2017 Chevrolet Volt Driver assistance Problems

Experiencing intermittent propulsion system failure with multiple simultaneous warning messages on 2017 Chevrolet Volt at approximately 59,000 miles. WARNINGS DISPLAYED: - "Propulsion Power Reduced" message - "Check Tire Pressure Monitoring System" (false alert - all tires properly inflated and recently replaced) - Multiple dashboard warning lights including exclamation point indicators - Vehicle exhibits abnormal driving characteristics PATTERN: Issue occurs intermittently while driving. Vehicle can be restarted and may operate normally afterward, then fault returns unpredictably. SAFETY CONCERN: This matches documented Battery Energy Control Module (BECM) failure pattern referenced in GM investigation N232432680/PE23022 and Customer Satisfaction Program 17228 recall N172096420 for reduced propulsion power in 2016-2018 Volts. Review of owner complaints shows other 2017 Volt owners experiencing sudden complete loss of propulsion while driving at highway speeds, creating dangerous situations requiring evasive action by other drivers. RISK: Loss of propulsion power while driving with dependent passengers creates serious crash risk. Vehicle is used for daily transportation of minor children. REQUEST: Vehicle exhibits known defect pattern but manufacturer has not extended recall coverage. Request investigation into whether recall should be expanded to cover additional affected vehicles.

NHTSA ID

11710156

Incident

Jan 10, 2026

I was driving in stop and go traffic on a relatively busy road when I was cut off. I braked hard to avoid a collision. Immediately afterwards, the car would not respond to the accelerator and would not go forward. I was in the middle of the road and the car would not respond. It could have caused an accident. I put the car into park and then back into drive and it seemed to work again. But I am now worried about the car.

NHTSA ID

11705387

Incident

Dec 15, 2025

The engine light starts blinking and telling me propulsion power reduced, and then I cannot use the cruise control after that turns on, and it starts losing power, driving on I 70 after work all of a sudden it turned on and wet from going 76 miles an hour to 52 on highway I 70 where the speed limit was 75. This problem was a recall problem which was fixed and now is happening again on the same part and having the same problems.

NHTSA ID

11702324

Incident

Nov 30, 2025

I am reporting a series of safety concerns regarding my 2017 Chevy Volt, which have persisted despite multiple attempts to address them with the dealership. These issues pose significant risks to my safety and that of others on the road. On January 18th, 2024, I brought my vehicle to the dealer after experiencing reduced propulsion power while driving on the highway, coupled with the illumination of the check engine light. The mechanic performed a quick inspection and used a GM scan tool to diagnose the issue, revealing the code P1E00 for the Hybrid Powertrain Control Module 2, which was cleared without a thorough investigation. I was advised to return if the issue reoccurred. Despite the reset, the problem persisted, and on February 9th, 2024, I scheduled another appointment due to my Chevy Volt's High Voltage battery charging only to 65% capacity despite indicating a full charge. Subsequently, on February 11th, 2024, the check engine light illuminated again, and on February 12th, 2024 and again on November 25th, 2025, while driving to work, both times I experienced a loss of propulsion power on the highway, placing my safety at risk and lost all power in a traveling lane of traffic. These ongoing issues with propulsion power and the high-voltage battery charging system are not only inconvenient but also potentially dangerous. Despite multiple visits to the dealership and attempts to diagnose and resolve the problem, it persists, indicating a systemic issue that requires immediate attention. The reduced propulsion power while driving on the highway, coupled with the illuminationI urge the National Highway Traffic Safety Administration (NHTSA) to investigate this matter thoroughly to ensure the safety of Chevy Volt drivers and passengers. It is imperative that General Motors addresses these issues promptly and implements appropriate measures to prevent further incidents.

NHTSA ID

11701635

Incident

Nov 25, 2025

While driving approximately 65 MPH on an interstate highway, the vehicle's check engine light illuminated. Very shortly after, the dashboard screen displayed the message "propulsion power reduced," and the internal combustion engine turned on. The vehicle's power was significantly reduced, almost causing an accident when another car started merging without checking their blind spot, forcing me into the left lane in front of a third vehicle that had to brake sharply to allow me to accelerate to keep up with traffic in that lane. Upon scanning the vehicle with an OBDII reader, codes P1E00, P1F06, U2603, U2604, U2605, U2606, U2617, and U2618 were present. Together, these codes indicate an issue with the Battery Energy Control Module (BECM). The vehicle is currently at a Chevrolet dealer, awaiting replacement of the BECM under the applicable warranty extension.

NHTSA ID

11678683

Incident

Aug 1, 2025

I got a warning from my car a little over a week ago (around 6/1, unsure of exact date) that I needed to service the battery charging system, but then the check engine indicator light shut off and so did the warning light. The hybrid battery took a charge with no issues after that. Then, I left work the evening of 6/9 and drove home. On my way home, the check engine light came back on, followed by warnings that I needed to shift to park. Before I could pull over, my car stopped moving. Cars had to stop abruptly behind me and navigate around me into incoming traffic. I shifted to park, then tried to turn my car off and on again. I tried to switch between the gas engine and the battery, I tried to move my vehicle in any way. I couldn't get it into neutral to push it out of traffic. I turned on my hazard lights and a person came out from his house to assist in directing traffic away from my car for about an hour while I waited for a tow truck to arrive. The kind bystander who directed traffic and I were very concerned about a car accident happening due to my stopped vehicle. A police officer stopped by to check on us and try and get my vehicle into neutral but he was unable and said he was on his way to a 911 dispatch so he did not write a report of any kind that I could see. He told me the vehicle placement was not safe and I agreed with him. The tow truck came as he was leaving. The dealership I sent my car to said it is likely a short circuit in the 12v battery but I know the BECM in the Chevy Volt is known to cause similar behavior. Dealership refused to service the BECM when asked about it.

NHTSA ID

11666820

Incident

Jun 9, 2025

Unknown My car has been accelerating and decelerating on it’s own while I’m driving.I got it checked with Fix Finder and states that my EGR Valve and ABS System failed. I brought it to a mechanic for a repair and I was told that the valve was unplugged so they plugged it back in and cleaned it , and said that everything was fine it said it might also be the cause of the failed ABS System but everything looks fine. After I got it fixed, it’s doing the same again and it’s worse this time. The car is accelerating on it’s own faster than what it did but the dashboard is saying 0mph. I was driving in the highway when it happened and it’s scary so I had to pull over.

NHTSA ID

11656857

Incident

Apr 25, 2025

I am submitting this complaint regarding a recurring and potentially hazardous issue in my Chevrolet Volt 2017.The vehicle frequently displays a “Shift to Park” warning message even when the gear shifter is correctly in the Park position. This malfunction prevents the car from shutting off properly, posing both safety and operational concerns. This issue is widely reported among Chevrolet Volt owners, and General Motors has acknowledged it in Technical Service Bulletin (TSB 19-NA-206). Despite this, no formal recall has been issued to ensure a permanent solution for affected drivers. My Volt currently has 138000miles, and although it is outside of the Voltec Warranty period, this is clearly a manufacturer defect—not a result of normal wear and tear. The problem affects the safe operation of the vehicle and may lead to battery drain, inability to power down the car, and driver confusion. I strongly urge the National Highway Traffic Safety Administration (NHTSA) to investigate this issue and consider initiating a recall to protect drivers and ensure accountability. Thank you for your time and attention to this matter.

NHTSA ID

11656069

Incident

Apr 15, 2025

On December 2023 the vehicle lost power and lost control while driving speed limit 55 Mph followed by check engine light associated codes due to known issue with BCEM controller failing. June 2024 Vehicle experienced the same issue with duplicate check engine codes associated with prior issue. Dealer states the vehicle has a bad battery pack and has been there for over 8 months. Vehicle has a BECM warranty due to a law suite filed and also has a battery pack warranty from GM that was extended for 150,000 miles or 10 years.

NHTSA ID

11646116

Incident

Jun 22, 2024

The EGR valve failed. This caused the vehicle to have insufficient propulsion while driving. The dealer has confirmed the EGR valve is the problem. The vehicle is at the dealership. The check engine light came on. The dealer is now stating the replacement EGR valve is a $4000 part because GM stopped making the part when they discontinued the Volt. An EGR valve should cost $250-$400 not $4000. The current trade-in value of my vehicle is only $7000. I cannot get my vehicle fixed due to the cost and the vehicle is too dangerous to drive due to the power loss issues.

NHTSA ID

11642680

Incident

Feb 5, 2025

Currently, two two issues are ongoing with my 2017 Chevrolet Volt Premier. I took my Volt to Epic Chevrolet in Sacramento, CA, on August 9, 2024, because the "Propulsion Power Is Reduced" warning and the "Service Park Assist System" warning came on with the "Check Engine" light. After diagnosis I was informed that the "EGR Valve" has failed; however, Chevrolet cannot procure the EGR Valve to repair my Volt and it is now October 14. I have been coordinating with Chevrolet Customer Assistance who continue to inform me that they are looking for the part but cannot provide it - apparently this part has been redesigned. This is the third time in 12 months that the Volt has been in for repair, all under warranty, for charging and propulsion related issues. On August 23, 2023, the Volt was in the shop for 15 days getting the "Battery Energy Control Module" replaced under warranty. On [XXX], one week after being repaired, my car would not start and had to be towed. That time the "Hybrid Battery Disconnect Relay Assembly" failed and was in the shop for 14 days, again repaired under warranty. This time, my car has been in the shop for 66 days waiting for an EGR Valve that, per Epic Chevrolet, is covered under warranty. It is unacceptable for Chevrolet to warranty its cars but not have the parts to perform the repair and let owners continue to pay loans on a car, insure a car, and have financial hardships for not having a car. I am not confident that, once fixed, something else will not go wrong. Plus, I was quoted $1,160 to fix the safety issue of the Parking Collision Warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11619651

Incident

Aug 9, 2024

This car has a failed EGR valve which first became evident in March of 2024. There are no parts available, this in an emissions issue but the failure causes blown fuses which can cause the car to completely stop running which is a safety issue. Reduced propulsion is a symptom which is dangerous and this has been confirmed by three Chevy dealerships. I have had the EGR valve cleaned to the tune of $1200, have a deposit on a new valve which doesn't seem to exist for $850. There were no other messages before the failure. I am driving the car with the EGR valve disconnected, mostly on the battery power but no end is in sight to this problem.

NHTSA ID

11615510

Incident

Mar 10, 2024

I had the BECM fail as part of many 2017 volts with this issue at around 40K miles. This failure has caused multiple near accidents with immediately losing power at highway speeds. The last time this happened (after the BECM was replaced) was a couple of weeks ago. They said the reason for the failure was a programming issue, and they have updated it. It is flabbergasting to me that a programming issue can result in such a dangerous result. The car reduced propulsion on the highway and got stuck on the offramp while trying to pull over on the busy highway. Not only were we left stranded on the highway with me being 8 and a half months pregnant, but my husband almost got into an accident twice while trying to make it over safely. Chevy needs to be accountable for these significant failures that seem to continuously happen to Chevy Volts. It's not just the BECM - they have multiple things that are causing extremely dangerous results. When they replaced the BECM they also replaced the 12V (with significant out of pocket cost to us) and leaving us with no vehicle for a long time. We bought a new car right after this incredibly scary incident.

NHTSA ID

11600663

Incident

Jun 3, 2024

On [XXX] while traveling at highway speed my Chevrolet volt abruptly lost propulsion and an alert was displayed to pull over and turn car off. I was on [XXX] in California a 4 lane highway forced to cross 3 lanes of traffic at an exceptionally slow speed in heavy traffic. It is a miracle a crash did not occur. Fortunately other drivers were aware and able to stop or quickly change lanes. AAA towed directly to Stewart Chevrolet in Colma Ca. It was diagnosed and I was advised it is under warranty HOWEVER parts are on back order. Today [XXX] ~ the car still has not been repaired and I have been advised parts will not ship until September 2024. This is both dangerous and unacceptable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11579412

Incident

Dec 8, 2023

I am writing to report a series of safety concerns regarding my 2017 Chevy Volt, which have persisted despite multiple attempts to address them with the dealership. These issues pose significant risks to my safety and that of others on the road. On January 18th, 2024, I brought my vehicle to the Provo Utah Chevrolet dealer after experiencing reduced propulsion power while driving on the highway, coupled with the illumination of the check engine light. The mechanic performed a quick inspection and used a GM scan tool to diagnose the issue, revealing the code P1E00 for the Hybrid Powertrain Control Module 2, which was cleared without a thorough investigation. I was advised to return if the issue reoccurred. Despite the reset, the problem persisted, and on February 9th, 2024, I scheduled another appointment due to my Chevy Volt's High Voltage battery charging only to 65% capacity despite indicating a full charge. However, upon arriving for the appointment at 4:00 PM, I was informed that the hybrid mechanic had left for the day, and I was asked to return on another day. Subsequently, on February 11th, 2024, the check engine light illuminated again, and on February 12th, 2024, while driving to work, I experienced a loss of propulsion power on the highway, placing my safety at risk. These ongoing issues with propulsion power and the high-voltage battery charging system are not only inconvenient but also potentially dangerous. Despite multiple visits to the dealership and attempts to diagnose and resolve the problem, it persists, indicating a systemic issue that requires immediate attention. I urge the National Highway Traffic Safety Administration (NHTSA) to investigate this matter thoroughly to ensure the safety of Chevy Volt drivers and passengers. It is imperative that General Motors addresses these issues promptly and implements appropriate measures to prevent further incidents.

NHTSA ID

11571609

Incident

Feb 13, 2024

While we were driving on the freeway, we saw a check engine light and “propulsion power is reduced” message. The car began driving very roughly and we had to slow down. We had this happen once before where the car engine stopped working entirely while driving at city speeds after seeing this error earlier in the summer, so we pulled over as soon as we could. We were traveling in a remote area at the time, just before the holidays, and it was fairly cold out. The car dealer inspected the car and told us it was unsafe to drive, that we could not take it back until it was fixed, and that it was an EGR valve problem. We previously had this fixed under warranty as well for similar behavior, and the car is barely five years old with very few miles on it. It’s our only car and we have been waiting on the part for weeks now, with no response on when we’ll be able to have our car back, and no rental car that we can drive in the meantime to get to our jobs and get groceries. The part is covered under our warranty. Both times this has happened to us, we were actively driving. In the city, it was very unsafe for the engine to unexpectedly stop as we were driving because of the amount of traffic and pedestrians, and because it meant we didn’t have full control of the vehicle. On the freeway, it was very unsafe because of the speed we were going on the freeway. Knowing that our engine was at high risk of unexpectedly stopping working while driving on the freeway from the past experience in the city made it difficult to safely concentrate on pulling over and also maneuver in traffic.

NHTSA ID

11567891

Incident

Dec 24, 2023

The contact owns a 2017 Chevrolet Volt. The contact stated that while driving approximately 65 MPH, the vehicle suddenly lost power and decelerated to 35 MPH. During the failure, the message "Reduced Power" was displayed. After turning off and restarting the vehicle, the failure remained, and the vehicle was driven to the residence at a reduced speed. The cause of the failure was not yet determined. The manufacturer and local dealer were contacted. The failure mileage was 26,000.

NHTSA ID

11561080

Incident

Dec 18, 2023

Mileage

26,000 mi

Consistent BCEM failure with volt. Power Reduced even if battery has full charge and gas is in tank. Forward Collision made unavailable without reason whilst driving. I rely on the forward collision system while driving at night in my area because of drivers cutting each other off constantly, so losing this feature without knowing why it failed feels unsafe to me. Forward collision would also activate when no vehicle is infront of me causing the car to suddenly stop and jerk on the road. Propulsion power is reduced is an extremely common occurrence in my volt. It happens randomly while driving and even while charging. When I'm on the highway the car would slow down when the warning came on; even with cars right behind me. I'm scared one day the car's system will cause an accident because of it's unpredictability. Regular maintenance has been performed and no issues have been found. The problem continues to persist.

NHTSA ID

11560582

Incident

Dec 17, 2023

On 3/11/2023, I was heading home when my vehicle lost power in the middle of the freeway. Luckily, I was able to safely pull over to the side of the freeway. Since this is a plug-in hybrid, there are two gauges showing how much electric and gas is in the car. When I checked, both showed were empty; however, although I knew that I did not have much electricity in the battery, I had nearly a full tank of gas. The vehicle should have had automatically switched over to the gas but did not. After a few minutes of leaving the car off, I was able to restart the vehicle in gas mode and drive home safely. I brought in the vehicle to my local Chevy dealership to have it diagnosed. It was determine that the computer had registerd multiple faults p0030, 31, 54, 135, 403, 405, 443, 458 and 537. They also found TSB 21-NA-116. They had found that the 15 AMP fuse was blown. They had to replace the EGR valve assembly. Total time was 2 weeks to repair as they had to wait for the parts from Chevy. Per WO, parts 12346290 (Coolant) and 12691147 (Valve) were replaced. After replacement, vehicle have been running fine for the past 9 months. Prior to the engine shutting off, there was a message on the screen while driving which says "Propulsion Power is Reduced". The electric gauge was empty but the gas tank show nearly a full tank.

NHTSA ID

11560268

Incident

Mar 11, 2023

On 2 separate time periods, "propulsion power reduced" message appears on dash: - 1st incident in November 2022, car would not move after powering off the vehicle. After sitting idle for a week, decided to retry, and car seemed to work normally. Took it in to Chevy service, they replaced the BECM. Car worked fine after this - 2nd incident in November 2023, again 'propulsion power reduced' message appeared. This time, however, car would suddenly cut off gas engine (even at highway speed), switching to 100% battery mode, and displaying 'Engine not available' on dashboard. Fuel level indicator would immediately display 'LOW' (even though gas tank was full). Reduced acceleration on battery mode. Car is now in same service center awaiting fix for the past month. Was quite an unsafe situation, especially at highway speeds, and especially given the fact that the battery also may have been at a low state of charge, risking complete vehicle breakdown. Coupled with both of these incidents, the cruise control intermittently shuts off, displaying 'Cruise control unavailable'. Car is lightly utilized, with just over 30k miles on the odometer to date. Additionally, the car is kept in a mild climate (coastal southern california) and parked in a covered spot shielded from sun and temperature extremes.

NHTSA ID

11559140

Incident

Nov 1, 2023

This vehicle has a very dangerous malfunction. There was no power when I tried to move out of the way of an out-of-control semi truck while driving on the highway by pressing the pedal. I made every effort to maneuver because I was terrified. But because of the power outage, I could have died. This is really worrying, and I hope you can address the issue raised by Chevy so that someone else might be spared and so that future generations of electric cars are constructed to a standard that includes safety. Thank you.

NHTSA ID

11558883

Incident

Nov 15, 2023

While driving after the electric battery is used and switches over to gas, I have been getting the check engine, ABS, steering, parking, and brake lights. I have lost power steering, lost the speedometer, lost fuel range, lost stabilitrak, it has randomly turned on the emergency brake while all these other things are happening, It also has said “shift to park”, propulsion power reduced. I have taken it to the dealer and they read some of the codes but say they can’t find anything wrong and they need to be able to reproduce the problem to find it. I lost all propulsion and pulled over and turned it off and it stopped with a “clunk.” Then I turn it back on and just the check engine light is on. I’m very afraid to drive it but with the lack of vehicles available to buy and the dealer not knowing how to fix it I don’t know what to do.

NHTSA ID

11549089

Incident

Oct 2, 2023

Several times since I purchased the car in Jan 2022, the left and/or right front brakes have dragged without brake pedal actuation while I was driving in surface street traffic, typically with speed limits of 25 to 35 mph. This has resulted in overheating of the brake caliper, rotor, and wheel. Typically the car can be driven again without issue after two hours of cool-off time. This phenomenon has occurred during both battery/electric and gasoline engine operation of the plug-in hybrid car. There are no instrument indications of a brake malfunction when it happens. It first becomes perceptible as a pulsation through the steering wheel and requires increased throttle pedal pressure to maintain speed. I brought the car to my local Chevrolet dealer after the first two of these incidents. Their first recommendation was a new set of tires to remove the influence of one mismatched tire. The new tires did not resolve the issue, and the dealer has not performed any other corrective action beyond a recommendation to replace calipers and rotors. Due to the intermittent nature of the failure and the fact that it affects both of the front brakes, I believe this is an ABS system issue and not a caliper/rotor issue, and I have not replaced those parts yet. The car's adaptive cruise control does not work properly. It almost always fails to set and shows "Adaptive Cruise Temporarily Unavailable" regardless of road conditions. This condition is intermittent and is not reproducible on demand. This condition is dangerous because it overheats the brake, wheel, and steering components. The heat may have damaged the wheel bearing, steering components, and CV joints. The heat also creates a risk of sudden wheel and/or tire failure while driving. The unexpected application of the brakes affects vehicle response to throttle and steering inputs, and has the potential to reduce driver control of the vehicle.

NHTSA ID

11516497

Incident

Jul 29, 2022

After the battery runs out, the engine loses propulsion and fails to run on gas. The car completely stalls in the middle of traffic. The speed drops from 70+ mph to 0. Extremely dangerous to myself and others. The issue suddenly appeared at the end of December 2022 during a long drive. The engine check light remains on and a warning re: reduced propulsion power is displayed every time the car is turned on. Dealer is unable to fix the issue because they already have multiple cars with the same issue waiting for weeks to be repaired. Recently filed class action law suit suggests that this problem is caused by defective BCEM unit.

NHTSA ID

11507401

Incident

Dec 26, 2022

Late 2021 I noticed a strange noise and a slight stutter in my breaks that would only happen at the end of the breaking motion just before the car would completely stop. The sound and stutter, felt as though a clutch was trying to engaged. I scheduled a service appointment in January to have my tire replaced and car checked. The stabilitrack light came on while I was on vacation and also asked the dealership to check the stabilitrack. The dealership replaced my tires and inspected my car, but found nothing wrong with it. The tested the car and it appeared to be working just fine. I drove around another couple months with no incident. And then the notice and stutter came back, however it was intermittent. The stutter and noise slowly got worse and worse, but stilled continued to be an intermittent issue. On August 1st, while driving to work, my breaks completely failed and I almost got into an accident. I was pulling away from a red that just turned green. There was a red light ahead, I barely got up to 30-35mph before I started cruising towards the light. Started to press down on the breaks to stop and the pedal went straight to the floorboard with resistance and the breaks did not engage. I pumped the breaks frantically several times, with no change and quickly swerved and made a last minute right turn to avoid traffic. I continued to pump the breaks until it eventually did engage. I took the car to the dealership to have it serviced and inspected again, and was told it was the master cylinder that had failed. After it got replaced it was about another 2 weeks before I started to experience a similar issue again.

NHTSA ID

11480635

Incident

Aug 1, 2022