2006 Chevrolet Silverado 2500 Tires & wheels Problems

265/75R16 9100 miles driven mostly on pavement with loads well within the vehicle capacity and never off road. Tires were rotated several months prior, about 100 miles ago and damage was not noted. Bubble appeared on sidewall which was noticed while parked; Tire shop dismounted the tire to inspect for possible causes and found nothing to explain damage (run flat, left deflated, road hazard damage). Secondary bubble slightly smaller on inside at same location. Smaller bubbles were felt inside tire and a longer, slight bubble follows the bead 1/3-1/2 of the diameter of the tire. Shop manager refused to remount tire due to risk to employees of catastrophic failure, indicating the tire poses significant safety risk if vehicle had been at highway speed and completed its deterioration. Mate to this tire on right rear shows same smaller bubble above the bead about 1/3 of tire diameter.

NHTSA ID

11585713

Incident

Apr 26, 2024

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 EQUIPPED WITH COOPER TIRES, DOT NUMBER: UTV6C8E4808, TIRE LINE: COOPER DISCOVERER ATR, TIRE SIZE: 265/75/R16. THE CONTACT STATED THAT WHILE DRIVING AT 63 MPH, THE CONTACT STATED THAT THERE WAS AN ABNORMAL VIBRATION FROM THE REAR OF THE VEHICLE. THE CONTACT STATED THAT THE TREAD SEPARATED FROM THE TIRE WHICH CAUSED DAMAGE TO THE BED OF THE VEHICLE. THE FAILURE OCCURRED ON THE REAR DRIVER SIDE TIRE. THE CONTACT STATED THAT THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS UNKNOWN. THE FAILURE MILEAGE ON THE VEHICLE WAS 114,900.

NHTSA ID

10967459

Incident

Mar 19, 2017

Mileage

114,900 mi

UNIROYAL LAREDO HD/H LT265/75 R15 HAD A TREAD SEPARATION THAT CAUSED CONSIDERABLE SHEET METAL DAMAGE WITHIN AND BEHIND THE RIGHT REAR WHEEL WELL OF MY CHEVY SILVERADO 2500 HD PICKUP. THE INCIDENT OCCURRED AT 60 MPH WHILE I WAS TOWING A TRAVEL TRAILER. I NEVER LOST CONTROL OF THE VEHICLE AND WAS ABLE TO BRING IT SAFELY TO A CONTROLLED STOP. THE TIRE WAS ONE OF FOUR INSTALLED NEW BY THE AUTO DEALER IN EARLY 2012 WHEN I PURCHASED THE TRUCK USED. THE TIRE HAD APPROXIMATELY 17,000 MILES OF USE WHEN THE SEPARATION OCCURRED. I ALWAYS KEPT THE TIRE INFLATED TO THE TRUCK AND TIRE MANUFACTURERS' RECOMMENDED 80 PSI AND HAD JUST INFLATED THE TIRE TO THAT PRESSURE (IT WAS AT 74 PSI BEFORE I TOPPED IT OFF) THREE DAYS EARLIER, BEFORE STARTING MY TRIP. I NOTICED A RECALL OF TIRES OF SIMILAR VINTAGE IN THE UNIROYAL LAREDO HD/H LT 245/75 R16 SERIES, AND I AM CURIOUS IF MANY TREAD SEPARATIONS HAVE ALSO BEEN REPORTED FOR THE 265/75 R16 SERIES OR IF THIS IS A ONE OFF INCIDENT. *TR

NHTSA ID

10678533

Incident

Jan 21, 2015

Mileage

127,451 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 THAT WAS EQUIPPED WITH BF GOODRICH COMMERCIAL T/A TIRES, SIZE LT265/75R16. THE CONTACT STATED THAT THREE OF THE FOUR TIRES EXPERIENCED TREAD SEPARATION WITHIN THE PAST SIX MONTHS. EACH TIRE NEEDED TO BE REPLACED, EXCEPT FOR THE FRONT PASSENGER SIDE TIRE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE VEHICLE FAILURE MILEAGE WAS 180,000.

NHTSA ID

10631606

Incident

May 1, 2014

Mileage

180,000 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE VEHICLE IS EQUIPPED WITH FEDERAL COURAGIA A/T TIRES, SIZE 33512.50R/20LT (NA). THE CONTACT STATED THAT THE SIDEWALLS OF THE TIRES CONTAINED BUBBLES. THE TIRES WERE NOT REPLACED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE TIRE FAILURE MILEAGE WAS 103,000 AND THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

NHTSA ID

10621317

Incident

Jul 1, 2014

Mileage

100,000 mi

FOUR BUBBLES ON THE SIDEWALL OF MY TIRE APPEARED - I TOOK THE TIRE TO A GOODYEAR DEALER AND HE CONCLUDED THAT THE TIRE WAS DEFECTIVE FROM THE BEGINNING WHEN I BOUGHT IT. IT HAD 10,000 MILES ON THE TIRE WITH ORIGINAL TIRE TREAD OF 7/32 - IT NOW HAS 6/32 TREAD. GOODYEAR GAVE ME A $80.00 DISCOUNT ON A NEW TIRE - I CALLED THEM AND ASKED FOR A 100% DISCOUNT SINCE THE TIRE WAS DEFECTIVE FROM THE BEGINNING. I HAVE THREE OTHER TIRES ON THE TRUCK ALL GOODYEAR TIRES AND IT APPEARS THEY COULD BE DOING THE SAME THING. I ALSO DISCOVERED THAT THERE WAS RECALL ON GOODYEAR WRANGLER TIRES HAVING THE SAME ISSUES JUST NOT ON MY TIRE SINCE IT IS MUCH LARGER AND NOT THAT POPULAR. *TR

NHTSA ID

10513291

Incident

May 17, 2013

Mileage

81,979 mi

MICHELIN LTX M/S LT245/75R16 TIRES (2007 CHEVY 2500 HD SINCE 11/06/2006) 07/15/2010: 79,144 MILES. FRONT DRIVER SIDE TIRE HI-SPEED BLOW-OUT (APPROX. 55 MPH). DAMAGE TO FRONT & REAR UTILITY TOOL BOXES; LEFT REAR MUD FLAP & FUEL FILTER ASSEMBLY RIPPED AWAY. 07/28/2010: 79,965 MILES. REPLACED TIRE DUE TO TREAD SEPARATION 08/31/2010: MICHELIN SENT LETTER STATING COMPLETION OF 07/15/2010 CLAIM FINDING NO DEFECT IN DESIGN OF TIRE OR REASON FOR INCIDENT; PAID PARTIAL REPAIR DAMAGES. 11/05/2010: REPLACED TIRE DUE TO TREAD SEPARATION. 02/01/2011: 90,101 MILES. REPLACED TIRE DUE TO TREAD SEPARATION. 06/18/2012: 112,000 MILES. NOTICED BUBBLE (APPROX. 1 INCH IN SIZE) ON FRONT PASSENGER TIRE; PARKED VEHICLE IN SHADE; APPROX. 1 1/2 HRS LATER REMOVED BAD TIRE; NOTICED BUBBLE GREW BIGGER IN SIZE (APPROX. 3 IN.); LEANED BAD TIRE UPRIGHT AGAINST VEHICLE; INSTALLED SPARE TIRE (APPROX. 15-20 MIN), TURNED TO RETRIEVE BAD TIRE; TIRE EXPLODED LITERALLY IN FACE; NO INJURY DUE TO SAFETY GLASSES. OTHER PERSON HAD JUST TURNED AWAY AT EXPLOSION WITH TIRE PARTS HIT HIM IN BACK; NO INJURY. *JS

NHTSA ID

10462466

Incident

Jun 18, 2012

Mileage

112,000 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 EQUIPPED WITH FEDERAL MOGUL CORAGIA M/T TIRES, LINE SIZE: 285/75/16, DOT NUMBER: E40010658 UXLS. THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE TIRE WAS FLAT. THE CONTACT INSPECTED THE TIRES AND DISCOVERED THAT THERE WERE LONG CRACKS BELOW THE THREAD ON THE FRONT AND REAR DRIVER AND PASSENGER TIRES. THE TIRES WERE NOT REPLACED. THE APPROXIMATE FAILURE MILEAGE WAS 8,000. KMJ

NHTSA ID

10426912

Incident

Sep 23, 2011

Mileage

8,000 mi

HAVE FEDERAL COURAGIA MT TIRES CURRENTLY ON MY TRUCK. BOUGHT LAST YEAR AND HAVE APPROXIMATELY 10,000 MILES ON THEM BOUGHT THEM NEW. NOTICES CRACKS IN THE SIDEWALK. NOW THEY ARE RUNNING AND GETTING LARGER, ALSO SEEN SEVERAL OTHER COMPLAINTS ON THESE TIRES FOR THE SAME THING. VERY DANGEROUS. SIZE 285/76/16 *TR

NHTSA ID

10426824

Incident

Sep 22, 2011

Mileage

109,000 mi

DRIVING DOWN THE HIGHWAY AT 65 MPH FRO APPROXIMATELY 2 HOURS. THE TIRES WERE DELAMINATING AND BLEW. ONE TIRE EXPLODED, WHILE THE OTHER HAD A BUBBLE (TREAD WAS SEPARATING FROM THE CASING. BOTH TIRE DOT # BF11KF112606. *TR

NHTSA ID

10348316

Incident

Aug 6, 2010

TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. IN MARCH OF 2007, THE REAR PASSENGER SIDE TIRE VALVE STEM FAILED WITHOUT WARNING. ON MARCH 28, 2009, BOTH THE FRONT AND REAR DRIVER'S SIDE VALVE STEMS FAILED LIKE THE ONE IN 2007. THE CONTACT WAS INFORMED BY THE TIRE COMPANY THAT THE VALVE STEMS WERE CRACKING, BUT COULD NOT PROVIDE AN EXPLANATION FOR THE FAILURES. THE CONTACT FEELS THAT THE VALVE STEMS ARE FAULTY AND DEFECTIVE AND SHOULD BE REPLACED BY THE MANUFACTURER. THE CURRENT AND FAILURE MILEAGES WERE 8,500.

NHTSA ID

10265156

Incident

Mar 27, 2009

Mileage

8,500 mi

THIS IS A 2006 6.6 TURBO DIESEL 2500 HD SILVERADO, THE FOUR WHEEL DRIVE WILL NOT ENGAGE LIGHT KEEP FLASHING, SERVICE 4 WHEEL DRIVE IS ON , THIS TRUCK ONLY HAS 19,000 MILES ON IT. *TR

NHTSA ID

10210481

Incident

Dec 1, 2007

Mileage

19,025 mi

TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT PASSENGER SIDE TIRE BLEW OUT. THE CONTACT WAS ABLE TO PULL TO THE SIDE OF THE ROAD WITHOUT A CRASH. HE STATED THAT HE WILL CONTACT THE MANUFACTURER. THE CONTACT STILL HAS THE FAILED AMERI-TECH TIRE. THE VIN, ENGINE SIZE, NUMBER OF CYLINDERS, AND DOT NUMBER WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 30,000. RETURNED USPS, 2ND ATTEMPT MADE 08/06/07 ATTEMPT FAILED . *LJ

NHTSA ID

10198616

Incident

Aug 5, 2007

Mileage

30,000 mi