL, THEN PUSH THE 4X4 BOTTOM,THEN CHANGE TO 2WLD. MAKES A LOT NOISE.UNSAFE TO DRIVE.HAPPEN IN THE HIGHWAY.

NHTSA ID

11359844

Incident

Aug 25, 2020

Mileage

13,100 mi

DUE TO FAULTY UNDERCOATING FROM FACTORY THE BACK CROSSMEMBERS ROT AND CAUSE SHOCKS TO BECOME DISPLACED AND GAS TANK TO UNSECURED ALONG WITH REAR SHAKELS TO GO THREW THE BOTTOM OF TRUCK BED.... WILL COST OVER $2500 FOR REPAIRS

NHTSA ID

11355237

Incident

Sep 15, 2020

Mileage

125,603 mi

THERE'S COMMON PROBLEM WITH GAS LINES AND FRAMES RUSTING OUT THE 2006 CHEVY PICKUP TRUCKS THAT IS A SAFETY PROBLEM. THE PRICE FOR THE GAS LINES ARE WAY OVER PRICED AT $318.

NHTSA ID

11351765

Incident

Jul 15, 2010

WE WERE DRIVING AND STARTED RUNNING REALLY ROUGH AND THE CHECK ENGINE LIGHT CAME ON. IT SAID REDUCED ENGINE POWER TOOK IT TO A SHOP THEY SAID IT WAS SOME WIRING THEY REPLACE THE WIRING ABOUT A MONTH LATER I WAS PARKED AT HOME STARTED THE TRUCK AND IT WAS DURING THIS SAME THING ANGELITE I JUST TURNED ON RUNNING ROUGH SAID LOW ENGINE POWER I TOOK IT BACK TO THE PLACE WE HAD TO WORK DONE THEY SAID A WIRE JIGGLED LOOSE AND THEY SCREWED IT BACK IN SAID I WAS GOOD TO GO LAST WEEK I WAS TAKING MY TRUCK TO GET IT INSPECTED WAS FINE ALL THE WAY TO TOWN PARKED IT AT THE SHOP GO IN AND TELL THEM I NEED INSPECTION THEY COME OUT START THE TRUCK SAME SCENARIO AS BEFORE ENGINE LIGHT WAS ON LOW ENGINE POWER RUNNING ROUGH COULDN'T GET IT INSPECTED THEY PUT THE CODE DEVICE ON IT AND IT SAID THROTTLE POSITION SENSOR HARNESS SOMETHING LIKE THAT

NHTSA ID

11319256

Incident

Dec 3, 2019

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE BRAKING SYSTEM HAD MALFUNCTIONED AND DID NOT STOP THE VEHICLE WHEN PRESSING THE BRAKE PEDAL CAUSING THE VEHICLE TO CRASH INTO A TREE. DURING THE CRASH, THE FRONT END EXPERIENCED SEVERE DAMAGE BUT THE FRONT AIR BAG DID NOT DEPLOY. NO INJURIES WERE REPORTED AND NO POLICE REPORT WAS FILED. THE VEHICLE WAS MANEUVERED TO A PARKING LOT AND A TOWING COMPANY WAS CALLED. THE COSMETIC DAMAGES WERE BEING REPAIRED AND THE CAUSE OF THE FAILURE WAS NOT DETERMINED AS OF YET. A LOCAL DEALER (UNKNOWN) WAS CALLED AND INFORMED ABOUT THE FAILURE. THE MANUFACTURER THEN CALLED THE CONTACT AND OPENED A CASE. THE FAILURE MILEAGE WAS 200,000.

NHTSA ID

11299520

Incident

Dec 1, 2019

Mileage

200,000 mi

AT 45,000 MI, HAD TO REPLACE ABS HUB SENSOR ASSY DUE TO FALSE ACTIVATION. I HAVE SINCE REPLACE 3 MORE ASSYS COSTING OVER $400 EACH OCCURANCE. AT 100,000 MI, HAD TO REPLACE A LEAKING BRAKE LINE WHICH HAD RUSTED THROUGH AND AT 120,000 MI LOST ALL HYD PRESSURE WHILE BRAKING TO AVOID SEVERAL DEER ENTERING THE ROADWAY. REPLACED ALL BRAKE LINES AT A COST OF $1200. THERE HAVE BEEN MANY CONSUMER COMPLAINTS ON BOTH ISSUES, BUT GM WILL NOT ASSUME RESPONSIBILITY FOR EITHER.THIS IS THE 9TH SILVERADO I HAVE OWNED OVER THE PAST 40 YEARS. NEXT ONE WILL BE A FORD.

NHTSA ID

11297284

Incident

Jan 5, 2020

Mileage

120,000 mi

RANDOMLY MY TRUCK WILL GO IN ENGINE POWER REDUCED AND TOP SPEED IS 35 MPH. IT HAPPENED A COUPLE OF TIME ON THE INTERSTATE. THE CODE THAT POPS UP IS P2135 AND I LOOKED IT UP ON LINE. THE INTERNET IS FULL OF FORMS AND VIDEOS ABOUT THIS PROBLEM. EVERYTHING ON THE INTERNET POINTS TO THE THROTTLE POSITION SENSOR. I'VE REPLACED IT TWICE AND REPLACED THE THROTTLE BODY TWICE AND WIRING TWICE. I PUT TRUCK IN THE SHOP THREE TIMES. SPENT A GOOD $1500 TRYING TO FIX THE PROBLEM AND IT STILL POPS UP EVERY COUPLE OF MONTHS.

NHTSA ID

11290120

Incident

Mar 15, 2018

Mileage

95,000 mi

BRAKE LINES HAVE ROTTED OUT AND NEED TO BE REPLACED

NHTSA ID

11283089

Incident

Nov 28, 2019

Mileage

254,000 mi

BRAKE PEDAL GOES TO FLOOR WITHOUT WARNING AT LOW SPEED.

NHTSA ID

11283087

Incident

Dec 28, 2016

Mileage

200,000 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE UNDERCARRIAGE WAS RUSTED. IN ADDITION, THE BRAKE AND STEERING WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO CAPE COD CARZ (153 CORPORATION ST, HYANNIS, MA 02601, (508) 778-2279) WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE WELDED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

NHTSA ID

11252370

Incident

Aug 1, 2017

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE FRAME, BODY, AND BRAKE LINES WERE ALL RUSTED OUT. BEST CHEVROLET (128 DERBY ST, HINGHAM, MA 02043, (781) 347-1886) WAS CONTACTED AND STATED THAT THERE WAS NO RECALL. THE MANUFACTURER HAD NOT BEEN CONTACTED. THE FAILURE MILEAGE WAS 212,000. *TT*JB

NHTSA ID

11246737

Incident

Aug 1, 2016

Mileage

212,000 mi

IN LATE FEBRUARY 2019, I ACQUIRED A TRUCK FROM A USED DEALERSHIP THAT I HAVE DONE BUSINESS WITH BEFORE. UPON OBTAINING THIS VEHICLE I STARTED HAVING ISSUES RIGHT AWAY. FIRST ISSUE I ENCOUNTERED, I WAS DRIVING BACK TO KANSAS CITY FROM LEBANON,MO AND ALL OF THE SUDDEN MY BRAKES WENT OUT AND MY STEERING LOCKED UP AND TRUCK STARTED JERKING REALLY BAD. I DROVE LIKE THIS ALL THE WAY HOME AND TOOK IT TO A MECHANIC AND LOW AND BEHOLD IT'S COST ME $100 TO REPAIR THE PROBLEM. SHORTLY AFTER I NOTICED MY TRUCK WAS HAVING ISSUES WITH GETTING UP TO SPEED WHILE GETTING ON THE HIGHWAY. I WOULD END UP HAVING THE PETAL TO THE FLOOR AND IT WOULD STILL ACT LIKE IT DIDN'T WANT TO ACCELERATE ALMOST LIKE A DELAY AND THEN SLOWLY GAIN SPEED. IT FELT AS IF IT WAS SLIPPING OR IT JUST WASN'T GETTING ANY POWER. MY OIL PRESSURE SENSOR HAD WENT OUT WITHOUT ME KNOWING AT THE TIME SO I THOUGHT THE PROBLEM HAD TO DEAL WITH MY OIL PUMP. I FINALLY TOOK IT BACK TO THE MECHANIC I USED BEFORE AND HE RAN A DIAGNOSTIC TEST ON MY TRUCK DUE TO HIM NOT FINDING ANY ISSUES BESIDES MY OIL PRESSURE SENSOR WAS DEFECTIVE. THE DIAGNOSTIC CAME BACK WITH MULTIPLE CODES AND 3 OF THEM HAD TO DEAL WITH THE TRANSMISSION. I DECIDED TO TAKE MY TRUCK TO MY BROTHER AND HAVE HIM LOOK AT IT FOR A SECOND OPINION. UPON DOING SO HE TEST DROVE AND INSPECTED THE TRUCK ENTIRELY AND CONCLUDED THAT HE DIDN'T FEEL THERE WAS AN ISSUE WITH THE TRUCK AT ALL. HE RAN HIS OWN DIAGNOSTIC ON IT AS WELL BUT HIS CANE BACK WITH NO CODES THAT CAME UP AT ALL. SO I DROVE OFF CONFUSED BECAUSE OF ALL THE DIFFERENT INFORMATION THAT WAS GIVEN TO ME ON TOP OF THE PROBLEMS I KNEW I WAS HAVING BECAUSE THE TRUCK WASN'T RUNNING LIKE IT DID WHEN I DROVE IT OFF THE LOT. SOME TIME PAST AND THEN ANOTHER PROBLEM. MY BRAKES AND ROTORS WERE TRASHED AND NEEDED TO BE REPLACED ASAP AND THEN MY ODOMETER STARTED READING SERVICE AIR BAG AND WOULD NOT GO OFF.

NHTSA ID

11228882

Incident

Jun 20, 2019

Mileage

134,167 mi

TAKATA RECALL. THE SERVICE AIRBAG SOON LIGHT IS ON.

NHTSA ID

11222027

Incident

Jun 23, 2019

Mileage

177,000 mi