2006 Chrysler 300C Owner Complaints

Completed x53 extended warranty a year prior at dealership, car still stalls only after putting fuel even though always filling to 3/4-7/8 of tank. Had my children with me Car stalled again today at middle of busy street when about to make a left turn after i filled to 3/4 of a tank. Had dodge dealer in Manteca, CA diagnose after first stall half a year prior and they would not replace faulty new tank. Still had to pay diagnostic fee saying fuel liquid was getting into vapor lines and flooding engine and that new tank is not the issue even though it is allowing fuel liquid to pass through vent valve which caused saturation of vapor canister and purge solenoid and engine stalling. Car only stalls when pumping gas 3/4 tank or above

NHTSA ID

11721320

Incident

Mar 1, 2026

Car will buck/jerk at higher speeds, will also die at low speeds or idle, will fall on its face when trying full throttle, the oil light, check engine light, Limp mode will flash sometimes traction control, esp will flash most the time the 2 lights stay on Problem has been confirmed by 2 dealers. Puts my saftry at risk because engine will js die at 20mph i lose brakes and steering. Problem first appeared about the beginning of this year when my camshaft went out but wasn't showing a code for a month and a half then gave me a code since then ive had this problem Vehicle has not been inspected

NHTSA ID

11684888

Incident

Jan 1, 2025

The contact owns a 2006 Chrysler 300C. The contact received notifications of NHTSA Campaign Numbers: 15V313000 (AIR BAGS) and 16V352000 (AIR BAGS); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11670803

Incident

Jul 2, 2025

After Fueling on several occasions the vehicle just abruptly stalls out and it's very dangerous I notice that there is recalls on other 2006 Chrysler but mine isn't on there but I am very concerned about this as it could cause me to get in a accident

NHTSA ID

11666755

Incident

Jun 13, 2025

car stalled after filling gas tank. I was driving through an intersection and had to stop for oncoming traffic, when the car stalled and would not immediately restart, it eventually did start after several panic moments of being stuck in the intersection while the light was changing to let opposite traffic proceed. It stalled 2 more times on the way home. Both times I was slowing the car down when this occurred. I have been fearful of driving this car again since this happened. I heard there was a recall from Chrysler for lifetime replacement of gas tank due to a possible control valve shutoff float failure. My vehicle has never had the gas tank or float replaced, but it does not show up for a recall when I enter VIN. What should I do?

NHTSA ID

11656550

Incident

Apr 14, 2025

There a problem with car stalling and dying because of power being lost to tcm because of tipm. Dealer had my car for 7 weeks and $1900 changing tcm and problems still exist. Didn't even make 10 miles from dealership. Very dangerous

NHTSA ID

11644961

Incident

Feb 26, 2025

gasket around fuel pump failed allowing gas to pool on top of fuel tank under the back seat on passenger side . this resulted in a strong "gas/fuel" smell from fuel vapors colecting inside the car and the obvious risk of ignition/explosion and negative health effects of breathing said fumes .the vehicle has not been inspected yet because we are afraid to start the vehicle let alone drive it to the shop . We are making araingements to have it towed to the repair shop . we have not had any warning lights . Mechanic said it was a common problem with seal failure around fuel pump . the vehicle has 127,000 miles

NHTSA ID

11634454

Incident

Jan 6, 2025

There is a fuel leak coming from the rear right side near the right rear wheel. Fuel leaks when the tank is full.

NHTSA ID

11577223

Incident

Mar 13, 2024

While I was driving the car, the car stalled on me at a stop light, its a safety risk and could caused an accident at anytime, yes its available for inspection. Yes the problem has been reported and inspected by auto shop and dealership. No warning lights it just randomly happened while driving, while I was driving the check engine light popped up then disappeared and 2mintues later my car power was reduced and car shutoff at stoplight.

NHTSA ID

11563081

Incident

Dec 15, 2023

The contact owns a 2006 Chrysler 300C. The contact stated that the fuel tank was previously replaced under an unknown extended warranty coverage; however, after the repair, the vehicle experienced a failure. The contact stated that after refueling the vehicle and driving at slow speeds, the vehicle stalled. The contact stated that the failure recurred several times while driving and coming to a complete stop. The vehicle was towed each time the failure occurred. The contact stated that the vehicle stalled in the middle of the road during the last failure. The contact was able to push the vehicle to the side of the road with assistance. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed and test-driven, but the cause of the failure could not be determined. The vehicle was not repaired. The failure mileage was approximately 214,624.

NHTSA ID

11562356

Incident

Dec 7, 2023

Mileage

214,624 mi

When car is cranked and put in gear or stop car will go dead. When driving if I ease off gas and then reapply the gas car will stall which can be quite hazardous while driving. The problem was intermittent has been going since I have had the car thought the tank recall would fix the problem which it we thought had corrected the problem for a time. But it became intermittent at first it was every few weeks and now it does it whenever I drive the car several times as I drive recently I am now afraid to try and drive it especially any distance. The gas tank was replaced due to a recall. Have replaced fuel tank and thermostat. My mechanic isn't sure what is going on. I have seen various forums where others are having the same problems with their 2006 Chrysler 300 C's and have taken them back to the dealer and they have not been able to determine what the problem is. I feel this should be investigated.

NHTSA ID

11557094

Incident

Nov 1, 2006

Once fueled, the engine will consistently stall from start to cruising speed, and has even shut off while driving. There was an issue with Chrysler fuel tanks evap valve sticking open, which causes this fault, however I have not received any assistance from Chrysler or any authorized dealer.

NHTSA ID

11555801

Incident

Oct 30, 2023

My Fuel Tank is stuck in open position, it is making my car stall, sputter, and cut off. When my gas is very low car doesn't cut off and runs fine, but when I fill car up it stalls and cuts off, this is very dangerous it cuts off at red lights, stop signs, slow traffic, I've seen this is a Warranty/Recall problem with the faulty fuel tanks, with stuck open fuel shutoff valve. My car is running at max fuel because of this problem. It's been like this since I bought car 2 months ago. I need this fixed immediately. And all parts on my car are brand new this Faulty fuel tank is the Culprit

NHTSA ID

11552587

Incident

Oct 16, 2023

The car will just shut off while driving or at rest. My safety and other people on the road is unsafe in the vehicle because when it shuts off in the middle of the road the steering wheel is also not working. The car has been to multiple shops with each shop guessing what could be the problem and fixing what they think may be wrong and after 2,000 dollars the car is still stalling out while being drove. No lights or diagnostic test come up with anything that could cause the problem

NHTSA ID

11541636

Incident

May 1, 2023

The contact owns a 2006 Chrysler 300C. The contact stated that while driving at slow speeds during traffic congestion, the vehicle inadvertently lost motive power and stalled. Upon restarting the vehicle, the vehicle hesitated but seemed to return to normal functionality. No warning lights were illuminated. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 200,000.

NHTSA ID

11530679

Incident

Jun 15, 2023

Mileage

200,000 mi

While driving my Chrysler when I stop at a red light or stop sign the car will simply stall out and die so I put it back in park and recrank it and sometimes it'll die immediately after that and sometimes it'll wait till the next red light or until I'm making next stop. And when the car is in park it'll stall out I'll simply have to crank it right back up sometimes it'll stall out immediately after that and sometimes it'll run for a minute or two and then stall out. But as long as I got my gas my foot on the gas while I'm breaking at the same time it won't die

NHTSA ID

11517173

Incident

Apr 14, 2023

Yesterday I experienced an SUA incident and nearly lost my life. I was entering a freeway and began to accelerate my car. Suddenly I felt as if the gears kicked and the car began to accelerate on its own to max revolutions. I pressed down on the brakes to see if it would stop and there was heavy resistance. I took my foot on the break and the car began to accelerate and rev completely on its own and the engine felt as if it was going to explode. I luckily was able to jam my foot on the break and pull over to the emergency lane and eventually come to a full stop. From there I put the car in park and removed my foot from the break pedal. Again the car began to jump to full revs with the engine screaming. I turned the car off and on several times and this continued to happen. After waiting one hour I was able to start the car and drive 20 mph back to my home and I will have it towed to a repair shop shortly. If I panicked or was not strong enough to press down on the brake pedal, the car would have accelerated to full speed and I certainly would have died and likely other people would have too.

NHTSA ID

11516176

Incident

Apr 8, 2023

Fuel leaking through gas gasket under rear passenger seat near electrical components. Gas Fumes fill vehicle cabin when fuel tank is full and could be ignited by a small spark. No warnings of issue on dashboard. EXTREME DANGER!

NHTSA ID

11515706

Incident

Apr 5, 2023

Vehicle stalls when idling or coming to a stop, mainly at low RPM. No codes are thrown. Gas tank has been replaced and fuel pump is new, still stalls. There are many reports on the Chrysler 300 Forum regarding the same situation. Many people have thrown good money after bad towards parts and still there's issues. I have my car at the Moss Bros Dealership in Riverside Ca. now for 5 days to try and repair this Safety Issue! 3/28/23. Car has stalled approximately 20 times, 4 times which were on the freeway. The car will start up and run fine for several days and then it acts up. Could be a number of things, but with no codes, pretty hard to diagnose the stalling issue.

NHTSA ID

11514143

Incident

Mar 1, 2023

The first time I was on the highway and then engine just stalled out on me during rush hour traffic is was almost rear-end by a simi truck I got off the highway and get the car started and then when I was at a stop sign and I started to make my left hand turn i was about half way into my turn and it sallied out again with traffic coming from both directions and it didn't want to start thank god that the oncoming car tired off and then other was able to slow down enough to go around me as I am scared to death that I was going to be hit due to the car stalled out and left me sitting in the middle of the road our car has left me twice now at the same intersection as I was making my turn these are not the only times that it's stalled out on us I am not comfortable driving our car as with it stalling out 3 time's in a 2 day time that put my life and others in danger something needs to be done about this issue before someone gets killed due to the sudden stalling we live out in a rural area with no other transportation so we need our car and depend on it and can't afford to get a new car this is a VERY SERIOUS ISSUE THAT NEEDS TO GET ADDRESSED ASAP

NHTSA ID

11511625

Incident

Mar 9, 2023

Everytime I fill the gas tank the car stalls out several times and then stalls when deceleration and turning.

NHTSA ID

11503965

Incident

Jan 27, 2023

The car engine just stops when in idle or while driving . I have almost been rear ended several times on the highway and on the city streets. the engine just stops running and the car shuts down.The car had a recall for the tank and fuel o ring which was suppose to fix the problem but it did not brought it to the dealer again had it replaced again problem still existed . Went back to the dealer they said they could not duplicate it then i drove it it stopped and i turned around and brought it back then they duplicated it . I have been replacing parts that have nothing to do with the stalling problem. it is currently in the dealer as we speak. this problem started when i had 64000 miles on it then it progressively got worse

NHTSA ID

11500696

Incident

Sep 14, 2022

Shifter into park have to tap it all the way to the left after car is off to remove key from ignition or car stays on.

NHTSA ID

11499308

Incident

Dec 29, 2022

Car stalls out when driving. Almost was rear-ended, broadside, front ended and sideswiped too many times to note! Have new gas tank per recall. Still stalls. Dealership has witnessed stall but can't locate problem and charges me 150.00 for useless diagnostic test and still not able to find stalling problem. Dealership doesn't care. Laughed at me. Had it in shop several times. Nothing. I'm disabled and on fixed income. Dealership attempts to have me purchase new vehicle. I can't afford one! Stalls out when turning, stopped and while maintaining consistent speed. Can't fill up gas tank or stalling is worse. Can't let tank run under 1/4 full or stalling. I'm barely able to drive anywhere due to fear of stalling and getting hit. Chrysler seems to not care. I told service manager that if I or someone else is hurt or killed its their fault for not fixing or caring about owners of this car. Death and injuries are going to happen cuz this is so dangerous and horror filled! I don't know what else to do. My beautiful 300 is not safe. I am basically carless. This has been going on for almost 4 years with no resolution or kindness. I almost was hit by a gravel truck when attempting to push car out of road! IM DISABLED!!! I can't go anywhere without being afraid it will stall at anytime for no reason. Dealership has checked repeatedly and diagnosis tests and even left car at dealership for days and still no resolution. They really don't care. I once loved Chrysler and now I am full of fear and anger that Chrysler doesn't care. There is numerous complaints about the same problem. Dealership did suggest I have a full tune up at several hundreds dollars! HA! Said a tune up will not fix it and nothing showed on diagnosis a need for tune up. Car runs beautiful when not stalling! My heart is broken. What's the point of charging me 150.00 for nothing? Then laugh when car stalls as I leave dealership. Guess that's how poor people are treated.

NHTSA ID

11498987

Incident

Dec 27, 2022

The car is prone to intermittent stalling, in which the engine cuts out without warning or signs of stumbling. Often it happens at idle or when initially accelerating from idle, but has also happened several times at speed, up to 40 mph, with accompanying loss of power steering. Sometimes the engine kicks back on after a momentary loss of RPMs, if at speed, but other times it does not. I have brought it to two Chrysler dealerships and three independent mechanics in an effort to find the problem, with various parts being replaced, including the X53 extended warranty for the 19 gallon fuel tank, but the problem persists without successful diagnosis. Only one of the independent mechanics was reportedly able to replicate the condition. Usually, the check engine light, electronic throttle control light, oil light, traction control, and electronic stability lights turn on during a stall, and sometimes the check engine light stays on. The car may several trips without a stall and then stall multiple times in one trip. It usually does not generate a code, but sometimes produces P0700 and U0100 codes. The car always starts again following a complete stall. These symptoms appear fairly widespread in 2006 Chrysler 300 vehicles, based on car owner forums. The level of fuel in the tank does not appear related.

NHTSA ID

11492107

Incident

Oct 30, 2022