1993 Chrysler Lebaron

MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.

CONTACT STATES: 1993 CHRYSLER LEBARON GASOLINE UNDER CARRIAGE OR LINE DEVELOPED A LEAK IS SUSPECTED. HAS NOT TAKEN THIS TO A DEALER OR MECHANIC. JUST NOTICED THIS YESTERDAY. CAN SMELL GAS AND SEE LEAKAGE, INFACT IT LOST A QUARTER OF A TANK WITHIN 20 MILES WHILE ON THE HIGHWAY.*AK

NHTSA ID

10119511

Incident

May 2, 2004

Mileage

170,000 mi

REAR AXLE: REAR CROSS-MEMBER: WELD SEPARATION; INCIDENT #1 7/24/97 MILEAGE 32,640, INCIDENT #2 12/13/04 MILEAGE 70,349. *AK

NHTSA ID

10102860

Incident

Dec 13, 2004

Mileage

70,349 mi

WHILE DRIVING THERE WAS A BANG. THE VEHICLE WAS TOWED AND IT WAS DISCOVERED THE TRANSMISSION WAS DEFECTIVE. AFTER HAVING THE TRANSMISSION REPLACED, THE TRANSMISSION WAS DEFECTIVE AGAIN. THE SECOND GEAR IS GONE. *AK THERE WAS A LOUD BANG AND THE VEHICLE JERKED EXTREMELY HARD. THE TRANSMISSION WAS REBUILT AND CURRENTLY IT WOULD NOT SHIFT FROM SECOND GEAR. *SC

NHTSA ID

10089215

Incident

Aug 10, 2004

Mileage

10,000 mi

THE VEHICLE CAUGHT ON FIRE WHILE DRIVING AND RESULTED IN EXTENSIVE DAMAGE. *AK *NLM

NHTSA ID

10009027

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID

766888

Incident

Jul 4, 2001

TRANSMISSION WENT INTO "LIMP-HOME" MODE (LOCKED IN 2ND GEAR. ALSO SHOWED SLIPPAGE IN R-D SHIFT. MECHANIC DIAGNOSED PROBLEM AS FAILURE IN INTERNAL VALVING. HE ALSO FOUND A DSCARDED CIGARETTE BET IN THE VALVE BODY. TRANSMISSION NOT REPAIRABLE. REPLACED TRANSMISSION AND TRANSMISSION SENSORS, TO THE TUNE OF $2,800. SPOKE TO CHRYSLER'S CUSTOMER RELATIONS DEPARTMENT BEFORE AUTHORIZING REPAIR. THEY FLATLY REFUSED TO OFFER ANY GOODWILL ADJUSTMENT, BECAUSE I WAS SECOND OWNER. HOWOVER, I HAVE ORIGINAL OWNER'S STATEMENT THAT CAR WAS SERVICED ACCORDING TO MANUAL, AND TRANSMISSION WAS NEVER OPENED WHILE SHE OWNED IT. THIS IS APPARENTLY A COMMON PROBLEM WITH TRANSMISSIONS USED IN THE EARLY 1990S. A TRANSMISSION SHOULD NOT FAIL THIS SOON, AND CHRYSLER SHOULD BE FORCED TO PAY FOR THE CONSEQUENCES OF ITS POOR DESIGN PRACTICES.*AK

NHTSA ID

761204

Incident

Apr 7, 2002

CONSUMER STATED THE TORQUE TUBE CRACKS INSIDE OF WELD ON LEFT HAND SIDE OF VEHICLE WHICH WEAKENS THE TRAILING ARM. DEALER CONTACTED. NLM *YH

NHTSA ID

8007827

Incident

Oct 1, 2000

WHILE DRIVING AT 55 MPH AND WITHOUT WARNING OCCURRED A COLLISION, RESULTING IN AIR BAGS NOT DEPLOYING, CAUSING DRIVER MINOR FACIAL INJURIES.*AK

NHTSA ID

8005502

Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. Please return suspect parts back to your facing depot using Return Code 02, before 13 September, 2016.

05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.

Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.

CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock and available for order. Please return suspect parts back to your facing depot using Return Code 02, before 16 September, 2016.

Warranty Operations Newsletter Updates from Warranty Operations

Return: Lamp Assy - CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of follow ing part numbers:55372082AE, 55372082AD, 55372082AC, 55372082AB, 55372082AA. Replacement part number is 55372082AF w hich is in stock and available. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.