2007 Chevrolet Silverado 1500 Suspension Problems

MY FRAME RAIL ON THE DRIVERS SIDE IS CORRODING AWAY TO THE POINT WHERE IT IS NO LONGER SAFE TO DRIVE / I HAVE BROUGHT THE VEHICLE TO THE GM DEALERSHIP TO VERIFY THE CONCERN / I HAVE CONTACTED GENERAL MOTORS ABOUT THIS CONCERN AND WAS GIVEN THE RUN AROUND / I HAVE A VEHICLE THAT HAS COSTED MY TIME AND MONEY TO PURCHASE / AND MAINTAIN / THIS TRUCK RUNS GREAT AND SHOULD BE CAPABLE OF LASTING MANY MORE YEARS - EXCEPT FOR THE FACT THAT THE FRAME RAIL IS CORRODING AWAY IN THE SAME SPOT ON THIS TRUCK AS ON OTHER GM TRUCKS FROM THIS YEAR AND MODEL RANGE . I BELIEVE GM DESIGNED A FAULTY FRAME/ I BELEIVE THE FRAMES ON THESE TRUCKS WERE NEVER TREATED TO RESIST THE ELEMENTS /

NHTSA ID

11631220

Incident

Jun 7, 2023

i have an 07 chevy silverado 1500 it has a rusted fram the dealer i got it from sed it had a littel rust on the fram .he also told me that the traction control senser needed to be replaced.but he did not tell me about the passenger sied wheel hub i have put in right around $ 1,800 on new parts & labor i had to have the wiering all redone.now it is going to cost me onther $ 959.95 to fix the fram.thats not counting the brakits for the fule tank.or tghe brackits for the shocks.i could really need your help i am disabled & i do not get that much.so any help you can give me i would greatly appreciaet it.thank you

NHTSA ID

11546767

Incident

Sep 14, 2023

Dash cracking, fuse box continues to throw codes, front end problems

NHTSA ID

11438244

Incident

Oct 26, 2021

The contact owns a 2007 Chevrolet Silverado 1500. The contact stated while driving 35 MPH, the driver’s side front wheel detached. Due to the failure, the vehicle was towed to his residence where he inspected the vehicle himself. Upon inspection, the contact discovered that the driver’s side wheel hub had been welded to another piece of metal that was bolted to the vehicle. The contact discovered that the metal piece fractured causing the wheel to detach from the vehicle. The manufacturer was notified of the failure but offered no assistance. The contact repaired the vehicle himself. The failure mileage was 154,195.

NHTSA ID

11419326

Incident

May 16, 2021

Mileage

154,195 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 1500. WHILE THE VEHICLE WAS STATIONARY, THE UPPER AND LOWER BALL JOINT WHEEL BEARING ASSEMBLY WORE OUT. THE CONTACT STATED THAT THE RUBBER BUSHINGS BECAME WORN, WHICH CAUSED THE BALL JOINT ASSEMBLY TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10965734

Incident

Mar 8, 2017

Mileage

150,000 mi

FRAME BEAMING ON THE 2007 X TRA CAB CLASSIC TRUCK. GENERAL MOTORS CAMPAIGN #PIT3009J. THE PROBLEM IS SO BAD THAT IT SHAKES THE SEAT SO VIOLENTLY THAT IT IS A HEALTH HAZARD TO DRIVE AROUND. I HAVE BEEN DRIVING MY TRUCK FOR TWO YEARS NOW AS MY DAILY DRIVER. THE FRAME SHAKES SO BAD ON THE FREEWAY THAT IT HAS CAUSED ME BACK STRAINS AND NECK PAIN WHEN DRIVING FOR OVER AN HOUR. I HAVE BEEN TO AMERICAS TIRE MANY TIMES THINKING IT WAS A TIRE PROBLEM THEY HAVE REBALANCED THE TIRES AND EVEN REPLACED THE WHOLE SET WITH ANOTHER BRAND WITH NO IMPROVEMENT. AFTER MY RECENT MRI FROM BACK PAIN I BELIEVE THAT DRIVING THIS TRUCK IS FULLY TO BLAME FOR MY PAIN. TWO YEARS BEFORE I HAD A CLEAN CT SCAN WITH JUST A SLIGHT DISC BULGE, NOW ALL MY DISCS ARE SMASHED KNOWN AS SCHMOR'LS DEPRESSIONS CAUSED FROM THE REPEATED UP AND DOWN BEATING ON MY SPINE FROM DRIVING THIS SILVERADO FOR THE LAST TWO YEARS UP AND DOWN THE CALIFORNIA FREEWAYS. THERE ARE TIMES IT SHAKES SO BAD I FEEL I AM GOING TO LOOSE CONTROL OF THE TRUCK. I WANT GENERAL MOTORS TO KNOW HOW SERIOUS OF A PROBLEM THIS IS, MORE THAN A SHAKE IT IS BEATING PEOPLE LIKE ME TO DEATH AND IS A SERIOUS HEALTH RISK. I FEEL I HAVE NO CHOICE BUT TO CONTACT AN ATTORNEY FOR HELP. *TR

NHTSA ID

10944561

Incident

Jan 6, 2017

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS ABOVE 30 MPH, THE FRONT END OF THE VEHICLE WOULD EXPERIENCE SEVERE SHAKING AND VIBRATING. THE CONTACT DISCOVERED THAT THE PASSENGER SIDE MOUNTING BRACKET FOR THE SUSPENSION AND STEERING HAD SEPARATED FROM THE VEHICLE AND A SUB FRAME HAD FRACTURED NEAR THE BRACKET. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10819265

Incident

Jan 8, 2016

Mileage

100,000 mi

I HAVE A MAJOR RATTLE, AND LOUD ROARING AT ALL SPEEDS. I TOOK IT TO THE SHOP AND THEY COULDN'T FIND ANYTHING. BUT IT SEEMS LIKE IT IS GETTING WORSE I DON'T WANT MY FRONT END TO FALL OUT AND KILL ME. COULD YOU PLEASE LOOK IN TO THIS PROBLEM AND TELL ME IF THERE IS A RECALL OR NOTICE THANK YOU *TR

NHTSA ID

10564456

Incident

Feb 3, 2014

SELECTED ADAPTIVE EQUIPMENT AND SUSPENSION AND BODY BECAUSE THERE IS NO PLACE TO ADD TAILGATE AND THAT IS WHERE HE PROBLEM IS - GEEZ - THAT PART MAKES NO SENESE AT ALL. *TR TAILGATE LOCK ON RIDERS SIDE OF VEHICLE DOES NOT ENGAGE PROPERLY. IT HAS BEEN REPLACED ONCE AND GREASED ONCE AT BUTCH OSTELETE IN PASCAGOULA, MS. I CALLED ABOUT REPAIR BUT THE PERSON ON THE PHONE SAID THEY WOULD HAVE TO CHARGE ME TO REPAIR IT. THE PROBLEM IS YOU HAVE TO STICK YOUR FINGER IN THE LOCK PIN AND SLIDE IT UPWARD TO MAKE IT ENGAGE WHEN THE TAILGATE IS CLOSED. THIS HAS BEEN ON GOING SINCE I HAVE ON THE VEHICLE. IT IS A DEFECT THAT COULD CAUSE SOMEONE (LIKE ME) TO INJURE THEIR FINGER IN THE LOCK OR JOLT A PERSONS WRIST AND ELBOWS (LIKE ME) AND CAUSE HARM. THIS DEFECT NEEDS TO BE CALLED TO GM ATTENTION AND HAVE THESE ISSUES REPAIRED.

NHTSA ID

10556749

Incident

Dec 11, 2013

Mileage

168,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THERE WAS A RATTLING NOISE FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE REAR PASSENGER'S SIDE FRACTURED LEAF SPRING. TWO WEEKS AFTER THE REPAIR WAS PERFORMED THE REAR DRIVER'S SIDE LEAF SPRING FRACTURED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 08/15/13*LJ

NHTSA ID

10523976

Incident

Jun 19, 2013

Mileage

70,000 mi

ON MY SILVERADO WITH JUST UNDER 39,000 THE LEFT WHEEL BEARING HAD TO BE REPLACED ON 8/9/11. ON 10/6/11 THE RIGHT SIDE HAD TO BE REPLACED. I CONTACTED CHEVY AND THEY WILL NOT LOOK INTO ANY COMPLAINTS ON THE FAILURE OF THESE WHEEL BEARINGS WITH SUCH LITTLE MILEAGE. BOTH TIMES MY TRUCK HAD TO BE TOWED. I DO TRAVEL THE INTERSTATE ROUTES AND AN CONCERNED ABOUT MY SAFETY AND OTHERS ON THE ROAD BUT CHEVY TOLD ME "I'M ENTITLED TO MY OPINION." *TR

NHTSA ID

10435305

Incident

Aug 8, 2011

Mileage

39,000 mi

STEERING WHEEL VIBRATES WHEN APPLYING BRAKE PEDAL. THIS OCCURS WHEN BRAKING FROM SPEEDS OF 60MPH OR MORE. I HAD THE AGENCY INSPECT THE BRAKE SYSTEM AND ALIGNMENT, WHILE STILL UNDER WARRANTY. THEY STATED THE ALIGNMENT WAS CORRECT, AND DID NOT FIND ANY PROBLEMS WITH THE BRAKE SYSTEM. I ASKED THEY INSPECT THE BEARING AND SHAFT OF BOTH FRONT WHEELS, BUT THE SERVICE FORM DID NOT SHOW THEY INSPECTED IT. PROBLEM PERSISTS TO THIS DAY. *TR

NHTSA ID

10319488

Incident

Aug 25, 2009

Mileage

25,000 mi

TL*THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 1500. NINE MONTHS AFTER THE CONTACT PURCHASED THE VEHICLE, HE HAD IT DETAILED. HE BEGAN NOTICING RUST SPOTS ALL OVER THE VEHICLE AND THE UNDERCARRIAGE. THE DEALER STATED THAT THE FAILURE WAS DUE TO IRON DEPOSIT FROM THE TRANSPORTATION RAIL. AN ACID BATH TO REPAIR THE VEHICLE WOULD COST $400. THE REPAIR WAS NOT PERFORMED BECAUSE THE VEHICLE WAS STILL UNDER WARRANTY. WHILE BACKING OUT OF THE DRIVEWAY, THE CONTACT HEARD A CLANKING NOISE. HE TOOK THE VEHICLE BACK TO THE DEALER FOR INSPECTION. THE DEALER STOPPED THE CLANKING NOISE; HOWEVER, IT RECURRED A WEEK LATER. THE VEHICLE HAS BEEN TO THE SHOP AT LEAST EIGHT TIMES FOR THE SAME FAILURE, BUT THERE IS NO REMEDY TO SATISFY THE ISSUE. THE VEHICLE WAS TOWED TO THE DEALER AND THE CONTACT STATED THAT HE WOULD NOT ACCEPT THE VEHICLE BACK UNLESS ALL THE FAILURES WERE RESOLVED. THE FAILURE MILEAGE WAS 20,386.

NHTSA ID

10251082

Incident

Aug 3, 2007

Mileage

20,386 mi

ON MY 2007 CHEVY SILVERADO I NOTICED THE FRONT TIRES WEARING BADLY ON THE INSIDE EVERYBODY SAID IT WAS THE ALIGNMENT. OVER THE PHONE AND IN PERSON THE DEALERSHIP TOLD ME IT WAS NORMAL WEAR AND IT LOOK LIKE AN ALIGNMENT. HAD TIRES REPLACED AND ALIGNMENT CHECKED, BUT IT CAME OUT WITH IN SPECS. NEXT DAY FRONT BRAKES STARTED FAILING, CHEVY DEALER SAID WEAR AND TEAR. HAVING THE BRAKES LOOKED AT MECH TOLD ME THAT RIGHT PASS SIDE ROTOR WAS BEYOND REPAIR AND NEEDED TO BE REPLACED, AND THAT THE PAD HAD RIPPED FREE ON THE METAL BRACKET. WENT TO SHOP TO LOOK AND FOUND ALL PADS ARE RIPPING FREE FROM THE METAL CAUSING TOTAL BRAKE LOSS. PROBLEM FIXED BUT MECH. UNABLE TO BLEED SYSTEM PROPERLY DUE TO FAULTY OR CRACK MASTER CYLINDER. DEALER HAS PASSED IT ALL OFF AS NORMAL WEAR AND TEAR. NOW A COMPLAINT HAS BEEN FILLED THROUGH GMC CORP. THE TOTAL LOSS OF BREAK PAD ARE UNKNOWN TO THE DRIVE AND COME ON WITH OUT ANY WARNING AS THE BREAK PADS DO NOT HAVE ANY WARNING STOPS TO INFORM DRIVER OF WORN OUT BRAKE PADS I ONLY HAVE 18,500 MILES AND PURCHASED HE TRUCK NEW FROM DEALER IN QUESTION. *TR

NHTSA ID

10240244

Incident

Aug 26, 2008

Mileage

18,000 mi

I BOUGHT A 2007 CHEROLET SILVERADO CREW CAB USED (19,000 MI.) FROM MAROONE CHEVEROLET. I NOTICED THAT THE STEERING WAS SHAKEY AND THERE WAS A VIBRATION. THE SALESMAN SAID THAT THE TRUCK HAD A FULL NEW CAR WARRANTY AND THEY WOULD FIX IT. NOTE: THEY CLAIMED TO DO A 117 POINT CHECK TO BE GM CERTIFIED! THIS TRUCK SHAKES, WOBBLES AND RATTLES FROM DRIVING FROM NORMAL TO A LITTLE BUMP IN THE ROAD. TRANSMISSION WAS KLUNKING BETWEEN GEARS, IT IS BETTER, BUT NOT NORMAL. THE GAS MILLAGE DOES NOT COME CLOSE TO THE ADVERTISE STICKER ON WINDOW OF 16 - 21 MPG. I AM ONLY GETTING 12 MPG IN TOWN AND 17 MPG ON THE HIGHWAY. ABOUT 75% OF WHAT WAS EXPECTED. THE DEALER CLAIMS THIS IS AN ALL NORMAL WITH THIS TRUCK! *JB

NHTSA ID

10199995

Incident

Jul 22, 2007

Mileage

19,300 mi

ON MY 2007 SILVERADO 4X4 THAT NOW HAS 4,870 MI.,I'M ON THE 2ND SET OF BRIDGESTONE DEULER TIRES. THE TIRES WON'T BALANCE PROPERLY,2 OF THEM ARE OUT OF ROUND ACCORDING TO EQU. USED BY GM DEALERSHIP. THE DEALER ALSO REFUSES TO REPLACE THEM AGAIN .I'M CONCERNED THAT THE TIRES COULD COMPLETELY FAIL AND BE A SAFETY HAZARD TO ME AND OTHERS!!! *JB

NHTSA ID

10199280

Incident

Jun 9, 2007