2007 Dodge Ram 2500 Powertrain (other) Problems

The contact owns a 2007 Dodge Ram 2500. The contact stated that it was difficult to shift the gear shifter out of park(P). The vehicle was taken to a dealer, where it was discovered that the vehicle could be shifted out of park(P) without depressing the brake pedal. The contact was informed that the brake transmission shift interlock (BTSI) had failed. The contact researched the failure and stated that millions of similar vehicles were included in a recall for the BTSI; however, the year and VIN were not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 59,242.

NHTSA ID

11731481

Incident

Apr 15, 2026

Mileage

59,242 mi

Engine died and would not start... while driving in traffic causing a near crash and blocking traffic..Problem confirmed to be the ECM, and confirmed to be faulty by Dodge Dealer and the Cummings repair factory and not repairable..did not see or hear any warning..

NHTSA ID

11442895

Incident

Oct 16, 2021

VEHICLE CUTS OFTEN WITHOUT ANY INDICATION THAT ANYTHING IS WRONG. IT DOES IT ANY SPEED AND THERE IS NO POWER STEERING, NO BRAKES. THIS HAPPENED THE FIRST TIME AT FREEWAY SPEED AND NEARLY CAUSED A REAR END COLLISION BECAUSE OF THE SUDDEN AND NEARLY UNCONTROLLABLE STOP.

NHTSA ID

11098443

Incident

May 25, 2018

Mileage

140,000 mi

FAILURE TO HONOR WARRANTY. 2007 POWER WAGON WAS ADVERTISED AS LIFETIME POWERTRAIN LIMITED WARRANTY (ATTACHED). PURCHASED TRUCK NEW FROM DEALER 1/15/08. 7/18/13 DEALER REPAIRED LEAKING DRIVE PINION OIL SEAL COVERED BY WARRANTY. 10/18/13 TRANSFER CASE MALFUNCTIONS WONT STAY IN 4X4 AND POPS INTO NEUTRAL WHEN CLIMBING HILLS OFF-ROAD CAUSING LOSS OF POWER. DEALER REFUSED TO HONOR WARRANTY. SAID WARRANTY COVERAGE CODE 803 INDICATED I DIDN'T HAVE A FREE 5 YEAR INSPECTION OF COVERED ITEMS. 4/19/14 REAR DIFFERENTIAL LOCK LIGHT MALFUNCTIONING WHILE DRIVING ON HWY. DEALER REFUSED TO HONOR WARRANTY. DEALER CLAIMED CORPORATE NOTIFIED ME OF REQUIRED INSPECTION. I ASKED FOR PROOF OF NOTIFICATION AND IT COULDN'T BE PROVIDED. I CONTACTED CHRYSLER DISPUTE RESOLUTION CENTER AND WAS TOLD THE DEALER WAS SUPPOSED TO INFORM ME OF THE NEEDED FREE INSPECTION TO CONTINUE LIFETIME WARRANTY. I ASKED FOR PROOF THAT I HAD BEEN NOTIFIED AND WAS TOLD THAT I HAD NO PROOF THAT I WASN'T NOTIFIED AND THAT THE LIFETIME WARRANTY WOULDN'T BE HONORED. THOUSANDS OF DOLLARS IN REPAIRS NOW FOR ITEMS COVERED UNDER LIFETIME WARRANTY.

NHTSA ID

10816650

Incident

Apr 19, 2014

Mileage

54,829 mi

2000 MILES AGO AS I WAS DRIVING DOWN THE FREEWAY THE TRUCK BEGAN TO PULL TO THE RIGHT AND HANDLED AS IF THERE WAS SOME BROKEN LINKAGE OR STEERING BOX WAS FAILING. AFTER INSPECTING AND NOT FINDING ANYTHING WRONG, I CONTINUED MY TREK HOME AND COULDN'T COMFORTABLY GO ABOVE 30 MPH, IT ALMOST FELT LIKE HALF OF THE FRONT AXLE WAS LOCKED IN 4WD. SEARCHED ONLINE AND SAW THAT SEIZED REAR BRAKE CALIPERS ARE NOT UNCOMMON SO I REPLACED THE ROTORS, CALIPERS, AND PADS. MADE SEVERAL SHORT TRIPS AND THOUGHT IT WAS RESOLVED. DURING A 1 HOUR DRIVE THE PROBLEM RETURNED AND I WAS UNABLE TO CONTROL VEHICLE AND STOPPED TO INSPECT. THE BRAKES WERE NOT HOT BUT THE REAR AXLE WAS BINDING BADLY, I LIMPED THE TRUCK HOME, AFRAID TO DRIVE IT AGAIN. AS I HAVE BEEN DOING RESEARCH ON THE PROBLEM, THE INTERNET FORUMS REVEALED MANY PEOPLES STORIES ABOUT DODGE RAM AXLES "LOCKING/SEIZING" WHILE DRIVING DOWN THE FREEWAY CAUSING ACCIDENTS AND ROLL-OVERS. JUST THOUGHT YOU MIGHT WANT TO LOOK INTO IT. THANKS, SIGNED AN IMMACULATELY CARED FOR AND BROKEN DODGE RAM :( UPDATE 9/15/15*CW AFTER REPLACING THE REAR CALIPERS, PADS AND ROTORS THE PROBLEM PERSISTED. PULLED REAR DIFFERENTIAL COVER AND INSPECTED RING GEAR, PINION, SPIDER GEARS AND BEARINGS. EVERYTHING IS GOOD. FINALLY AFTER REPLACING ALL THE REAR BRAKES LINES THE PROBLEM WAS SOLVED. UPDATED 09/29.15*JB

NHTSA ID

10743671

Incident

Jul 25, 2015

Mileage

78,650 mi

REFERENCE THE BELOW COMPLAINT, AND OTHERS: DATE COMPLAINT FILED: 03/02/2015 COMPONENT(S): POWER TRAIN , SUSPENSION DATE OF INCIDENT: 10/01/2014 NHTSA ID NUMBER: 10691476 DRIVING APPROXIMATELY 50 MPH ON WINDING TWO LANE COUNTRY ROAD, WHILE EXECUTING CURVE TO RIGHT, AFTER PASSING OVER A SLIGHT BUMP IN THE ROAD, FRONT SUSPENSION ENTERED WHAT IS COMMONLY CALLED A " DEATH WOBBLE". STEERING QUICKLY BECAME INEFFECTIVE, BRAKING WAS DIMINISHED DUE TO LOSS OF FIRM CONTACT BETWEEN FRONT TIRES AND ROAD SURFACE. WOBBLE IS REGENERATIVE IN THAT IT CONTINUES TO GET WORSE UNTIL VEHICLE SPEED IS REDUCED TO 15-20 MPH. I WAS UNABLE TO PRECISELY CONTROL DIRECTION OF TRAVEL, CROSSING INTO ONCOMING LANE BEFORE REDUCING SPEED ENOUGH TO REGAIN CONTROL. VEHICLE SHAKES SO BAD AS TO DISLODGE ITEMS FROM THE DASH AND CONSOLE POCKETS. THIS EVENT REPEATED SEVERAL TIMES AT A PARTICULAR SPOT ON MY WAY TO WORK, WHERE THERE WAS AN IRREGULARITY IN THE ROADWAY ON A STRAIGHT SECTION OF PAVED TWO LANE ROAD. BEHAVIOR WAS THE SAME AS DESCRIBED ABOVE. THE LAST EVEN WAS WHILE PULLING A TWENTY TWO FOOT TRAILER ON A MAJOR INTERSTATE, WHILE NEGOTIATING A RIGHT HAND CURVE ON A DOWN HILL MERGE LANE AT FREEWAY SPEED OF APPROXIMATELY 60-65 MPH. AGAIN I WAS UNABLE TO MAINTAIN MY LANE OF TRAVEL AND A CRASH WOULD HAVE RESULTED IF ANY OTHER TRAFFIC HAD BEEN NEAR ME! DEFINITELY A SAFETY ISSUE! LOCAL DEALERSHIP ASSURED ME A NEW STEERING DAMPER WOULD CURE THE PROBLEM. (IT DIDN'T) I EVENTUALLY FIXED THE PROBLEM MYSELF BY RESEARCHING WHAT OTHER OWNERS HAD DONE ONLINE (THERE IS A LOT OF INFO ON THIS ISSUE!), AND REPLACING THE PITMAN ARM, DRAG LINK, TIERED, AND ADDING A STEERING SHAFT STIFFENING BRACE. THE DRAG LINK, TIERED AND TIERED ENDS WERE A MOPAR PART KIT. MUCH HEAVIER CONSTRUCTION THAN THE ORIGINAL PART. RESPONSE TO A KNOWN ISSUE? THIS ISSUE MAKES THE TRUCK NEARLY UN DRIVABLE. *TR

NHTSA ID

10692745

Incident

Jan 15, 2014

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2007 DODGE RAM 2500. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE EXPERIENCED SEVERE SHAKING ON THE FRONT END AND WOULD LOSE STEERING CONTROL. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. ALSO, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE GEAR BOX NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

NHTSA ID

10691476

Incident

Oct 1, 2014

Mileage

110,000 mi

THE SHIFT MECHANISM ON THE STEERING COLUMN FOR THE TRANSMISSION WILL SHIFT INTO REVERSE WITHOUT WARNING WHEN PUTTING TRANSMISSION IN DRIVE PARK WHILE THE ENGINE IS RUNNING. TRANSMISSION SHIFT DETENT DOES NOT KEEP THE TRANSMISSION IN REVERSE BUT CAN UNEXPECTEDLY SHIFT INTO NEUTRAL FROM THE REVERSE POSITION. *TR

NHTSA ID

10649100

Incident

Oct 21, 2014

Mileage

108,239 mi

UPDATED FROM PREVIOUS VERSION. DRIVING THROUGH TOWN, CLEAR WEATHER, GOOD ROAD CONDITIONS, LUCKILY GOING ONLY 25 MPH, THERE WAS A GRINDING NOISE UP FRONT FOR TWO SECONDS THEN, ALL OF A SUDDEN, THE FRONT WHEELS LOCKED UP AND THE TIRES SKIDDED APPROXIMATELY 5 FEET. THE ENGINE REMAINED RUNNING, THE TRANSMISSION SHIFTED FINE BUT THE FRONT WHEELS WERE LOCKED AND THE TRUCK WOULD NOT MOVE! THE TRUCK HAD TO BE DRAGGED ONTO THE TOW TRUCK. THE DODGE DEALERSHIP HAS DEEMED THIS A WEAR AND TEAR INCIDENT, WHICH I COMPLETELY DISAGREE WITH. HAD I BEEN GOING AT HIGHWAY SPEED, I AM CONVINCED I WOULD HAVE LOST CONTROL AND/OR MUCH MORE DAMAGE WOULD HAVE BEEN DONE. THE RING AND PINION GEAR GOT SO HOT, THEY WELDED TOGETHER, WHICH CAUSED THE AXLE TO SEIZE AND THE WHEELS TO LOCK UP. REPLACING THE RING AND PINION WILL COST $1,150. I ALSO NEED A DIFFERENTIAL OVERHAUL AT A COST OF $1,500. THE GRAND REPAIR TOTAL WILL BE IN THE NEIGHBORHOOD OF $2,650! WHEN HAS THERE EVER BEEN A WEAR AND TEAR REPAIR THAT WOULD COST THAT MUCH? SINCE WHEN DO WEAR AND TEAR ITEMS GET SO HOT THAT THEY WELD THEMSELVES TO EACH OTHER? I JUST HAD THE DRIVELINE SERVICED 6,000 MILES PRIOR TO THIS! AND BEFORE THAT AT 60,000 MILES. I KEEP MY TRUCK MAINTAINED TO THE BOOK. IT CANNOT BE NORMAL WEAR AND TEAR! THIS TRUCK IS PAMPERED AND NOT USED COMMERCIALLY NOR NEVER UNDER EXTREME CONDITIONS ABOVE AND BEYOND TOWING A 7500 POUND CAMPER. I'M AFRAID TO CONTINUE DRIVING IT. I ESPECIALLY WORRY FOR MY WIFE AND TEENAGE SON IF SOMETHING THIS SEVERE AND ABRUPT SHOULD OCCUR WHILE THEY ARE DRIVING IT IN THE FUTURE! I FEEL LIKE IT WILL ONLY BE A MATTER OF TIME BEFORE THE REAR DIFFERENTIAL DOES THE SAME THING! SOMETHING FAULTY HAD TO OCCUR EITHER THROUGH DEFECTIVE MATERIALS OR INCORRECT MAINTENANCE PROCEDURES PERFORMED BY THE DEALERSHIP WHEN I HAD THE DRIVELINE SERVICED. BUT IT'S MY WORD AGAINST THEIRS, IMPOSSIBLE TO PROVE. *TR

NHTSA ID

10567976

Incident

Feb 26, 2014

Mileage

96,300 mi

DRIVING THROUGH TOWN, CLEAR WEATHER, GOOD ROAD CONDITIONS, LUCKILY GOING ONLY 25 MPH, THERE WAS A GRINDING NOISE UP FRONT FOR TWO SECONDS THEN, ALL OF A SUDDEN, THE FRONT WHEELS LOCKED UP AND THE TIRES SKIDDED APPROXIMATELY 5 FEET. THE ENGINE REMAINED RUNNING, THE TRANSMISSION SHIFTED FINE BUT THE FRONT WHEELS WERE LOCKED AND THE TRUCK WOULD NOT MOVE! THE TRUCK HAD TO BE DRAGGED ONTO THE TOW TRUCK. THE DODGE DEALERSHIP HAS DEEMED THIS A WEAR AND TEAR INCIDENT, WHICH I COMPLETELY DISAGREE WITH. HAD I BEEN GOING AT HIGHWAY SPEED, I AM CONVINCED I WOULD HAVE LOST CONTROL AND/OR MUCH MORE DAMAGE WOULD HAVE BEEN DONE. THEY WANT $1,800 FOR THIS REPAIR! I JUST HAD THE DRIVELINE SERVICED 6,000 MILES PRIOR TO THIS! AND BEFORE THAT AT 60,000 MILES. I KEEP MY TRUCK MAINTAINED TO THE BOOK. IT CANNOT BE NORMAL WEAR AND TEAR! THIS TRUCK IS PAMPERED AND NOT USED COMMERCIALLY NOR NEVER UNDER EXTREME CONDITIONS ABOVE AND BEYOND TOWING A 7500 POUND CAMPER. THEY ARE ESSENTIALLY REBUILDING THE FRONT DIFFERENTIAL! I'M ALMOST AFRAID TO CONTINUE DRIVING IT. I ESPECIALLY WORRY FOR MY WIFE AND TEENAGE SON IF SOMETHING THIS SEVERE AND ABRUPT SHOULD OCCUR WHILE THEY ARE DRIVING IT IN THE FUTURE! *TR

NHTSA ID

10567611

Incident

Feb 26, 2014

Mileage

96,300 mi

I WAS TRAVELING A VERY CURVY ROAD TO GET TO MY DESTINATION. TIME TO GET TO DESTINATION WAS ABOUT 30 MINUTES. ONCE I GOT THERE, I PARKED, AND GOT OUT OF MY 2007 DODGE RAM 2500 TRUCK. THE LEFT REAR WHEEL WAS SMOKING LIKE IT WAS ON FIRE. THE RIGHT REAR WHEEL WAS SMOKING AS WELL, BUT NOT AS BAD. THIS WAS THE FIRST TIME I'D SEEN THIS PROBLEM. I THOUGHT MAYBE I HAD BEEN ON THE BRAKES TOO MUCH GOING DOWN THE CURVY ROAD. I TOOK THE TRUCK TO THE DODGE DEALERSHIP SERVICE DEPARTMENT TO GET IT CHECKED OUT. I WAS TOLD MY BRAKES WERE FINE, THAT I HAD ABOUT 50% BRAKE PAD STILL LEFT ON THE REAR BRAKES. I TOLD THE SERVICE MANAGER ABOUT THE ENORMOUS AMOUNT OF SMOKE I HAD WHEN I PARKED THE TRUCK. THEY INVESTIGATED AND CAME BACK TO TELL ME THE REAR SEALS WERE GONE ON THE TRUCK ALLOWING THE FLUID TO GET ON THE BRAKE PADS. THEY SAID THE FLUID ON THE BRAKES PADS WAS GETTING HOT AND THIS WAS CAUSING THE SMOKE. THEY ALSO STATED THAT I SHOULD NOT DRIVE THE TRUCK WITH THE REAR SEALS GONE BECAUSE IT COULD POTENTIALLY CAUSE ME TO HAVE A FIRE. THE TRUCK ONLY HAS 70,000 MILES ON IT AND THE SERVICE REP TOLD ME IT WAS NOT NORMAL FOR THE REAR SEALS TO FAIL LIKE THESE HAVE. THE REAR SEALS ARE NOT COVERED UNDER ANY WARRANTY AND THERE IS NO RECALL, THAT I COULD FIND. THE DEALERSHIP WANTS $500.00 TO REPLACE THE SEALS AND THE BRAKE PADS SINCE THEY GOT WET. THIS IS UNSAFE CONDITION BECAUSE OF THE POTENTIAL FOR A FIRE CAUSED BY THE REAR SEAL FAILURE. THIS FAILURE SHOULD BE INVESTIGATED AND DODGE RECALL AND REPLACE FAULTY REAR SEALS FOR THE CONSUMERS. *TR

NHTSA ID

10346042

Incident

Jul 17, 2010

Mileage

70,000 mi

TL*THE CONTACT OWNS A 2007 DODGE RAM 2500. THE CONSUMER STATED THE PROBLEM STARTED A YEAR AGO WITH THE TURBO, AND THE CHECK ENGINE LIGHT COMING ON. ALSO THE ACCELERATOR WOULD OPEN UP TO FULL THROTTLE WITHOUT ANY CONTROL, UNLESS HE CUT THE ENGINE OFF. AT TIMES THE GAS PEDAL WOULD NOT MOVE AT ALL. THE REAR BRAKES LOCKED UP AND THE ABS FAILED. THE VEHICLE PULLED TO THE RIGHT, DUE TO THE ALIGNMENT BEING OUT OF SPECIFICATION. THE FAILURE MILEAGE WAS 12,000 AND CURRENT MILEAGE WAS 22,400. UPDATED 04-28-09 *BF THE TRANSMISSION WOULD NOT GO INTO OVERDRIVE. THERE WERE TIMES WHEN THE VEHICLE HAD TO HUNT FOR GEARS AND THE INDICATOR WOULD DISAPPEAR ON THE DASH. UPDATED 04/29/09.*JB

NHTSA ID

10266296

Incident

Apr 14, 2008

Mileage

12,000 mi

I HAVE A 2007 DODGE RAM 2500 DIESEL 5.7. THE ENGINE CAUGHT FIRE ON 10/31 FOR NO APPARENT REASON. WE HAD NOTICED A FUNNY NOISE IN THE ENGINE BUT HAD TAKEN IT TO THE DODGE DEALER AND THEY DID NOT FIND ANYTHING WRONG WITH IT. THE DAY OF THE FIRE THE CHECK ENGINE LIGHT CAME ON AND IT STARTED ACCELERATING ITSELF LIKE IF YOU HAD THE VEHICLE ON NEUTRAL BUT WERE HITTING THE GAS PETAL ALL THE WAY. THEN MY HUSBAND PULLED OVER AND WHILE HE WAS LOOKING AT THE ENGINE TO SEE WHAT WAS THE PROBLEM SPARKS STARTED COMING OUT AND THEN THE ENTIRE ENGINE CAUGHT FIRE AND THE MY TRUCK WAS DEEMED A TOTAL LOSS. I PURCHASE IT NEW IN JUNE 2007, THERE IS NO REASON FOR THIS. WE DID REGULAR MAINTENANCE ON IT. *TR

NHTSA ID

10247932

Incident

Oct 31, 2008

Mileage

45,000 mi

2007 DODGE RAM 2500 (2771 MILE,9 MON OLD) FRONT END LOCKED UP AT 60 MPH. DEALER CLAIMED EXTERNAL DAMAGE TO DIFFERENTIAL CASING..NOT COVERED BY WARRANTY.....INSURANCE AGREES TO PAY... NO WARNING PRIOR TO EVENT. 2 CHILDREN IN VEHICLE AT THE TIME. NO RECOLLECTION OF ANY COLLISION TO CAUSE "DAMAGE. *TR

NHTSA ID

10233094

Incident

Jun 26, 2008

Mileage

2,771 mi

TL*THE CONTACT OWNS A 2007 DODGE RAM 2500. WHILE DRIVING 50 MPH OVER A BUMP IN THE ROAD, THE VEHICLE BECAME DIFFICULT TO MANEUVER. THE CONTACT HAS AVOIDED SEVERAL NEAR CRASHES. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR A DIAGNOSIS. THE CURRENT MILEAGE WAS 12,500 AND FAILURE MILEAGE WAS 100. UPDATED 03/05/08. *LJ THE CONSUMER STATED THE GAS VENT DOES NOT VENTILATE PROPERLY, HEARS A WHINE FROM REAR, AND VEHICLE PULLS TO THE RIGHT. UPDATED 03/04/08 *TR

NHTSA ID

10211620

Incident

Feb 4, 2007

Mileage

100 mi