2024 Chevrolet Suburban Problems

While driving down a two-lane blacktop road at 70 MPH (the posted speed limit) the engine, a 6.2 L L87 with a little over 15,000 miles, grenaded and seized. At the time I recall a warning message that said something like "engine shutdown". Fortunately the electronic transmission self-shifted into neutral so the car could coast to a stop. Had it not done this a loss of control would have been likely at this speed. The vehicle was towed to the local Chevrolet dealer in Bozeman, Montana (Resseler Chevrolet) where it was confirmed the next day the engine had seized. The dealer is currently replacing the seized engine with a replacement long block. The dealership currently has the engine and is planning to ship it back to Chevrolet or GM for tear down and inspection. They are also replacing the radiator and all coolant hoses as a precaution. Two weeks prior I took the vehicle to the same Chevrolet dealer complaining that on one day the engine shut off four times within 1 mile. Each time it displayed a warning message that said "restart engine", which it did each time. I also complained about a ticking noise that began in the engine at 12,000 mile. The dealer reported that the engine sounded fine and that they could not reproduce the engine shutting off on its own. This engine was NOT part of the large L87 recall. At time of purchase I was told by the selling dealer (Kendall Chevrolet in Maryville, Washington) and the local dealer (Resseler) that the engine was assembled after assembly line procedure were put in place to avoid the same issues as the recall engine. I've been and engineer for 46 years. The problem with this engine is not the assembly line, it is the never before used tight moving component tolerances and the water thin oil demanded by the manufacturer. The design shortcomings are compounded by systems such as cylinder deactivation and auto stop that significantly acceleration engine component wear.

Vehicle brought to Chevrolet dealer for recall# N252494000 at 27,626 miles. Vehicle passed inspection and oil replaced per recall. Despite engine passing and recall complete the engine failed at 29,861 miles requiring an engine replacement which was provided under warranty. The failed engine was taken by GM.

Transmission faulty, loud, clunky and hard shifting! Service transmission now alert and code P0747

The vehicle would jerk when changing gears and would have a rattle and vibration when accelerating.

The contact owns a 2024 Chevrolet Suburban. The contact stated that while towing a trailer, the message "Trailer Brakes Disconnected" was displayed. Due to the failure, the trailer brakes locked up and the trailer came to an abrupt and rough stop. Upon investigation, the contact discovered Technical Service Bulletin: 23-NA-149; which was related to the solar panel battery charger or generator on the trailer. The trailer battery was fully charged and had a higher charge than the battery needed and could back feed into the trailer brake power module and cause it to shut down. The dealer was notified of the failure, and the contact was informed that the vehicle was not under recall. The manufacturer was also notified of the failure, and the contact was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 5,000.

The vehicle went into limp mode! Everything associated with it happened so quickly,no brakes,no steering ,it was terrifying. We got safely to a gas station. We were advised to take it to a certified Chevrolet dealer which we did We had it towed to the certified Chevrolet dealer in Charlevoix, Michigan.They hooked it up to the diagnostics and said they found absolutely nothing wrong with the vehicle.Very Frustrating! After experiencing this terrible incident will never feel safe in this vehicle!

i pulled on to the road and i heard a loud knocking and my vehicle started skipping and wouldn't go. the lights on the dash lit up and said, "brake failure" and "emergency brake failure" and i had no brakes. I managed to coast into a parking lot. The engine light was on. I turned the vehicle off and waited about 5 minutes and turned it back on, The engine light remained. The first time this happened I was going down the road and the vehicle started sputtering, the emergency brake light came on the dash and the car shut off. It has a rough idle when you start it. I am terrified of this car. I have grandbabies in the car with me, Had i been on the highway either time i would have caused a terrible accident. The dealer says they can't get the car to do it so they can't fix anything. It has happened twice so you know it will again.

I have had my cruise control set and my car will slam on the brakes with no vehicles in front of my car or on each side. This has happened multiple times, it doesn’t matter if I am going 40MPH or 60+MPH. I have taken it in and they say there is nothing they can do for the issue. I’m worried for the safety of myself, my family, and my unborn child. As well as any cars around (behind me potentially) when this happens. I do not want to unintentionally cause an accident.

The engine light comes on and then the rpm's drop to 35 and a notification comes up that says "reduced acceleration. driving with caution". If I stop and turn of the vehicle and restart the rpm's will be better but the truck still seems to have a difficult time increasing in rpm's and accelerating gears. It's incredibly dangerous as if I'm driving at a substantial speed on the highway or freeway and it drops rmp's rapidly I'm likely to be in an accident which could be detrimental. The dealer has had my vehicle on two separate occassions. The most recent time they've had it for 5 days and still do not know what's wrong with it. The engine light will not turn off.

I have had my cruise control set and my car will slam on the brakes with no vehicles in front of my car or on each side. This has happened multiple times, it doesn’t matter if I am going 40MPH or 60+MPH. I have taken it in and they say there is nothing they can do for the issue. I’m worried for the safety of myself, my family, and my unborn child. As well as any cars around (behind me potentially) when this happens. I do not want to unintentionally cause an accident.

Transmission faulty, loud, clunky and hard shifting! Service transmission now alert and code P0747

The vehicle went into limp mode! Everything associated with it happened so quickly,no brakes,no steering ,it was terrifying. We got safely to a gas station. We were advised to take it to a certified Chevrolet dealer which we did We had it towed to the certified Chevrolet dealer in Charlevoix, Michigan.They hooked it up to the diagnostics and said they found absolutely nothing wrong with the vehicle.Very Frustrating! After experiencing this terrible incident will never feel safe in this vehicle!

Since purchasing the vehicle on September 27, 2024, I have experienced a series of troubling issues that raise serious concerns about its design, manufacturing, and overall safety, including: Airbag system malfunction: My airbags were nonfunctional for over a month. Tire-related issues: Required full replacement of the initial set of tires. Persistent alignment problems Bluetooth audio problems: Poor quality and connectivity with multiple phones, resolved only after a service visit in May 2025. Defective seat frame: Rear passenger-side bucket seat required full replacement. Defective paint: Blisters and bubbles in the rear quarter panel paint. Fuel module failure: Most concerning, the vehicle abruptly stopped on the road last week and required towing. I was later told the cause was a fuel module failure. Each of these issues is concerning on its own. Taken together, they represent a troubling pattern of unreliability and potential risk to my safety and that of others on the road. They’ve also resulted in a significant loss of my time. This vehicle has spent over a month at the dealership for service—astounding for a truck that’s only eight months old. These are the kinds of delays and disruptions I specifically try to avoid by purchasing and maintaining new Chevrolet vehicles.

Windshield wipers stopped working

Since purchasing the vehicle on September 27, 2024, I have experienced a series of troubling issues that raise serious concerns about its design, manufacturing, and overall safety, including: Airbag system malfunction: My airbags were nonfunctional for over a month. Tire-related issues: Required full replacement of the initial set of tires. Persistent alignment problems Bluetooth audio problems: Poor quality and connectivity with multiple phones, resolved only after a service visit in May 2025. Defective seat frame: Rear passenger-side bucket seat required full replacement. Defective paint: Blisters and bubbles in the rear quarter panel paint. Fuel module failure: Most concerning, the vehicle abruptly stopped on the road last week and required towing. I was later told the cause was a fuel module failure. Each of these issues is concerning on its own. Taken together, they represent a troubling pattern of unreliability and potential risk to my safety and that of others on the road. They’ve also resulted in a significant loss of my time. This vehicle has spent over a month at the dealership for service—astounding for a truck that’s only eight months old. These are the kinds of delays and disruptions I specifically try to avoid by purchasing and maintaining new Chevrolet vehicles.

The contact owns a 2024 Chevrolet Suburban. The contact stated that upon brushing snow off the vehicle, the contact noticed that there was snow inside the headlights, which later turned into ice and dimmed the headlights. The contact stated that while driving at an undisclosed speed, the failure recurred, causing the contact to pull over to the side of the road to clean the headlights. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 360.

Subject: Formal Safety Complaint—Cracked 22-Inch Polished Aluminum Wheels on 2024 Chevrolet Suburban To Whom It May Concern: I am submitting a formal complaint concerning repeated failures of the original 22-inch polished aluminum wheels installed on my 2024 Chevrolet Suburban, which I purchased new. Two wheels have cracked without any known impact, collision, road-hazard event, or other incident that would reasonably explain the damage. The first wheel cracked at approximately 25,000 miles. Tire pressure began dropping unexpectedly and ultimately fell to zero. The wheel was inspected and replaced by a dealership in Cincinnati. A second wheel later cracked and caused another sudden loss of tire pressure without warning. During that incident, I experienced difficulty maintaining steering control, creating a serious risk of a crash and injury. The second wheel was inspected and replaced by Tire Discounters in Lebanon, Ohio. The recurrence of substantially similar failures raises concern that the wheels may contain a material, manufacturing, or design defect. Aluminum wheels should not crack during normal operation in the absence of impact damage. A sudden loss of tire pressure, especially while the vehicle is moving, presents an unacceptable safety risk to the vehicle’s occupants and other road users. I respectfully request that Chevrolet and General Motors promptly: 1. Investigate these wheel failures as a potential safety-related defect; 2. Arrange for a thorough inspection of all remaining wheels on the vehicle; 3. Replace any affected wheels at no cost to me and review reimbursement for related expenses already incurred; 4. Confirm whether similar complaints, technical service bulletins, special coverage programs, or recalls have been identified; and 5. Provide a written response explaining the findings and proposed corrective action. I can provide the vehicle identification number, purchase documentation, mileage records, photographs, inspection findings, r

The contact owns a Nuna Rava Car Seat, Model Type: Convertible, Model Number: CS05013-GRN, Manufactured Date: July 16, 2016. The contact stated that the harness buckle became difficult to adjust while attempting to secure the child in the car seat. The contact received notifications of NHTSA Campaign Numbers: 24C002000 (Child Seat); however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue.

The contact owns a 2024 Chevrolet Suburban. The contact stated that while driving at approximately 30 MPH, the steering wheel locked at an angle, and the message "Power Steering Not Active" was displayed, causing the vehicle to strike a curb. The steering column, control arm, radiator, fender, and wheel were significantly damaged due to the incident. The vehicle was then towed to a dealer, where it was diagnosed that the power steering module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and an investigation was completed. The failure mileage was 58,277.