2003 Chevrolet Trailblazer Ext Owner Complaints

TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THAT FUEL WAS LEAKING NEAR THE BOTTOM REAR OF THE VEHICLE. THE CONTACT INSPECTED UNDERNEATH THE VEHICLE AND NOTICED THAT THE CHECK VALVE WAS FRACTURED. JOE LUNGHAMER CHEVROLET (475 SUMMIT DR, WATERFORD TWP, MI 48328, 1-(248) 683-7100) WAS NOTIFIED AND STATED THAT THE VEHICLE WOULD NEED TO BE DIAGNOSED AND THERE WAS NO FUEL SYSTEM RECALL. THE MANUFACTURER ISSUED EXTENDED WARRANTY CAMPAIGN NUMBER: 14423, BUT THEY HAD NOT PROVIDED A RECALL REMEDY TO PREVENT THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS OUT OF WARRANT. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11190295

Incident

Nov 1, 2017

THE ABS LIGHT HAS COME ON AND THEN IT WOULD WORK SOMETIMES AND NOT OTHER TIMES. NOW IT NEVER WORKS. NOW THAT ITS WINTER I'M SLIDING AT STOP SIGNS THAT AREN'T EVEN THAT SLIPPERY. THE ACTUATORS IN THE HEATING AND COOLING ARE NOT WORKING PROPERLY. ALL SUMMER I HAD HEAT BLOWING ALL THE TIME AND SUDDENLY THERE WOULD BE NOTHING. NOW IT'S COLD AIR ALL THE TIME. MAKES MY WINDOWS FOG UP AND NOT DEFROST. I HAVE DONE THE RESET PROCEDURE AND HEAR THINGS MOVING BUT IT DOESN'T FIX IT. THE BLOWER IN THE BALL SEAT AND THIRD ROW IS HIT OR MISS FOR EVEN WORKING AT ALL.

NHTSA ID

11155988

Incident

Apr 1, 2017

Mileage

120,600 mi

HAS A BAD GAS SMELL LEAKING GAS SOMEWHERE

NHTSA ID

11139626

Incident

Oct 8, 2018

Mileage

194,000 mi

ONE BY ONE THINGS HAVE BEEN GOING OUT AND NOT WORKING. FIRST THE CAR WOULD NOT START ALL THE TIME WITH THE KEY, THEN THE A/C STOPED WORKING, NEXT WAS THE FUEL PUMP, THEN THE INJECTORS. I CHECKED EVERYTHING IT COULD BE. I WAS DRIVING WITH MY KIDS DOWN THE HIGHWAY WHEN MY CAR JUST DIED LOST POWER STEERING SO IT WAS HARD TO GET OFF THE ROAD FAST. I GOT IT STARTED AND WAS DRIVING AND IT DID IT AGAIN. I WAS ABLE TO FINALLY GET IT HOME WHEN IT WOULD NOT START AGAIN. AFTER SOME RESEARCH ONLINE FOUND OUT THIS CAR HAS ISSUES WITH THE FUSE BOX ITSELF UNDER THE HOOD. I OPENED IT UP JUST TO FIND THE WORDING THAT CONNECTED THE PINS WAS BROKEN IN NUMEROUS PLACES AND HAD STARTED TO BURN UP IN THE BOX.

NHTSA ID

11098831

Incident

May 27, 2018

Mileage

177,000 mi

WHEN DRIVING FOR 30 TO 45 MINS ALL THE INSTRUMENTS ON DASH START STICKING AND READING WRONG INFORMATION. IN THE PICTURE MY CAR IS PARKED .

NHTSA ID

11074590

Incident

Feb 23, 2018

Mileage

140,443 mi

SPEEDOMETER IS ERRATIC OFTEN SHOWING FALSE SPEED OR GOES TO ZERO.ALL MOVING SPEEDS HIGHWAY OR STREETS.

NHTSA ID

11033243

Incident

Nov 11, 2016

Mileage

108,321 mi

THE ELECTRONIC THROTTLE MODULE TO PCM COMMUNICATION ERROR COMES UP AND THE VEHICLE STARTS THE WARM UP PROCESS AND THEN DIES IN THE PROCESS OF WARM UP PROCEDURES. I GUESS MY QUESTION TO YOU IS HOW CAN I FIX THIS OR DOES A DEAL NEED TO FIX IT OR IS THERE A RECALL ON THIS ISSUE?

NHTSA ID

11019931

Incident

Aug 19, 2017

Mileage

199,263 mi

DRIVING DOWN ROAD ON THE WAY TO HOSPITAL AND TRAILBLAZER MADE A LOUD CLUNK. THEN STARTED MAKING A WHIRRING NOISE. FINISHED DRIVING SLOWLY TO HOSPITAL AS NOT TO MESS ANYTHING ELSE UP. PULLED IN AND PARKED. GOT READY TO LEAVE HOSPITAL AND HAD NO REVERSE ONLY FOWARD.

NHTSA ID

11010243

Incident

Jul 15, 2017

Mileage

150,000 mi

MY KEY WILL NOT COME OUT OF THE IGNITION I HAD TO UNSCREW AND REMOVE THE BOTTOM OF MY STEERING TO PUSH THE BUTTON ALSO ALL OF MY INSTRUMENT GAUGE DO NOT WORK INCLUDING THE SPEEDOMETER AND ALL GAUGES SO I NEVER KNOW MY TEMPERATURE OR FUEL LEVEL, OIL PRESSURE THEY ALL ARE NOT WORKING PROPERLY MY SPEEDOMETER ONLY WORKS SOMETIMES. ALSO MY ENGINE IS RUNNY ROUGH AND I HEAR A VIBRATION AND TICKING. MY CHECK ENGINE LIGHT IS AND I'M GETTING CODE SAYING THERES A LEAK IN THE FUEL EVAP SYSTEM. I HAVE SEARCHED THE INTERNET AND EVERYONE HAS THE SAME PROBLEMS WITH THEIR 2003 TRAILBLAZERS. WHY ISN'T CHEVROLET RECALLING THESE PROBLEMS ITS FUSTRATING THEY WANT SEVERAL HUNDREDS OF DOLLARS I CANNOT AFFORD

NHTSA ID

10981537

Incident

Jul 29, 2010

Mileage

80,000 mi

LOW BEAMS INTERMENTLY GO OFF AND ON ! EXHAUST MANIFOLD IS CRACKED CAUSING A LEAK ! ALL DASH GAUGES BUT FUEL GAUGE DONT WORK !

NHTSA ID

10956914

Incident

May 7, 2011

Mileage

120,000 mi

NONE OF MY GAGES WORK AND A LOT OF MY DASH LIGHTS ARE ON. I HAVE NO IDEA HOW MUCH GAS I HAVE. MY SPEEDOMETER AND RPM GAGES WORK BUT NOTHING ELSE DOES. THIS HAS BEEN HAPPENING ON AND OFF FOR ABOUT 3 MONTHS BUT THEY WOULD ALWAYS GO BACK ON. BUT NOW IT HAS BEEN OFF FOR A WEEK WITHOUT GOING BACK TO NORMAL. TWICE LAST WEEK THE RADIO AND THE POWER WINDOWS STOPPED WORKING AS WELL. THIS HAPPENS WHILE DRIVING PARKED ALL THE TIME AND IT DOESNT GO BACK TO NORMAL. I HAVE SEEN A LOT OF COMPLAINTS ABOUT THIS SO I HAVE NO CLUE WHY THERE ISN'T A RECALL. IT IS NOT SAFE TO DRIVE MY TRAILBLAZER UNTIL THESE THINGS ARE FIXED. I WORK AT A CHEVROLET DEALERSHIP AND THEY COULDN'T FIGURE OUT HOW TO FIX THIS EITHER. GM NEEDS TO PUT OUT A RECALL TO GET THIS FIXED ASAP.

NHTSA ID

10882369

Incident

Apr 4, 2016

Mileage

184,000 mi

THE GAS GAUGE STARTED MESSING UP/NOT READING RIGHT ESPECIALLY IN THE RAIN AND THEN SHORTLY AFTER THAT THE SPEEDOMETER STARTED DOING THE SAME THING. NOW NEITHER ONE WILL WORK AT ALL. THIS STARTED ABOUT TWO YEARS AGO AND QUIT WORKING ALL TOGETHER ABOUT 1 YEAR AGO. I HEARD THAT THIS IS HAPPENING TO ALOT OF TRAILBLAZERS. THIS STARTED WHILE THE VEHICLE WAS IN MOTION.

NHTSA ID

10852479

Incident

Mar 15, 2014

I HAVE REPLACED THE FRONT DIFFERENTIAL TWICE IN 10 MONTHS. I BOUGHT NEW PARTS FOR IT NOT USED THAT WERE REDONE TO GET RID OF THE PROBLEMS IT HAD NOW IT HAS GONE AGAIN. THIS TIME I HAVEN'T EVEN USED THE FOUR WHEEL DRIVE YET SINCE THE LAST REPAIR. I HAVE RESEARCH IT AND I NOTICED A LOT OF PEOPLE WITH THE SAME PROBLEM.

NHTSA ID

10811324

Incident

Dec 5, 2015

THE CHECK ENGINE LIGHT WENT ON AND THERE WAS A STRONG GAS ODOR. GAS HAD ALSO PREVIOUSLY SPILLED OUT WHEN FUELUNG.

NHTSA ID

10764433

Incident

Mar 29, 2015

Mileage

155,000 mi

MY WIFE AND FIVE CHILDREN TRAVELING ON I-94 E AND EXITED THE FREEWAY AT THE 12 MILE EXIT IN ROSEVILLE MI. MY WIFE ATTEMPTED TO BRAKE AS THEY APPROACHED THE RED TRAFFIC SIGNAL ON THE 12 MILE EXIT RAMP AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WITHOUT WARNING. SHE WAS UNABLE TO STOP THE VEHICLE AND PROCEEDED THROUGH THE RED LIGHT NARROWLY MISSING A HIGH SPEED COLLISION WITH BOTH EAST AND WEST BOUND TRAFFIC ON 12-MILE ROAD. SHE CONTINUED THROUGH THE INTERSECTION ON THE RED LIGHT AND WAS ABLE TO STOP THE SUV SEVERAL HUNDRED YARDS DOWN THE SERVICE DRIVE. SHE SLOWLY DROVE THE VEHICLE HOME AND I CHECKED THE BRAKES AND THE PEDAL WENT STRAIGHT TO THE FLOOR WITH NO BRAKE WARNING OR ANY OTHER INDICATORS ON THE DASH. I PUMPED THE BRAKES SEVERAL TIMES AND COULDN'T EVEN HOLD THE VEHICLE WHILE IDLING IN THE DRIVE POSITION. I ALSO NOTICED A LARGE PUDDLE OF FLUID UNDER THE DRIVER'S SIDE OF THE VEHICLE. I'M GOING TO LIMP THE VEHICLE TO MORAN CHEVROLET IN CLINTON TOWNSHIP, MI AND LEAVE IT WITH THOSE THAT SOLD ME THIS DEATHTRAP. ANOTHER AND PERHAPS EVEN GREATER SAFETY CONCERN I HAVE IS THE SUV'S TENDENCY TO MISBEHAVE WHILE IN AWD MODE. THE VEHICLE SOMETIMES GOES IN REVERSE WHILE DRIVE IS SELECTED AND VICE VERSA. ADDITIONALLY, THE VEHICLE WILL SOMETIMES PUT ITSELF IN NEUTRAL WHILE ENGAGED IN DRIVE MODE OR WHILE STOPPED AT TRAFFIC SIGNALS. OH AND LAST WEEK I REPLACED THE WINDSHIELD WIPER ASSEMBLY AFTER IT FAILED AND FOUND NO EVIDENCE THAT GM HAD COMPLETED THE RELATED RECALL WORK THAT SIGNED OFF AS BEING COMPLETE FOR THE WINDSHIELD MOTOR AND LINKAGE ASSEMBLY. I SEE I'M NOT ALONE IN HAVING SUFFERED CATASTROPHIC SAFETY RELATED FAILURES WITH THIS PARTICULAR SUV. PLEASE TAKE NOTICE AND FORCE GM TO RECALL TO FIX THIS CORROSION ISSUE WITH THE BRAKE SYSTEM. I ALMOST LOST MY FAMILY LAST EVENING AND WILL ASSUME IT WOULD HAVE MADE NATIONAL NEWS HAD THEY DIED IN AN ACCIDENT.

NHTSA ID

10761751

Incident

Sep 4, 2015

Mileage

88,000 mi

I PURCHASED A 2003 TRAILBLAZER FROM AN INDIVIDUAL. THE FRONT DIFFERENTIAL HAD A HOLE IN IT. SO I PURCHASED A DIFFERENTIAL FROM A SCRAP YARD. 90 DAY WARRANTY. STILL HAD A NOISE . I STILL HAD A NOISE FRONT DIFFERENTIAL WAS OUT AGAIN. I PURCHASED THE THIRD DIFFERENTIAL FROM A DIFFERENT YARD TOOK IT APART . FOUND THE DRIVER SIDE BEARING BAD. IT SEEMS TO BE A VERY COMMON PROBLEM BECAUSE THE DRIVER SIDE DRIVERS CONSTANT. I WAS WONDERING IF THERE IS A RECALL. I SEE A LOT OF COMPLAINTS ONLINE. THANK YOU THERE WAS A FIRE THE DIFFERENTIAL GREASE BURNT BEARING WENT OUT AND CHARD MOTOR AND SURROUNDING AREA NO REAL DAMAGE. *TR

NHTSA ID

10760210

Incident

May 1, 2015

FIRST OIL PRESSURE GAUGE WENT AND NOW MY SPEEDOMETER IS ALSO GONE STUCK AT 50 MPH. CALLED CHEVY CAN'T GET STRAIGHT ANSWER FROM THEM AND ASK WHAT OTHER VEHICLES WITH THE SAME PROBLEM WITH GAUGE CLUSTER ADVISED CAN'T DISCLOSED ANY INFORMATION.

NHTSA ID

10722806

Incident

Jun 1, 2015

Mileage

131,000 mi

NHTSA ACTION NUMBER : PE07014 OCCURRED ON MY VEHICLE AROUND NOVEMBER 2014. THE PROBLEM PRESENTED AS P0442 CEL AND ODOR OF GAS AFTER PARKING IN GARAGE. GM HAS INDICATED BECAUSE THE SPECIAL CONSIDERATION ALLOWANCE HAS EXPIRED, DESPITE THE LOW MILEAGE THEY WILL DO NOTHING. THIS VEHICLE WAS PURCHASED NEW IN AUGUST 2003. I DO NOT UNDERSTAND WHY GM WAS NOT COMPELLED TO ISSUE A SAFETY RECALL DUE TO THE RISK OF GAS LEAKING. I WOULD APPRECIATE ASSISTANCE TO GET GM TO MINIMALLY PROVIDE DEFECTIVE PARTS REPLACEMENT, DUE TO THE KNOW MANUFACTURING DEFECT IN THE GAS TANK. *TR

NHTSA ID

10678685

Incident

Nov 15, 2014

Mileage

56,000 mi

IT WAS SLEETING AND I LOST CONTROL ON A CURVE. I HAD BEEN DRIVING ABOUT 50 MPH, BUT BRAKE BEFORE THE CURVE AND BRAKE VERY HARD WHEN I TRIED TO REGAIN CONTROL OF THE VEHICLE, AS IT WAS SLIDING SIDEWAYS TOWARD THE CURVE. I WENT OFF THE CURVE AND HIT AN ELEVATED CROSSROAD, WHICH SENT THE VEHICLE AIRBORNE. I WAS AIRBORNE OVER MOST OF THE SIDE ROAD, WITH THE REAR OF THE VEHICLE HITTING JUST THE LAST FEW INCHES OF PAVEMENT, WHICH THEN SENT THE VEHICLE NOSEDIVING INTO THE DITCH. THE EMBANKMENTS WERE 4-5 FEET TALL. I HAD TWO VERY HARD FRONT END IMPACTS AND HIT MY HEAD ON THE STEERING WHEEL TWICE. THE FRAME OF THE VEHICLE WAS BENT AND THERE WAS A LOT OF DAMAGE TO THE UNDER OF THE VEHICLE, BUT THE AIRBAGS DID NOT DEPLOY. THE VEHICLE HAS BEEN DEEMED A TOTAL LOSS BY MY INSURANCE COMPANY. I HAVE A LOT OF CONCERN WITH THE FACT THAT THE AIRBAGS DID NOT DEPLOY AND KNOW THAT THERE WERE OTHER VEHICLES OF MY YEAR AND TYPE THAT DID HAVE FAULTY AIRBAGS RECALLED, BUT MINE HAS NOT BEEN. *TR

NHTSA ID

10670844

Incident

Dec 22, 2014

Mileage

120,000 mi

PLASTIC WELD CONNECTING FUEL FILL PIPE TO FUEL TANK HAS CRACKED.CONTACTED GM ABOUT THIS ISSUE & WAS INFORMED THAT THIS VEHICLE HAD JUST MISSED THE CAMPAIGN TO FIX THIS PROBLEM BY ONE MONTH. WHY IS THIS CAMPAIGN (07099) A LIMITED TSB & NOT A SAFETY RECALL? VEHICLE WOULD NOT PASS STATE EMISSIONS INSPECTION. TECHNICIAN REPAIRED LEAK WITH EPOXY THAT SEALED LONG ENOUGH TO PREVENT VAPOR LEAKAGE TO PASS EMISSION TEST.NOW THAT HAS FAILED AND ONCE AGAIN VEHICLE WILL NOT PASS EMISSIONS. MORE IMPORTANTLY THE FUEL VAPORS EMITTING FROM VEHICLE MAKE IT UNSAFE AND IMPOSSIBLE TO PARK IN AN ENCLOSED AREA.THIS IS NOT DUE TO A WORN PART OR CORROSION,THIS IS DUE TO A FAULTY DESIGN THAT EVENTUALLY WILL CAUSE AN EXPLOSION.WORSE YET GM OFFERS NO DISCOUNT ON THIS VERY EXPENSIVE TANK ASSEMBLY TO CORRECT THIS PROBLEM.I CAN NOT THINK OF A MORE DANGEROUS CONDITION THAT HAS BEEN SO IGNORED.PERHAPS WHEN THE FIRES START THERE WILL BE ANOTHER CONGRESSIONAL HEARING ABOUT GM'S ABILITY TO RESPOND TO SUCH A SERIOUS AND POSSIBLY LOSS OF LIFE HAZARD THAT THEY REFUSE TO ASSIST OWNERS IN CORRECTING. *TR

NHTSA ID

10633459

Incident

Sep 26, 2013

Mileage

149,420 mi

THE DRIVERS SEAT HEATER GOT VERY HOT AND THEN STOPPED WORKING SHORTLY AFTER. I DID AN INTERNET SEARCH AND FOUND THAT THIS IS VERY COMMON. I FOUND THAT ONE OF THE WIRES HAD OVERHEATED AND ACTUALLY BURNED THE FOAM AND COVERING. THERE ARE MANY COMPLAINTS AND PICTURES ON THE INTERNET. I REMOVED MY SEAT AND FOUND THE EXACT SAME PROBLEM. I AM ASTOUNDED THAT NOTHING IS BEING DONE TO STOP THE USE OF THESE DEFECTIVE HEATERS. THIS IS MOST CERTAINLY A VERY SERIOUS FIRE AND BURN HAZARD. *TR

NHTSA ID

10632616

Incident

Jan 10, 2012

Mileage

83,000 mi

SES LIGHT CAME ON. DEALERSHIP HAD NO APPS BROUGHT TO MECHANIC. CODE WAS FOR FUEL EMISSION LEAK. REPLACE GAS CAP. WEEK LATER CODE SES CAME ON AGAIN. BROUGHT BACK TO THE MECHANIC, SAID FUEL TANK IS CRACKED. CALLED CHEVY AND WAS TOLD THERE WAS A RECALL BUT NOT MY VIN..... *TR

NHTSA ID

10618346

Incident

Jul 20, 2014

Mileage

77,000 mi

MY VEHICLE STARTED RANDOMLY SHUTTING OFF WHILE DRIVING. LOSS OF POWER TO EVERYTHING BUT THE BRAKES. LUCKILY I WAS ONLY GOING 10-15MPH EACH TIME THIS HAPPENED. WITH THE RECENT RECALL IN GM VEHICLES REGARDING THE IGNITION SWITCH I THOUGHT IT WOULD BE A GOOD IDEA TO SWITCH THIS PART OUT FIRST. FIXED THE PROBLEM IMMEDIATELY. I WOULD LIKE TO BE REIMBURSED MY COST FOR PART AND LABOR. I CAN'T BELIEVE AS MANY KNOWN PROBLEMS THE TRAILBLAZER HAS WITH THIS THAT IT HAS YET TO BE ADDED TO THE RECALL LIST. *JS

NHTSA ID

10616831

Incident

Jun 25, 2014

Mileage

131,000 mi

WHEN I PULLED INTO DRIVEWAY, I PUT THE VEHICLE IN PARK, AND TURNED THE KEY OFF, AND ACTUALLY PULLED THE KEY OUT OF THE IGNITION SWITCH, WITH THE VEHICLE STILL RUNNING. I BACKED THE CAR UP, WITHOUT THE KEY IN THE IGNITION, WHERE I STARTED SMELLING WIRES BURNING. I CALLED FIRE DEPARTMENT, AND THEY PUT FIRE OUT ON THE FUSE BOX, WITH EVERYTHING MELTED AROUND IT. I HAVE HAD MINOR PROBLEMS WITH THE CAR, I.E. WHEEL BEARING AND BRAKES, BUT, NOTHING LIKE THIS. WHILE MY 14 YEAR OLD DAUGHTER AND I WERE IN THE CAR AT THE TIME, WE DID GET OUT, AND NO ONE WAS HURT. *TR

NHTSA ID

10605774

Incident

Jun 24, 2014

Mileage

127,000 mi

THERE IS A STRONG ODOR OF GASOLINE VAPORS COMING FROM THE REAR OF THE VEHICLE, A CRACK CAN BE SEEN IN THE NECK OF THE FUEL TANK. WHEN FILLING THE VEHICLE, FUEL SPILLS OUT OF THE TANK FROM THE CRACK. THE FUEL GAUGE CLUSTER IN THE DASH DOESN'T WORK. THE BLOWER ON THE A/C UNIT DOESN'T WORK ON THE HIGHEST (5) LEVEL. ALSO, THE FAN CLUTCH WENT OUT CAUSING THE CAR TO OVERHEAT SEVERELY. THE FAN DOES NOT ENGAGE, CAUSING THE WATER PUMP SHAFT TO BECOME DAMAGED. ALSO, THE REAR DRIVER SIDE WINDOW QUIT FUNCTIONING, DESPITE BUYING AN EXPENSIVE NEW REGULATOR AND REPLACING IT. HAVING RESEARCHED THE ISSUES, I FIND THAT I AM AMONG HUNDREDS, POSSIBLY THOUSANDS OF UNSATISFIED PEOPLE WITH THE SAME PROBLEMS. *TR

NHTSA ID

10605390

Incident

Jun 9, 2014

Mileage

140,000 mi