Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 51 NHTSA owner-reported complaints for the 2024 Dodge Hornet PHEV. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 51 · page 1 of 3
Just 5 minutes after starting the drive, the 'Limp Mode' warning light illuminated, and the accelerator pedal became completely unresponsive. The vehicle decelerated rapidly and came to a sudden stop in the middle of an intersection, putting me in a highly dangerous situation. Furthermore, I pressed the emergency SOS button, but it failed to function entirely.
The contact rented a 2024 Dodge Hornet from Avis Car Rental. The contact stated that while starting the vehicle, the message "URGENT SAFETY RECALL - Your vehicle has an urgent safety recall: NHTSA Recall Number 24V752000 (Service Brakes, Hydraulic), Collapsed Brake Pedal - Call Customer Care or the Dealer to Schedule Repair" was displayed. The contact stated that while driving at an undisclosed speed, the brake pedal was firm while depressed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The contact emailed Avis Car Rental about the recall and the failure. The failure mileage was approximately 40,000.
Tail light bar fractured spontaneously without any external physical impact due to structural over-tightening at the factory, creating a risk of water intrusion that can short out required FMVSS rear lighting. What the data shows is that this isn't a random occurrence — it's a known manufacturing and installation defect. If you look at the accounts from dozens of owners on places like Reddit and Hornet forums, they describe identical failures across the board. Here is the breakdown of why so many people are running into this exact problem: 1. The Real Cause: "Over-Torque" From the Factory The most eye-opening discovery from owners who have dealt with this multiple times is that the cracks are usually mechanical, not environmental. When the "racetrack" light bar is installed at the factory, the securing bolts are often tightened too far down. This leaves virtually zero gap between the plastic light assembly and the metal car body. As you drive, hit bumps, or slam the rear liftgate, the light bar literally smashes against the vehicle's body panels, causing the plastic to buckle and fracture under the stress. 2. Spontaneous Hairline Fractures Many owners report walking out to their driveway to find massive spiderweb cracks along the top edge of the light bar, despite swearing they never backed into anything. The tension on the plastic is so high that temperature changes (like going through a cold car wash on a hot day) are enough to spontaneously trigger the fracture. 3. The Secondary Nightmare: Water Traps Once the plastic casing gets that hairline crack along the top edge, rain and car wash water seep right into the lens. Because the assembly is sealed tightly, the water gets trapped inside, causing: Condensation that can short out the racetrack LED segments. Delamination, where the water forces the internal tint film to separate from the plastic, making the crack look much wider and worse over time.
On [XXX] the electrical system on the 2024 Dodge Hornet R/T malfunctioned and all warning lights were simultaneously flashing on the screen and all driver safety warnings malfunctioned. There was loss of Power Steering Assist while driving the car as well as an Electronic Parking Brake malfunction.. It is unknown what other specific electronic safety functions failed as well but the complete system was severely malfunctioning and all warning lights displayed simultaneously. The car was brought in for service May 30, 2026, at Westbury Chrysler Jeep Dodge Service Center located at 111 Bond Street, Westbury, NY 11590 to repair the electrical system. On June 10, 2026, the car was ready for us to pick up. It was driven back to our house (a 30 minute drive) with no incident and was used by my wife this morning, on. June 11, for her short commute to work. [XXX], my wife started the Hornet and the same electrical problem occurred with the same safety issues. This electrical failure occured within 24 hours of receiving the car back from the service center. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
At approximately 11:00PM on April 24, 2026 I received a phone call from a neighbor telling me that my car was on fire. I went outside and the car, which was parked in the driveway, was pouring out smoke and making popping noises. We called the fire department and watch from a safe distance. The smoke and popping got worse another were large flares or jets of flame visible. The fire department attempted to contain the fire but the priority was our house. After multiple attempts to put out the fire the fire fighters used a specially manufactured blanket to aid in keeping the fire from spreading. The fire burned for roughly 3-4 hours before burning itself out.
This involves a rental from AVIS at Orlando International Airport that I picked up on the 24th of March. I drove up to Palm Coast, as that journey progressed I began to notice that turning the steering wheel, either right or left the beginning of that motion had no effect on the direction of the car, which meant you had to turn the wheel further than you would normally that gave the driver a lack of confidence in the steering. This got progressively worse over the next couple of days, so I investigated to see what was wrong. It took me a little over one minute to find the pinch bolt in the knuckle joint, where the steering column joins to the steering rack, was completely missing. Realising how dangerous this was, I contacted AVIS, who asked me to drive the car some 30 miles to their nearest depot/office, which I declined to do, telling the vehicle was dangerous in it's current condition. They brought a replacement car on a recovery lorry and took the first car away. I told the driver that the car he was taking should not be put on rental until the issue was sorted.
Have been, unsuccessfully, attempting to get my vehicle repaired under Safety Recall Notice 25V-246 for almost 1 year. Today was my fourth attempt. I do not believe the manufacturer is making a good faith attempt to rectify a built in defect with my car.
The contact rented a 2024 Dodge Hornet. While driving 50-75 MPH, the vehicle made an abnormally loud sound, and the steering wheel was not turning as intended. Additionally, the steering wheel and the front axle were not responding as intended, and constant adjustments were needed; the contact had to grip the steering wheel tightly. The contact stated that the failure increased while turning the steering wheel. The vehicle was driven back to the rental agency. No further information was available. The failure mileage was approximately 48,025.
While commuting to work, my vehicle’s dashboard illuminated with the indicators for both the engine and hybrid electric systems. Subsequently, the vehicle began to hydroplane across lanes into the median, rendering it impossible to regain control. prior to the incident, my electrical system on my dash been flickering and blacking out Random occasions for the past weeks
Since delivery, the Adaptive Cruise Control (ACC) system intermittently fails without warning while in motion. The system frequently displays an "Unavailable" message, particularly during stop-and-go traffic at speeds around 20 mph. This sudden deactivation occurs with no prior audible or visual alert, leaving the driver with dangerously limited time to manually intervene and avoid potential rear-end collisions. Attempted Repairs: The vehicle has been to the dealership service department multiple times for this specific issue. While technicians acknowledge the system failure and have documented the error, they stated there is currently no functional repair or software fix available from the manufacturer. The safety risk remains unresolved.
I am filing this complaint due to repeated and dangerous electrical and hybrid system failures in my 2024 Dodge Hornet, which have resulted in sudden loss of acceleration, loss of braking performance, dashboard warning lights, and system malfunctions while driving. The vehicle has been serviced multiple times at Meadowland of Carmel Chrysler/Dodge/Jeep/Ram with the following documented incidents: • Check engine light and loss of acceleration on highway – Vehicle would not accelerate while driving on the highway. • Repeated highway loss of power – Vehicle drops speed while driving and will not accelerate, requiring me to pull over and shut the vehicle off to regain acceleration. • Battery/Hybrid system malfunction – Vehicle experienced abnormal battery percentage drops and required multiple software flashes and reprogramming of PCM, hybrid control processor, and transmission control modules. • Grinding noise from engine with complete loss of acceleration – Vehicle had to be towed. Dealer found active hybrid generator performance code (P0A92). The motor generator unit (MGU) was found to have failed and required replacement. • All dashboard warning lights illuminated / Drive mode unavailable message – Vehicle would not accelerate and multiple control modules required flashing and updates. • Brake pedal went soft – Loss of normal brake pedal feel was reported. • Electrical communication faults – Stored codes for lost communication with AC compressor control module and cabin air heater module. • Frozen backup camera (intermittent issue not always replicated at dealer) – Rearview camera screen has frozen while reversing, creating risk of collision. The most serious safety concern is the repeated loss of acceleration while driving at highway speeds, forcing me to pull over in active traffic. Additionally, the soft brake pedal and electronic failures raise concerns about braking reliability. These failures create a serious risk of crash or injury to myself and others.
The Center Display Screen on about 18,800 of the above vehicles may have been built with a defect, which may result in the rearview image not displaying in a backing event. A rearview image that does not display reduces the driver's view of what is behind the vehicle. A blank screen will appear in place of the rearview image. If the driver does not heed the blank screen warning and fails to otherwise make sure it is safe to operate the vehicle in reverse, a vehicle crash can occur.
Anytime it is cold out, there is an issues with the doors not closing. Today it us 4 degrees out and I was able to get the doors closed. As I was driving down the road I live on the door popped open. I stopped, opened the door shut the door and locked it. I proceeded to drive a little more and it happened again. I again stopped and opened the door and shut and locked it again. I turned around to go back home and it did it a third time. I stopped and shut it, locked it and started to drive. This time I went around a ben and the door flew open. I am a member on a Facebook group of other Hornet owners and ther is an ongoing issue with the doors not closing when it's cold. Its a huge safety issue! I am scared to drive this car in winter, it's not safe.
-Blank screen -When driving sound rough and feels like it’s shifting -Navigation takes me obviously wrong directions -would not start a couple of times and had to tow to dealership ***I feel very unsafe to drive the car with the current safety recalls***
We had a sudden heavy wet snow that accumulated a couple inches on the roadway. This made the roadway very slippery. The vehicle could not be driven safely. Upon lifting my foot off the gas pedal, the rear wheels would enter regenerative braking and cause the rear wheels to skid (no matter the drive mode or speed down to less than 5 mph), leading to fishtailing and no ability to control the vehicle. The only way to operate the vehicle without extreme risk was to immediately put the vehicle in neutral as I lifted my foot off of the gas pedal to decelerate or when going down hill. Otherwise you would immediately go into an uncontrollable skid. I researched the problem extensively. There is no way to disable the regenerative braking. With the design of this vehicle, if you cannot disable regenerative braking for slippery conditions, the vehicle cannot be safely operated. This vehicle cannot be safely driven on winter roadways. Dodge should add the ability to turn off regenerative braking. Lives are at risk. I queried Grok AI and it explains the problem and lack of a resolution quite well. Question: Is there a way to turn off the regenerative braking on a 2024 Dodge Hornet R/T Plus plug in hybrid to allow for safe driving on slippery roads? Answer: The 2024 Dodge Hornet R/T Plus is a plug-in hybrid (PHEV) based on the Alfa Romeo Tonale platform, featuring regenerative braking as a standard part of its hybrid system. This recaptures energy during deceleration to recharge the battery. From official Dodge sources, reviews, and owner discussions, there is no user-selectable option to completely turn off or disable regenerative braking in the Hornet R/T PHEV. It is integrated into the powertrain and operates variably depending on the drive mode. No sources indicate a hidden way to fully disable regen without aftermarket modifications (which could void warranty or affect safety systems). The design prioritizes efficiency and performance over a full "off" switch.
we had to have our dash harness replaced due to an electrical short, the USB would not power on, they replaced the usb and it immediately fried due to the short. This is not a one off incident apparently. There are a few posts on the owners forum about harness issues, extreme parasitic draw, and even a few vehicle fires [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Heavy vibration/ shaking felt in steering, floorboard, seats and all. I purchased this car February 14, 2025 and reported this within 24 hours of be driving the car home. I was told it most likely was due to the car sitting on the lot for over 300 days. First took car back for them to assess 3 days after purchase. I was told to drive it and put 500 miles on it and see if it self corrected. It did not. I have 9,400 miles now and nothing they have done as resolved it. It is getting worse. I cannot drive the car on a long trip and do not feel safe driving it. I have had the car in the shop over 5 times. I initiated a support ticket with the main Stellantis Corp the last time it was taken in. I was assured they would have a Technical Advisor work with the dealership on the issue. Car was there over 3 months just the last time it was there. They put new tires and brakes on it and it did not resolve the shaking and vibration issues. Now the issue can be felt at lower speeds like 40MPH and is worse at 72 to 75. I contacted them after picking my car up last time and spoke to a different agent who asked me to schedule and appt with the service dept once again and they would have a Tech Advisor work with them. I reminded him that was what was supposed to happen the last time and did not. My safety and the safety of others are my main concern. Merging is difficult to feel comfortable doing because of this issue. I am a nervous wreck thinking this may cause an accident harming myself or others but they do not care.
Driving on the highway at 75 mph, slowing down to 55mph exiting the highway by braking manually, gently. The car started juddering slightly, we assumed it was the road and carried on, then the car following us started to flash for us to stop, we did, got out and all 4 wheels / brakes were on fire, we put them out and carried on driving assuming the brakes would be ok, but we had not put any other kind of brake on except the brake pedal. Then this past weekend a mechanic was trying to move the car and moved it only 5 ft before the brakes all came on and jammed the car. I have no files to upload as the car is currently with a Dodge dealer and they are inspecting it.
I purchased a 2024 dodge hornet RT February of 2025. Since purchasing the vehicle, I now have had issues where my breaks are screeching so loud that it is heard from my camera inside my house and blocks over from my street. I tried to address this issue with the Sterling Kunes location and they said nothing is wrong and offered to put a desqeak on it and they never did when they fixed my recalled screen. I also contacted the Belvidere Kunes location to get my car in because my car would randomly shut off when parked when I pick up my child from school. I told them it was a severe safety concern and it has been 2 months with no call from the Belvidere, IL location to get my car seen! Now my fuel door is randomly opening on its own. The dealerships will not help me and I have the numbers saved to show how many times I have tried to call them! Receipts of taking it in! And no one is doing anything. When I try to break, sometimes my car speeds up rather than breaking like it should and I then have to put my car in sport mode to get my car to slow down faster before an accident is caused. I have children! And no dealership is willing to fix these issues!
I purchased this vehicle in December of 2024 at 37 miles on the car. The car shut down three times on me due to electrical issue, but the dealership said it was the battery and the electric, i have invoices for all of the visits. i didnt feel safe driving the vehicle so i let the car sit and rented through Turo. Recently in October, there was a loud squeek sound and vibration coming from my brake, it was so loud, and i can feel the vibration. I didnt want to drive my car. Took my car to the Folsom CDJR dealership to get service. Car was returned to me, squeeking noise went away, but now im hearing squeeling sounds from my front and rear brake when my car is on reverse or neutral and im steering my wheels left to right. So I bring th3 car back in for service the following day and told them my concern. The car stayed in the shop for another 3 days just for them to bring my car back to me with the squeeking sound coming back. The advisor told me that it was a normal sound but I told them no it's not, he kept saying it's the rain..etc Its the same squeeking sounds that I brought the car in service for. So the car stays, the car was returned a couple more days, theres still sounds and vibration coming from the brakes. Now they are telling me that the regenerative braking system that use to work when I first bought the car that it doesnt work and Sacramento cdjr is saying that it only charges 1% over where it's at. All false. (They also mention that there were a recall and that they needed to reprogram the car but we never got a letter or notice for it). Folsom CDJR also said they resurfaced the rotors, but when the car was returned to me they were all rusty rotors. Also the fuel meter gauge started jumping up and down, and fuel burning faster then before. Things were were not normal after the services. They are saying that they cant duplicate the issue, but when I took it to an independent shop, they notice the problem and also said that I have an electrical issue still.
While in reverse vehicle automatically switched to drive forward mode and then reverse mode and kept alternating where the car would drive forward and reverse back on its own without the gas pedal pressed. The transmission was in reverse the entire time. Also, the vehicle keeps having electrical issues throughout the car, has been in repair for over 15 days combined. The electrical system reboots while the vehicle is turned on and the battery does not charge, instead it throws a fault. Have a video that was provided to the dealership with the reverse issue. Cant upload since it is not an accepted file type.
Upon purchasing the vehicle on September 26th, 2024, my brand new Dodge hornet started experiencing critical failures between the gas engine, the hybrid electrical system, and various safety features in the vehicle. At just 1,800 miles, the vehicles auxiliary coolant pump needed to be replaced along with several other components within that system. The vehicle was at the dealership for 2 months for the repair. Shortly after that, there is electrical systems started to malfunction including the blind spot monitoring system and other safety features. A few months ago, the entire engine blew and needed to be replaced. It was in the shop for over a month for that and the day after I got the vehicle back, it experienced more electrical failures causing the car to brick. The car has been in the shop for a few weeks now with no root cause provided. This vehicle, meets all of the Lemon Law criteria. Also, just a few days before the electrical system failed, the headlights went out while I was driving at night. This was actually the second time this happened. The dealership said they couldn't find any issues the first time but I am waiting to hear what they discover with it now. With the headlights shutting off in the middle of the night, I was unable to see the road ahead of me and almost crashed into a car in front of me. All of these issues have put my son, my friends and myself in danger. Dodge has been having consistent problems with their electric vehicles including their plug-in hybrids over the past 2 years and many of them are still sitting in dealerships bricked. Various recalls have already been issued for the Hornet although none seem to pertain to the powertrain or the hybrid system
The contact owns a 2024 Dodge Hornet. The contact received notification of NHTSA Campaign Number: 25V246000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
The contact owns a 2024 Dodge Hornet. The contact stated that while reversing, the back-over prevention display failed to function as intended. The contact stated that the back-over display screen displayed a black screen. The contact stated that because of the failure, the contact vehicle crashed into another vehicle. The contact stated that it was a minor crash. The vehicle was towed to an independent mechanic for damage repairs. The dealer was made aware of the failure. The contact received notification of NHTSA Campaign Number: 25V246000 (Back Over Prevention). The vehicle was taken to the dealer; however, the contact was informed that the parts were on back order. In addition, the contact stated that parts were on back order for two months and were still unavailable. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 5,100.
The automatic cruise control will suddenly stop working and I’m not sure why. At first I thought it was only because of glare into the radar camera, but I’ve noticed even when conditions are cloudy it still happens. The dash lights up and claims the radar is obstructed and will disengage all of the forward safety features instantly… this doesn’t seem good and it can be very alarming at times.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .