1999 Chevrolet Silverado Owner Complaints

The contact owns a 1999 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 00V097000 (Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the contact became aware that the driver's side seat belt was not functioning properly. The vehicle was taken to the dealer where it was diagnosed that the driver's side seat belt assembly had failed and needed to be replaced. The vehicle was not repaired due to the parts not being available. The manufacturer was made aware of the failure. The failure mileage was approximately 418,000. Parts distribution disconnect.

NHTSA ID

11614850

Incident

Sep 16, 2024

Mileage

418,000 mi

The contact owned a 1999 Chevrolet Silverado. The contact stated that while driving at 55 MPH, he dozed off as the vehicle drifted off to the right shoulder of the highway. The contact regained alertness once the vehicle drove over the highway's rumble strip. As the contact attempted to regain control of the vehicle; the vehicle crashed into a tree. The contact's face smashed into the steering wheel as both the driver's seat belt shoulder strap and the driver's air bag failed to operate as needed. Moments after smashing his head into the steering, the contact stated that the air bag deployed with a delay which caused severe cuts to the contact's face. The contact was taken to the hospital by ambulance where he was treated for multiple severe injuries. Due to the air bag failure, the contact suffered a severe laceration that started from the right corner of the contact's mouth and extended to the contact's left earlobe. The contact suffered another laceration that started from the center of his bottom lip and curved down to the left side of his chin. In addition, the contact suffered a right orbital socket fracture, two vertebrae fractures in the neck, a torn right shoulder, multiple torn tendons in the right arm and five broken teeth. A police report was not filed. The vehicle was towed from the scene to an independent tow yard where it was destroyed. The dealer nor the manufacturer were notified of the failure. The failure mileage was approximately 160,000.

NHTSA ID

11612838

Incident

Oct 29, 2017

Mileage

160,000 mi

DRIVING ALONG ROAD, BRAKE PEDAL WENT TO THE FLOOR WHEN I ATTEMPTED TO STOP. UPON INSPECTION, DISCOVERED THAT THE HYDRAULIC LINE GOING FROM THE ABS MODULE TO THE REAR BRAKES HAD RUPTURED DUE TO CORROSION. UPON FURTHER INSPECTION IT HAS BEEN DETERMINED THAT ALL OF THE HYDRAULIC BRAKE LINES ARE SWOLLEN AND CORRODED TO THE POINT OF FAILURE AND MUST BE REPLACED AT A COST OF OVER $1200. MY TRUCK HAS NOT MOVED SINCE, AS I CANNOT AFFORD TO REPAIR THIS ISSUE.

NHTSA ID

10809995

Incident

Jul 15, 2014

Mileage

230,000 mi

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE TECHNICIAN INFORMED THE CONTACT THAT THE FRAME WAS SEVERELY FRACTURED AND NEEDED TO BE REPLACED. THE FAILURE HAPPENED WITHOUT WARNING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 176,000. UPDATED 1/14/16 LN UPDATED 02/12/16*LJ *TR

NHTSA ID

10795128

Incident

Nov 20, 2015

Mileage

176,000 mi

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH, THE VEHICLE STARTED MAKING A LOUD CRACKING NOISE CAUSING THE VEHICLE TO DRIVE ABNORMAL. THE CONTACT NOTICED THAT THE FRAME WAS FRACTURED IN TWO AREAS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 168,000.

NHTSA ID

10787318

Incident

Sep 15, 2015

Mileage

168,000 mi

I CAME OUT TO MY TRUCK ONE DAY AND THE CAB WAS TOUCHING THE BACK OF MY BOX. I LOOK UNDER IT AND THE FRAME WAS BROKEN AND RUSTED OUT ON BOTH SIDE BY THE GAS TANK. VEHICLE I'D BEYOND REPAIR AND NOT DRIVABLE. ONLY HAS 181XXX MILES ON IT.

NHTSA ID

10780239

Incident

Aug 10, 2015

Mileage

18,100 mi

WHILE APPROACHING INTERSECTION PUT ON BRAKES AND THEY FAILED, PEDAL WENT TO THE FLOOR. IF I HAD NOT BEEN A TEST DRIVER FOR CHRYSLER CORP. AND DOING LOTS OF BRAKE AND SUSPENSION WORK I COULD HAVE EASILY BEEN SERIOUSLY HURT. THE BRAKE LINES WERE SHOT, RUSTED THROUGH. THIS VEHICLE HAS SPENT IT'S LIFE IN FL. NO SALT ON THE ROAD. I KNOW YOU HAVE RULED ON THIS BEING A RECALL, BUT I THINK YOU MADE A HUGE MISTAKE, SOMEONE WILL BE KILLED BY THIS. THANKS

NHTSA ID

10761469

Incident

Sep 3, 2015

Mileage

170,000 mi

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO EQUIPPED WITH COOPER DEAN MUD TERRAIN RADIAL SXT, SIZE: 119/116N. WHILE DRIVING 65 MPH, THE STEERING WHEEL STARTED TO WOBBLE AND MADE A LOUD ABNORMAL NOISE UNDER THE VEHICLE. THE CONTACT STATED THAT THE FRONT DRIVER SIDE TIRE BLEW OUT. AN INDEPENDENT MECHANIC REPLACED THE TIRE. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 149,910 AND THE TIRE FAILURE MILEAGE WAS UNKNOWN. MA 10/23/15 *CN

NHTSA ID

10745842

Incident

Jul 31, 2015

Mileage

149,910 mi

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO. WHILE DRIVING 20 MPH AND ATTEMPTING TO ENGAGE THE BRAKES, THE ACCELERATOR PEDAL WENT TO THE FLOOR AND THE BRAKES FAILED WITHOUT WARNING. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE BRAKE LINE WAS CORRODED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE WHERE HE DISCOVERED LARGE AMOUNTS OF BRAKE FLUID LEAKING FROM VARIOUS SPOTS ON THE BRAKE LINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 138,000.

NHTSA ID

10735923

Incident

Jul 19, 2015

Mileage

138,000 mi

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 35 MPH HAULING A TRAILER, THE FRONT AND REAR BRAKE HYDRAULIC LINES FAILED. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY USING THE BRAKES ON THE TRAILER. THE VEHICLE WAS TAKEN TO THE DEALER; HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT, AN EXPERIENCED MECHANIC, DIAGNOSED AND REPLACED THE BRAKE LINES. ON A SEPARATE OCCASION WHILE DRIVING 50 MPH, A PLASTIC COMPONENT OF THE DRIVER'S SEAT FRACTURED AND CAUSED THE SEAT TO SLIDE BACK AND FORTH INTO THE STEERING WHEEL. THE FAILURE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 58,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10731242

Incident

Jan 1, 2015

Mileage

58,000 mi

I WAS DRIVING HOME ON MEMORIAL DAY 2014 PULLING MY BOAT AND TRAILER. TRAFFIC WAS STOPPED OUTSIDE CRIVITZ, WI AND I HAD TO HIT MY BRAKE PEDAL. IT WENT RIGHT TO THE FLOOR - NO BRAKES AT ALL - CONTRARY TO THE GM INFO IN AN ARTICLE I READ ON YAHOO. I QUICKLY HIT THE SHOULDER, FORTUNATELY WIDE AND HARD, AND COASTED INTO A MINI MALL IN CRIVITZ. DOWN SHIFTED AS I WENT AND HIT THE EMERGENCY IN THE MALL LOT. FEEL VERY FORTUNATE THAT MY WIFE AND I ARE ALIVE AS WELL AS THOSE IN FRONT OF US. BOTH BACK BRAKE LINES WERE BLOWN AS WELL AS A FRONT. TRUCK IS MAINTAINED EVERY 3-4 MONTHS. GM IS FULL OF BEANS. I HAVE DRIVEN NUMEROUS CHEVROLET CARS IN EXCESS 0F 180,00 MILES WITHOUT ANY BRAKE LINE ISSUES. THIS TO ME IS FAULTY ENGINEERING. $1100+ TO REPAIR.

NHTSA ID

10705722

Incident

May 26, 2014

Mileage

142,000 mi

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHEN THE PICKUP BOX WAS REMOVED, THERE WAS EXCESSIVE RUST ON THE BRAKE LINES AND FUEL TANK STRAPS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TWO REAR BRAKE LINES AND THE REAR FUEL TANK STRAP HAD EXCESSIVE RUST AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10704948

Incident

Dec 10, 2014

Mileage

140,000 mi

I WAS DRIVING TO MY HOME FROM WORK WHEN I NOTICED AN EXCESSIVE KNOCKING SOUND COMING FROM THE FRONT OF THE TRUCK. I PULLED INTO MY DRIVEWAY LOOKED AT THE FRONT SUSPENSION AND AROUND BOTH TIRES. THAT'S WHEN I SAW THAT THE PASSENGER SIDE FRONT UPPER SHOCK MOUNT HAD BROKEN FREE FROM THE FRAME. THE SHOCK WAS JUST BANGING FREELY AGAINST THE FRAME. THE TRUCK IS 15 YEARS OLD SO I KNOW ITS NOT UNDER WARRANTY, BUT THAT'S JUST POOR CONSTRUCTION. THE TRUCK HAS BEEN MY DAILY DRIVER AND HAS NEVER BEEN OFFROAD. JUDGING FROM THE OTHER COMPLAINTS REGARDING THE FRAME CRACKING AND/OR BREAKING THAT I'VE READ, I'M ASSUMING GM ISN'T GOING TO DO ANYTHING ABOUT IT. IT'S JUST SAD. REGARDLESS, I THINK NHTSA SHOULD ISSUE A RECALL BECAUSE THIS IS A SAFETY CONCERN. THE EXCESS BOUNCE CAN CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICLE. *TR

NHTSA ID

10704776

Incident

Apr 2, 2015

Mileage

143,000 mi

BRAKES: SINCE APPROXIMATELY 136,000 MILES TO PRESENT MILES, THE VEHICLE HAS EXHIBITED AN ABS AND BRAKE WARNING LIGHT INTERMITTENTLY ON THE DASH. THIS IS A KNOWN GM ISSUE THAT WAS RECALLED IN CERTAIN STATES, BUT NOT ALL. IT STEMS FROM FAULTY SOLDERING POINTS IN THE ABS CONTROL MODULE AND CAN AFFECT THE VEHICLES ABILITY TO STOP CORRECTLY WHICH COULD RESULT IN AN ACCIDENT. ENGINE/ EMISSIONS: THE PASSENGER SIDE EXHAUST MANIFOLD BOLT HAS BROKEN OFF. THIS IS A KNOWN ISSUE WITH THIS 5.3L ENGINE AS WELL AS THE 4.8L AND 6.0L ENGINES. GM HAS FAILED TO RECALL IN SPITE OF HAVING THOUSANDS OF COMPLAINTS. THE ISSUE CAN CAUSE FAILED EMISSIONS AND POTENTIALLY ENGINE FIRES. ENGINE: AS OF 164,000 MILES, THE ENGINE IS EXPERIENCING LOUD "PISTON SLAP". THIS IS A KNOWN ISSUE WHICH GM ADDRESSED THROUGH REDESIGN IN LATER MODELS. IT LEADS TO EXCESSIVE ENGINE WEAR AND POTENTIAL ENGINE FAILURE. IT APPEARS TO BE A FACTORY DEFECT, YET GM HAS CLAIMED IT IS NOT IMPORTANT DESPITE NUMEROUS COMPLAINTS FROM CUSTOMERS THAT THE ENGINES HAVE REQUIRED REPLACEMENT AS A RESULT. *TR

NHTSA ID

10703787

Incident

Apr 5, 2015

Mileage

164,000 mi

THE CHROME ON THE CHEVROLET BADGE ON THE FRONT GRILL HAS STARTED TO PEEL. WHILE WASHING THE TRUCK THE CHROME, SLIVER, SLICE MY FINGER OPEN LIKE A RAZOR BLADE. *TR

NHTSA ID

10691811

Incident

Mar 3, 2015

Mileage

121,333 mi

ONE MORNING OUT OF THE BLUE WHEN I WENT TO DRIVE MY TRUCK, PRESSED THE BRAKE PEDAL TO PUT IT IN GEAR MY PEDAL WENT TO THE FLOOR WITH VERY LITTLE GIVE. LOOKING UNDER THE TRUCK I NOTICE A METAL BRAKE LINE HAS A HOLE. THE WORST PART, ALL THE MEDAL BRAKE LINES ARE SO RUSTED IT LOOKS AS IF THEY COULD ALL FAIL AT ANY TIME. *TR

NHTSA ID

10676251

Incident

Jan 15, 2015

Mileage

147,248 mi

PUSHED THE BRAKE PEDAL AND WAS NOT ABLE TO STOP DUE TO A BLOWN BRAKE LINE. THIS WAS MY FIRST INCIDENT, BUT THE SECOND FOR THE TRUCK. THIS ISSUE OCCURRED WHEN MY FATHER OWNED THE TRUCK AND HE HAD GM REPLACE THE BRAKE LINES. I HAD GM REPLACE THE BRAKE LINES FOR A SECOND TIME. IT'S VERY SCARY NOT BEING ABLE TO STOP A VEHICLE, BUT LUCKILY I WAS ON A HIGHWAY AND WAS ABLE TO DRIFT OVER TO THE SHOULDER. *TR

NHTSA ID

10667210

Incident

Nov 12, 2014

Mileage

213,000 mi

DRIVING ON TWO WAY STREET ATTEMPTED A RIGHT HAND TURN APPLIED BRAKES, PEDDLE WENT TO FLOOR, ATTEMPTED TO PUMP, TRUCK SLOWED TO STOP. NOTED LARGE AMOUNT OF FLUIDS ON ROAD. TRUCK WAS TAKEN TO MECHANIC, FOUND BRAKE-LINE HAD BURST ON LEFT FRONT WHEEL. AFTER INSPECTION NOTED THAT ALL BRAKE-LINES LOOKED LIKE KFC CHICKEN WERE ALL CORRODED AND BRITTLE. MECHANIC INDICATED THAT THIS WAS A EXTREME SAFETY HAZARD. RECOMMENDED THAT I CONTACT DEALERSHIP AND REPORT INCIDENT. ALSO, FILL OUR AND FILE A VEHICLE SAFETY COMPLAINT. I WAS NOT INFORMED BY GM THAT THERE MAYBE A PROBLEM THAT HAS BEEN ON GOING AND AFTER LOOKING INTO IT HAVE FOUND BOTH GM'S CAVALIER ATTITUDE, AND THE GOVERNMENTS NOT REQUIRING AT THE VERY LEAST A NOTIFICATION NEVER MIND A TOTAL FIX TO BE REQUIRED OF GM A SERIOUS BREACH OF CONFIDENCE IN MY GOVERNMENT TO PROVIDE FOR THE SAFETY OF ITS CITIZENS. *TR

NHTSA ID

10661101

Incident

Nov 25, 2014

Mileage

10,045 mi

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO. WHILE DRIVING 35 MPH AND APPROACHING A TRAFFIC LIGHT, THE BRAKE PEDAL SANK TO THE FLOORBOARD WHEN DEPRESSED. THE CONTACT HAD TO QUICKLY SHIFT THE TRANSMISSION IN ORDER TO STOP THE VEHICLE SAFELY. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE CONTACT DETERMINED THAT THE ABS HYDRAULIC UNIT WOULD NEED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT INFORMED IF THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 00V345000 (SERVICE BRAKES, HYDRAULIC) AND NHTSA CAMPAIGN NUMBER: 00X001000 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 185,000.

NHTSA ID

10658636

Incident

Nov 14, 2014

Mileage

185,000 mi

I OWN A 1999 SILVERADO EXT CAB 4X4 AND THE FRAME IS ROT IN MANY DIFFERENT PLACES THE DRIVER AND PASSENGER MID SECTIONS ARE HALF GONE AND NOW THE REAR SECTIONS UNDER THE BED ARE ROTTING TO THE POINT TO WHERE THE IS NO GOOD METAL LEFT THE BED BUCKLED AND IS HITTING THE CAB THE REST OF THIS VEHICLE IS IN VERY GOOD CONDITION BUT THE FRAME IS GONE. *TR

NHTSA ID

10651289

Incident

Oct 11, 2011

Mileage

115,000 mi

HELLO IM REPORTING A PROBLEM I HAVE NOTICED ABOUT RUST ON THE UNDER BODIES OF THE CHEVY AND GMC PICK UPS. IT IS A WIDESPREAD PROBLEM AND NEEDS TO BE RESOLVED. THERE ARE TOO MANY VEHICLES REPORTING THIS PROBLEM TO MAKE IT A COINCIDENCE. I MYSELF HAVE THIS PROBLEM WHERE MY FRAME HAS NOW CRACKED FOR THE SECOND TIME. PEOPLE ARE COMPLAINING MORE AND MORE AND OUR SAFETY IS AT STAKE. PLEASE WHATEVER CAN BE DONE TO BRING GM TO RECOGNIZE THIS PROBLEM CAN AND WILL SAVE A LOT OF LIVES AS WELL AS HUNDREDS OF THOUSANDS OF DOLLARS. THANK YOU *TR

NHTSA ID

10643196

Incident

Oct 7, 2014

Mileage

96,000 mi

WAS GOING TO WORK AT ABOUT 3:40 PM ABOUT 15 MILES FROM MY HOUSE HAD STOPPED AT 2 STOP SIGNS AND 3 RED LIGHTS WAS GOING DOWN HILL TOWARDS 4TH STOP LIGHT CARS WERE SLOWING DOWN IN FRONT OF ME SPEED LIMIT WAS 45 I WAS SLOWING MY VEHICLE AT ABOUT 25MPH OR LESS LOST ALL BRAKES PEDAL WENT COMPLETELY TO FLOOR WAS NOT ABLE TO STOP VEHICLE HIT TRUCK IN FRONT OF ME NO ONE WAS INJURED THANK GOD THIS VEHICLE WAS BOUGHT BRAND NEW BUY US AT SHELOR MOTOR MILE CHEVROLET IN CHRISTIANSBURG VIRGINIA IT CAME WITH LIFETIME INSPECTION BY THEM HAD ALWAYS BEEN INSPECTED BY THEM LAST INSPECTION 7 MONTH THIS YEAR LAST DAY OF MONTH NEVER GOT ANY CALL OF RECALL NOTICE FROM GM OR CHECK BRAKE LINE INFORMATION FROM THEM I THINK GM SHOULD PAY TO HAVE MY TRUCK BRAKE LINES REPLACED AND BE HELD LIABLE FOR DAMAGES TO MY AND THE OTHER PERSONS TRUCK THIS IS A MUCH MORE SEVERE PROBLEM THEN IGNITION SWITCH CUTTING OFF I THINK GM IS PUTTING THIS OFF BECAUSE OF COST AND LABOR CHARGES THE TRUCK IS BEING TOWED TO DEALERSHIP TODAY BY THE WAY BRAKE LINES AT LEFT UNDER DRIVERS DOOR AT ABS VALVE BURST WITH NO WARNING DUE TO CORROSSION. *TR

NHTSA ID

10632341

Incident

Sep 10, 2014

Mileage

150,000 mi

I WAS MOVING THE 1999 CHEVROLET SILVERADO 1500 IN MY DRIVEWAY TO MAKE ROOM TO MOVE ANOTHER CAR. I BACKED THE TRUCK INTO MY TURN AROUND, THEN PUT THE TRUCK INTO DRIVE TO MOVE IT FORWARD A LITTLE. WHEN I PUSHED ON THE BRAKES TO STOP THE PEDAL WENT HALFWAY TO THE FLOOR STOPPED THEM WENT CLEAR TO THE FLOOR. I HAD NO BRAKES, OTHER THAN THE EMERGENCY BRAKE ON THE TRUCK, WHICH I USED TO STOP THE TRUCK. AFTER GETTING THE TRUCK STOPPED AND TO A SPOT I COULD INSPECT IT. I DISCOVERED THAT TWO BRAKE LINES HAD BURST AND WERE LEAKING FLUID ONTO THE GROUND. THE BREAKS WERE NOT IN A BEND IN THE LINE WHERE THEY SEEMS TO TYPICALLY HAPPEN. THEY WERE IN A STRAIGHT SECTION JUST UNDERNEATH THE DRIVERS SIDE DOOR WHERE THE LINES RUN ALONG THE FRAME. UPON FURTHER INSPECTION I NOTICED THAT ALL THE BRAKE LINES WERE AS HEAVILY CORRODED AS THE SECTION THAT HAD BURST. LUCKILY THIS HAPPENED IN THE DRIVEWAY AS I WAS PREPARING TO LEAVE IN THE TRUCK. *TR

NHTSA ID

10629992

Incident

Aug 18, 2014

Mileage

95,757 mi

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE EXHAUST MANIFOLD STUDS DETACHED FROM THE CYLINDER HEAD CAUSING EXHAUST FUMES TO LEAK FROM THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

NHTSA ID

10626555

Incident

Apr 16, 2013

Mileage

90,000 mi

ABS FAILURE TO STOP VEHICLE. ACCIDENT OCCURRED. *TR

NHTSA ID

10626001

Incident

Sep 9, 2010

Mileage

156,386 mi