2001 Chevrolet Suburban 1500 Problems

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE WAS PUT ON A LIFT AND IT WAS DISCOVERED THAT THE BRAKE LINE WAS CORRODED, CAUSING A LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE CONTACT CALLED THE ED BOZARTH CHEVROLET DEALER (877-721-4901, 3731 SW TOPEKA BLVD, TOPEKA, KS 66609) AND WAS TOLD THAT THERE WAS NO RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000. *TT CONSUMER STATED BRAKE LINES CORRODED AND WAS LEAKING. UPDATED 12/18/18*JB

I WAS SLOWING FOR A STOP SIGN WHILE LEAVING A PARKING LOT WHEN THE STEEL REAR BRAKE LINE SPONTANEOUSLY SPLIT AND DUMPED ALL LINE PRESSURE. THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR, AND I ROLLED RIGHT INTO TRAFFIC BEFORE I WAS ABLE TO PUMP THE PEDAL ENOUGH TIMES TO STOP THE VEHICLE AGAINST A CURB. HAD I NEARED THE STOP SIGN 2 SECONDS EARLIER OR LATER, I WOULD HAVE EITHER BEEN T-BONED BY A BOX TRUCK, OR T-BONED A SMALL SEDAN. I EMPHASIZE THAT THE BRAKE LINES SHOWED NO WARNING SIGNS BEYOND THE TYPICAL SURFACE RUST THAT CAN BE FOUND ON ANY VEHICLE THAT HAS BEEN DRIVEN FOR MORE THAN A FEW WINTERS IN THE "RUST BELT". HOWEVER, THOSE VEHICLES DO NOT HAVE BRAKE LINES SPONTANEOUSLY FAIL AT THE RATE THAT THESE GM TRUCKS DO. THIS TRUCK'S PRIMARY PURPOSE IS TOWING A CAMPING TRAILER FOR VACATIONS WITH MY YOUNG FAMILY, SO THIS COULD HAVE ENDED VERY DIFFERENTLY. I URGE YOU TO TAKE GM TO TASK AND FORCE THEM TO FIX THEIR MISTAKE OF CHEAPING OUT ON BRAKE LINE MATERIALS!

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL PUMP WAS DISABLED AND THE ODOR OF FUEL WAS PRESENT. ALSO, THE CONTACT INDICATED THAT THE FUEL GAUGE DISPLAYED INACCURATE FUEL LEVELS WHILE OPERATING THE VEHICLE AND THE SERVICE ENGINE SENSOR LIGHT HAD ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V155000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 260,000.

WENT TO START MY 2001 CHEVY SUBURBAN AND IT WOULDN'T START. I LISTENED FOR THE FUEL PUMP TO ENGAGE AND IT WASN'T WORKING. I CHECKED THE RELAY AND NOTICED IT WAS MELTED ON ONE CORNER. I HAVE RESEARCHED THIS ONLINE AND FOUND SEVERAL COMPLAINTS ABOUT THE SAME PROBLEM. ALSO NOTICED THAT GM HAS DONE NOTHING TO FIX THIS ISSUE. I HAVE BEEN A GM FAN ALL MY LIFE AND WOULD LIKE TO CONTINUE BEING ONE. PLEASE RECALL THIS ON GOING PROBLEM GM. *TR

WHEN VEHICLE IS IDLING WHILE NOT MOVING EXTREME AMOUNTS OF EXHAUST FUMES ARE ENTERING THE CABIN AREA THROUGH THE VENTILATION SYSTEM. THIS IS DUE TO DEFECTIVE EXHAUST MANIFOLD BOLTS WHICH ARE BREAKING ALLOWING THE EXHAUST MANIFOLD TO OPEN AND ALLOW FUMES TO ENTER THE ENGINE COMPARTMENT WHICH RESULTS IN THE EXHAUST FUMES ENTERING THE PASSENGER CABIN AREA THROUGH THE VENTILATION SYSTEM. THIS IS A HEALTH ISSUE FOR PASSENGERS INSIDE THE CABIN BREATHING THE TOXIC EXHAUST FUMES. THIS SHOULD BE A SAFETY RECALL ON GM TO FIX THE PROBLEM DUE TO POOR ENGINEERING DESIGN AND FOR USING POOR QUALITY COMPONENTS WHICH FAIL FOR NO REASON. ALSO THIS IS AN EXTREMELY DANGEROUS SITUATION FOR PASSENGERS INSIDE THE VEHICLE, WHICH HAVE TO BREATH THE DANGEROUS EXHAUST FUMES. GM SHOULD BE MADE TO REPAIR ALL VEHICLES AFFECTED BY THIS PROBLEM WHICH WERE DESIGNED AND ENGINEERED WITH INFERIOR PARTS WHICH ARE CAUSING THIS DANGEROUS SITUATION FOR MILLIONS OF PEOPLE ACROSS THIS COUNTRY.

EXHAUST BOLTS BROKEN AND CAUSING A LEAK MAKING THE VEHICLE UNABLE TO PASS EMISSIONS ALSO. STEERING STABILIZERS BROKEN.

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500 EQUIPPED WITH FIRESTONE WILDERNESS LETIRES, TIRES SIZE: 265/70R16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY AT 55 MPH, THE VEHICLE BEGAN TO VIOLENTLY SHAKE AND VIBRATE BEFORE A LOUD BOOMING SOUND WAS HEARD. AFTER STOPPING THE VEHICLE, IT WAS DISCOVERED THAT THE REAR PASSENGER SIDE TIRE HAD EXPERIENCED A BLOWOUT. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 150,000 AND THE TIRE FAILURE MILEAGE WAS 10,000. THE VIN WAS NOT AVAILABLE.

HAD NEW WILDCOUNTRY TIRE, PURCHASED FROM LES SCHWAB SEPARATE FROM THE WHEEL OUT TO A DEFECT. TIRE HAD ONLY BEEN ON THE WHEEL APPROXIMATELY 6 HOURS BEFORE THE INCIDENT. LT 26570R16. *TR

EXHAUST BOLTS BROKEN AND CAUSING A LEAK MAKING THE VEHICLE UNABLE TO PASS EMISSIONS ALSO. STEERING STABILIZERS BROKEN.

MY 2001 SUBURBAN COMPLETELY SHUTS OFF AND THE STEERING STOPS WHEN I AM AT SPEEDS BELOW 10 MPH, IF I AM MAKING A TURN, BACKING OUT OF MY DRIVEWAY, OR COME TO A STOP AT A STOP SIGN. I TOOK IT TO MANY PLACES TO HAVE IT TESTED AND THEY ALL STATED THAT EVERYTHING IS FINE NOTHING WAS DETECTED. I HAVE HAD THE FUEL PUMP REPLACED BY DEALERSHIP WHEN IT JUST COMPLETELY STOPPED RUNNING ON THE HIGHWAY. I AM AT A LOSS FOR WORDS AND THIS IS DANGEROUS WHEN IT IS THE ONLY CAR YOU HAVE TO HAUL YOURSELF AND KIDS AROUND IN. THIS IS HAPPENING EVERYDAY AND IT SEEMS THAT I AM NOT THE ONLY ONE HAVING THIS PROBLEM. THIS IS A SERIOUS PROBLEM FOR AMERICANS TRYING TO MAKE AN HONEST LIVING. *TR

I WAS DRIVING ON THE NJ TURNPIKE NEAR EXIT 10, TRAVELLING TO BOSTON. AHEAD, ALL TRAFFIC WAS STOPPED IN BOTH THE INNER AND OUTER SET OF LANES. AS I DECELERATED, I HEARD A NOISE AND THE TRUCK JERKED SLIGHTLY. WHEN I TRIED TO PULL OFF THE ROAD INTO THE SERVICE LANE, I HAD NO TRANSMISSION AND HAD TO DRIFT TO THE SHOULDER. I WAS TOLD THERE WAS A CATASTROPHIC FAILURE OF THE TRANSMISSION AND IT HAD TO BE COMPLETELY REBUILT (UNDER WARRANTY). WHEN THE VEHICLE HAD AROUND 70,000 MILES (ABOUT 2 YEARS AGO, 2013), THE TRANSMISSION FAILED AGAIN AND HAD TO BE COMPLETELY REBUILT AGAIN. PATHETIC. THE VEHICLE CURRENTLY HAS 83,000 MI ON IT.

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE WAS SHIFTED INTO DRIVE AND THE VEHICLE FAILED TO MOVE FORWARD. THE CONTACT ALSO STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED. ON ANOTHER OCCASION WHILE DRIVING AT APPROXIMATELY 5 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE ANTI LOCK BRAKE SYSTEM FAILED AND UNKNOWN PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE ANTI LOCK BRAKE SYSTEM FAILURE BUT THE FUEL PUMP WAS NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 05V379000 (SERVICE BRAKES, HYDRAULIC) AND 05V155000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

DRIVING ON HIGHWAY AT 75MPH BATTERY, SECURITY AND LOW FUEL POPPED ON INTO MESSAGE CENTER. GAS GAUGE, VOLT METER, AND TEMPERATURE GAUGE QUIT WORKING, HAD TO PULL OFF THE SIDE OF THE HIGHWAY BECAUSE OF IT ALMOST GOT HIT. I KNOW NUMEROUS PEOPLE WITH SAME ISSUE.

WENT TO START MY 2001 CHEVY SUBURBAN AND IT WOULDN'T START. I LISTENED FOR THE FUEL PUMP TO ENGAGE AND IT WASN'T WORKING. I CHECKED THE RELAY AND NOTICED IT WAS MELTED ON ONE CORNER. I HAVE RESEARCHED THIS ONLINE AND FOUND SEVERAL COMPLAINTS ABOUT THE SAME PROBLEM. ALSO NOTICED THAT GM HAS DONE NOTHING TO FIX THIS ISSUE. I HAVE BEEN A GM FAN ALL MY LIFE AND WOULD LIKE TO CONTINUE BEING ONE. PLEASE RECALL THIS ON GOING PROBLEM GM. *TR

I HAVE SUBURBAN 2001, THE REAR WINDOW (TAILGATE WINDOW) GLASS SEPARATED FROM THE HINGES SUDDENLY. THIS IS COMMON PROBLEM IN GM SUBURBANS AND I AM AFRAID THIS MAY RESULT IN A SERIOUS ACCIDENT AS THE TAILGATE WINDOW MAY SEPARATE, FLY OFF AND HIT SOMETHING. I AM NOT SURE IF THE WINDOW WILL FLY OFF, MINE WAS HANGING FROM ONE HINGE UNTIL I CORRECTED IT. *TR

24 HOURS PREVIOUS THE DRIVER SIDE WINDOW SWITCH MADE A CLICKING SOUND. THE CAR THEN CAUGHT ON FIRE AT THE DOOR, BURNING TO THE FRAME. *TR

WHILE BACKING OUT OF DRIVEWAY, OUR 2001 CHEVY SUBURBAN 1500 BEGAN SMOKING FROM UNDER THE DRIVER'S SEAT. AS I PARKED TO INVESTIGATE, FLAMES BEGAN TO CAME OUT FROM UNDER THE SEAT AND I PUT OUT THE FIRE WITH A WATER HOSE. THE FIRE SEEMS TO INITIATE FROM THE WIRING FOR THE SEAT CONTROL. LEFT MINOR DAMAGE UNDER THE SEAT, BURNT RUG AND WATER LOG FROM PUTTING THE FIRE OUT. INSURANCE COMPANY TO FOLLOW UP INVESTIGATION. *TR

I HAVE A 2001 CHEVY SUBURBAN 1500 WHILE GOING OVER A SPEED BUMP AT THE SPEED OF 20MPH THE LUMBAR SUPPORT IN MY DRIVER'S SEAT "POPPED". WE HEARD A VERY LOUD EXPLODING SOUND AND AT THE SAME TIME I FELT A EXTREME PRESSURE AND PAIN IN MY LOWER BACK... I NOW HAVE LOWER BACK PAIN A DAY LATER. *TR

WHILE TRAVELLING ON THE HIGHWAY AT APPROXIMATELY 50 MPH, VEHICLE STRUCK AN ADULT DEER - FRONT END SQUARE HIT OFFSET TO PASSENGER SIDE. FRONT PASSENGER LIGHTS, GRILL, RADIATOR SUPPORTS, BUMPER, SIDE FENDER, AND HOOD ALL SEVERELY DAMAGED. AIRBAGS DID NOT DEPLOY. DAMAGE TO THE VEHICLE ENDED UP AT $4,386.

ON JANUARY 29, 2014, MY HUSBAND WAS DRIVING MY SUBURBAN TRAVELING ON A SNOW AND ICY ROAD WHEN THE SUBURBAN BEGIN TO SPIN AND WENT DOWN AN EMBANKMENT. HE WAS TRAPPED IN THE VEHICLE BETWEEN THE STEERING WHEEL AND WINDSHIELD. HE WAS WEARING THE SHOULDER AND LAP BELT.THE AIR BAGS DID NOT DEPLOY. TWO OTHER PASSENGERS IN THE VEHICLE HAD ONLY MINOR INJURIES. THE TENNESSEE TRAFFIC REPORT I RECEIVED STATED: AIRBAG AVAILABLE-NO DEPLOYMENT. *TR

ABS RECALL 05068, CLEAN & INSPECT WHEEL SENSORS, 18 NOV 2005. ABS & TRACTION CONTROL WARNING LIGHTS ON,16 JUN 2006 (55977 MILES). DEALER DIAGNOSTIC CODE C0265, ECBM ($925.59 PART) AND ALSO BPMV ($761.14 PART) PLUS APPROX 2HRS LABOR. I ASKED IF IT WOULD BE SAFE TO DISCONNECT THE PUMP FROM THE ABS SYSTEM UNTIL I COULD SEE IF THE RECALL WOULD COVER THIS COST, IT HASN'T HAPPENED AS OF THIS DATE. THE VEHICLE HAS BEEN IN OPERATION SINCE THIS SYSTEM FAILURE. I NOW HAVE LEARNED THAT THE RELAY ON THE EBCM THAT CONTROLS THE POWER HAS CONTACTS THAT WELD CLOSED WHICH CAUSES THE PUMP TO RUN CONTINUOUSLY. I ASKED IF I COULD HAVE THE OLD PART WHEN I GET IT FIXED AND WAS TOLD NO BECAUSE IT MUST BE RETURNED. I ALSO FEEL THAT WHEN I WAS TOLD IT MAY ALSO NEED THE BPMV THAT THE CHECK VALVE HOLDING THE PUMP PRESSURE COULD BE THE TRUE CAUSE OF SYSTEM FAILURE. I FEEL THAT PEOPLE THAT BUY THIS SAFETY FEATURE SHOULD HAVE IT WORK FOR THE LIFE OF THE VEHICLE. I ALSO KNOW THAT THE REPAIR COSTS HAVE SINCE GONE UP. *TR

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WOULD STICK DURING THE INITIAL STARTING. THE FAILURE GENERALLY OCCURRED DURING WARM WEATHER. AS OF DECEMBER 11, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 68,000 AND CURRENT MILEAGE WAS 78,000. UPDATED 03/14/08. *LJ

I HAVE SUBURBAN 2001, THE REAR WINDOW (TAILGATE WINDOW) GLASS SEPARATED FROM THE HINGES SUDDENLY. THIS IS COMMON PROBLEM IN GM SUBURBANS AND I AM AFRAID THIS MAY RESULT IN A SERIOUS ACCIDENT AS THE TAILGATE WINDOW MAY SEPARATE, FLY OFF AND HIT SOMETHING. I AM NOT SURE IF THE WINDOW WILL FLY OFF, MINE WAS HANGING FROM ONE HINGE UNTIL I CORRECTED IT. *TR

THE 2001 SUBURBAN'S BODY FRAME AND FRONT WHEEL WELLS ARE POORLY DESIGNED IN THAT THEY ALLOW EXTENSIVE AMOUNTS OF WATER SPRAY FROM FLOODED ROADWAYS TO SATURATE THE WINDSHIELD WHILE DRIVING, CAUSING THE DRIVERS VIEW OF THE ROAD TO BE COMPLETELY OBSTRUCTED CREATING AN UNSAFE DRIVING ENVIRONMENT. *TR

I WAS DRIVING ON THE HIGHWAY 95 COMING BACK FROM DAYTONA WHEN A DRIVER LET ME KNOW THAT MY TIRES WHERE LOW SO I WHEN TO A GAS STATION TO PUT SOME AIR IN AND THATS WHEN I NOTICE THAT MY TIRES HAD A LOT OF NAILS LTHE 4 TIRES. THIS IS RIDICULOUS. MY TIRES ARE LNOT EVEN 2 YEARS OLD AND I HAVE THE RECEIPT TO PROVE IT. SOMEONE HAS TO DO SOMETHING. BECAUSE I HAVE A NEW BORN BABY WITH ME AND DRIVING WITH FLAT TIRES IS NOT AN OPTION. PLEASE TAKE MY COMPLAINT IN CONSIDERARATION. THANK YOU

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THREE OF THE FOUR WHEELS HAVE FAILED ON THE VEHICLE. THE WELDS DETACHED FROM ONE OF THE RIMS AND CAUSED A FLAT TIRE. THE CONTACT STATED THAT THE VEHICLE BEGAN TO VIBRATE. THE CONTACT HAS PICTURES OF THE VEHICLE. THE CURRENT MILEAGE IS 141,352 AND FAILURE MILEAGE WAS 106,532. THE CONSUMER STATES THAT THE VEHICLE IS OWNED BY MIDDLEBURGH CENTRAL SCHOOL. THE CONSUMER PROVIDED COPY OF INVOICE. UPDATE 05/23/07 *TR

I PURCHUSED 2001 SUBURBAN AND TRIED TO CONTACT THE RECALL PEOPLE AT 18006302438 ABOUT RECALL #54628-05V379000.THEY TOLD ME THAT THEY COULD NOT HELP ME BECAUSE THE SERVICE ALREADY BEEN DONE. BUT THE VEHICLE IS DOING THE SAME THING THE RECALL SAID ITS DOING. *TR

I HAVE A 2001 CHEVY SUBURBAN AND THIS IS THE 5TH. TRANSMISSION I HAVE PUT IN THE VEHICLE. THE TRANSMISSION FIRST FAILED AT 15,339 MILES AND WAS REPAIRED UNDER WARRANTY. AT 50,525 MILES IT FAILED AGAIN AND COST ME $1802.94 TO FIX. AT 62,823 IT FAILED AGAIN AND A CHEVROLET DEALER IN OKLAHOMA REPAIRED IT,FOR $2279.24, AND GAVE IT A ONE YEAR WARRANTY. 11 MONTHS AND 10800 MILES LATER IT FAILED AGAIN. THIS TIME THE CHEVY DEALER IN MISSOURI WANTS $1600 TO REPAIR IT AND SAID THE SAME EXACT PARTS DID NOT FAIL SO THE ONE YEAR WARRANTY DOES NOT APPLY!!!!!!!! THIS VEHICLE IS DRIVEN BY MY WIFE AROUND TOWN. ALL OF A SUDDEN YOU LOOSE POWER. *JB