2018 Chevrolet Volt Fuel system Problems

While driving on a highway the car started to hesitate, a message appeared on the console "Propulsion power is reduced" and the engine light turn on. After driving some miles, a new message appeared: "Engine unavailable, service soon" and the car only ran on electric power, no motor engine. I had the same problem 3 year ago and the dealer identified the problem as a shorted EGR valve. This time I knew this shorted EGR valve burns the F3 fuse. I managed to get to a car part shop and bough several fuses (15 amp). After replacing the fuse 3 times I managed to get to the dealer. The repairs cost $3000+ (up from $1000+ 3 years ago). This problem is well documented on the GM service technical bulletin "21-NA-116" dated February, 2023. Three years ago I was in the middle of nowhere in South Texas and it took 6 hours to get a tow truck This time I was lucky enough to be close to to a town that the remain battery power was enough to get to the store where I bought the fuses. GM should recall this part and do a proper fix

NHTSA ID

11755062

Incident

Aug 2, 2026

The Vehicle had a the BECM fail at 64,000 miles. This is a known issue that GM still refuses to recall, and is refusing to warranty

NHTSA ID

11754026

Incident

Jul 27, 2026

I was investigating a thumping sound coming from the vehicle when going over bumps. I discovered that the left fuel tank strap had completely broke into two pieces and was no longer holding up the tank. The fuel tank straps are not readily viewed on the vehicle until you lower/remove the underbody aerodynamic material. It appears that the underbody aerodynamic material may have been contributory by retaining dirt and trapping moisture in contact with the tank straps. The failed tank strap parts are available for inspection. No other indication of the failed tank strap other than the minor noise and no other inspections have been performed on the failed component.

NHTSA ID

11753393

Incident

Jul 11, 2026

The Battery Energy Control Module (BECM) failed. Before repair, the check-engine light appeared intermittently, the vehicle sometimes had difficulty starting, and the indicated electric range could suddenly drop from about 30 miles to zero despite a charged high-voltage battery. When this occurred, the gasoline engine started unexpectedly. The air conditioning also intermittently blew warm air until the vehicle was restarted. These symptoms created a safety concern because propulsion mode and indicated range could change without warning, and the vehicle could fail to start in traffic or another unsafe location. An authorized Chevrolet dealer confirmed the problem. The dealer retrieved DTCs U2624 and U2629, performed circuit testing, and diagnosed an internal short in the BECM causing loss of communication with high-voltage battery modules. The dealer stated this failure caused the warning light, starting issue, sudden loss of indicated battery range, and air-conditioning symptoms. The BECM was replaced and programmed after removal of the high-voltage battery assembly. The warning light first appeared about one month before repair, with the other symptoms becoming more apparent in early July 2026. The vehicle had approximately 80,918 miles when inspected. The failed component was retained by the dealership as a core and is not available to me for inspection. To my knowledge, the vehicle was not separately inspected by police, insurance, or GM engineering personnel. My vehicle was excluded from GM Special Coverage N232432680 even though it is a 2018 Chevrolet Volt with the same confirmed BECM failure addressed by that program and NHTSA investigation PE23022. I paid $3,970.56 for the repair. I am filing this complaint because this defect can cause no-start, loss of indicated battery range, warning lights, unexpected propulsion changes, and potentially reduced propulsion, while some affected 2016–2018 vehicles appear excluded from the special coverage.

NHTSA ID

11752752

Incident

Jul 13, 2026

The car suddenly lost power and produced error messages on the screen. I had to quickly change lanes to get out of traffic on the highway. My dealer diagnosed the issue as a BECM malfunction and quoted a repair cost of approximately $3500. However, due to my car originally being registered in California, this failure is not covered under GM Special Coverage Bulletin N232432680 (issued March 2024), which provides an extended warranty for BECM issues on affected 2016-2018 Volts up to 15 years or 150,000 miles. My VIN does not qualify for this coverage despite the vehicle being within the model years affected by known BECM soldering/connection failures. This appears to be part of a broader pattern of BECM defects in 2016-2019 Volts that can lead to sudden loss of propulsion, as previously investigated by NHTSA. GM should extend coverage or issue a recall for all affected vehicles, as this defect compromises vehicle safety and leaves owners with expensive out-of-pocket repairs for a known issue.

NHTSA ID

11748652

Incident

Apr 20, 2026

I was driving my 2018 Chevy Volt at about 30 mph on EV mode. The battery was at 50%, the car was performing normally. Then the battery jumped to 100%, the check engine light came on, and the vehicle lost power. I was in rush hour traffic and unable to get the vehicle to go faster than 5-10 mph. I switched to "normal" mode to engage the gasoline engine, hoping this would help but it did not. The gas engine RPM fluctuated wildly and did not restore the ability to accelerate the vehicle. I was still unable to go faster than 5-10 mph. I was a few blocks from home and managed to get home safely. The engine code was P1E00. I put the vehicle on the charger and it seemed fine the next day. This exact situation I ran into - reduced engine power - is addressed in Special Coverage N232432680, which includes this vehicles VIN. I took the car to the GM dealer today and they are telling me that the car is fine, they can find no problems. I mentioned that this issue is covered under Special Coverage N232432680, and was told that unless they can reproduce the issue in the shop, that they cannot apply Special Coverage N232432680.

NHTSA ID

11735155

Incident

Apr 29, 2026

The vehicle losses power on high speed, check engine comes on, low propulsion massage displays. Vehicle does not charge. Issues similar to the investigation DCS6812.

NHTSA ID

11726565

Incident

Jan 11, 2026

It was the XXX recall for the DTC P0442/check engine light code. The dealership said that the recall had been satisfied in 6/2020 by putting a buffer in to separate the 2 lines but not replacing the part. Now the exact same code DTC P0442/check engine light in the exact spot that occurred for the original recall. The dealership originally quoted $5,093, then after me complaining that it is the same recalled problem they dropped the cots to $2384. I believe that is an agreement that the manufacturer should cover this. Of course I will have to pay to get my car but I would like the manufacturer to reimburse me for it seeing it was a manufacturer default. I spoke to the manufacturer they flat out refused to cover it. I obviously disagree. Would like you to pressure them to change their decision. Thank you, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11716611

Incident

Feb 2, 2026

On June 27, 2025, while driving, the vehicle displayed a "Propulsion Power Reduced" warning message and a Check Engine Light illuminated. I immediately experienced a loss of power. I brought the vehicle to an authorized Chevrolet dealer the same day. On July 1, 2025, the dealer diagnosed the failure as a faulty Battery Energy Control Module (BECM) and high-voltage system fault (Code P1E00), requiring a full replacement of the high-voltage battery pack (Part #24296900). The manufacturer (GM) was contacted, and the replacement battery was ordered on July 2, 2025. As of December 2025, the vehicle remains in dealer possession (over 5 months) with no repair completed. The manufacturer has stated the part is on indefinite backorder with no ETA. The failure of this component renders the vehicle inoperable and presents a safety risk due to sudden loss of propulsion power while in motion. The manufacturer has confirmed the failure but is unable to provide a remedy within a reasonable timeframe.

NHTSA ID

11704006

Incident

Jun 27, 2025

Why in operation the car goes into Shift to Park and Also getting a Propulsion Power Reduce

NHTSA ID

11699315

Incident

Jul 24, 2023

Component: Battery Energy Control Module, available from dealership ATM Daughter's safety compromised when vehicle power decreased quickly to 5mph in the middle of fast heavy city traffic. The problem has been confirmed by Chevrolet dealership service department The vehicle has not been inspected by other than dealership service center. I contacted GM, and was told that the component was replaced once already in 2021, so they will not replace it a second time on special coverage N232432680 released March 6, 2024. Warnings:Propulsion 11/3/25 Power Reduced and check engine light on 11/3/25. GM dealer service center cleared codes, did a software update 11/7/25: Propulsion Power Reduced and check engine light again. Vehicle is at GM dealer service center.

NHTSA ID

11699163

Incident

Nov 7, 2025

Chevy had done an update for the Propulsion Power being reduced. In 2024, I had to do another update when the check engine light came on. After that the electric battery power decreased, I am only getting 17 miles per charge. August 2025, the check engine light came on again. I had it check and no codes came up. While driving home on the freeway, the Propulsion Power being reduced warning came up. I had to pull off the freeway. Once I turned my vehicle off, I was unable to drive my car. There was not any acceleration. I had to have my car towed 50 miles home. A mechanic was able to repair it at that time. On 10/7/2025 the check engine light came on again and once again no codes appeared, on 10/14/25 the Propulsion Power being reduced warning came on again. I was able to get home safely, but I got off the freeway and took side streets home. At this time, the vehicle will not accelerate.

NHTSA ID

11693560

Incident

Oct 14, 2025

The car can't decide if it wants to use the battery or the engine. It shows zero charge even though it is full. It lurches at stop lights as it tries to decide whether to use battery or engine. It says "propulsion power reduced". "Not able to charge". "Shift to park". Check engine light is on.

NHTSA ID

11693450

Incident

Sep 26, 2025

In 2020, GM issued a recall (#N192273600) for emissions pipes on the Chevy Volt that could be compromised by rubbing against the A/C hose connector. I took my vehicle to my local dealership (Chesrown Chevrolet) to have this issue remedied, that same year. This year, my check engine light came on and this same dealership informed me that the cause was this same issue (i.e. a compromised emissions pipe due to rubbing against the A/C/ hose connector). Assuming the fix was conducted per GM's specs, GM did not provide an adequate fix for their faulty design.

NHTSA ID

11687927

Incident

Sep 1, 2025

Electrically actuated EGR valve fails, it draws too much current and blows the F03 fuse (Labeled “No Walk Home”) which has 4 other components on it, this causes “Reduced propulsion” message, soon after the engine overheats due to one or more of the 3 other components that lost power, and the “Engine not available” message appears and the vehicle loses all motive power. This syndrome is well documented in the GM-Volt online forum. Additionally this vehicle has portions of the EV battery that failed, I am still waiting for battery parts to arrive and its been 4 months, many owners have waited between 1 and 2 years for the battery to be fixed, this contributed to this issue as the electric propulsion would have possibly been available if the warrantied battery was repaired within a reasonable timeframe. I was refused a service loaner. My recent contact with Chevrolet customer service suggested I rent a car, and they will reimburse $45 per day, however they insist I pay for it and when the repair is complete, they will reimburse me. There is a gentleman on the Volt forum who has laid out about $5,000 on rental cars for well over a year, and is finally reluctantly getting a buyback, but they depreciated the car but did separately make good on the rental reimbursement. Neither he nor I really want that result, we want the car repaired in a good faith effort, instead both battery parts and EGR valves are in short supply. Currently the GM part is between $1400 and $2500 when in 2024 the same part was widely available for $240. I understand this is a bit rambling, but the context matters, and GM is dragging their feet on servicing the warranty liability they have. My TZEV warranty is good until 2034 and they are actively trying to kill my car off to save the ongoing cost of servicing this warranty. They are also putting owners at risk. Please consider a battery recall and an EGR valve recall. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11683029

Incident

Aug 16, 2025

On [XXX], our 2018 Chevy Volt experienced a critical BECM (Battery Energy Control Module) failure while being driven by our [XXX] daughter. The failure caused the vehicle to enter limp mode, resulting in a severe loss of power and the inability to shift properly. Most alarmingly, the brakes failed to function correctly—despite being fully engaged, the car continued to move forward at a red light, placing our daughter in immediate danger. She was only able to safely stop the vehicle by maneuvering it off the road into a parking lot. This BECM defect is a well-documented issue for Chevy Volts from 2016 to 2018. However, Chevrolet has refused to cover our VIN under the existing special service bulletin, despite our vehicle using the same faulty part number as those included in the recall, and has provided no explanation for this exclusion. As a result, we are being forced to pay $2,100 out of pocket to replace a part that GM knows is defective. This is an unacceptable financial burden for a safety-critical issue. GM should immediately issue a recall for all vehicles equipped with this faulty part number to ensure the safety of all drivers and prevent further undue costs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11678250

Incident

Aug 1, 2025

On May 26, the car was running in electric mode and switched to gas because the power batteries were depleted. Shortly after switching to gas mode, lights came on the dash board saying Engine Not Available Get Service Immediately. I was on a highway at the time and fortunately had just enough left to get off and the car would not move any further. Turning the car on and off did not resolve the problem. It had to be towed to a Chevy dealer. Even after an hour, the messages would come on when trying to start the car. The next day, the dealer called and said they could find no problems with the car and it works fine. This happened once before, but that time there was enough charge in the battery to get home and then later it would start without the message.

NHTSA ID

11663118

Incident

May 26, 2025

BECM module is failing producing a reduced propulsion message. This is happening while driving which is a safety issue. Limiting the ability to drive, handle and brake with the vehicle.

NHTSA ID

11661821

Incident

May 16, 2025

Vehicle produced error without any warning about propulsion system no longer working shortly after low fuel warning when tank is fuel and engine fails and vehicles comes to a crawl.

NHTSA ID

11652969

Incident

Apr 5, 2025

Issue Summary: The Chevy Volt has experienced recurring electrical problems, including the "Shift to Park" message, loss of power, and dead 12V battery. The vehicle had to be towed to the dealership three times due to these issues. One incident involved a power loss while driving at 65 mph, which caused a near-miss with a semi-truck, posing a significant safety risk. Warranty Status: The additional warranty was purchased, but only one of the three incidents occurred while the vehicle was under warranty. Safety Concerns: The repeated electrical failures, especially while driving at high speeds, raise serious safety concerns

NHTSA ID

11652364

Incident

Jan 1, 2025

EGR valve failure at highway speed of 70mpg on busy road with passenger and service dog in vehicle on a road trip (on ICE not electric). This produces a reduced propulsion in the vehicle and it becomes unsafe to drive. The EGR failure blew the 15A #3 fuse known as the "no walk home" fuse, so I needed to be towed to a parts store then unplug the EGR valve to make it somewhere safe. It was a Sunday, so every dealership (in the VA area at least) was closed. It is a well known/documented issue and the warranties have been extended, but only in a few states with the CARB protections. There are no warnings, if I was not an adept driver, we could all be dead. I also became stranded ~six hours from my home and only ~eight thousand miles outside of warranty. The replacement part costs ~$1800 without labor - the most expensive EGR valve the 60yr old parts employee at the dealership had ever seen, on a hybrid car which doesn't even truly require the part to operate or to pass emissions in some states. I think GM will help me with a goodwill repair in this case, as I have been a loyal Chevy customer my entire life and Volt owner since 2013 - but that is not the norm, so please take action and extend warranty protection to all Volt owners like the BECM issue.

NHTSA ID

11651999

Incident

Mar 30, 2025

Yesterday, my daughter was driving on [XXX] in Seattle traveling around 65mph when the vehicle lost power and reported the error of "shift to park", "Propulsion reduced" and "StabiliTrak failure". Luckily, she coasted to an off-ramp and safely put the vehicle in park. Thankfully she was not involved in an accident, but was very shaken by the experience. After doing some research it seems that the Chevy Volt has a known issue with the BECM and GM has failed to issue a recall, putting thousands of lives at risk. After turning the vehicle on and off several times, she was able to get it started and with minimal propulsion on residential streets was able to return to our house. this morning I dropped the vehicle at our local GM dealer for diagnosis and repair, but wanted to file a report, to hopefully prevent this from happening to another unsuspecting driver/child. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11642763

Incident

Feb 13, 2025

The contact owns a 2018 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the EVAP pipe was rubbing against the air conditioning hose connector. The dealer informed the contact that the vehicle was previously repaired under GM Campaign Number: N192273600; however, the failure persisted. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 84,800.

NHTSA ID

11642577

Incident

Jan 15, 2025

Mileage

84,800 mi

Randomly getting Propulsion power is reduced and loss power while driving. Been force to pull over to the side on the freeway to restart the car.

NHTSA ID

11641591

Incident

Apr 6, 2023

The BECM (Battery Electric Control Module) failed in November of 2023. Mountain Chevrolet has had my vehicle since then, claiming to be unable to find replacement battery module. The vehicle is available for inspection at Mountain Chevrolet (it has been left unlocked, unprotected, and exposed to the elements for almost 15 months now). When the BECM failed, the vehicle lost virtually all power and slowed dramatically from highway speeds to ~20 mph. There were no warnings prior to the failure.

NHTSA ID

11637803

Incident

Nov 1, 2023