RoadVitals

2005 Chevrolet W4500 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jul 14, 2011
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Chevrolet W4500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Powertrain (other)150.0%
  • Visibility150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

1
report

From owner reports, verbatim

DT: WHILE DRIVING AND WITHOUT WARNING THE TRUCK SHOOK. DEALER SAID THEY FIXED IT ABOUT 5 TIMES, BUT CALLER INSISTED IT WAS NOT FIXED. MANUFACTURER HAS NOT CALLED CALLER BACK YET. *AK

NHTSA ID 10125672 · filed Jun 17, 2005

Too few reports in this category for a page of its own — they appear in the full complaint list.

Visibility

Reports naming windshields, glass, wipers, defrosters and mirrors.

1
report

From owner reports, verbatim

TL* THE CONTACT OWNS A 2005 CHEVROLET W4500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH WITH THE HEATER IN OPERATION, HE BEGAN TO SMELL A BURNING ODOR AND NOTICED SMOKE EMITTING FROM THE DASHBOARD AND AIR VENTS. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT WAS UNABLE TO DETECT A PROBLEM UNDERNEATH THE HOOD AREA AND RESUMED DRIVING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THEY STATED THAT THERE WAS A SHORTAGE WITHIN THE AIR CONDITIONERS BLOWER MOTOR AND THE AIR CONDITIONER/HEATER RESISTOR AND CONNECTOR WERE MELTED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 177,000. UPDATED 08/31/2011 *LN

NHTSA ID 10412244 · filed Jul 14, 2011

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .