2006 Chevrolet Trailblazer Ext Body & structure Problems

THE ELECTRIC SEAT CONTROL PANEL WHICH IS LOCATED ON THE DRIVERS SEAT ON THE LOWER LEFT SIDE BECOMES DISLODGED UPON A LARGER PERSON SITTING IN THE DRIVERS SEAT. MY VEHICLE HAD THIS PROBLEM AND WAS TAKEN TO A GM GARAGE AND THE PANEL WAS REATTACHED MORE THAN ONCE IF I REMEMBER CORRECTLY. THE SIDE PANEL STILL CONTINUES TO COME OFF. THE DISLODGING OF THIS PANEL COULD CAUSE THE SEAT TO MOVE WHILE THE VEHICLE IS IN MOTION UNEXPECTEDLY REPOSITIONING THE DRIVER AND CHANGE THE DRIVERS POSITION RELATIVE TO THE STEERING WHEEL AS WELL AS THE BRAKE AND GAS CAUSING LOSS OF CONTROL. *TR

NHTSA ID

10587544

Incident

Jan 17, 2007

Mileage

40,000 mi

I HAD BY BACK HATCH OPEN AND I GRABBED THE DOOR HANDLE TO CLOSE IT. I PULLED IT DOWN AND AS I PULLED IT DOWN I HEAR A POP AND ALL THE GLASS SHATTERED DOWN ON ME WITH THE DOOR STILL OPEN UP IN THE AIR. THREE WEEKS LATER I REPLACED THE WINDOW. (NOT A CHEAP GLASS ALMOST $1000 WITH LABOR TO REPLACE) THE MECHANIC OPENED AND CLOSED THE DOOR AND THE HATCH TO TEST FOR DEFECTS. ALL WENT WELL. I WENT TO CLOSE THE DOOR SO THAT I CAN LEAVE THE MECHANIC SHOP AND I HEARD THE POP AND THE GLASS SHATTERED AGAIN. GMC HAS NO RECALLS FOR THE 2006 CHEVY TRAILBLAZER EXT LS AND I HAVE TO GO GET THIS BACK WINDOW AGAIN. THIS IS A GREAT TRUCK JUST DON'T KNOW WHAT IS WRONG WITH THIS BACK WINDOW. UGHHHH! *TR

NHTSA ID

10471492

Incident

Jul 27, 2012

Mileage

144,000 mi

GAS GAUGE BECAME VERY ERRATIC. FINALLY DIDN'T REGISTER AT ALL. CHECK ENGINE LIGHT CAME ON WHILE OUT OF TOWN. TOOK THE CAR TO A MERLIN AUTOMOTIVE FOR REPAIR. SPENT HUNDREDS OF DOLLARS AND THE LIGHT WOULD NOT GO OFF. MASS AIR FLOW METER, PLUGS, FUEL RAIL, THROTTLE POSITION SENSOR, FUEL INJECTORS. THEY EVEN CALLED IN A CHEVY TECHNICIAN WHO COULD NOT FIGURE IT OUT. WHEN I RETURNED HOME I TOOK IT TO MY LOCAL REPAIR SHOP WHERE THEY DROPPED THE TANK AND REPLACED THE SENDING UNIT. HUNDREDS OF DOLLARS IN EXPENSES. THEN THE HEATING FAN SWITCH STARTED SMOKING AND HAD TO BE REPLACED AS IT HAD MELTED AND NOTHING WORKED . ALSO, EVERY DOOR RUSTED THROUGH AT THE BOTTOM INCLUDING THE REAR HATCH. DEALERS' RESPONSE:WELCOME TO WISCONSIN. I SPENT $700 TO HAVE THE RUST CLEANED UP. *TR

NHTSA ID

10425343

Incident

May 2, 2011

Mileage

99,000 mi

I HAVE A 2006 CHEVY TRAILBLAZER EXT. I WAS DRIVING AROUND AND IT WAS PRETTY WINDY. I NOTICED THAT THERE SEEMED TO BE ALOT OF AIR COMING IN THRU THE REAR HATCH. WHEN I OPENED THE GLASS ON THE REAR HATCH I NOTICED THAT THE HINGE HAD COME UNGLUED FROM THE WINDOW. SINCE IT WAS WINDY IT ALSO CAUSED SOME OF THE OTHER HINGES TO CRACK AND BREAK WHERE THE 3RD BRAKE LIGHT IS LOCATED. I HAD TO FORCIBLY CLOSE THE REAR WINDOW AND NOW IT IS ONLY BEING HELD BY ONE HINGE ON THE RIGHT SIDE AND IN THE LOWER MIDDLE WHERE IT CLOSES AND LOCKS. CHEVY SAYS THAT IT'LL COST ME OVER $1,300 TO GET FIXED SINCE IT IS OUT OF WARRANTY. IT ONLY HAS 53,000 MILES ON IT. *TR

NHTSA ID

10399952

Incident

May 7, 2011

Mileage

53,000 mi

TL*THE CONTACT OWNS A 2006 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT WHILE DRIVING 60 MPH IN THE RAIN THE REAR OF THE VEHICLE STARTED SHAKING AND THE RAIN GUARD TRIM KIT ON THE TAILGATE BROKE AND WAS HANGING FROM THE VEHICLE. THE CONTACT PULLED OVER AND REMOVED THE TRIM KIT SINCE IT COULD HAVE FALLEN OFF OF THE VEHICLE AND HIT SOMEONE'S VEHICLE AND CAUSED A CRASH. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THERE WAS NO REASON THAT THE TRIM KIT SHOULD HAVE BROKEN OFF OF THE VEHICLE BECAUSE IT WAS NOT DAMAGED. THE DEALER STATED THAT THE CONTACT WAS RESPONSIBLE FOR THE REPAIR SINCE THE WARRANTY EXPIRED AND THERE WERE NO RECALLS. THE CONTACT STATED THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE REPAIRS SINCE THE FAILURE WAS A DESIGN DEFECT. THE FAILURE MILEAGE WAS 74,000.

NHTSA ID

10357220

Incident

Sep 4, 2010

Mileage

74,000 mi

THE GLUE THAT HOLDS THE REAR WINDOW ON THE VEHICLE SEPARATES FROM THE WINDOW, CAUSING THE WINDOW TO BLOW OUT. WE NOTICED THE WINDOW WAS LOPSIDED SO WE OPENED IT AND FOUND THAT ONE SIDE OF THE WINDOW HAD COME UNGLUED. WE TOOK IT TO THE DEALERSHIP THIS MORNING AND THEY SAID IT COULDN'T BE REGLUED - IT WOULD HAVE TO BE COMPLETELY REPLACED. CHEVY WON'T COVER IT BECAUSE IT'S OUT OF WARRANTY. WE LEFT AND HE CALLED US WITH THE QUOTE OF $1000 FOR REPLACEMENT. JUST A FEW MINUTES LATER, THE ENTIRE WINDOW BLEW OUT. IT SHATTERED GLASS ALL OVER THE ROAD AND VEHICLE, EVEN HITTING US IN THE BACK OF THE HEAD. LUCKILY OUR DAUGHTER WAS NOT IN THE CAR. THE PLASTIC COVER THAT SITS OVER THE TOP OF THE WINDOW FLEW OFF THE BACK AND INTO TRAFFIC. THERE WAS A CAR BEHIND US BUT THERE WASN'T MUCH TRAFFIC SO THEY MANAGED TO AVOID BEING HIT. NO ONE WAS HURT WHEN IT EXPLODED BUT IT COULD VERY EASILY HAVE HURT SOMEONE IN THE BACK SEAT OR IN VEHICLES BEHIND US. *TR

NHTSA ID

10340832

Incident

Jun 30, 2010

Mileage

82,331 mi

I OWN A 2006 CHEVROLET TRAILBLAZER EXT, DURING THE SUMMER HEAT I OPENED THE TOP PART OF THE BACK HATCH (THE GLASS AREA) AND THE ENTIRE LEFT SIDE OF THE HATCH DETACHED FROM THE CAR, LIFTING THE PLASTIC MOLDING ON TOP OF THE VEHICLE HOLDING THE 3RD BRAKE LIGHT. THE BOTTOM PART OF THIS "HINGE" WAS ONLY ATTACHED WITH AN ADHESIVE WHICH OBVIOUSLY MELTED FROM THE FLORIDA HEAT AND DISASSEMBLED. AT THIS POINT I CAN NO LONGER LIFT THE BACK GLASS OR THE ENTIRE REAR HATCH. CHEVROLET WILL NOT REPAIR OR COMPENSATE US FOR REPAIR OF THIS ISSUE AS THE VEHICLE IS NOW OUT OF WARRANTY. THEY STATED THAT THIS HAS BEEN A PROBLEM ON SOME TAHOES, YUKONS AND TRAILBLAZERS AND IT WOULD COST AROUND $1700 TO FIX THIS "DEFECT". *TR

NHTSA ID

10340703

Incident

Jun 25, 2010

Mileage

71 mi

MY 2006 CHEVY TRAILBLAZER EXT IS JUNK! WE PURCHASED IT USED IN 06 IT HAD AROUND 20,000 MILES IT NOW HAS 75,000 THE FRONT DOORS MAKE LOUD POPPING NOISES WHEN OPENED AND SHUT. THEY ARE COMING LOOSE FROM THE FRAME. *TR

NHTSA ID

10270226

Incident

Apr 1, 2009

Mileage

70,000 mi

MY 2006 CHEVY TRAILBLAZER EXT IS JUNK! WE PURCHASED IT USED IN NOVEMBER OF 06 IT HAD AROUND 20,000 MILES IT NOW HAS 70,000 THE FRONT DOORS MAKE LOUD POPPING NOISES WHEN OPENED AND SHUT CHECK ENGINE LIGHT STAYS ON HAVE HAD IT SERVICED TWICE WONT GO AWAY HAD MASTER CYLINDER REPLACED ITS NOW MAKING A HORRIBLE WHINING NOISE WHEN STARTED BEING DRIVEN HORRIBLE WIND NOISE FROM FRONT PASSENGER DOOR IT IS HORRIBLE! WHILE DRIVING DOWN THE ROAD THE WINDSHIELD JUST POPPED! IT WASN'T HIT BY A ROCK OR ANYTHING! BACK HATCH SEEMS TO BE COMING LOOSE HAVE HAD MANY MANY BRAKE PROBLEMS. *TR

NHTSA ID

10209874

Incident

Nov 15, 2006

Mileage

50,000 mi