Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Electrical reportsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
11
Latest Apr 21, 2025
Share of all reportsThis category as a share of every owner report on file for this model year. One report can name more than one component, so the categories overlap.
32%
of 34 total
Crash or fire reportedReports in this category whose submitter recorded that a crash or a fire occurred. The reporter's own answer on the NHTSA form, not a verified finding.
2
Injuries or deaths reportedTotals the submitters entered on their own reports in this category. Not verified by NHTSA and not a casualty statistic.
1
What this page shows
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 2019 Chevrolet Volt submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 11 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Owner reports naming electrical
Shown in the owner’s own words, exactly as filed
Electrical
Filed Apr 21, 2025
The contact owns a 2019 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the battery high-voltage disconnect relay. The vehicle was not repaired due to a lack of part availability. The manufacturer was notified of the failure, a case was opened, and the manufacturer confirmed that the part was on backorder. The failure mileage was 80,000.
NHTSA ID
11655912
Incident
Apr 21, 2025
Mileage
80,000 mi
ElectricalEnginePowertrain (other)
Filed Jun 5, 2024
Mileage: 38523 Engine Not Available Service Soon Propulsion Power Is Reduced Fuel Range Low: 3/4 Tank full of gas [XXX] - I was driving Northbound on [XXX] South of Castlewood in Northern California. I was driving 70 mph when I suddenly received the error messages above on my dashboard screen. The vehicle immediately had power from 70 mph quickly going below 59 mph. The traffic was extremely high and I had to quickly use my hazard flashes and carefully maneuver to the right shoulder of the frwy. The vehicle lost power so quickly I could have easily been rear ended or in a serious vehicle accident. The dealer test drove the vehicle and stated they received the errors at 95 mph. The dealership is recommending I have the entire transmission replaced with the assembly and the 45,000 mile maintenance. No other warning lamps, messages or symptoms or failures occurred. First occurrence [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ID
11592645
Incident
Jun 1, 2024
ElectricalFuel systemPowertrain (other)
Filed Dec 2, 2023
Crash reported
Vehicle lost propulsion and all power mid turn at approximately 45mph. Powe steering and assisted brakes were gone. Conditions were rainy, resulting in single car crash. Car did not restart. No codes present. Occurred again after repairs at 70mph on highway. Codes P0AC4 and P0C0E indicating Drive Motor Power Inverter B. Despite being under warranty, GM cannot repair, and has no replacement parts. GM has ignored messages requesting buyback per federal law.
NHTSA ID
11558106
Incident
Sep 23, 2023
Electrical
Filed Sep 15, 2023
Vehicle has developed an intermittent issue when placed in park. Displays a message "Attention Needed: Shift to Park" accompanied by audio alerts inside and outside of the vehicle. This is obviously unsafe as the vehicle cannot be parked and turned off reliably. GM Technical Bulletin 19-NA-206 issued in May 2021 (attached) specifically states that that this repair is covered for the Volt by the separate Voltec Component Warranty. GM refuses to honor the warranty.
NHTSA ID
11544689
Incident
Sep 15, 2023
Electrical
Filed Oct 1, 2022
Car just stops when the battery control module stops working. Potential to leave us stranded in traffic. Confirmed as a defective part by the dealer.
NHTSA ID
11487388
Incident
Aug 9, 2022
Electrical
Filed Jun 14, 2022
1. Intermittent instruction to put vehicle in PARK when trying to start or shut down when in PARK already. 2. Intermittent NO REMOTE DETECTED when remote is in the car
NHTSA ID
11469129
Incident
Jun 14, 2022
BrakesElectrical
Filed May 16, 2022
Crash reported1 injury reported
Was approaching an intersection with a stoplight that was red. Another car stopped at light. Applied brakes, but car slowed down only slightly, no matter how hard the brake pedal was applied. It was like braking on black ice, even though the cars wheels were still going around. Rear ended the car at the light. Suspect that computer was telling the car to try to charge the battery using the forward motion of the car instead of stopping the car. All air bags deployed. Injuries were limited to bruises, abrasions, and general body soreness. Vehicle currently in possession of Allstate Ins. Have requested that brake system be inspected, and computer info be downloaded. Car was totaled. No injuries in other vehicle. No previous problems, no warning lamps or messages prior to accident. Car had been well maintained, including all recalls, and received routine maintenance (oil change, tire rotation) about three months before the incident. Problem has not been reproduced, nor is it likely to be since the vehicle is undrivable.
NHTSA ID
11464877
Incident
May 9, 2022
Electrical
Filed Apr 23, 2022
Car does not shift into park without multiple tries. I can’t turn off car if it’s not on park
NHTSA ID
11461871
Incident
Mar 1, 2022
Electrical
Filed Mar 15, 2022
2019 Volt - Shift to Park issue My 2019 Chevy Volt is having an issue when shifted to Park from Drive and all shift stick positions. If you shift to park to turn off engine you get a message on console that says "SHIFT TO PARK). You have repeatedly turn off/on engine/system to message to clear so you can leave vehicle off. System will not shut off until car reads that car is park. Something (sensor?) is not telling system that car is in Park.
NHTSA ID
11456829
Incident
Feb 15, 2022
ElectricalEngine
Filed Apr 21, 2021
'SHIFT TO PARK' ISSUE. AFTER POWERING OFF CAR I GET AN ALERT ON DASHBOARD THAT LOOKS LIKE THIS 'SEE IMAGE'. THIS HAPPENS EVEN THOUGH THE VEHICLE IS SET TO PARK. VEHICLE WILL NOT TURN OFF UNTIL JIGGLING THE SHIFT HANDLE OR TURNING ON CAR AND RE SETTING SHIFT HANDLE TO PARK. RECURRING ISSUE.
NHTSA ID
11413280
Incident
Apr 21, 2021
Mileage
40,000 mi
ElectricalPowertrain (other)
Filed Dec 17, 2020
HAD SHIFT TO PARK APPEAR AND CAR WOULD NOT SHUT OFF. IF YOU PLAY WITH IT IT MIGHT SHUT OFF BUT WILL NOT ALLOW IT TO RESTART. GM IS AWARE OF THIS AND HAS PUT MULTIPLE TSB'S OUT TO FIX IT AND NOW THEY HAVE A NEW ONE. IT AFFECTS ALL GEN 2 VOLTS AND OTHER MODELS. IT CAN STRAND YOU IF IT HAPPENS. THIS SHOULD BE A RECALL NO ONE WANTS TO BE STRANDED IN THE DARK ANYWHERE.
NHTSA ID
11383858
Incident
Nov 10, 2020
Mileage
5,200 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Other components reported on this vehicle
Categories with enough reports to have a page of their own