2007 Dodge Grand Caravan Owner Complaints

The contact owns a 2007 Dodge Grand Caravan equipped with Cooper Tires, Tire Line: Evolution Tour, Tire Size: 215/65/R16, DOT Number: (not available). The contact stated while driving 60 MPH, the driver’s side front tire experienced a blowout causing the steering wheel to shake. The contact was able to pull over safely and replace the tire. The failure reoccurred while driving however, the front passenger’s side the tire experienced the blowout. The dealer was contacted and stated that the tire was not under warranty. The manufacturer had been notified of the failure. The failure mileage was approximately 112,393.

NHTSA ID

11472773

Incident

Jul 7, 2022

Mileage

112,393 mi

WHILE TRAVELING ON I-84 IN IDAHO THE TIRE TREAD SEPARATED FROM THE TIRE. THIS WAS THE SECOND TIRE TO FAIL. THE TIRES WERE COOPER CS5 GT 98T SERIAL NUMBER U96V1CW1617

NHTSA ID

11355415

Incident

Sep 15, 2020

Mileage

400,828 mi

AFTER EACH AND EVERY VEHICLE FUELING, THE VEHICLE STALLS SEVERAL TIMES CAUSING LOSS OF STEERING AND BRAKES. THIS IS DANGEROUS AND UNSAFE AS THIS SCENARIO HAPPENED TO ME AT AN INTERSECTION AND AT A TURN NEARLY CAUSING ME TO HAVE AN ACCIDENT. *TR

NHTSA ID

11323890

Incident

May 1, 2020

Mileage

130,000 mi

WHEVER I FILL UP THE GAS TANK, THE CAR STARTS TO STALL AND JERKS AND STOPS ALL THE WAY. IT DISPLAYS ENGINE LIGHT AND GOES INTO CRUISE MODE. I HAVE TO TURN IT OFF N BACK ON AND STILL JERKS UNTIL THE FUEL IS LITTLE EMPTY. WHEN I DON'T FILL IT FULL THEN IT DOESN'T DO THIS

NHTSA ID

11298613

Incident

Jan 10, 2020

Mileage

115,000 mi

MY 2007 DODGE GRAND CARAVAN SE CAN BE EASILY SHIFTED INTO GEAR WHILE IN AUXILIARY POWER, AND IT SOMETIMES LOCKS OUT MY BRAKES, AS THERE IS A LOCKED STEERING WHEEL YOU CAN'T STEER IT AND CAN'T TURN IT ON WITHOUT SHIFTING BACK TO PARK WHICH CAN BE DIFFICULT IF THE BRAKES LOCK. A CHILD COULD EASILY SET IT IN GEAR IF YOU ARE RUNNING THE AIR AND YOU LEAVE THE CAR BRIEFLY, I DO NOT HAVE KIDS BUT I DO RUN SOME TAXI WORK IN THE NEIGHBORHOOD. IT COULD BE DONE ANYWHERE AS LONG AS IT'S IN AUXILIARY POWER TO RADIO AND ELECTRICS BUT NOT FULLY ON

NHTSA ID

11297532

Incident

Jan 6, 2020

Mileage

494,194 mi

AFTER ALMOST EVERY FILL UP VEHICLE STALLS WHEN GOING DOWN ROAD. AFTER RESEARCHING THE PROBLEM I FOUND THE VAPOR/LIQUID SEPARATOR VALVE IS DEFECTIVE. EVIDENTLY THIS IS A COMMON PROBLEM AND A SAFETY ISSUE IN MY OPINION. TO BE DRIVING DOWN THE ROAD AND YOUR VEHICLES SHUT DOWN IS DANGEROUS. WHY DOES THE MANUFACTURER NOT HAVE A RECALL ON THIS PROBLEM.

NHTSA ID

11280686

Incident

Nov 17, 2019

Mileage

132,000 mi

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHEN THE CONTACT ATTEMPTED TO LOCK THE VEHICLE WITH THE POWER LOCK FUNCTION, BOTH REAR SLIDING DOORS SEIZED WITHOUT WARNING AND WOULD NOT REOPEN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 145,000.

NHTSA ID

11267634

Incident

Sep 17, 2019

Mileage

145,000 mi

AS I WAS DRIVING IN TOWN THE VEHICLE STARTED RUNNING VERY ROUGH, I PULLED OVER INTO A PARKING LOT AND THEN IT WOULDN'T RUN AT ALL. I HAD IT TOWED TO AN AUTO REPAIR PLACE. THEY REPLACED A SENSOR. THAT DID NOT FIX THE PROBLEM, SO AFTER A FEW WEEKS THEY FINALLY DIAGNOSED IT AS NEEDING A VALVE JOB. I BOUGHT THIS VEHICLE NEW IN 2007 AND HAD IT REGULARLY SERVICED.

NHTSA ID

11254173

Incident

Dec 28, 2018

Mileage

80,000 mi

BRAKES PEDAL GOING TO THE FLOOR WHEN STOPPING AT INTERSECTION! THIS JUST OCCURRED OR STARTED YESTERDAY! I AM TAKING TO A MECHANIC IN THE MORNING TO EVALUATE.

NHTSA ID

11231168

Incident

Jul 10, 2019

Mileage

178,000 mi

IF VARIOUS OTHER DESIGN FLAWS WITH OTHER VEHICLE PARTS HAVE BEEN DEEMED WORTHY OF RECALL TO BE REDESIGNED BECAUSE THEY HAVE FAILED TO DO THAT FOR WHICH THEY WERE DESIGNED...THEN I FEEL LIKE DODGE AND CHRYSLER SHOULD RECALL MILLIONS OF MINI VANS THEY HAVE PRODUCED IN EARLY 2000'S THAT HAVE TOTALLY RUSTED OUT LOWER PORTION OF SIDE SLIDING DOORS...TOTAL DESIGN FLAW!!!!! A DESIGN FLAW IS A DESIGN FLAW...MANUFACTURES FAULT. THANKS FOR LISTENING..[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

NHTSA ID

11228404

Incident

Jan 1, 2007

WHILE DRIVING AT 35 MPH OR LESS FOR LESS THAN 5 MINUTES IN CITY TRAFFIC, MY RIGHT REAR TIRE BLEW OUT. FIRESTONE FR710. PURCHASED 11/30/15

NHTSA ID

11183305

Incident

Feb 27, 2019

Mileage

150,000 mi

TAKARA RECALL- MY VEHICLE WAS PARKED AT A STORE IN WAS WORKING IN, I WENT OUT TO TAKE A BREAK AND HAD THE SEAT WARMER ON HIGH BECAUSE MY BACK WAS HURTING. I STARTED SMELLING BURNING RUBBER, SO I TURNED IT OFF. UPON EXITING MY VEHICLE THERE WERE TWO HOLES BURNED INTO MY DRIVERS SEAT. I HAD USED THE SEAT WARMER NUMEROUS TIMES PRIOR TO THIS AND HAD NO PROBLEMS. I BELIEVE IF I HADN'T TURNED THE SEAT WARMER OFF MY VAN AND MYSELF PROBABLY WOULD HAVE BEEN ON FIRE.

NHTSA ID

11163736

Incident

Dec 20, 2018

Mileage

119,000 mi

AFTER FILLING THE FUEL TANK THE VEHICLE STALLS, AND SPUTTERS WHEN PULLING INTO TRAFFIC, AND DRIVING DOWN THE ROAD FOR UP TO 1 MINUTE

NHTSA ID

11154221

Incident

Nov 27, 2018

Mileage

123,000 mi

WHEN TURNING ON RIGHT TURN SIGNAL IT FLASHES AND SHUTS OFF WHILE THE SWITCH IS STILL ON. WHEN I SIGNAL LEFT IT DOESN'T WORK AT TIMES, ALL THIS HAPPENS WHILE THE VEHICLE IN IN MOTION ON THE ROAD. I TRIED CONTACTING DODGE AND THEY WERE NO HELP. THIS IS A HUGE SAFETY ISSUE AND COULD LEAD ME TO GET PULLED OVER OR IN AN ACCIDENT

NHTSA ID

11109498

Incident

Jun 20, 2018

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE REAR GLASS ABRUPTLY FRACTURED WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED. THE CONTACT PURCHASED THE VEHICLE ON MARCH 28, 2018 AT (DON WOOD CHRYSLER, DODGE, JEEP, RAM 58 WEST SECOND STREET LOGAN, OHIO 43138 740-385-5626). THE VEHICLE WAS NOT TAKEN BACK TO THE DEALERSHIP FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 170,732. *TT

NHTSA ID

11081974

Incident

Mar 29, 2018

Mileage

170,732 mi

VEHICLE LEAKS ON PASSAGENER SIDE.WHEN IT RAINS OR U RUN IT THROUGH THE CAR WASH WATER SOMETIMES RUNS BEHIND THE DASH UNTO THE FLOOR. WE HAVE TRIED TO FIND THE LEAK TO NO AVAIL. CARPET HAS FORMED MILDEW FROM THE LEAK. CANNOT GET THE CO. TO FIX OR TELL US WHERE THE LEAK IS.

NHTSA ID

11080750

Incident

Oct 20, 2014

Mileage

75,000 mi

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING 60 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE FUSE BOX LOCATED UNDER THE HOOD IN THE ENGINE COMPARTMENT BECAME OVERHEATED. THE FUSES WERE EXTREMELY HOT AND SMOKING. THE VEHICLE WAS TOWED BACK TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 189,863.

NHTSA ID

11060690

Incident

Jan 4, 2018

Mileage

189,863 mi

ON OR ABOUT DECEMBER 2017, A 2007 DODGE GRAND CARAVAN WAS TRAVELING NB ON THE INTERSTATE AND WAS HIT FROM THE REAR BY A LARGER VEHICLE. BOTH THE DRIVER AND FRONT PASSENGER WERE WEARING THEIR SEAT BELTS AND TRAVELING 50-55 MPH. AFTER BEING IMPACTED FROM THE REAR, THE VEHICLE SPUN 360 DEGREES. AFTER THE SPIN, THE VAN WAS IMPACTED DIRECTLY HEAD ON, IN THE FRONT, ON THE PASSENGER SIDE, BY A 4 DOOR SEDAN. THE AIR BAGS FAILED TO DEPLOY AND BOTH THE DRIVER AND PASSENGER SEAT BELTS FAILED TO LOCK THE OCCUPANTS TO THEIR SEATS. THIS SAFETY EQUIPMENT FAILURE ALLOWED SIGNIFICANT BODY MOVEMENTS OF BOTH THE DRIVER AND PASSENGER. IT CAUSED ABRUPT FORWARD AND BACKWARD MOTION OF THEIR HEADS, NECKS, BACKS, ARMS, LEGS AND TORSOS, RESULTING IN SIGNIFICANT PHYSICAL INJURY AND EMOTIONAL TRAUMA. THE DRIVER ACCOMPANIED THE FRONT PASSENGER TO THE EMERGENCY ROOM. PHYSICAL EXAMINATION AND X-RAY EVALUATIONS WERE PERFORMED BY A MEDICAL SPECIALIST. THE PASSENGER WAS DIAGNOSED WITH UPPER SPINE, HEAD AND NECK INJURIES WITH SIGNIFICANT MUSCLE PAIN AND SEVERE CONCUSSION. THE DRIVER HAD INJURIES TO HIS SHOULDER, NECK, KNEE, TORSO AND BACK AREAS WITH SIGNIFICANT MUSCLE PAIN. SUMMARY, HAD THE SEAT BELTS FUNCTIONED, AS WAS ADVERTISED AND DESIGNED BY THIS MANUFACTURER, BOTH PASSENGERS WOULD NOT HAVE SUSTAINED SUCH SEVERE PHYSICAL INJURIES, AND HAD THE AIR BAGS FUNCTIONED AND DEPLOYED, AS ADVERTISED AND DESIGNED, BY THE MANUFACTURER, THE DRIVER AND PASSENGER WOULD NOT HAVE BEEN INJURED IN THIS IMPACT-COLLISION. HISTORY, THE DODGE GRAND CARAVAN OF PAST YEARS DESIGN INCLUDING THIS 2007 MODEL YEAR HAVE HAD SIMILAR AND REPEATED REPORTS OF SEAT BELT AND AIR BAG FAILURE. CONCLUSION, THIS MANUFACTURER KNEW OR SHOULD HAVE KNOWN OF THESE SAFETY DEFEATS, FROM PAST SETTLEMENT LITIGATION. THIS MANUFACTURER ALLEGEDLY HAS FAILED OR REFUSED TO CORRECT THESE ALLEGED INJURY CAUSING VEHICLE SEAT BELT AND AIR BAG DEFECTS.

NHTSA ID

11056329

Incident

Dec 21, 2017

Mileage

134,121 mi

TL* THE CONTACT OWNS A 2007 DODGE GRAN CARAVAN. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR HAD BEEN ILLUMINATING ON AND OFF FOR APPROXIMATELY ONE MONTH. THE VEHICLE WAS TAKEN TO MACDONALD MOTORS AUTO GROUP DEALER IN BRIDGTON, ME THAT DIAGNOSED THE VEHICLE AS HAVING OCCUPANT RESTRAIN MODULE FAILURE AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED BUT THE WARNING INDICATOR KEPT ILLUMINATING. THE VEHICLE WAS DIAGNOSED AGAIN BY MACDONALD MOTORS AUTO GROUP DEALER AND WAS DIAGNOSED AS A SEAT SENSOR FAILURE. THE CONTACT PURCHASED A USED SEAT FROM A SALVAGE YARD. THE VEHICLE WAS REPAIRED, BUT THE WARNING INDICATOR WAS STILL ILLUMINATING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

NHTSA ID

11021471

Incident

Sep 5, 2017

Mileage

113,000 mi

CAR STALLS AND SOMETIMES DIES AFTER REFUELING. THIS ALWAYS HAPPENS AFTER PULLING ONTO ROAD INTO TRAFFIC. SO FAR I HAVE AVOIDED BEING HIT BY ANOTHER CAR! THIS HAS BEEN HAPPENING FOR A LONG TIME. DEALER SAYS REPLACE FUEL TANK,POOR DESIGN.

NHTSA ID

11000575

Incident

Jun 18, 2017

Mileage

95,000 mi

MY WIFE IS HANDICAPPED. I OWN A LOWERED FLOOR MINIVAN WITH A RAMP FOR WHEELCHAIR ACCESS. VANTAGE MOBILITY INTERNATIONAL ("VMI"), 5202 SOUTH 28TH PLACE, PHOENIX, AZ 85040, (602) 243-2700 DID THE CONVERSION OF MY 2007 DODGE GRAND CARAVAN TO MAKE IT HANDICAPPED ACCESSIBLE ("RAMP VAN"). DODGE/CHRYSLER ("DODGE") WORKS WITH VMI AND A DODGE DEALER IN TEMPE ARIZONA TO SELL RAMP VANS NATIONWIDE THROUGH A DEALER NETWORK. RAMP VANS ARE SOLD THROUGH LOCAL DEALERS WHO PROVIDE BOTH WARRANTY AND NON WARRANTY SERVICE FOR THE CONVERSION ELEMENTS OF THE RAMP VANS. LOCAL DODGE DEALERS PROVIDE NON-CONVERSION WARRANTY AND NON-WARRANTY SERVICE. IT IS NOT UNUSUAL FOR EACH TO POINT THE FINGER AT THE OTHER CONCERNING ELECTRICAL AND MECHANICAL PROBLEMS. THE DRIVER'S SIDE FRONT AIR BAG DOES NOT WORK PROPERLY. IT ONLY OPERATES INTERMITENTLY. IT HAS BEEN TAKEN TO BOTH VISION DODGE (920 PANORAMA TRAIL SOUTH, ROCHESTER, NY 14625, (585) 385-5700, AND AUTOCRAFTING 72 HINCHEY ROAD, ROCHESTER, NY 14624 ON SEVERAL OCCASIONS FOR REPAIRS TO THE AIRBAG SYSTEM. AUTOCRAFTING REPORTED THAT VMI WAS INVOLVED IN TROUBLESHOOTING THE PROBLEM. BETWEEN VISION DODGE AND AUTOCRAFTING THERE HAVE BEEN 3 OR 4 ATTEMPTS TO FIX THE AIRBAG PROBLEM TO NO AVAIL. VISION DODGE CHARGED ME SUBSTANTIAL COSTS FOR REPAIRS THAT DID NOT FIX THE PROBLEM. NEITHER DODGE NOR VMI HAS BEEN ABLE TO FIX THE PROBLEM. THE AIR BAG FAILURE AND THE INABILITY OF DODGE AND VMI TO FIX IT INDICATES A MAJOR DESIGN FAILURE IN AN ESSENTIAL AND LEGALLY REQUIRED SAFETY SYSTEM. THE AIRBAG SYSTEM GOES ON AND OFF WHILE BEING DRIVEN ON CITY STREETS AND HIGHWAYS AS REPORTED BY THE VEHICLE'S WARNING LIGHTS. WHOEVER IS DRIVING THE VEHICLE IS AT SERIOUS RISK OF DEATH OR INJURY SHOULD THE VAN BE INVOLVED IN AN ACCIDENT WITH THE AIRBAG NOT WORKING. OCCURRED 12/2015 AND FROM OCTOBER 2016 TO DATE.

NHTSA ID

10985501

Incident

Dec 29, 2015

Mileage

50,000 mi

WITHIN MINUTES OF FUELING, THE ENGINE WILL STALL CAUSING A LOSS OF STEERING AND BRAKES.

NHTSA ID

10960186

Incident

Mar 5, 2017

Mileage

82,000 mi

HEADLIGHTS AND DASH LIGHTS RANDOMLY SHUT OFF WHILE IV AM DRIVING DOWN THE HIGHWAY STRAIGHTAWAY IN THE DARK I MONKEY WITH HEADLIGHT SWITCH AND THE LIGHTS COME BACK ON. THIS HAS HAPPENED TO ME ABOUT 8 TIMES IN THE LAST YEAR. BUT RECENTLY IT HAS GOTTEN WORSE.

NHTSA ID

10957406

Incident

Feb 25, 2017

Mileage

156,000 mi

SEAT BELT LIGHT STAYS ON EVEN THOUGH THERE HAVE BEEN NO ACCIDENTS OR BAG DEPLOYMENTS.

NHTSA ID

10940294

Incident

May 1, 2015

Mileage

90,000 mi

CAR STALLS AFTER YOUR FILL THE GAS TANK THIS IS A KNOWN ISSUE WITH SEE CASE #66165038FL DOES SOMEONE HAVE TO DIE ? THIS IS A SAFETY CONCERN YOUR CAR COULD DIE IN TRAFFIC

NHTSA ID

10934701

Incident

Dec 1, 2016