2019 Chevrolet Sonic Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2019 Chevrolet Sonic, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine457.1%
- Fuel system228.6%
- Electrical114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The thermostat housing and water pump keeps failing and leaking.The seat heaters dont work. The car started leaking antifreeze real bad which cause it to overheat and lock up. Yes it has been confirm by a dealer that alot of the chevys been coming for new thermostat housing and water pumps. No vehicle was only inspected by a dealer. The overheating like came on and then 10 seconds later the car locked up
The contact owns a 2019 Chevrolet Sonic. The contact stated while pulling into the garage, the high engine temp warning light illuminated, and the engine was overheating. The contact immediately turned off the vehicle. The contact stated there was coolant underneath the front of the vehicle. The contact had learned that the water pump failure was common for the vehicle and believed that the water pump had failed. The contact was able to identify an extended warranty for the failure. The vehicle had not been taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure when it was confirmed that the VIN was not covered under warranty or recall. The manufacturer had referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 81,400.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The thermostat housing and water pump keeps failing and leaking.The seat heaters dont work. The car started leaking antifreeze real bad which cause it to overheat and lock up. Yes it has been confirm by a dealer that alot of the chevys been coming for new thermostat housing and water pumps. No vehicle was only inspected by a dealer. The overheating like came on and then 10 seconds later the car locked up
cooling ISSUES - the WATER PUMPLE , cooling TANK . the WHOLE COOLING . my CARE HAS BEEN SHOP 5 TIMES AT JBA for cooling system
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The thermostat housing and water pump keeps failing and leaking.The seat heaters dont work. The car started leaking antifreeze real bad which cause it to overheat and lock up. Yes it has been confirm by a dealer that alot of the chevys been coming for new thermostat housing and water pumps. No vehicle was only inspected by a dealer. The overheating like came on and then 10 seconds later the car locked up
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .