2011 Dodge Grand Caravan Electrical Problems

The contact owned a 2011 Dodge Grand Caravan. The contact stated that while the vehicle was parked, turned off, and unoccupied, the front driver’s side of the vehicle near the driver’s door caught fire. The contact extinguished the fire. No fire or police report was filed. The front driver’s side of the vehicle was consumed by the fire. The contact believed the failure was due to an electrical malfunction located in the driver's door that caused the fire. The dealer was contacted. The vehicle was not diagnosed or repaired. The vehicle was towed to a salvage facility. The manufacturer was made aware of the failure. The approximate failure mileage was 200,000.

NHTSA ID

11733269

Incident

Mar 25, 2026

Mileage

200,000 mi

Odometer Fraud. The contact stated that while considering purchasing a 2011 Dodge Grand Caravan, the odometer mileage was 101,000 but the registration information indicated that in 2022 the odometer mileage was 125,000. The vehicle was a private sale.

NHTSA ID

11692544

Incident

Oct 10, 2025

Mileage

125,000 mi

V51 recall cause problems with power control module. Poor fuel economy Trouble starting/ restarting Engine not receiving power

NHTSA ID

11597511

Incident

Jun 17, 2024

The contact owns a 2011 Dodge Grand Caravan. The contact stated that while driving at an undisclosed speed, the vehicle suddenly stalled. There were no warning lights illuminated. The vehicle was repaired; however, the failure reoccurred. Additionally, the contact stated that the instrumental panel became inoperable. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ID

11597035

Incident

Apr 25, 2023

The contact owns a 2011 Dodge Grand Caravan. The contact stated that the engine turned over, but the vehicle failed to start. The contact became aware that the jumper ends were burned. There was no fuel entering the engine. The contact stated that the silicon on the relays needed to be replaced and the fuel pump had failed. Additionally, the driver's side window became inoperable. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 19V813000 (Electrical System). The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 160,000.

NHTSA ID

11595037

Incident

Jun 17, 2024

Mileage

160,000 mi

Dealership still cannot pinpoint exactly what is wrong but the car does not start. One time it’ll start and the next it won’t. It’s actually left me stranded in the cold because that seems to be the only time it won’t start. It’s happened to many other grand caravan owners too. No mechanic I’ve taken it to can solve the problem I’ve spent so much money replacing parts on this car.

NHTSA ID

11583251

Incident

Mar 24, 2024

Vehicle randomly dies completely like no battery connected either while parked or in motion. Then after a few moments vehicle starts like nothing is wrong. No codes no warning.

NHTSA ID

11542324

Incident

Aug 27, 2023

My van caught fire. Randomly after not being driven for more than 15 hours. The investigator says it is believed to be the inverter in the back drivers side panel under the cup holders which short circuited and caught fire which engulfed my entire vehicle in a mater if 40 minutes while waiting for the fire department to arrive. The van is obviously a goner. Burnt to a crisp along with all of our DeWalt power tools batteries fishing poles tackle chainsaw and 4 brand new car seats that were just purchased with the last 2 months. Along with cracking all the windows on that side of my home due to the heat from the blaze...

NHTSA ID

11527347

Incident

Jun 15, 2023

The TIPM failed which caused a loss of power to the vehicle and power to the fuel pump. I was driving at approximately 60 MPH when the vehicle lost all power and the steering wheel felt locked. I was unable to turn the steering wheel as the Dodge Grand Caravan came to a quick stop as if it was out of gas. Luckily I reacted quickly and was able to avoid an accident. After approximately 10 minutes of trying to restart the vehicle and drive to a safe location the vehicle restarted. This happened again when I was driving and came to a red light at a major intersection and the vehicle stalled out as if out of gas and the steering locked. I again tried to restart the vehicle intermittently for 15 minutes; after which it finally restarted, and I was able to drive and get out of the intersection without an accident. I was lucky that this didn't cause an accident. The other times the defective TIPM and power to the fuel pump caused the vehicle to fail to start and left me stranded. I have had the vehicle diagnosed and the TIPM repair price is quite expensive. The vehicle did not have any check engine or warning lights before this occurred. I have read many similar complaints of this occurring with others driving Dodge/Chrysler vehicles. I feel that there is evidence that the TIPM and the fuel pump on the 2011 Dodge Caravan are safety concerns. Every experienced mechanic I have spoken with is aware of the common issue with the TIPM, and power to the fuel pump and vehicle. Although I avoided an accident there is a concern for everyone's safety.

NHTSA ID

11525717

Incident

Mar 31, 2023

The contact owns a 2011 Dodge Grand Caravan. The contact stated while driving 45 MPH, the battery warning light illuminated. The contact was able to continue driving to his residence. The contact inspected the vehicle and noticed that the alternator was burned and needed to be replaced. The contact towed the vehicle to the local dealer however, the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 99,938.

NHTSA ID

11521320

Incident

Apr 10, 2023

Mileage

99,938 mi

Hi. The heater turn on and off without me touching the button to turn it on this problem is very annoying I almost had a accident due to this annoying problem. I drive a 2011 dodge grand caravan crew. This problem started 2 months believe me is very annoying problem. Need to recall this problem fix it asap. Thanks.

NHTSA ID

11510819

Incident

Feb 1, 2023

New battery is dead after sitting for a week or more. Has happened several times…

NHTSA ID

11494282

Incident

Nov 18, 2022

This vehicle always fails to start in the colder weather. After a review of this condition. It has been found that the fuel pump relay does not send proper signal. This relay is a part of the Totally Integrated Power Module (TIPM). When it fails to operate, the vehicle will experience long crank times. With its ignition switch style, as soon as you turn the key, the vehicle will continue to crank UNLESS you manually turn the switch all the way back to the off position. This condition will cause the starter motor to overheat or burn up. Eventually the vehicle may start then die. Fuel delivery is too inconsistent when colder weather arises. You can't just replace a plug-in-style replacement fuel pump relay since it is a part of the whole TIPM. This vehicle has not yet died in traffic or on the highway thank God. There is never any CEL illumination or any stored fault codes. It started doing this the first winter I bought it. This is my second year and it's only just Fall and it is acting up again. This is a KNOWN issue among these TIPMs that are on more than just this vehicle but many other Dodge/Chryslers with this same TIPM. Someone needs to take accountability for a faulty product that needs redesigned before these issues continue to affect the consumers that trust in their product. I hope that this issue is addressed and resolved before others continue to complain about vehicle faults, or even worse experience any catastrophic conditions resulting in death of consumers based on this faulty TIPM, that controls most aspects of the whole vehicle.

NHTSA ID

11491408

Incident

Nov 15, 2021

Vehicle windows intermittently would roll down on there own and car horn would beep, than vehicle intermittently would not start engine would just shut off. Vehicle, stalls when in gear and wouldn't restart. Replaced, TIPM vehicle seemed to go back into normal operation for few minutes than TIPM faulted again. I understand, NHTSA has investigated this issue with Dodge Caravan and needing to recall faulty TIPM.

NHTSA ID

11470200

Incident

Jun 13, 2022

Car starts intermittently especially when In colder conditions takes 3 to 4 starts , hard to start , put in neutral and starts right away ,car feels like it’s going to stall out when accelerating at times

NHTSA ID

11451642

Incident

Feb 12, 2022

My car was fine until one day in rain the whole dash and radio shut off and came back on repeatedly, spedometer bouncing each time. Took it to dealer/JDByrider and "they dont know prob/happens all the time" w a very "oh well" attitude. They did nothing. I called again when car ALSO started shutting completely off at long red lights. I was told next appt available would be 23 days! Thats still 4 days away. NOW in addition to dash/radio/spedometer problem the van doesnt just die at LONG lights, it dies if I have to stop for drive thrus, stop signs, short lights. The headlights have also started flickering very very badly. Im upset that repairs are supposed to be covered by JDByrider and theyve had me driving this dangerous car for almost a month before trying to fix it. Im not allowed to get work done on it elsewhere or else it makes future repairs on parts not covered by JDByrider. I have 4 kids and this car is not safe on road and Im literally not allowed to get someone else to fix it if I want it to continue to be covered by JDB. JDB blames Dodge. My car purchase was supposed to cover repairs and instead Im being forced to drive 4 kids around in car dealer cant fix and they claim Dodge dont know how to either. I should have never been expected to wait almost a month for this to be addressed.

NHTSA ID

11441091

Incident

Oct 21, 2021

DRIVING AT ABOUT15 M.P.H. I HAD TROUBLE STEERING AND NOISE WAS COMING FOR UNDER THE HOOD, I PULLED OVER AND I LOOK UNDER THE CAR IT WAS LEAKING LOTS OF OIL. I HAD IT TOWED TO THE DEALER,THE PROBLEM WAS A HOLE IN THE TUBING ON THE RACKEN PINEN STEERING .IF IT WAS ON A HIGHWAY OR ON A FASTER ROAD IT WOULD HAVE BEEN A VERY BAD ACCIDENT WITH OIL LEAKING AND COULD NOT STEER THE VAN. I WAS VERY VERY LUCKY.THERE WAS NO WARNING LIGHT. I HAVE A PICTURE OF THE HOLE. I REPORTED TO CHRYSLER. Consumer stated metal that was replaced rusted.

NHTSA ID

11432932

Incident

Sep 25, 2020

Battery light turned on and vehicle immediately shut off. Got car jump to make it home and all electrical components went hay wire - all dash lights blinking - transmission wouldn’t not shit and accelerated by itself, headlights wouldn’t go on, windows wouldn’t go down. Dodge recalled every other car model in their line for a bad ALTERNATOR rapid failure, except Caravan, which should absolutely be included. It’s a know issue - car shouldn’t be dying while driving with under 100k miles.

NHTSA ID

11431864

Incident

Sep 4, 2021

It started a few months ago with my van not starting properly. After being stranded multiple times & it stalling once while driving, I had my mechanic check multiple issues we assumed the fuel pump was going bad. Nearly $600 later and a new fuel pump the issues continued until today when it is now dead! After searching I found 2010 and older models of my van were recalled for this EXACT issue, just not 2011! I don’t have the money to fix it and am pissed that while it’s the same problem it is not covered in the recall.

NHTSA ID

11431155

Incident

Aug 31, 2021

Vehicle shakes, dash lights flash on an off, doesn't want to accelerate, check engine light flashes occasionally. Mechanic has run diagnostic tests, the only code the vehicle is showing is oil pressure.

NHTSA ID

11425394

Incident

Jul 18, 2021

purchased van no problem mechanic gave great review following week wouldnt start mechanic said tipm is bad we had tipm rep[laced already 3 times and now its bad again this time i was with my family when van completly shut off on highway doing 70 miles a hour we have to carry a jumper battery pack with us to start van i called crysler and they informed me there is no problems with my vans tipm well thats funny google has over 45 thousand articles about these problems and nobody does anything about it till people die

NHTSA ID

11422425

Incident

Jun 25, 2021

The contact owns a 2011 Dodge Grand Caravan. The contact stated while driving at various speeds, the vehicle stalled without warning. The contact stated that several electrical failures had occurred on the vehicle while the vehicle was turned off. The failures included the sliding doors independently unlocking and opening without warning or input. The contact also stated that the safety alarm would sound independent while the power windows rolled down independently while the vehicle was turned off. The contact had the vehicle towed by a dealer and was informed that the Totally Integrated Power Module (TIPM) was defective and needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 160,000. Consumer is still having issues with the vehicle.

NHTSA ID

11419965

Incident

Oct 1, 2020

Mileage

160,000 mi

Van has stalled and quit while at intersections and while driving on busy hwy. Have had looked at and seems that the TIPM is the problem. Same as many over vehicles that was recalled for this same reason suck as the Jeep Cherokees. VERY DANGEROUS for it to stall and quit in the middle of traffic, almost been rearended due to the stalling and hit at intersection due to it cutting off completely. Accident wating to happen and have someone be badly injuried or killed. This needs to be addressed and recalled ASAP. Dealership looked at this and stated the same. Please investigate and take correct steps on getting this fixed/recalled before someone is killed.

NHTSA ID

11418763

Incident

May 25, 2021

CAR SHUTS OFF WHILE DRIVING. SOMETIMES WON'T START BACK UP. ISN'T RUNNING WELL. MOST LIKELY THE TIPM, WHICH SEEMS TO BE A BIG ISSUE FROM WHAT I'M FINDING WITH DODGE CARAVANS.

NHTSA ID

11415658

Incident

May 4, 2021

Mileage

50,000 mi

I WAS DRIVING ON THE ROAD AT ABOUT 30 MPH GOING STRAIGHT (WITH MY WIFE/KIDS) AND THE CAR JUST TURNED OFF COMPLETELY. THERE WAS NO ELECTRICAL, NO PROPULSION, POWER STEERING WENT OUT. THE ELECTRICAL BLINKED ON AND OFF A COUPLE TIMES LIKE IT WAS TRYING TO COME BACK ON BUT I HAD TO PULL OVER (LUCKILY WE WERE ON A RURAL ROAD) AND TURN THE CAR OFF AND BACK ON.

NHTSA ID

11414748

Incident

Apr 30, 2021

Mileage

110,000 mi