2019 Coachmen Freedom Express Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2019 Coachmen Freedom Express, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure125.0%
- Other / unspecified125.0%
- Suspension125.0%
- Tires & wheels125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2019 Forest River Freedom Express RV. The contact stated while driving 55 MPH, the contact noticed that the RV was leaning abnormally. The contact pulled over into a park lot, inspected the vehicle but could not determined the cause of the issue. Upon arriving to the residence and inspecting underneath the RV, the contact noticed that both left springs were hanging on the front driver-side and passenger-side of the RV, and the whole rear axle had detached from trailer. The RV was taken independent mechanic where it was diagnosed that the frame had failed and needed to be replaced. The RV was not repaired. The manufacturer was notified of the failure but denied assistance. The failure mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
Stove came equipped in my 2019 Coachmen Freedom Express 204RD and is in many other RVs. Staged a pot of coffee on the Furrion RV stove and the pot tipped over. Have had this occur multiple times. No injuries but there are multiple blogs on the internet of people experiencing the same issue with this unsafe RV stove top grate design. Smaller pans, coffee pots, etc. can tip over which could lead to a serious injury, legal liability and fires. Contacted the manufacturer of the stove (Lippert/Furrion) reporting the hazard with no reply back in June of 2025. Contacted CPSC in 2025 and filed a report with them. CPSC stated it is a vehicle related concern and should be filed with NHTSA. I believe the manufacture is still selling stoves with this unsafe design today as I have seen pictures of new brand new RVs with the same grate design. I do not want to see a pet, child or any other person injured due to this significant stove flaw. Thank you.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
The contact owns a 2019 Forest River Freedom Express RV. The contact stated while driving 55 MPH, the contact noticed that the RV was leaning abnormally. The contact pulled over into a park lot, inspected the vehicle but could not determined the cause of the issue. Upon arriving to the residence and inspecting underneath the RV, the contact noticed that both left springs were hanging on the front driver-side and passenger-side of the RV, and the whole rear axle had detached from trailer. The RV was taken independent mechanic where it was diagnosed that the frame had failed and needed to be replaced. The RV was not repaired. The manufacturer was notified of the failure but denied assistance. The failure mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
Pulling out of camping park noticed wheel leaning outward. Pulled off wheel and noticed axel, wheel bearing and hub damaged along with two cracks in frame. RV only 3 years old.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .