RoadVitals

2003 Country Coach Lexa Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
4
Newest Apr 10, 2006
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

4 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

06V110000

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Apr 10, 2006
21 units potentially affected
The defect: ON CERTAIN MOTOR HOMES, THE EXHAUST PIPE CONNECTION TO THE INLET AND OUTLET SIDE OF THE MUFFLER MAY COME APART.
The risk: SHOULD EITHER OF THE CLAMPS COME APART THE SUPER-HEATED EXHAUST BEING EXPELLED IN THE ENGINE COMPARTMENT COULD CAUSE A FIRE.
The remedy: DEALERS WILL REPLACE THE EXISTING BAND TYPE CLAMPS ATTACHING THE MUFFLER TO THE EXHAUST PIPE AND SECURE THE MUFFLER TO THE TAIL PIPE WITH GUILLOTINE TYPE CLAMPS FREE OF CHARGE. THE RECALL BEGAN ON MAY 8, 2006. OWNERS MAY CONTACT COUNTRY COACH AT 800-547-8015.
COUNTRY COACH INCView on NHTSA.gov
03V109000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Mar 26, 2003
485 units potentially affected
The defect: ON CERTAIN MOTORHOMES EQUIPPED WITH INTERNATIONAL THERMAL RESEARCH (ITR)HURRICANE HOT WATER HEATERS, THE ELECTRONIC CONTROL BOARD MAY ADVERSELY AFFECT SAFETY FEATURES IN SOME OF THE SYSTEMS PROTECTING AGAINST OVERHEATING AND POTENTIAL FIRE SITUATION.
The risk: IF THE SAFETY FEATURES DO NOT SHUT DOWN PROPERLY, THE HEATING SYSTEM CAN CONTINUE HEATING, POSSIBLY RESULTING IN A FIRE.
The remedy: THE DEFECTIVE ELECTRONIC CONTROL BOARD WILL BE REPLACED. IN THE MEANTIME, CUSTOMERS SHOULD TURN THE SYSTEM OFF USING THE MASTER ON/OFF SWITCH LOCATED ON THE SIDE OF THE ELECTRONIC CONTROL BOX WHICH IS ADJACENT TO THE HEATER. OWNERS WHO TAKE THEIR MOTORHOMES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ITR AT 1-800-755-1272 OR COUNTRY COACH AT 1-800-547-8015.
COUNTRY COACH INCView on NHTSA.gov
02V149000

VISIBILITY:WINDSHIELD WIPER/WASHER

Jun 21, 2002
8 units potentially affected
The defect: CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS." THE WINDSHIELD WIPER SYSTEM MANUFACTURED BY AM EQUIPMENT AND INSTALLED ON THESE MOTOR HOMES WAS DETERMINED NOT TO MEET THE MINIMUM PERCENT OF AREA TO BE WIPED WHILE THE MOTOR HOME IS DRIVEN AT SPEEDS OF 55 MPH OR MORE.
The risk: THE FAILURE OF THE WINDSHIELD WIPER SYSTEM TO ADEQUATELY CLEAR THE WINDSHIELD COULD LEAD TO A REDUCTION IN VISIBILITY DURING CRITICAL PERIODS WHEN SURFACE WIPED IS REDUCED AND COULD POTENTIALLY RESULT IN A CRASH.
The remedy: DEALERS WILL REPLACE THE WINDSHIELD WIPER MOTORS, WIPER MOTOR PANTOGRAPHS, WIPER ARMS AND BLADES. OWNER NOTIFICATION BEGAN JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.
COUNTRY COACH INCView on NHTSA.gov
02V164000

EQUIPMENT:ELECTRICAL

Jun 13, 2002
6 units potentially affected
The defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH SLIDE-OUT GENERATORS, CERTAIN GENERATOR SLIDE-OUT BALL SCREW ACTUATOR BRAKE HOLDING COMPONENTS ARE DEFECTIVE. THE BRAKE MAY NOT ALLOW THE ACTUATOR TO HOLD THE LOAD IN POSITION WITH THE POWER OFF. THE AMOUNT THE LOAD MAY MOVE CAN VARY AND IN SOME CASES THE ACTUATOR MAY NOT HOLD AT ALL. THESE ACTUATORS ARE USED TO CONTROL THE MOVEMENT OF THE SLIDE-OUT GENERATOR MOUNTED IN THE FRONT OF THE MOTOR HOMES.
The risk: THE FAILURE OF THE ACTUATOR TO HOLD THE GENERATOR IN POSITION COULD POTENTIALLY RESULT IN A VEHICLE CRASH AND/OR INJURY TO A PEDESTRIAN.
The remedy: DEALERS WILL REPLACE THE ACTUATOR. OWNER NOTIFICATION BEGAN JUNE 19, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.
COUNTRY COACH INCView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .