2019 Chevrolet Tahoe Powertrain (other) Problems

I recieved this message after bringing my 2019 Chevy Tahoe to the dealership today for regular maintenanceand to check out a slight noise coming from under my hood: Rotational noise in your engine compartment had to remove the belts to be able to isolate where the sound was coming from. The noise is coming from the camshaft inside your engine so we know that is going bad. He also noticed that the engine mounts are worn out, oil cooler lines leaks and water pump leaking. I have kept up all required/recommended maintenance on time and didnt have any reason to believe I needed anything more then belts replaced and fluids changed when I took my truck to the dealer. After recieving that message, I spoke with the manager at the dealer and he said its a common issue. I've loved on my vehicle and value it as it is my only vehicle that transports my 2 children and myself around. Therefore im confused how this could happen outside of a manufacturer defect. There werent any warning lights, just a slight chirp coming from under the hood which sound like maybe a belt was going. The truck is at Boniface Chevy Melbourne Florida where I purchased it from.

NHTSA ID

11742796

Incident

Jun 5, 2026

While driving, the engine started to shutter and run rough. Pulled over to check and see if everything was ok. When restarting engine it developed a ticking noise which got worse and worse. We then made an appointment at a transmission specialist to get it serviced. While driving there the engine started experiencing engine failure with loss of power and loud ticking noise. Diagnostic from trans shop showed issues with engine and cylinder 4 misfire detected. Yes, the vehicle can be inspected upon request. Safety was put at risk while driving when engine started to fail. Had to pull over and have towed. Independent service center has confirmed issues. Report in attachments. No warning lamps or messages appeared prior to failure issues. The issues first started on March 18th 2026. SUV has been un drivable since. We have been unable to find a repair shop who is willing to do the repairs needed. The vehicle really needs a whole new engine.

NHTSA ID

11739731

Incident

Mar 18, 2026

From purchase date -25,000 miles- vehicle had clunk every few minutes when driving. progressed to high RPM and shuddering. Transmission/Power drive

NHTSA ID

11731524

Incident

Dec 31, 1969

At 64000 miles my 2019 Chevy Tahoe has to be replaced due to lifters failing. GM/Chevy wants to charge me $17000 to install a new 6.2L - V8 engine. (Same engine that had the lifter problem). That engine has been recalled on earlier and later models. What do I do to fight the cost of new motor ?

NHTSA ID

11721709

Incident

Feb 25, 2026

The contact owns a 2019 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stalled while attempting to shift gears. There was no warning light illuminated. The vehicle was able to be restarted. The vehicle was towed to an independent mechanic, where it was diagnosed that metal shavings were found in the transmission, causing the transmission to fail. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was made aware of the failure. The approximate failure mileage was 127,000.

NHTSA ID

11713889

Incident

Jan 28, 2026

Mileage

127,000 mi

Ticking sound started from the motor and the check engine light came on. We took it to the dealership and was informed the vehicle had bad lifters with a bent push rod needing a full motor replacement. The vehicle has 92k miles and was purchased a year and a half ago from that same dealership. The vehicle is currently at the dealership awaiting costly repairs.

NHTSA ID

11712073

Incident

Jan 7, 2026

The automatic transmission on my 2019 Chevrolet Tahoe has failed prematurely at approximately 88,000 miles. The dealership confirmed internal transmission damage, specifically that Solenoid #3 in the valve body is sticking and not engaging, which requires a complete transmission replacement. Their written inspection states: “Possible internal damage in transmission. Solenoid 3 in valve body is not engaging.” The component is available for inspection upon request. Safety Risk: This malfunction created several dangerous situations. The vehicle hesitated, struggled to shift into gear, and at times moved forward while in reverse. These symptoms could cause loss of control, delayed acceleration when entering traffic, or unexpected movement putting myself and others at risk. Diagnosis Confirmation: Yes. The problem has been fully inspected, reproduced, and confirmed by an authorized Chevrolet dealership service center. They provided a written estimate of $8,669.59 for a complete transmission replacement. Inspection by Others: The transmission has been inspected by the dealership where the vehicle was purchased. No independent mechanic, police, or insurance representative has inspected it yet, but the dealership’s findings are available. Warning Lamps or Symptoms: Prior to the failure, I experienced hesitation, difficulty engaging gears, harsh shifting, and the vehicle lunging forward while in reverse. Shortly after these symptoms appeared, both the check engine light and tire pressure light came on. Additional Context: GM has released multiple Technical Service Bulletins (TSBs), including 19-NA-153 and 21-NA-199, addressing known issues with their 8-speed transmissions such as harsh shifting, slipping, and valve body/solenoid problems. This suggests a broader pattern of defects. GM and the dealership offered only 10% goodwill assistance, leaving almost the entire repair cost to the consumer, despite this being an internal mechanical defect with normal personal use.

NHTSA ID

11700961

Incident

Oct 1, 2025

The contact owns a 2019 Chevrolet Tahoe. The contact stated that the vehicle was consuming an excessive amount of engine oil. While driving at 30 MPH, the vehicle stalled consistently while shifting gears. There were no warning lights illuminated. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was taken to three independent mechanic,s who indicated that the failure was related to the engine. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 120,000.

NHTSA ID

11689444

Incident

Aug 24, 2025

Mileage

120,000 mi

While driving on the expressway I heard a rattling noise coming from my undercarriage, by the time I got off my exit the sound got louder, I attempted to make it home and when I pulled in my driveway, and popped the hood, fluid starting pouring out the bottom as well as splashed on other components. Upon further inspection it was determined that the fluid was coolant. There was no dashboards lights or warning signs indicating that something was wrong or that my car was at risk of overheating. I had the vehicle towed to an auto repair shop and the following was diagnosed and repaired: •Water pump •Cooling System •Engine Water pump •Engine Coolant thermostat housing assembly. •Serpentine Belt

NHTSA ID

11681700

Incident

Aug 10, 2025

The contact owns a 2019 Chevrolet Tahoe. The contact stated that while driving approximately 25-30 MPH, a message advising that the transmission fluid was overheating and to pull over was displayed. The contact coasted to the side of the road where, the vehicle became inoperable. The vehicle was towed to a certified mechanic, who diagnosed that the transmission fluid was burnt, causing the transmission to slip while switching gears. The mechanic informed the contact that the failure was a known issue and to contact the dealer. The dealer was contacted and informed the contact the VIN was not included in a recall. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed that the VIN was not included in a recall. The manufacturer referred the contact to the NHTSA Hotline to file a vehicle safety complaint. The failure mileage was 100,000.

NHTSA ID

11662399

Incident

May 20, 2025

Mileage

100,000 mi

When slowing down and accelerating there is a shutter and a jerk to my transmission. While I am driving the shuttering is sometimes so loud I can hear it over the radio and it is a vibration motion.

NHTSA ID

11643718

Incident

Feb 19, 2025

Transmission needed replacing at 110,000 miles. Torque converter went bad

NHTSA ID

11638333

Incident

Nov 15, 2023

Driving on the interstate when all the sudden there was no power to drive train, the rpm gauge red lined. I put gear shift to neutral and rpm gauge came down, at this time no check engine light. Coasted to exit and parked. Got out and look around Tahoe for damage none found, looked under hood and no damage or fluid anywhere, none found. Got back in Tahoe and shifted into drive. I drove on 2-line highway to nearby town; 25 mph is all it would go. There was not a chevy dealer in town, stop at a Ford dealership and they sent me to an independent shop. Check engine light came on as I drove to independent dealer. Independent dealer checked for codes found transmission he checked fluid level it was full, but fluid smelled burnt and had metal shavings. He pulled it into shop and dropped fluid pan, to visually verify transmission parts were bad. He had to install a new gm transmission.

NHTSA ID

11632956

Incident

Dec 2, 2024

1-*: Pressure Control Solenoid Valve 3 - STUCK OFF - Diagnostic code# P0796 (5/5) Permanent 2-*: Yes, The cars rear brakes suddenly locked and veered the car off the road. Check engine light came on and the car had trouble driving up my driveway. There was a burning smell coming from the front engine. 3*: Unknown - Confrimed with a Mobile Mechanic - I have a photo of the diagnostic code. Diagnostic code# P0796 (5/5) Permanent - Pressure Control Solenoid Valve 3 - STUCK OFF 4*: Yes, inspected by a mobile mechanic. Diagnostic code# P0796 (5/5) Permanent -Pressure Control Solenoid Valve 3 - STUCK OFF 5*: Check Engine Light appeared after the rear brakes locked up. After the Check Engine light appeared; minutes later the car had extreme trouble driving up my driveway. There was a burning smell coming from the front engine.

NHTSA ID

11629292

Incident

Dec 6, 2024

In March of 2023, my 2019 Chevy Tahoe began having episodes where while driving there would be no gas power. The needle on the speedometer would start dropping to zero and the truck would sound like it was in neutral without notice putting everyon in the vehicle and outside of the vehicle at risk. My kids travel long distance for their AAA sports. Then all of a sudden there would be a loud noise (sound like hitting a rock with a sledge hammer) and you would feel the jarring noise and it would engage again. It was taken into the dealer and they found nothing wrong with it, couldn't duplicate the problem. This was at approximately 128,000 miles. On and off it happened all from March through April 2023 without notice, on the expressway traveling at 70 mph and having no control over the speed of the vehicle. In April, it became more apparent that when you hit 50 mph and 70 mph it was happening on cue, at 130,000 miles. Took it to the dealer again in April 2023, gave them the information and all they told me was that it was the transmission, $12,000 and it would be $500 to just take it apart to confirm, no error code was scanning and if I wanted to trade it in they would get a sales person. I spoke with the sales person who couldn't help because the balance on the loan is $28,000. Went back to the sales to get the car and a different service person helped me and couldn't find the truck. The truck had never been entered into anything in the service department. I took the truck home and it has sat in my driveway. It is a shame that you purchase a $70,000 vehicle and cannot get quality service from the dealer and a vehicle that doesn't make it past 130,000 miles. We have a 2013 Ford Edge that has 358,000 miles on it. What does that say about Chevy currently? Currently I have been starting the vehicle and driving it down my block and back daily to keep it from deteriorating, it cannot go over 20 mph without the gas power failing. I am hoping someone can help.

NHTSA ID

11603391

Incident

Mar 1, 2023

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 7-12-23 Stalled in intersection and turned off Engine wont start Will start again after several minutes CHECK UNIT CODE P2635 PINPOINT TEST NEED FUEL PUMP 2-12-24 Sputters and stalls and stumbles CHECK UNIT NO ENGINE LIGHT AND NO CODES. REPLACE FUEL PUMP DRIVER MODULE

NHTSA ID

11601488

Incident

Jul 12, 2023

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 7-5-23 Cause- Performed DTC scan and found coed P2635 which signifies Fuel pump A Low flow/ performance. With key on, engine off I used a scan tool to command the fuel pump on while monitoring the fuel pressure sensor parameter and found that the fuel pressure was below specifications of 46-84 psi. Inspected fuel pump assembly and connector and no faults were found. Test results verified faulty fuel pump replacement needed at this time! 4-2-24 Check engine light went on & Car shut off out of nowhere. scan engine for codes and found codes p2535 and code po300 fuel pump pressure under performance replaced fuel pump

NHTSA ID

11601462

Incident

Apr 2, 2024

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 7-11-23 Driver noted the unit stalls while driving. they couldn't get past 5mph without stalling. check engine light on. tried starting unit multiple times. officer was unable to get the unit to turn over. unit was towed in by westway around 0100AM CHEK UNIT CODES P2635 PINPINT TEST NEED FUEL PUMP 02-12-24 Stalls over and over again Cause- Performed a DTC scan and found codes (P2635) fuel pump flow performance and (P018B) fuel pressure sensor performance. With pinpoint test I found that the fuel pump and module assembly need replacement at this time! Correction- Replaced and tested the fuel pump

NHTSA ID

11601456

Incident

Jul 19, 2023

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 03-04-24 Engine sputtering Scanned vehicle and codes P2635 fuel pump low fuel/performance was detected. Ordered fuel pump and fuel pump module.

NHTSA ID

11601454

Incident

Mar 4, 2023

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 9-8-23 customer states vehicle hard to start and doesn't accelerate scan vehicle for codes found codesp2635 fuel pump performance vehicle has low fuel pressure recommend replace fuel pump 10-31-23 Sputters & won't accelerate CEL correction: replace high pressure fuel pump test drive vehicle work complete.

NHTSA ID

11601450

Incident

Sep 7, 2023

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 7-30-23 Stalled & Died twice replaced Fuel Pump 3-08-24 Unit died at stop light CEL replaced fuel pump

NHTSA ID

11596945

Incident

Jul 30, 2023

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 7-8-2023 Unit stumbles & CEL on Replaced fuel pump 11-17-23 Units stumbles & CEL on Replaced fuel pump

NHTSA ID

11596938

Incident

Jul 8, 2023

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 6/5/24 The vehicle continues to stall out and shut off in the middle of the street. Start violently shaking and gas pedal does not work.

NHTSA ID

11594232

Incident

Jun 5, 2024

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. unit had to be towed in to repairer twice in 4 days. Both times for stalling out.

NHTSA ID

11594224

Incident

Feb 12, 2024

This vehicle is owned by the City of Fort Lauderdale Police Department. We are submitting complaints for multiple Tahoe's that have stopped during operation causing extreme danger to our staff and other drivers in the city. The cause is always bad fuel pumps and our units have had to have the pumps replaced in some cases multiple times. 1/2023 Vehicle stalled while idling - Replaced Fuel Pump 8/2023 Vehicle stalls while idling - Replaced Fuel Pump

NHTSA ID

11594218

Incident

Jan 25, 2023