2005 Chevrolet Suburban 1500 Problems

I NOTICED CORRODED AND WHAT I WOULD CALL CHARRED OR BURNT WIRING ON THE WIRING HARNESS FOR THE REAR LIFT GATE OF MY SUBURBAN. I NOTICED IT WHEN I OPENED THE LIFT GATE TO GAIN ACCESS TO THE REAR OF THE SUBURBAN. IT APPEARS THAT THE RUBBER GROMMET MATERIAL PROTECTING THE WIRING HARNESS, WAS BURNT OR MELTED AWAY. THE RUBBER HOSE THAT SUPPLIES WATER TO THE REAR WINDOW WASHER/WIPER HAD A HOLE IN IT, AND MAY HAVE BEEN LEAKING WINDSHIELD WASHER FLUID ONTO THE WIRES FOR A TIME. THE WIRES WERE BARE IN SOME SPOTS, SOME OF THE WIRE INSULATION LOOKED MELTED/BURNT AWAY, AND THEY LOOKED CORRODED/WITH A GREEN COLOR TO THEM. THE CONNECTOR THAT CONNECTS THE HARNESS, TO THE REST OF THE ELECTRICAL SYSTEM, LOOKED LIKE IT HAS SOME BLACK/ POSSIBLY BURNT RESIDUE ON IT. I CAN TAKE A GUESS AT BEST, THAT BECAUSE OF THE HOLE IN THE RUBBER HOSE, WATER MAY HAVE BEEN LEAKING ONTO THE ELECTRICAL WIRING/CONNECTIONS WHEN I USED THIS FEATURE TO CLEAR DIRT FROM THE LIFT GATE WINDOW, BUT I DON'T REALLY KNOW FOR SURE IF THAT IS HOW THE DAMAGE TO THE WIRING HARNESS HAS OCCURED! THANKS!

2005 CHEVROLET SUBURBAN 1500 4X4 FLEX FUEL, 5.3L. THIS VEHICLE'S INSTRUMENT CLUSTER DOES NOT WORK. TACHOMETER PEGS AND STICKS. THE SPEEDOMETER IS STUCK AT ZERO. THIS IS A VERY SERIOUS SAFETY CONCERN THAT GENERAL MOTORS/GM SHOULD DO A FREE RECALL FOR AS MANY OWNERS OF THIS VEHICLE HAVE THE SAME PROBLEMS. MY ABS SENSOR LIGHT COMES ON AND OFF NUMEROUS TIMES A DAY, AND CLUSTER STATES SERVICE AIR BAG. GENERAL MOTORS SHOULD ALSO FIX THIS FOR FREE UNDER A RECALL AS OTHERS HAVE THE SAME ISSUE WITH THIS VEHICLE. MY THIRD MAJOR COMPLAINT, IS THE VEHICLE STARTING PROBLEM/HARD START. IT TAKES TWO TURNS OF THE ENGINE FOR THE VEHICLE TO TURN ON AND STAY RUNNING. I HAVE RESEARCHED THIS ON VARIOUS SEARCH ENGINES, FORUMS, AND INCLUDING RECALL.GOV. GENERAL MOTORS SHOULD ADDRESS THIS ISSUES AS WELL UNDER A RECALL. GM INSTALLED FAULTY FUEL PUMPS OR FUEL PUMPS WITH FAULTY COMPONENTS IN THEM. A VEHICLE SHOULD START WITH ONE TRY. I SHOULD NOT HAVE TO GET THE FUEL PRESSURE GOING IN THE ON POSITION, OR CRANK IT TWICE FOR MY TRUCK TO START.

I HAD A RUSTED BRAKE LINE (DRIVER SIDE FRONT) FAIL JUNE 25TH, 2017. THIS TRUCK IS 12 YEARS OLD AND HAS LESS THAN 90,000 MILES. IMMEDIATELY ALL BRAKING WAS LOST AND THE PEDAL PUSHED TO THE FLOOR. REPEATED PRESSING THE BRAKE ONLY PUMPED OUT ALL THE BRAKE FLUID. THIS WAS A SUDDEN AND CATASTROPHIC LOSS OF BRAKING. THE WORST PART IS, BRAKING IS SUPPOSED TO BE SPLIT AND INDEPENDENT BETWEEN FRONT AND REAR BRAKES, SO IF YOU LOSE THE FRONT, THE REAR BRAKES STILL WORK, AND VICE VERSA. WELL I LOST ALL BRAKING, I HAD NO FRONT OR REAR BRAKING! THIS SHOULD BE A CLEAR SAFETY PROBLEM AND A MANDATORY RECALL! I CRASHED INTO THE CAR IN FRONT OF ME, BECAUSE OF COURSE MY EMERGENCY BRAKE DIDN'T WORK EITHER. DESPITE GM'S INSISTENCE THAT SOMEHOW THIS PREMATURE BRAKE LINE FAILURE IS NORMAL AND THE OWNER'S MAINTENANCE PROBLEM, IT SHOULD BE A VERY SIMPLE ISSUE FOR THE NHTSA TO SIMPLY OPEN A SINGLE BRAKE LINE AND TEST TO REALIZE THE AFFECTED VEHICLES DO IN FACT LOSE ALL BRAKING, NOT JUST FRONT OR REAR. I'VE ALREADY COMPLETELY LOST FAITH IN GM TO DO THE RIGHT THING, BUT I'D LIKE TO BELIEVE THE NHTSA WILL STILL DO THE RIGHT THING, AND NOT LET GM OFF WITH A CLEAR SAFETY PROBLEM WITH THEIR BRAKE DESIGN. THIS CRASH WAS PULLING UP TO THE STOPLIGHT IN PRESCOTT, WI, HEADING INTO TOWN ACROSS THE PRESCOTT BRIDGE. I WAS DRIVING MAYBE 30 MPH WHEN I REALIZED I HAD LOST ALL BRAKES.

FIRST INCIDENT EASTERN PA: 05/19/2014 APROX 119000 MILES: AFTER HITTING THE BRAKES HARD TO AVOID A VEHICLE THAT PULLED IN FRONT OF ME, THE BRAKES FAILED (BRAKE PEDAL WOULD GO TO THE FLOOR WITH LITTLE BRAKING ACTION). MANAGED TO SAFELY STOP. FOUND BURST BRAKE LINE IN THE REAR END OF VEHICLE. TWO REAR CORRODED REAR BRAKE LINES REPLACED BY LOCAL REPAIR SHOP. SECOND INCIDENT MILFORD MA: 09/17/2015 127336 MILES: HIT BRAKES GOING DOWN DRIVEWAY. BRAKES WERE SOFT AND SANK TO FLOOR. BRAKE LINE GOING TO FRONT PASSENGER WHEEL WAS BURST. ALL THE BRAKE FLUID DRAINED QUICKLY OUT OF THE MASTER CYLINDER ONTO THE DRIVEWAY. ORDERED ACDELCO 22932592 GM ORIGINAL EQUIPMENT HYDRAULIC BRAKE PIPE KIT AND AM IN THE PROCESS OF REPLACING ALL BRAKE LINES AS ALL OF THEM OTHER THAN THE TWO REPLACED IN PA ARE VERY CORRODED. THE REPLACEMENT LINES ARE NOT REALLY OEM AS THEY HAVE A NYLON COATING FOR BETTER CORROSION PROTECTION

FOR APPROXIMATELY THE LAST 4 YEARS THE AIRBAG LIGHT HAS BEEN ON INDICATING AN ISSUE WITH THE AIRBAG SYSTEM. GIVEN ALL THE AIRBAG PROBLEMS IN RECENT YEARS AND THE FACT THIS SEEMS TO BE A COMMON PROBLEM WITH 2005 GM SUVS AND GIVEN AIRBAGS ARE VITAL SAFETY EQUIPMENT GM NEEDS TO PROVIDE OWNERS WITH THESE PROBLEMS A FREE FIX OR BE FORCED TO RECALL THESE VEHICLES IMMEDIATELY FOR REPAIRS BEFORE ALOT OF PEOPLE GET HURT OR KILLED.

2005 CHEVROLET SUBURBAN 1500 4X4 FLEX FUEL, 5.3L. THIS VEHICLE'S INSTRUMENT CLUSTER DOES NOT WORK. TACHOMETER PEGS AND STICKS. THE SPEEDOMETER IS STUCK AT ZERO. THIS IS A VERY SERIOUS SAFETY CONCERN THAT GENERAL MOTORS/GM SHOULD DO A FREE RECALL FOR AS MANY OWNERS OF THIS VEHICLE HAVE THE SAME PROBLEMS. MY ABS SENSOR LIGHT COMES ON AND OFF NUMEROUS TIMES A DAY, AND CLUSTER STATES SERVICE AIR BAG. GENERAL MOTORS SHOULD ALSO FIX THIS FOR FREE UNDER A RECALL AS OTHERS HAVE THE SAME ISSUE WITH THIS VEHICLE. MY THIRD MAJOR COMPLAINT, IS THE VEHICLE STARTING PROBLEM/HARD START. IT TAKES TWO TURNS OF THE ENGINE FOR THE VEHICLE TO TURN ON AND STAY RUNNING. I HAVE RESEARCHED THIS ON VARIOUS SEARCH ENGINES, FORUMS, AND INCLUDING RECALL.GOV. GENERAL MOTORS SHOULD ADDRESS THIS ISSUES AS WELL UNDER A RECALL. GM INSTALLED FAULTY FUEL PUMPS OR FUEL PUMPS WITH FAULTY COMPONENTS IN THEM. A VEHICLE SHOULD START WITH ONE TRY. I SHOULD NOT HAVE TO GET THE FUEL PRESSURE GOING IN THE ON POSITION, OR CRANK IT TWICE FOR MY TRUCK TO START.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE GEAR SHIFTED INTO NEUTRAL INDEPENDENTLY. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE RESUMED IN THE FOUR WHEEL DRIVE MODE. THE FAILURE OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TWICE WHERE THE SHIFT GEAR ACTUATOR WAS REPLACED. ON A SEPARATE OCCASION, THE PUSH BUTTON GEAR SELECTOR WAS ALSO REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.

MY 2005 SUBURBAN CHEV. HAS 46,000 AND THE TRANSMISSION WILL NOT SHIFT BETWEEN 3RD AND 4TH GEAR. THE DEALER SAID THIS IS FAIRLY NORMAL TO HAPPEN. IT IS NOT INCLUDED IN THE POWER TRAIN WARRANTY. THE COST TO REPAIR IS $3000.00 TO $4000.00. THE CAR STARTED MAKING AN AWFUL NOISE, THE INSTRUMENT PANEL SAID TRANSMISSION HOT. WHEN I PUSHED ON THE ACCELERATOR THE CAR WOULD NOT GO IT JUST MADE AN AWFUL NOISE. THANK GOD I WAS ON A ROAD I COULD PULL OVER ON. THE CAR HAD TO BE TOWED IN TO THE DEALER.I HAVE A $50,000 CAR THAT CAN'T BE DRIVEN. IS THIS A COMMON PROBLEM TO 2005 SUBURBAN? *TR

HAD SERVICED THE TRANSFER CASE AND HAD TAKEN IT BACK TWICE NOW BESIDES A NOISE LIKE THAT OF A POWER STEERING PUMP GOING BAD ( WHINING ) , HAD A TURNING CLUNK NOISE COMING AND AT A STOP LIGHT I SAW SMOKE COMING FROM PASSENGER SIDE, GOT TO PARK IT AND SMELLED LIKE SOMETHING IS BURNING .BRING IT BACK TO SEE IF THE MECHANIC WILL WORK ON IT SINCE IT HASN'T BEEN 30 DAYS. PLEASE NOTIFY ME OF ANYTHING DO TO THE TRANSFER CASE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE GEAR SHIFTED INTO NEUTRAL INDEPENDENTLY. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE RESUMED IN THE FOUR WHEEL DRIVE MODE. THE FAILURE OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TWICE WHERE THE SHIFT GEAR ACTUATOR WAS REPLACED. ON A SEPARATE OCCASION, THE PUSH BUTTON GEAR SELECTOR WAS ALSO REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.

THE SPEEDOMETER NEEDLE BEGAN "CATCHING," NOT MOVING SMOOTHLY. AFTER ABOUT 2 WEEKS IT WOULD NOT RESET TO 0 WHEN STOPPED THEN AFTER 1 MORE DAY IT QUIT REGISTERING COMPLETELY.

2005 CHEVROLET SUBURBAN. FAILURE OF THE ABS / TRACTION CONTROL COMPUTER (GM PART NO.15234605). FAILURE OCCURRED AT 62,000 MILES DUE TO CORROSION INSIDE THE MODULE. *TR

2005 CHEVROLET SUBURBAN 1500 4X4 FLEX FUEL, 5.3L. THIS VEHICLE'S INSTRUMENT CLUSTER DOES NOT WORK. TACHOMETER PEGS AND STICKS. THE SPEEDOMETER IS STUCK AT ZERO. THIS IS A VERY SERIOUS SAFETY CONCERN THAT GENERAL MOTORS/GM SHOULD DO A FREE RECALL FOR AS MANY OWNERS OF THIS VEHICLE HAVE THE SAME PROBLEMS. MY ABS SENSOR LIGHT COMES ON AND OFF NUMEROUS TIMES A DAY, AND CLUSTER STATES SERVICE AIR BAG. GENERAL MOTORS SHOULD ALSO FIX THIS FOR FREE UNDER A RECALL AS OTHERS HAVE THE SAME ISSUE WITH THIS VEHICLE. MY THIRD MAJOR COMPLAINT, IS THE VEHICLE STARTING PROBLEM/HARD START. IT TAKES TWO TURNS OF THE ENGINE FOR THE VEHICLE TO TURN ON AND STAY RUNNING. I HAVE RESEARCHED THIS ON VARIOUS SEARCH ENGINES, FORUMS, AND INCLUDING RECALL.GOV. GENERAL MOTORS SHOULD ADDRESS THIS ISSUES AS WELL UNDER A RECALL. GM INSTALLED FAULTY FUEL PUMPS OR FUEL PUMPS WITH FAULTY COMPONENTS IN THEM. A VEHICLE SHOULD START WITH ONE TRY. I SHOULD NOT HAVE TO GET THE FUEL PRESSURE GOING IN THE ON POSITION, OR CRANK IT TWICE FOR MY TRUCK TO START.

GAS SMELL WHEN IDLING....TOOK TO DEALER AND THEY FOUND THE (FLEXIBLE) FUEL LINE LEAKING. THEY SHOWED ME THE PROBLEM AND IT SURE LOOKED LIKE THE LINES WERE CROSSED WHEN THEY WERE INSTALLED, EVEN THE MECHANIC SAID SOMETHING TO THAT NATURE, BUT I WILL GUARANTEE YOU HE WOULD NEVER ADMIT THAT......IT IS GOING TO COST ME $651.00 TO HAVE JUST ONE LINE REPLACED............THE LINE WORE A HOLE THRU IT WHERE THE LINES WERE CROSSED AND RUBBING ON EACH OTHER. *TR

MY 2005 CHEVROLET SUBURBAN Z71 SWITCHES RANDOMLY AND WITHOUT SPECIFIC CAUSE INTO REDUCED ENGINE POWER WHICH NEARLY GO ME KILLED WHEN MERGING INTO A HIGH-SPEED INTERSTATE PULLING A TRAILER. THE ONLY WAY TO "FIX" IT (MAKE THE ENGINE RUN NORMAL AGAIN) IS TO PULL TO THE SIDE IF THE HIGHWAY (DANGEROUS!) AND SHUT THE TRUCK OFF FOR A FEW MINUTES. THIS HAPPEN RANDOMLY BUT AT LEAST THREE TIMES A DAY. I KNOW OTHERS HAVE THIS PROBLEM AND GM SAYS I HAVE TO BRING IT TO THEN WHEN THIS IS OCCURRING BUT I CAN'T DO THAT WHEN THE TRUCK IS BARELY LIMPING ALONG! THIS IS A SAFETY ISSUE AND IS WELL DOCUMENTED ON GM CHAT SITES ACROSS THE INTERNET. *TR

I WAS DRIVING ON THE HIGHWAY AND LOOKED DOWN AND THE SPEEDOMETER SAID 100! CARS WERE PASSING ME AND I KNEW THERE WAS NO WAY I WAS DRIVING 100. ONCE I GOT TO MY DESTINATION, SITTING STILL THE SPEEDOMETER WAS AT EITHER 50 OR 60. WHEN IN MOTION IT USUALLY READS ABOUT 105-115 WHEN GOING BETWEEN 60-70 MPH. (I THINK, I REALLY HAVE NO IDEA SINCE MY SPEEDOMETER IS BROKEN!!!) I HAVE JUST OVER 75,000 MILES ON A 2005 SUBURBAN 1500. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING AT HIGHWAY SPEEDS, THE HODO LATCH FAILED AND THE HOOD OPENED, BLOCKING THE VIEW OF THE HIGHWAY. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 125,000.

I OWN A 2005 CHEVROLET SUBURBAN, THE REAR LIFT GATE HAS A WINDOW THAT IS INCORPORATED INTO THE LIFT GATE AND CAN BE OPENED INDEPENDENTLY THERE ARE PLASTIC HINGES ATTACHING THE GLASS TO THE LIFT GATE AND ONE OF THE TWO HINGES FAILED AND IS BROKEN. I HAVE SEARCHED THE FORUMS ON THIS ISSUE AND IT APPEARS TO BE WIDESPREAD AND CHEVROLET WANTS $1000.00 TO REPLACE THE GLASS WITH THE DEFECTIVE HINGE. *TR

I OWN A 2005 CHEVROLET SUBURBAN, THE REAR LIFT GATE HAS A WINDOW THAT IS INCORPORATED INTO THE LIFT GATE AND CAN BE OPENED INDEPENDENTLY THERE ARE PLASTIC HINGES ATTACHING THE GLASS TO THE LIFT GATE AND ONE OF THE TWO HINGES FAILED AND IS BROKEN. I HAVE SEARCHED THE FORUMS ON THIS ISSUE AND IT APPEARS TO BE WIDESPREAD AND CHEVROLET WANTS $1000.00 TO REPLACE THE GLASS WITH THE DEFECTIVE HINGE. *TR

ISSUE WITH INSTRUMENT PANEL (INCLUDING STEREO, LIGHTS ON PANEL, INSTRUMENT GAUGES), POWER WINDOWS/LOCKS & SECURITY SYSTEM - RANDOMLY SHUTS OFF. SOMETIMES THE ODOMETER WORKS AND OTHER TIMES IT DOES NOT. THE INSTRUMENT PANEL GAUGES ALL MOVE TO THE LEFT WITH THE GAS LIGHT COMING ON. THE TIRE PRESSURE MONITOR IS ACTIVATED. PANEL INDICATORS COME ON (ENGINE LIGHT, SECURITY SYSTEM, SEAT BELTS, ETC.). STEREO SYSTEM IS COMPLETELY OFF WITH NO LIGHTS ON THE PANEL. THE HEATER/AC SYSTEM SOMETIMES GOES OFF ALSO. THE POWER WINDOWS AND LOCKS DO NOT WORK DURING THESE TIMES. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THE REAR LIFTGATE POWER LOCK MECHANISM BECAME INOPERABLE AND PREVENTED AN OCCUPANT FROM ENTERING OR EXITING FROM THE REAR. THE VEHICLE WAS NOT DESIGNED WITH A MANUAL KEY LOCK FEATURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE.

I OWN A 2005 CHEVROLET SUBURBAN, THE REAR LIFT GATE HAS A WINDOW THAT IS INCORPORATED INTO THE LIFT GATE AND CAN BE OPENED INDEPENDENTLY THERE ARE PLASTIC HINGES ATTACHING THE GLASS TO THE LIFT GATE AND ONE OF THE TWO HINGES FAILED AND IS BROKEN. I HAVE SEARCHED THE FORUMS ON THIS ISSUE AND IT APPEARS TO BE WIDESPREAD AND CHEVROLET WANTS $1000.00 TO REPLACE THE GLASS WITH THE DEFECTIVE HINGE. *TR

HAD TO REPLACE THE SENSOR FOR THE AIR BAG. THIS SHOULD HAVE BEEN COVERED BY GENERAL MOTORS. I KNOW THAT A LOT OF PEOPLE WOULD NOT HAVE THIS PROBLEM FIXED DUE TO THE COST. WHEN THE SERVICE AIR BAG LIGHT COMES ON IT DEACTIVATES THE AIR BAGS. THIS IS A MAJOR SAFETY ISSUE. WE HAVE A 2000 CHEVROLET TAHOE IN OUT FAMILY THAT HAS NOT HAD THIS PROBLEM. I FEEL THERE NEEDS TO BE A RECALL. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE DRIVER SIDE SHOULDER SEAT BELT IN THE CENTER ROW WILL NOT RETRACT AND APPEARS TO BE JAMMED. THE FAILURE OCCURRED 100 MILES AFTER THE WARRANTY EXPIRED. THE DEALER HAS NOT BEEN NOTIFIED. NHTSA CAMPAIGN ID NUMBER 05V163000 (SEAT BELTS:REAR) WAS REFERENCED. THE CURRENT MILEAGE WAS 42,000 AND FAILURE MILEAGE WAS 35,900.

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. WHILE THE VEHICLE WAS BEING SERVICED, THE MECHANIC DISCOVERED THAT THE TWO FRONT TIRES WERE WORN ON THE INSIDE. THE CONTACT PURCHASED FIVE SETS OF TIRES. THE CURRENT MILEAGE WAS 55,223 AND FAILURE MILEAGE WAS 13,000. UPDATED 04/03/08. *LJ

HAD SERVICED THE TRANSFER CASE AND HAD TAKEN IT BACK TWICE NOW BESIDES A NOISE LIKE THAT OF A POWER STEERING PUMP GOING BAD ( WHINING ) , HAD A TURNING CLUNK NOISE COMING AND AT A STOP LIGHT I SAW SMOKE COMING FROM PASSENGER SIDE, GOT TO PARK IT AND SMELLED LIKE SOMETHING IS BURNING .BRING IT BACK TO SEE IF THE MECHANIC WILL WORK ON IT SINCE IT HASN'T BEEN 30 DAYS. PLEASE NOTIFY ME OF ANYTHING DO TO THE TRANSFER CASE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET K1500 SUBURBAN. THE CONTACT STATED THAT THE SPARE TIRE CARRIER ON THE VEHICLE WOULD NOT LATCH OR DETACH PROPERLY. THE VEHICLE WAS NOT INSPECTED, DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 91,175.