Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 507 NHTSA owner-reported complaints for the 2003 Chevrolet Tahoe. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 507 · page 1 of 21
When in drive the car will not go into 3rd gear. It slips from. 2nd and back passes 3rd gear completely and goes into 4th gear and the engine revs up/rpm. The transmition filter/screen has been replaced and all transmission fluids were drained and flushed and replaced with new transmittion fluids. And this did not fix the issue.
I bought my 2003 Chevy Tahoe used and as is at a dealership for $10,000. Yes, I've been robbed. The truck is in great LOOKING condition. Has a little bit of superficial dings and a couple dents but overall exterior is great. Interior isn't shabby. Has wear on the driver's seat but not bad. The first thing that happened, I was on my way to work at 4 in the morning, turned on right blinker to change lanes, about blinded the guy in front of me with high beam lights. I thought I had bumped the switch, I took the right to get off at my exit I was more mindful. Definitely not a me thing. The high beam came on with the right blinker. So, the next thing. CD player runs continuously without a disc in. I cannot put a disc in. There may be discs already in there, it is a 6 disc changer, but it will not play. The radio has a mind of its own. Plays what it wants at anytime its on. My husband drove it, tried to adjust the driver's seat and all it did was growl at him. It doesn't move except forward and back. My speedometer had a glitch one time. I was driving at 35mph and it showed 60mph. I turned it off, then back on, hasn't done that again. My heater works but it's difficult to change the individual temp settings. Almost as if the push buttons are worn inside or have a bad connection. The air conditioner only works when I'm on the freeway and not in stop and go traffic. The first time I turned on the AC, it blew all hot air for longer than 10 minutes. Halfway home I turned it on again but kept the button in off setting, I have cold air. There is a loud popping underneath when I turn left. Also, dropped into 4H driving down the highway at 65mph. Thought I was going to die. I have to drive in auto all wheel because the buttons are messed up. In 2H or 4H I get 4L. It is a mess. The dash is confused. 4 wheel does not go in easily, It bangs when it goes in and comes out. It really isn't safe but I was soaked on the price, I am female and first purchase. Should have bought a Ford
The cable on the rear passenger seat is broken and can't get seat down to escape in an emergency.
WELL MY AIR BAG LIGHT STAY ON NEVER GOES OVER AND MY DRIVER SEAT BELT DOES NOT EVEN LOCK AT ALL. THEN I KEEP HEAR THIS POPPING NOISE THAT COME FROM HUB AND SHOCKS AND NOTHING ON MY DASH WORKS 1ST IT STARTED OFF BY I COULDNT SEE WHAT GEAR I WAS IN. MY DRIVER SEAT U PUSH THE BUTTON TO GO FORWARD IT MOVES THE SEAT BACK. MY HEAT BLOWER HAS SOMETHING WRONG WITH AND IT HAS SOMETHING TO DO WITH THIS PURPLE WIRE ON THE FLOOR BORED. NOW MY TRUCK CANT GET ON THE FREE WAY BECAUSE EVERY THIME I GET ON THE FREEWAY AND ON THE FREE WAY FOUR MORE THEN 10-15 MIN MY TRUCK JUST SHUTS OFF. MY HEATED SEATED ONLY STAY ON FOR 1 TO 2 MIN AND THEN KEEPS SHUTTING OFF. MY BACK SEATS DONT LET DOWN AT ALL. THEN AT THE BOTTOM OF MY TRUCK WHERE THE OIL PAN IS FOR SOME REASON THERE IS ALWAYS ALOT OF OIL ALL OVER AT THE BOTTOM LIKE SOMEONE JUST DIP MY TRUCK IN A BIG BOWL OF OIL. THEN WHEN MY IGNITION WHERE THE YELLOW BLACK AND RED WIRE GO TO THE TOP OF MY IGNITION THE BLACK PLUG IS REAL LOSE AND CAN'T REPLACE AT ALL. AND WITH EVERYTHING ON NOW WITH MY INCOME IM ALREADY OUT OF $5,000 ALREADY FOR PARTS AND LABOR THIS IS MU ONLY CAR I HAVE AND I REALLY NEED MY CAR RIGHT NOW DONT HAVE MONEY TO GO BUY A NEW TRUCK OR CAR. I REALLY NEED MY TRUCK IT MEAN ALOT TO ME.
WHILE DRIVING THE TAHOE CLOSE TO HOME I STARTED TO SMELL OF BURNING AND I COULD SEE SMOKE COMING UP FROM THE DASH. I PULLED OVER AND BY THEN THE WHOLE CAR WAS FILLED WITH SMOKE AND I COULD SEE FLAMES COMING FROM UNDER THE DASH ON THE PASSENGER SIDE. I TRIED TO PUT OUT THE FLAMES (NOT RECOMMENDED) BUT THE FIRE JUST SPREAD UPWARDS INTO THE DASH AND WAS OBVIOUSLY OUT OF CONTROL. I LEFT THE VEHICLE AND CALLED 911 AND WITHIN MINUTES THE WHOLE FRONT OF THE CAR WAS ENGULFED IN FLAMES. THE POLICE AND FIRE SERVICE ARRIVED AND EVENTUALLY THE FIRE WAS EXTINGUISHED AFTER IT HAD BURNED THROUGH MOST OF THE VEHICLE. FORTUNATELY I WAS ON MY OWN AND I SUFFERED NO INJURIES EXCEPT A FEW MINOR BURNS TO MY HANDS. I AM GUESSING THE FIRE MAY HAVE STARTED WITH THE BLOWER MOTOR RESISTOR WIRING WHICH IS A PROBLEM MANY OTHERS HAVE REPORTED. *TR
CABLES FOR SEAT FOLDING MECHANISM BREAKING, PREVENTING THE SECOND ROW 60/40 SEATS FROM FOLDING TO ALLOW ACCESS TO THIRD ROW SEATS (THIRD ROW OCCUPANTS CANNOT EXIT VEHICLE - SAFETY ISSUE). *TR
DESCENDING A GRADE APPROACHING A T INTERSECTION BRAKE PEDDLE WENT NEARLY TO FLOOR. CAUSE WAS A SEVERELY RUSTED REAR BRAKE LINE. THIS LINE IS ROUTED ABOVE THE LEFT FRAME RAIL IN A NEARLY INACCESSIBLE AREA, SO THE NOTION THAT THIS IS AN OWNER MAINTENANCE ISSUE IS GARBAGE.
TAKATA RECALL, TODAY, MAY 31, 2019, I DROVE MY TRUCK TO A MEETING AT 1:30 IN THE AFTERNOON AND PARKED MY VEHICLE IN THE PARKING LOT (IT WAS STATIONARY IN A CITY PARKING LOT). WHEN I RETURNED TO MY CAR AFTER THE MEETING AT 3:30 IN THE AFTERNOON I OPEN MY CAR AND THE INTERIOR WAS ENGULFED IN SMOKE. A COMPONENT OF THE POWER SEAT ON THE DRIVERS SIDE STARTED THE FIRE. IT WAS FORTUNATE NO ONE WAS IN THE TRUCK AT THE TIME AND THE WINDOWS WERE CLOSED. AFTER THE FIRE IGNITED AND USED UP ALL THE OXYGEN IN THE INTERIOR THE FIRE BURNED OUT ON IT'S OWN. I DID CALL THE FIRE DEPARTMENT HE HAD NEVER SEEN ANYTHING LIKE THIS BEFORE. (I'VE INCLUDED THE FIRE DEPARTMENT INVESTIGATORS CARD AND I CAN OBTAIN A REPORT IF NEEDED). THE INVESTIGATOR WAS THE ONE THAT DETERMINED WHERE THE FIRE STARTED. HE EXPLAINED THAT THE TOP LAYER OF THE SEAT UPHOLSTERY HAS SOME FIRE RETARDANT BUT THE UNDERSIDE DOES NOT. YOU CAN SEE THAT THE SEAT WAS BURNED FROM THE BOTTOM TO THE TOP, THE ELECTRICAL WAS STILL OPERATIONAL AS YOU CAN SEE FROM THE LIGHTS THAT ARE ON IN THE PHOTOS. I CAN FIND NO RECALL ON THIS ISSUE AND YOUR ASSISTANCE WOULD BE APPRECIATED. I CAN ONLY IMAGINE WHAT WOULD HAVE HAPPEN IF I HAD BEEN BEHIND THE WHEEL WHILE DRIVING AND OR HAD MY DAUGHTER WITH ME. I AM THE SOLE OWNER OF THIS CHEVY TAHOE SINCE 2003. I WAS COMPLETELY STOCK AND NO OUTSIDE WORK HAS EVER BEEN DONE TO IT. I HAVE HAD IT REGULARLY SERVICED AND IT WAS RUNNING GREAT. I HAVE NEVER NOTICED ANY PROBLEMS WITH MY SEATS. I DO NOT SMOKE AND HAD NO OTHER COMBUSTIBLES IN THE CAR. PLEASE SEE PHOTO'S ATTACHED. ## VIN PASSED ## CHEVY TAHOE 2003 ##
MY CONTROL PANEL LIGHTS AND HEAT AND AIR CONTROL KNOBS ARE GOING OUT. MY BACK SEAT SEATBELT SOMETIMES WANT LATCH AND MY 3RD ROW SEATING WILL NOT LATCH TO THE BRACKET. MY STEARING IS BAD IT WILL NOT LINE UP AND THATS JUST THE BEGINING OF THE PROBLEMS THAT SHOULD NOT HAPPEN. MY GRANDKIDS RIDE IN THIS VEHICLE.
WHILE DRIVING MY INSTRUMENT CLUSTER STOPPED WORKING PULLED OVER UNPLUGGED BATTERY STARTED WORKING BUT BEEN HAPPENING A LOT IT HAS 180,000 ON IT
THE PIECE BROKE OFF THE BOTTEM LATCH TO THE FRAME ON THE SEAT FOR THE 3RD ROW SEATING AND SOMETIMES THE SEATBELT WANT LATCH IN BACK SEAT. DASHBOARD GAUGE LIGHTS BLOWN ALOT OF INSIDE GAGE LIGHTS ARE NOT WORKING AND HEATER/AIR STOPPED WORKING ON NUMBER 5 FAN.
EXITING FROM THE EXPRESSWAY WITH TRAFFIC LIGHT ABOUT 20 YARDS AWAY, CARS WERE STOPED DUE TO RED LIGHT AND I AM COMING DOWN HILL EXITING. APPLYING THE BREAKS AND THE PADDLE GOES TO THE FLOOR, I REAR ENDED THE VEHICLE ON THE FAR RIGHT .
MY AIR BAG LIGHTS ARE ALWAYS AND 4WD LIGHTS ARE I TOOK MY TRUCK TO A TRANSMISSION SPECIALIST THEY REPLACE THE TRANSFER CASE FOR THE 4WD BUT LIGHT REMAIN ON AND I STIIL FEEL THE SHIFT FROM 2-4 I TOOK IT BACK TO THE SPECIALIST AGAIN AND AGAIN STILL THE SAME PROBLEM
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED AFTER THE TIRE BLEW THEY MOVED THE VEHICLE TO THE SIDE OF THE ROAD AND ATTEMPTED TO DETACHED THE SPARE TIRE, HOWEVER IT DID NOT DETACH. THE CONTACT STATED THAT THE INSTRUCTIONS STATED THAT IF THE SPARE TIRE DID NOT DETACH THE LATCH MECHANISM WAS IN SAFETY MODE. THE CONTACT CALLED A TOW DRIVER AND THEY ATTEMPTED TO REMOVE THE SPARE PER GMC OWNERS MANUAL INSTRUCTIONS HOWEVER, THEY COULD NOT REMOVE THE TIRE. THE TOW DRIVER CALLED ANOTHER TOW TRUCK DRIVER, THEY CUT THE LATCH MECHANISM OFF THE VEHICLE, AND THE TIRE WAS LOWERED. THE CONTACT STATED THAT THEY WERE ON THE SIDE OF THE ROAD APPROXIMATELY THREE HOURS ATTEMPTING TO CHANGE THE SPARE TIRE. THE VEHICLE WAS TAKEN TO TIRE SHOP WHERE IT WAS DIAGNOSED THAT DUE TO THE SALT ON THE ROAD THE LATCH CORRODED. RYAN CHEVROLET LOCATED 911 HWY 55 BUFFALO, MN WAS CONTACTED AND THE TECHNICIAN ALSO INFORMED THE CONTACT DUE TO THE STATE THEY WERE LOCATED IN IT WAS AN INHERENT FAILURE WITH THE VEHICLE. THE MANUFACTURER WAS NOTIFIED HOWEVER NO FURTHER ASSISTANCE WAS OFFERED. THE CONTACT STATED IT WAS NOT STATED IN THE OWNERS MANUAL THAT THE LATCH NEEDED TO BE CUT AND THE SITUATIONAL FAILURE SHOULD BE REFLECTED IN THE MANUAL. THE FAILURE MILEAGE WAS APPROXIMATELY 285,000. *TT CONSUMER STATED WHEEL BLOCKS, ONLY MADE THE VEHICLE LESS STABLE AFTER IT WAS LIFTED UP BY THE SPARE TIRE, BALANCING ACT. DESIGN PROBLEM UPDATED 10/1/18*JB
TAMARA RECALLS
I BROUGHT IN MY 2003 CHEVROLET TAHOE TO CUTTER CHEVROLET IN HONOLULU, HAWAII TO REPORT AN "ENGINE LIGHT ON" CONCERN. SERVICE ADVISOR JULIANNA PARKS REPORTED THAT THE ISSUE MAY BE ATTRIBUTE TO (2) BROKEN EXHAUST BOLTS ON MY VEHICLE'S 5.3 LITER MFI IRON V8 ENGINE. CUTTER CHEVROLET IS AT 711 ALA MOANA BOULEVARD, HONOLULU, HI 96813. IN FOLLOWING UP TODAY OCTOBER 18, 2017, SHOP MANAGER BRAD EISEN REPORTED THAT THESE BOLTS BREAKING IS NOT A COMMON PROBLEM, AND THAT THERE IS NO RECALL FOR SUCH ISSUES. CUTTER CHEVROLET HAS HAD MY VEHICLE SINCE OCTOBER 01, 2017 AND REPORTED THAT IN ADDITION TO MY $500+ INSPECTION COSTS, THAT MY COSTS FOR REPAIR THUS FAR HAS EXCEEDED $1,400.00 IN THEIR ATTEMPTS TO REPAIR THESE BROKEN BOLTS, AND THAT THEY EXPECT THE FINAL COST TO BE MUCH HIGHER BY THE TIME THEY ARE DONE AS THEY HAVE TO CONTRACT A SPECIALIST MECHANIC FROM ANOTHER TOWN TO COME INTO THE CUTTER CHEVROLET REPAIR SHOP THIS COMING SATURDAY OCTOBER 21, 2017 TO MEET WITH MANAGER MS. TINA TO DO SPECIAL WORK TO REMOVE THESE BROKEN BOLTS. THIS IS RIPOFF BY GM TO HAVE SUCH SUB-QUALITY EXHAUST MANIFOLD BOLTS BREAKING OFF. HELP!!!! GM NEEDS TO DO A RECALL ON THIS!
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING DOWN AN INCLINE AT APPROXIMATELY 10 MPH, THE BRAKES FAILED AND THE VEHICLE ACCELERATED TO APPROXIMATELY 30 MPH. THE VEHICLE STOPPED AT THE END OF THE ROAD ON A FLAT AREA ON ITS OWN. THE CONTACT ALSO STATED THAT THE BRAKE PADS, ROTORS, AND MASTER CYLINDER WERE REPLACED APPROXIMATELY ONE YEAR AGO IN AUGUST OF 2016 BY AN INDEPENDENT MECHANIC. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AGAIN. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
TAKATA RECALL IS NECESSARY MY AIRBAG LIGHT IS ON UPON STARTING VEHICLE ALONG WITH SERVICE AIRBAG WARNING. I AM AFRAID THAT THIS IS AN UNSAFE CONDITION THAT SHOULD BE REPAIRED AT NO COST TO ME AS THERE SEEMS TO BE MANY OTHER COMPLAINTS ON THIS SAME ISSUE.
WHEN MAKING A RIGHT TURN VEHICLE LOSES POWER STEERING. DOESN'T HAPPEN ALL THE TIME COMES AND GOES. IF YOU GIVE VEHICLE A LITTLE GAS IT WILL START WORKING AGAIN BUT THAT'S NOT ALWAYS AN OPTION. I NOTICE IT MOST IF MY VEHICLE IS MOVING AT A SLOW RATE OF SPEED OR STOPPED. THIS IS A VERY DANGEROUS ISSUE AND NO ONE CAN SEEM TO OFFER ANY IDEAS ON FIXING IT.
MY TAHOE CAUGHT FIRE INSIDE THE DRIVER SIDE DASH. IT WAS PARKED, NO ONE HAD DRIVEN IT THAT DAY. I PUT IN A CLAIM WITH GM (CLAIM #SR 8-2955875514) AND IT WAS DENIED AS THEY SAID THERE ARE NO RECALLS FOR MY TAHOE. THIS FIRE STARTED OUT OF NO WHERE. THANK GOODNESS OUR NEIGHBOR CAME BANGING AT THE DOOR TO LET US KNOW THAT OUR TAHOE WAS ON FIRE. WE WEREN'T HOME AT THE TIME BUT MY SON WAS, WE ARRIVED TO FIND HIM WITH THE WATER HOSE EXTINGUISHING THE FLAMES THAT WERE COMING FROM INSIDE THE VEHICLE. I SENT THE PICS TO GM AND THEY JUST DENIED IT WITH NO OTHER EXPLANATION OTHER THAN THERE WAS NO CURRENT RECALL. THEY DIDN'T EVEN TELL ME WHY THE FIRE STARTED NO ONE CAME OUT TO SEE THE VEHICLE.
THE "SERVICE AIRBAG" WARNING LIGHT AND "SERVICE AIRBAG" DISPLAY COMES ON WHEN I START THE VEHICLE--AND STAYS ON. EVERY SO OFTEN, WHEN I START THE CAR, THE WARNINGS DISAPPEAR, ONLY TO REAPPEAR AFTER THE NEXT START OF THE ENGINE.
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT THE CRUISE CONTROL WAS INOPERABLE. THE ABS AND THE PARKING BRAKE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 172,000.
WHILE DRIVING THE BRAKES TOTALLY FAILED. PEDAL WENT TO THE FLOOR WITH NO BRAKES AT ALL. VEHICLE HAD TO RUN OFF THE ROAD AND STOP USING THE EMERGENCY BRAKE. AS SOON AS THE BRAKE PEDAL WAS PUSHED IT WENT TO THE FLOOR AND THEN WARNINGS LIGHT TO SERVICE ABS STARTED FLASHING AND BEEPING. THERE WAS NO WARNING PRIOR TO THE FAILURE OF THE BRAKE SYSTEM. AFTER THE VEHICLE WAS TOWED WE FOUND THAT THERE WAS NO BRAKE FLUID AND A LARGE RUPTURE WAS FOUND IN THE BRAKE LINE ON THE DRIVERS SIDE TOWARDS THE FRONT OF THE DRIVERS SIDE DOOR.
TL* TAKATA RECALL. THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED FOR AN EXTENDED PERIOD OF TIME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 136,000.
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHEN THE VEHICLE WAS STARTED, THE BRAKE PEDAL TRAVELED TO THE FLOOR. THE CONTACT EXITED THE VEHICLE AND NOTICED BRAKE FLUID ALL OVER THE DRIVEWAY. THE CONTACT INSPECTED UNDER THE VEHICLE AND DISCOVERED THAT THE BRAKE LINE WAS CORRODED AND LEAKING FLUID. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .