2009 Dodge 1500 Engine Problems

WHILE DRIVING MY TRUCK IT JUST SHUT OFF, DIED AND WOULD NOT START BACK UP. THIS WAS VERY DANGEROUS! GOING 65 MILES AN HOUR, IN THE CENTER LANE TRYING TO GET OVER TO THE SIDE OF THE ROAD...SAFELY! I TRIED TO START THE TRUCK...EVERYTHING CAME ON AS NORMAL, BUT WOULD NOT CRANK. I HAD TO HAVE THE TRUCK TOWED $$. THE ALTERNATOR WAS REPLACED $$. TRUCK STILL WOULD NOT START. IT WOULD NOT CRANK, YOU COULD HEAR CLICKING UNDER THE HOOD AND YOU COULD HEAR THE FUEL PUMP COME ON. I WAS TOLD IT WAS THE WIN MODULE WHICH COST ME $870.00!! (WIN MODULE AND PROGRAMMING) EVIDENTLY THIS IS A COMMON PROBLEM WITH DODGE TRUCKS. WHAT DOES IT TAKE TO HAVE A RECALL ON THIS PART?!! DOES IT TAKE A CERTAIN NUMBER OF CRASHES OR DEATHS? ALL IN ALL IT COST ME ABOUT $1500, BUT IT COULD HAVE COST ME MY LIFE, MY GIRLFRIENDS LIFE, AND POSSIBLY PEOPLE IN OTHER VEHICLES THAT WERE DRIVING AROUND ME. I HAVE RESEARCHED AND FOUND THAT OTHER DODGE VEHICLES WERE AFFECTED WITH THIS FAULTY PART AND THERE WAS A RECALL PUT OUT. THERE AGAIN, I ASK DODGE....WHAT DOES IT TAKE TO HAVE A RECALL ON THIS PART FOR RAM 1500 TRUCKS?? I HOPE THAT ALL OWNERS THAT HAD OR IS HAVING THIS PROBLEM TO FILE A REPORT! PLEASE! READ ALL THE DISCUSSIONS SIMILAR TO MINE ON DODGE FORUM. AGAIN, PLEASE REPORT THESE TYPES OF PROBLEMS, THEY WILL NOT KNOW HOW MAY VEHICLES ARE AFFECTED IF IT'S NOT REPORTED. YOU MAY SAVE SOMEONE'S LIFE.

NHTSA ID

11397758

Incident

Jan 9, 2021

Mileage

157,000 mi

EXHAUST MANIFOLD BOLTS BROKEN. CAUSES TICKING ON START UP. ITS BAD ON YOUR ENGINE AND IT WON'T PASS EMISSIONS. HOW HAS AN INVESTIGATION NOT BEEN DONE ON THIS?! SO MANY COMPLAINTS ON FORUMS, FACEBOOK, EVEN ON HERE. WITH LESS THEN 80K MILES THIS IS RIDICULOUS

NHTSA ID

11375474

Incident

Aug 1, 2020

Mileage

79,000 mi

EXHAUST MANIFOLD LEAK. BOLTS BROKE OFF

NHTSA ID

11362071

Incident

Aug 31, 2020

Mileage

79,000 mi

THE TOTAL INTEGRATED POWER MODULE FAILED AND IT'S A COMMON PROBLEM IN ALL CHRYSLER AND DODGE VEHICLES. THAT FAILS THE ENGINE RUNS ROUGH, AC, BRAKE LIGHT, TURN SIGNAL, HORN, WIPERS, STOP WORKING AND TRANSMISSION STAYS IN 1ST GEAR. THE LIGHTS ON THE DAS STAY ON: BRAKES, ABS, SEATBELT, CHECK ENGINE LIGHT AND AIR BAG... THIS IS AN SPECIALLY WHEN THE MODULE FAILS WHILE DRIVING IN THE ROAD. DEALERS KNOW IT'S A COMMON PROBLEM BUT THEY RATHER HAVE CUSTOMER PAY FOR A NEW TIPM.

NHTSA ID

11320900

Incident

Oct 25, 2018

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHEN THE VEHICLE WAS STARTED, THE CONTACT HEARD A LOUD ABNORMAL NOISE COMING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE EXHAUST MANIFOLD FAILED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 167,000.

NHTSA ID

11191718

Incident

Mar 1, 2009

Mileage

167,000 mi

ON MARCH 5, WHILE DRIVING TO WORK, I HEARD A KNOCKING SOUND FROM THE ENGINE. LATER IN THE DAY WHEN DRIVING, THE TRUCK WOULD LOSE POWER WHEN I ACCELERATED. I CALLED A DOGE DEALERSHIP AND MADE AN APPOINTMENT WITH THE SERVICE DEPARTMENT EARLY THE NEXT MORNING. THE NEXT MORNING, THE SOUND WAS LOUDER AND HAD LESS POWER THROUGH ACCELERATION WHEN DRIVING TO THE DEALERSHIP. I AGREED TO HAVE A DIAGNOSTIC AND WAS LATER CALLED AND TOLD MY FUEL PUMP NEEDED TO BE REPLACED. I WAS CHARGED $1,045. WHEN I DROVE HOME, THE TRUCK STALLED OUT ONCE BUT I MANAGED TO MAKE IT HOME. I HAD SEVERAL MECHANICS INCLUDING ONE THAT WORKED AT A DIFFERENT DODGE DEALERSHIP LISTEN TO THE KNOCKING AND EACH MECHANIC IMMEDIATELY SUSPECTED A PROBLEM WITH THE LIFTERS. ALSO, ACCORDING TO EACH MECHANIC, THIS WAS A COMMON PROBLEM WITH DOGE RAM TRUCK. I TOWED THE TRUCK TO A MECHANIC AND FOUND THAT THE 5TH CYLINDER LIFTER HAD FROZE UP AND CARVED A GROOVE INTO THE CAM. THE MECHANIC HAS ORDER THE LIFTERS AND PARTS TO REPAIR THE ENGINE AND FOUND A BACKLOG OF ORDERS FOR THE SAME PARTS. I'M CURRENTLY HAVING TO RENT A CAR. MY WORK REQUIRES ME TO SOMETIMES DRIVE ON THE HIGHWAY 100 MILES ROUND TRIP. FORTUNATELY I WAS NOT IN THAT REQUIRED SITUATION AT THE TIME OF THE BREAKDOWN.

NHTSA ID

11190525

Incident

Mar 5, 2019

Mileage

137,000 mi

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING 70 MPH, THE VEHICLE DECELERATE AND WOULD NOT EXCEED 40 MPH. THE VEHICLE VIBRATED VIOLENTLY AND THE ABS WARNING INDICATOR ILLUMINATED. AN INDEPENDENT MECHANIC REPAIRED THE MOTOR. THE DEALER WAS CONTACTED AND DID NOT ASSIST. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 185,000.

NHTSA ID

11190083

Incident

Mar 1, 2019

Mileage

185,000 mi

CHECK ENGINE LIGHT CAME ON WITH CODE FOR CYLINDER MISFIRE. DID RESEARCH ONLINE WHAT PROBLEM MIGHT BE AND SEEN THOUSANDS OF COMPLAINTS WITH EXACT SAME ISSUE. TOOK IT TO MECHANIC AND HE SAID LIFTER FAILURE. ROLLERS SEIZED UP AND TOOK LOBE OFF CAM. THIS IS THE EXACT SAME THING I SEEN ON THOUSANDS OF OTHER COMPLAINTS ONLINE.

NHTSA ID

11183114

Incident

Nov 1, 2018

Mileage

90,000 mi

SO THE HEMI 5.7 HAS NUMEROUS COMPLAINTS ON CYLINDER 5 MISFIRE AND RESULTING IN MAJOR ENGINE WORK DO TO THE MDS SYSTEM DODGE FAILED MISERABLY ENGINEERING . MY TRUCK HAS 80,000 MILES ON IT AND I GET IT MAINTAINCE REGULARLY . WHY AT CONSUMERS HAVING TO COME OUT OF POCKET AND IT NOT BE RECALLED YET FROM DODGE FOR POOR DESIGN ON THIS ENGINE .

NHTSA ID

11180677

Incident

Feb 1, 2017

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING 50-55 MPH, THE VEHICLE MISFIRED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT CYLINDER NUMBER FIVE WAS DEAD. THE VEHICLE WAS TAKEN TO HEBERTS TOWN AND COUNTRY CHRYSLER DODGE JEEP RAM (1155 E BERT KOUNS INDUSTRIAL LOOP, SHREVEPORT, LA 71105, (888) 881-5163) WHERE IT WAS DIAGNOSED THAT THE LIFTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 131,049. THE VIN WAS NOT AVAILABLE.

NHTSA ID

11174522

Incident

Nov 1, 2018

Mileage

131,049 mi

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT TOOK THE VEHICLE TO AN UNKNOWN DEALER FOR ROUTINE MAINTENANCE. THE CONTACT WAS INFORMED THAT THE ALTERNATOR WAS ABOUT TO FAIL. THE CONTACT HAD THE ALTERNATOR REPLACED WITH A REBUILT ONE; HOWEVER, THE REPLACEMENT ALTERNATOR FAILED A WEEK LATER. THE CONTACT HAD THE VEHICLE TESTED FOR A NEW BATTERY AND SHE DISCOVERED THAT THE ALTERNATOR FAILED AGAIN. THE DEALER REPLACED THE ALTERNATOR AGAIN AND INFORMED THE CONTACT OF RECALLS FOR THE DODGE RAMS FROM 2007 THROUGH 2013. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 103,917. *TT*JB

NHTSA ID

11171472

Incident

Jan 12, 2019

Mileage

103,917 mi

4TH GENERATION RAM 1500 PICKUPS WITH THE 5.7L HEMI ARE BECOMING NOTORIOUS FOR PREMATURE LIFTER FAILURE RESULTING IN DAMAGE TO THE CAMSHAFT LOBE. THESE REPAIRS ARE OFTEN OCCURING JUST AFTER EXPIRY OF CCHRYSLER'S POWERTRAIN WARRANTY. THERE ARE HUNDREDS OF CASES ON ONLINE OWNER FORUMS THAT PRESENT SIMILARLY. CHRYSLER HAS NOT SOUGHT TO REMEDY THE PROBLEM WITH OWNERS. SEE THE FOLLOWING LINK FOR DOZENS OF EXAMPLES FROM THE LAST FEW YEARS: HTTPS://WWW.RAMFORUMZ.COM/SHOWTHREAD.PHP?T=188978 MAJOR POWER LOSS OCCURED AT HIGHWAY SPEEDS AND PUT THE VEHICLE IN "LIMP" MODE. THE RESULT WAS A NEAR ACCIDENT WITH A LARGE TRUCK AS POWER LOSS OCCURED WHILE PASSING ON THE HIGHWAY.

NHTSA ID

11166579

Incident

Oct 1, 2018

Mileage

100,000 mi

THE MANIFOLD BOLTS ON THE 5.7 HEMI BREAK SOMETIMES BREAKS OFF IN THE HEAD AND ARE NOT EASILY REMOVED. THUS CAUSING AN EXHAUST LEAK (AKA HEMI TICK). AND MY TRUCK ONLY HAS 77000 MILES ON IT. BOUGHT USED SO NO WARRANTY TO COVER THE REPAIRS.

NHTSA ID

11164107

Incident

Dec 23, 2018

Mileage

77,000 mi

IN 2018,YR 2012 DODGE RAM TRUCK, WAS RECALLED FOR THE T79 RECALL. AFTER RECALL WAS INSTALLED, NOW TRUCK STALLS-GOES DEAD WHEN BRAKE PUSHED & DIES IN REVERSE. AFTER RESEARCH, IT'S A MAJOR ISSUE W/THE 1500'S YET THERE HASNT BEEN A RECALL. THIS IS A VERY DANGEROUS SITUATION THAT DODGE HAS PUT THE OWNERS IN. SO WHEN I BRAKE FOR ANYTHING ON A HWY, IT GOES DEAD! THE DEALER CHECKS FOR AN ERROR CODE & YET THERE IS NO ERROR CODE SO THEY CANT DO ANYTHING ABOUT IT-DEPENDENT ON COMPUTERS VERSUS HANDS ON MECHANICS. DEALER SUGGESTED TO LEAVE MY TRUCK & THEY'LL DRIVE IT UNTIL IT HAPPENS WHICH IS RANDOM. IT'S RIDICULOUS THAT MECHANICS HAVE NO REAL HANDS-ON MECHANICAL ABILITY & DEPEND ON COMPUTERS TO PROVIDE ERROR CODES. AFTER THE T79 RECALL WAS DONE, WAS IT REQUIRED TO UPGRADE/UPDATE OR REFRESH THE COMPUTER SYSTEM AFTERWARDS? DEALER SAID THE RECALL DID NOT CALL FOR AN COMPUTER UPDATE AS DODGE DID NOT REQUIRE IT. PER INTERNET FORUMS, YOUTUBE, & INTERNET, THE STALLING IS A MAJOR ISSUE! GUESS I HAVE TO TAKE CHANCES W/THIS ISSUE OF STALLS/DYING ON HWY TRAVEL-DANGEROUS! ALSO, THE STEERING WHEEL HAS SOMETHING LOOSE INSIDE OF IT. IT SOUNDS LIKE THE AIRBAG HAS COME LOOSE & IS MOVING WHEN WHEEL TURNED. ANY RECALLS OR WORD ON THIS? AGAIN THE DEALER PLUGS IN HIS COMPUTER & DOESN'T SEE ANYTHING WRONG EVEN THOUGH YOU CAN HEAR IT. DODGE NEEDS TO BE ACCOUNTABLE & RESPONSIBLE FOR ALL THESE MISTAKES-ESP SINCE THIS IS A SAFETY ISSUE! ALSO, ON THE 1ST DAY OF PURCHASING MY TRUCK, THE PASS AIRBAG LIGHT REMAINED ON. DEALER KEPT NEW TRUCK FOR 6 WKS TO ATTEMPT RESOLUTION & ENDED UP CONTACTING DODGE ENGINEERING & FOUND OUT THE COLORED WIRES WERE CROSSED - THE COLORS WERE INTERCHANGED AT THE FACTORY! AMAZING & NO RECALL WAS DONE. IT'S IMPOSSIBLE TO SPEAK W/CUST SERV AT DODGE RAM- SOMEONE THAT IS KNOWLEDGEABLE.

NHTSA ID

11153094

Incident

Aug 2, 2018

2009 DODGE RAM 1500. WHEN THE VEHICLE WAS STARTED, A TICKING NOISE WAS HEARD FROM THE EXHAUST MANIFOLD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT BOTH SIDES OF THE ENGINE BLOCK HINGES WERE FRACTURED AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 80000

NHTSA ID

11130552

Incident

Jan 15, 2015

ON MY 2009 DODGE RAM 1500 HEMI I HAVE BROKEN BOLTS ON MY EXHAUST MANIFOLD, SOMETHING IS WRONG WITH MY HVAC SYSTEM IN MY TRUCK ALSO. BOTH OF WHICH I SEE ARE VERY COMMON PROBLEMS WITH THESE TRUCKS.

NHTSA ID

11088948

Incident

Feb 12, 2017

Mileage

102,000 mi

I HAVE A 2011 DODGE RAM. I HAD TO MARK 2009 BECAUSE MY YEAR WANT IN THE OPTIONS. I HAVE REPLACED MY FUEL PUMP TWICE TO FIND OUT I HAVE A BAD TIPM. MY FUEL PUMP WON'T SHUT OFF EVEN WHEN THE TRUCK IS OFF CAUSING A DEAD BATTERY. WINDOWS ROLL UP AND DOWN ON THEIR OWN, TRUCK LOSSES POWER OUT OF NO WHERE, AND DOOR LOCKS WON'T WORK SOMETIMES. I'VE SPENT A FEW THOUSAND TO TRY TO GET THIS FIXED JUST TO LEARN IT'S THE TIPM.YOUR OPTIONS WON'T ALLOW ME TO CHECK THE PROPER BOXES

NHTSA ID

11064557

Incident

Dec 2, 2017

Mileage

99,000 mi

I HAVE 93000 ON MY TRUCK AND THE LIFTER SEIZES I CHANGE MY OIL AS RECOMMENDED THIS IS TO LOW OF MILES TO DEAL WITH THIS PROBLEM

NHTSA ID

11033905

Incident

Aug 10, 2017

Mileage

93,000 mi

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART WHILE HOLDING THE KEY FOB BUT, WHEN RELEASED, THE VEHICLE LOST ALL POWER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIRELESS IGNITION SWITCH NEEDED REPALCEMENT. THE VEHICLE WAS NOT REPAIRED DUE TO THE COST. THE CONTACT FOUND NHTSA CAMPAIGN NUMBER: 10V2400000 (ELECTRICAL SYSTEM) ONLINE FOR THE 2010 RAM QUAD CAB REGARDING THE SAME FAILURE. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER FOR DIAGNOSTIC TESTING. THE CONTACT STATED THAT THE MANUFACTURER WAS NOTIFIED, BUT OFFERED NO FURTHER ASSISTANCE. THE CONTACT WAS REFERRED TO CONTACT NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 99,900.

NHTSA ID

11020095

Incident

Aug 23, 2017

Mileage

99,900 mi

DRIVING DOWN THE ROAD AND THE ENGINE SHUTS OFF.....RANDOMLY HAPPENS - EXTREMELY DANGEROUS...HAPPENS ON THE HIGHWAY TOO. NO RECALL OR ANYTHING ON THIS ISSUE........WHY IS THIS NOT A HIGH PRIORITY......A CLASS ACTION LAWSUIT WON'T DO FAMILIES ANY GOOD WHEN A LIFE OR SEVERAL LIFES ARE LOST.....PLEASE MAKE THIS A TOP PRIORITY. THANK YOU.

NHTSA ID

11001927

Incident

Jun 9, 2017

Mileage

158,000 mi

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT STATED THAT THE ENGINE STARTED AUTOMATICALLY WITHOUT THE KEY IN THE IGNITION. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

NHTSA ID

10968750

Incident

Feb 1, 2017

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.

NHTSA ID

10913957

Incident

Sep 2, 2016

Mileage

37,000 mi

2009 DODGE RAM 1500 THERE IS A MANIFOLD BOLT THAT IS INFERIOR/DEFECTIVE PART DEALERSHIP HAS ADMITTED THEY KNOW IT IS.. THEY ARE REPLACING ATLEAST ONE A WEEK. THIS BOLT CAN BREAK OFF AND CAUSE THE MOTOR TO CEASE... WARRANTY WILL NOT REPLACE AND THIS IS HAPPENING TO HUNDREDS OF PEOPLE ITS IN ALL DODGE FORUMS... $400 + TO REPLACE THIS DEFINITELY NEEDS TO BD A RECALL ONLY 50,000 MILES ON TRUCK

NHTSA ID

10906290

Incident

Sep 12, 2016

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE STARTING THE VEHICLE, A TICKING SOUND WAS HEARD CONSTANTLY. THE CONTACT NOTICED THAT THE ENGINE MANIFOLD BOLTS HAD FRACTURED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000.

NHTSA ID

10887863

Incident

Apr 21, 2016

Mileage

53,000 mi

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. IT TOOK SEVERAL ATTEMPTS BEFORE THE ENGINE RESTARTED. THE MANUFACTURER WAS NOTIFIED AND NO REPAIRS WERE PERFORMED. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10872124

Incident

Jun 1, 2013

Mileage

100,000 mi