2020 Chrysler Pacifica Owner Complaints

While driving on XXX in [XXX], the van suddenly said "Stop safely, the vehicle will shut off soon". We were in a dangerous spot on a narrow section of the freeway. I was able to turn the van back on and drive for a couple of miles and then it forced me to pull over again. There was a lot of traffic driving by and swerving toward us so I started the car again and made it to an exit, where we were towed to the dealership. The dealership pulled a code P0A43 and noted a rattling sound from the transmission, and a burnt smell/metal contamination in the transmission fluid. The dealership sent the information to the manufacturer for a warranty replacement of the transmission. The manufacturer denied coverage, claiming that the Salvage title voids the warranty. However, this warranty is a result of recall 03A/23V-010, which should remain to be covered by law, regardless of title status. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11776834

Incident

Oct 8, 2026

The contact owns a 2020 Chrysler Pacifica. The contact stated that while driving 35 MPH, the second-row driver's side seat adjuster latch failed to lock as intended. The contact's minor child was seated in the seat when the seat independently moved forward and backward. The contact stated that two days later, the second-row passenger's side seat adjuster latch failed to lock as intended. The vehicle was taken to the dealer where it was diagnosed with failed seat cable latches. The contact was informed that the seat cable latches needed to be replaced. The contact was informed that the repairs were not covered under recall. The contact was informed that the failures were normal wear and rear. The manufacturer was contacted, and a case was filed. The failure mileage was approximately 64,900.

NHTSA ID

11775405

Incident

Oct 24, 2026

Mileage

64,900 mi

Over the past couple of years the auto start-stop system has progressively gotten worse with erratic issues. I've been to the dealership, and have replaced the main and aux batteries multiple times to reset the system and fix the problem. New batteries do not fix the problem. The vehicle's electrical system has turned off the engine and stalled multiple times in the middle of intersections. The vehicle has shut down twice while attempting left turns across lanes of oncoming traffic and three times pulling from a side street onto a major road. This has started to happen everyday and is posing a safety issue for my two young children, family, and other motorists. This electrical issue is a well known problem of this model and multiple calls to the manufacturer and the dealership leaves me in the middle where neither want to provide a path for assistance as the dealership explains my issue as a manufacturer problem. In the past 3 weeks the electrical issue has impacted the vehicles ability to consistently start, sometimes the engine won't turn over and I have to jump the vehicle on an increasing basis. The start-stop system has created further electrical problems where the start-stop dash signal is on constantly, the dashboard lights up sporadically, and today the vehicle would not unlock by using the key fobs and with no physical key I am not able to access the vehicle.

NHTSA ID

11775305

Incident

Oct 3, 2026

File an Immediate NHTSA Safety Complaint (Do This Tonight) The vehicle intermittently stalls completely while decelerating or braking at low speeds when the engine is warm. The dashboard flashes an ACC/FCW warning as the engine dies. This requires a full shift into Park to restart in active traffic, creating an imminent crash hazard. The vehicle has only 26,000 miles. Chrysler Case #98023933 is refusing to authorize diagnostic flight data logging or precautionary repairs because the dealer cannot immediately replicate it." •

NHTSA ID

11773331

Incident

Jun 1, 2026

My 2020 Chrysler Pacifica Plug-In Hybrid (VIN [XXX]) is covered by safety recall NHTSA 26V-362 / FCA 52D (shown as "Recall Incomplete" on NHTSA's VIN lookup as of October 17, 2026), high-voltage battery fire risk. FCA advises owners not to charge the vehicle and to park it outside, away from structures, until it is repaired. FCA's dealer notice states the remedy for 2020-2021 model-year vehicles became available June 12, 2026. Shortly before drop-off, the vehicle's electronics began failing intermittently; no battery warning messages appeared and there was no fire. I purchased the vehicle from Clay Cooley CJD Ram (Irving, TX) on November 27, 2020. I presented it to Meador Chrysler Dodge Jeep Ram, Fort Worth, TX on August 18, 2026 (repair order [XXX]) for this recall. As of [XXX], 65 days later, the recall repair has not been completed and the vehicle has not been returned. The dealer has provided no status updates. The dealer provided a loaner that is far below the Pacifica in quality, with much worse fuel economy. Under 49 U.S.C. 30120(c), failure to repair within 60 days after presentation is prima facie evidence of failure to repair within a reasonable time. I request that NHTSA look into FCA's remedy timeliness and parts availability for this campaign, including replacement battery packs, which FCA's remedy instructions say are ordered through its STAR Center only after approval, and whether FCA has met its remedy obligations for this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11772909

Incident

Aug 18, 2026

While standing sideways, my left shoulder towards the rear of the car, I pushed the open hatch button. The automatic door began to rise and lifted me up and tossed me against some metal furniture that was behind the car, in the parking lot of a deli. It was over in a second, I couldn't step out of the way because I was holding two bags of firewood, one in each hand, and there was a tall curb, say ten inches high that prevented me from moving quickly out of the way. The automatic return function failed and the power gate just lifted me off my feet and I landed badly on the metal stadium type chairs severely injuring my ribs. It took me a minute to compose myself and rise, shut the hatch and hobble to the drivers door and drive home. The next day I tested the auto return function on the hatch and with the smallest amount of resistance it worked, and auto reversed and closed, multiple times. I could not and can not repeat the failure. I weigh over 250 pounds and am amazed that the hydraulics had that much force to be able to lift me off my feet. My ribs still hurt 2 weeks later but are definitely on the mend. No one witnessed the accident, it may have been captured on video at the store? I have not taken the vehicle anywhere for testing. I believe it may have been raining lightly.

NHTSA ID

11771492

Incident

Sep 27, 2026

I took my 2020 Chrysler Pacifica Hybrid (VIN: [XXX]) to Sames Bastrop Chrysler Dodge Jeep Ram in [XXX], to have Safety Recall 52D performed on the high-voltage battery. Prior to bringing the van in, the vehicle was driving and charging completely normally with no charging errors. Sames performed the recall software update to the Battery Pack Control Module (BPCM) under Recall 52D, but their diagnostic scan logged an active high-voltage fault code (DTC P0E15-00 for the battery pack coolant heater) and a stored bypass valve code (DTC P0E7C-00). Despite these active thermal management codes showing up in their system, the technician marked the vehicle as passed and returned it to me. After driving the van home the vehicle completely refused to charge on my very first attempt at home. The dashboard displayed a "Service Battery" warning message, and the charging system has been completely locked out ever since. This is a serious safety concern because the high-voltage battery recall was issued specifically to prevent battery fires and thermal runaway caused by internal cell defects. Returning a hybrid vehicle with an active thermal management failure during a fire-related recall leaves the battery vulnerable to overheating and disables the charging safety systems. The van was returned to [XXX], where it has sat for over a month. Sames initially stated that Stellantis was refusing to cover the battery replacement even though federal law requires safety recall remedies to be completed free of charge regardless of mileage. The charging failure and trouble codes have been confirmed by the dealership under Repair Order #XXX. I have also opened an active corporate case directly with the manufacturer under Stellantis Case #XXX, and Sames has provided a temporary rental vehicle through Enterprise while this is investigated. The van and all of its original high-voltage components are currently in the service bay at [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11764090

Incident

Jul 31, 2026

I was about to pull out into a main road with my 3 kids in the car, and my steering wheel locked up and became impossible to drive, had to quickly reverse and could not make it home. I then received an error message on my dash saying power steering unavailable, service requested. The car only has 118,000 miles on it.

NHTSA ID

11763944

Incident

Sep 12, 2026

I experienced a sudden loss of power and steering while driving my vehicle. The screen advised me to pull over because the engine would shut off soon, but I already had lost steering and power. I turned the car off and was able to restart it and drive it 1 mile home, and the check engine light was on. I had it towed to the dealer. After 2 weeks of testing, the dealer reported, “When your vehicle was initially checked in, the following trouble codes were present: 5 BPCM FAULT CODES P1A21-00, P1D43-00, P1C01-00, P1A2A-00, and P1A29-00. We have completed Recall Y40.” The repair tech said they expected the engine to lose power again at some point and I would need to have it towed in again to be repaired then. The repairs made so far are only software updates, no hardware has been repaired because the dealer said the errors didn’t recur after they reset the system. I have elevated the issue with the dealer and am awaiting a response. I am concerned based on the error codes and technician information that my vehicle is still at risk of catching fire at any time or experiencing another catastrophic loss of power if the faulty hardware is not replaced.

NHTSA ID

11762907

Incident

Aug 15, 2026

Our family was driving and our teen in the third row said his seatbelt came apart. We pulled over to inspect. He was in the third row driver side seat. The stitching for the seatbelt and the seat had disintegrated. There is a sticky residue but no stitching. The leather is in pieces and the seatbelt is unusable. This vehicle is used for family transport so there is no known cause as to why this would have happened. The middle seatbelt stitching is also disintegrating

NHTSA ID

11762579

Incident

Sep 6, 2026

We own a 2020 Chrysler Pacifica Hybrid that had been operating without any significant issues for approximately six years. Recently, the vehicle was subject to a recall involving the charging system, and we brought it to the dealership to have the recall work completed. Nine days after the recall service, the vehicle would not start and displayed a “Service Charging System” error message. The dealership arranged to have the vehicle towed back for evaluation. They kept the vehicle for approximately a week and a half but ultimately stated that they were unable to identify any problem. We were charged $200 for the diagnostic evaluation, and our insurance covered the cost of the tow. Approximately 10 days after receiving the vehicle back from the dealership, it again failed to start and displayed the same “Service Charging System” error. Given that we had no significant issues with the vehicle for approximately six years and that this problem began only nine days after the recall work was performed—and has now occurred twice—we are very concerned that the issue may be related to the recall service or that the underlying problem was not identified during the dealership’s initial evaluation.

NHTSA ID

11761392

Incident

Jul 29, 2026

Vehicle has suffered from electrical issues since 2023 with effects to front windows causing window to reverse down when trying to roll up, radio malfunctions that is a known Chrysler issue that removes the ability to control rear entertainment center from front screen leaving the feature unusable with small children in the rear for long periods of time, rear cross traffic warning detection malfunctioning and not making audible alarms or warning with vehicles and pedestrians behind vehicle, loud noises when braking that according to Chrysler TA is potentially the ABS system wanting to engage but didn't, electrical shorts causing intermittent surging of interior lights - slower functioning of sliding doors - shorted out multiple window washer pump systems leading to replacement - lane departure system malfunctioning causing vehicle to drastically steer vehicle towards a curbed center island in which I as the driver had to manipulate the wheel to avoid crashing - passenger slider door at time malfunctions causing the door to repeatedly open and close on it's own and also open on its own while vehicle was underway in reverse - blind spot monitoring system malfunctioning at times to not warn of vehicles in blind spot - vehicle stalled twice with check engine light on but no recorded data in computer of the events ever occurring. All of these issues have been inspected under both factory warranty and extended Mopar warranty with service department stating they could not replicate the error and no further investigation or diagnosing was completed. After "repair attempts" were made the malfunctions reoccurred with another service appointment being needed and more electrical errors happening over time. Per service department there were no DTC or check engine lights for our malfunctions, however years later they finally admitted there had been DTC logs but were ignored and not diagnosed. We feel the safety of our family and public are at great safety risk from the failures.

NHTSA ID

11759715

Incident

May 27, 2026

Backup camera goes in and out and then blue.

NHTSA ID

11753734

Incident

Jun 19, 2026

The contact owns a 2020 Chrysler Pacifica. The contact stated that while driving at higher speeds and attempting to veer over to the left or right, the steering wheel failed to return to center. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

NHTSA ID

11752426

Incident

May 15, 2026

Mileage

90,000 mi

Intermittent power steering loss, when I turn van off and back on and go in reverse it stops sometimes.

NHTSA ID

11748384

Incident

May 28, 2026

Head gasket is cracked causing cylinder 5 to misfire and burned up coolant in the engine causing the engine to overheat while driving and put safety of driver and passengers in danger while vehicle was traveling at high speeds.

NHTSA ID

11744283

Incident

Jun 7, 2026

Driving down a road, Power Steering warning light came on, and the power steering went completely out. My wife was driving, and is not strong enough to steer manually. She was able to partially get off the road to stop. Needed other drivers to help get it off the road. We had it towed to a repair shop, and they said the electronic components replaced and only the dealerships do it. Made an appointment and will have to pay to have it towed to the dealership

NHTSA ID

11743035

Incident

Jun 8, 2026

I purchased my 2020 Chrysler Pacifica in January 2020. By April 2021, I began experiencing ongoing issues that have never been fully resolved. In the six years I have owned this vehicle, I have gone through six batteries. The vehicle has stalled in the middle of the road and, at other times, has failed to start altogether. The vehicle also does some jolting randomly which can be very harsh to the passengers inside. I specifically purchased this vehicle because of its safety features, as I have young children. Unfortunately, these repeated failures have left me feeling unsafe and concerned about the reliability of the vehicle. Each time I have brought the Pacifica to the dealership, the battery has been replaced or recharged and I have been told the issue was fixed. However, within six months to a year, the same problem returns and the vehicle is back in the shop. The issue has occurred again, and I am at a loss as to what to do next. It is clear that there is an underlying problem that has not been properly diagnosed or repaired. After six years of recurring breakdowns and unsuccessful repair attempts, I have been unable to fully enjoy or rely on this vehicle. I am requesting that this matter be taken seriously and that a thorough investigation be conducted to permanently resolve this ongoing issue. Given the repeated repair history and the safety concerns involved, I believe this situation warrants immediate attention.

NHTSA ID

11741930

Incident

Apr 1, 2021

On October 7, 2024, my vehicle was serviced at Coastal Chrysler Dodge Jeep Ram for a front-end rubbing/scrubbing noise that increased with speed. The dealer diagnosed both front hub assemblies as failed and replaced both front hub assemblies. I was charged a total of $2184.41 for the repairs, including parts and labor. In less than two years, I again experienced significant front-end noise and safety concerns. On May 19, 2026, because I urgently needed the vehicle and was unable to obtain a timely appointment with the dealership, I took the vehicle to a well-regarded independent repair facility, Koala Automotive Repair LLC. Their findings were extremely concerning. The mechanic documented that: The front wheel bearing was completely worn out. The axle had ripped due to contact with the strut assembly. Bolts on the hub bearing assembly were “very loose” and reportedly “finger loose” The vehicle owner stated that the hubs had recently been replaced by the dealership The independent mechanic further advised that the components replaced in October 2024 should still have been under dealer warranty, and that the second repair involved the same components and directly related failures. I am deeply concerned that: Components replaced by the dealer failed again prematurely; The loose hub bearing assembly bolts may indicate improper installation or insufficient torque procedures during the prior dealer repair; and The subsequent failure created additional damage to the CV axle and related front-end components. This situation caused: Significant unexpected repair expenses: I had to spend a total of $1,932.71 for the second repair. Loss of use of the vehicle. Safety concerns for myself and my passengers. Additiona

NHTSA ID

11739575

Incident

May 17, 2026

car goes into park while driving

NHTSA ID

11739262

Incident

May 4, 2026

Driver side air bags did NOT deploy resulting in injury

NHTSA ID

11738242

Incident

Apr 20, 2026

I am writing to formally express my dissatisfaction with the handling of repairs on my Chrysler Pacifica and the significant financial and personal impact this situation has caused my family. The issue began when the engine suddenly stopped, leaving us stranded. The vehicle was first taken to an insurance-recommended shop that could not diagnose the issue, then transferred to Wischsnewsky Dodge in Baytown, TX. There, we were told the problem was the starter and fuse box. Based on their professional assessment, we approved costly repairs, which required financing. However, just one day after picking up the vehicle, it failed to start again. This not only showed a lack of proper diagnosis, but also placed my wife and children in an unsafe situation. We were also forced to cancel a prepaid family trip due to lack of transportation. The dealership retrieved the vehicle and promised a loaner, but none has been provided after more than two weeks. We have since incurred additional expenses for rentals and rideshare services. We are now being told the issue may be a head gasket failure—something that could have been identified earlier with a basic test and is reportedly a known issue with this model. The estimated cost to replace the engine per the dealership is $16,000. At this point, we have taken on debt for ineffective repairs and continue to face mounting costs without a clear resolution. I am requesting immediate assistance from Chrysler to address this situation and provide a fair outcome.

NHTSA ID

11736724

Incident

Mar 2, 2026

Back up camera works intermittently and freezes or shows incorrect image. Wife almost backed into another car/family because the camera froze showing a clear driveway when there actually was a car there. We have an appoint with the dealership next week to investigate. Has not been inspected by police or insurance. No warning lights or messages came.

NHTSA ID

11736162

Incident

May 6, 2026

I have a 2020 Chrysler Pacifica. There was a recall last year and I brought it in to the dealership. At that time, I wasn't even sure what the recall was for. This year, about a month ago, I was driving (I take XXX to work everyday) and the display had a notice that said "Stop safely, the engine will turn off". I pulled over and turned the car off and turned it back on. The check engine light came back on but it drove fine. The check engine light eventually went off but the same thing happened again a few days later. I brought it into my mechanic who couldn't read the diagnostics. I brought it back into the dealership and they said I just needed a software upgrade so they did that. Unfortunately, the engine died again on the road. I shut the car off and turned it back on. I brought it back to the dealership and said the issue wasn't fixed. They haven't taken the issue seriously so I started searching and found this issue. It sounds like Chrysler is aware of the issue but I'm nervous even a new transmission won't fix the issue. In the meantime, I've had to rent a car as the dealership doesn't do loaners. This is a pretty big safety issue as now my car has shut down on the middle of the highway multiple times! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11735452

Incident

Apr 21, 2026

Third row randomly closes on my kids who are buckled in them. I've reported this to the dealer shortly after getting my van in 2021. Brought it back to them twice where they found "no problem", then I made an additional report here last year after it closed on them an excessive amount of times and I felt helpless. I was forced to move the child who was sitting in the back to front seat after it closed on them multiple times in one ride. A head on collision occurred a few miles down the road with my child in front seat. He was injured more than he should have ever been, due to needing to be moved from the rear of the van. Furious Chrysler did not take my previous complaints more seriously.

NHTSA ID

11733112

Incident

Apr 20, 2026