2004 Dodge Sprinter Problems

TL* THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT STATED THAT THE VEHICLE CONSISTENTLY MISFIRED. THE DODGE MANUFACTURER INCLUDED THE VEHICLE IN ITS T21 EMISSIONS RECALL FOR THE ENGINE CONTROL UNIT; HOWEVER, THE TOOLS, AN AVAILABLE TECHNICIAN, AND THE PART WAS NOT AVAILABLE TO SCHEDULE THE REPAIR APPOINTMENT. THE FOLLOWING DEALERS WERE CONTACTED: ED VOYLES CHRYSLER DODGE JEEP RAM (789 COBB PKWY SE, MARIETTA, GA 30060, (844) 715-5921), SHOTTENKIRK CHRYSLER DODGE JEEP RAM (200 LIBERTY BLVD, CANTON, GA 30114, (678) 535-3417), LANDMARK DODGE CHRYSLER JEEP RAM (6850 MT ZION BLVD, MORROW, GA 30260, (770) 968-4900), DON JACKSON CHRYSLER DODGE JEEP RAM (3950 JONESBORO RD, UNION CITY, GA 30291, (770) 969-7229), AND MALL OF GEORGIA CHRYSLER DODGE JEEP (4345 BUFORD DR, BUFORD, GA 30518, (888) 522-5112). THE VEHICLE WAS NOT DIAGNOSED AND WAS NOT BEING DRIVEN DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ASSIGNED A CASE MANAGER WHO WAS TO RESPOND WITHIN ONE BUSINESS DAY. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE MANUFACTURER. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TT CONSUMER STATED TODAY IS AUGUST 10,2018 AND WE ARE STILL ATTEMPTING TO RESOLVE OUR RECALL T-21 OF SPRINTER 2004. ALTHOUGH IT HAS TAKEN 3 MONTH TO EVEN ATTEMPT TO GET THIS RECALL RESOLVED. WE WENT TI HAVE THE SITUATION SOLVED ON AUG 7. NOW AFTER A SERVICE MANAGER ASKED HIS OWN PERSONAL COMPUTER TO DO THE UPDATE... WE NOW HAVE A "CHECK ENGINE" LIGHT ON- STILL NOT RESOLVED MANY POOR EXCUSES FROM CIA- CASE# 3646736668. UPDATED 10/9/18*JB

DRIVING AT FREEWAY SPEED THE VEHICLE LOSSES POWER AND THE SPEED DECREASES TO ABOUT 40 MPH. I CAN PULL OVER AND TURN OF THE MOTOR FOR ABOUT 10 SECONDS AND START UP AND THE VEHICLE WILL RESET AND RUN FINE UNTIL IT DOES IT AGAIN RANDOMLY. THIS IS VERY DANGEROUS ESPECIALLY WHEN YOU ARE IN THE LEFT HAND LANE AND YOU ARE TRYING TO GET TO A SAFE PLACE TO PULL OVER. THIS HAS HAPPENED SEVERAL TIMES AND I HAVE REPLACED THE TURBO RESONATOR 3 TIME ON THIS TRUCK. THIS IS A PLASTIC PART AND THE BODY CRACKS FROM THE VIBRATION AND PRESSURE. *TR

FOUR P225/75R15XL SCORPION STR TIRES PURCHASED & INSTALLED 8-5-10 AT EVANS TIRE &SERVICE CENTER 1530 GARNET AVE. SAN DIEGO CA 92109 ONTO 2004 DODGE SPRINTER 2500, MILEAGE 28274. ON 2-28-2015 MILEAGE APPROX.43125MI. : PASSERBY REPORTED LEFT REAR TIRE APPEARED VERY LOW ON AIR; DRIVER IMMEDIATELY PRESENTEDVAN TO SAME SHOP WHERE EMPLOYEE REFUSED TO FILL ADJUST AIR PRESSURE DUE TO HIS REPORTING EVIDENT SIDEWALL CRACKS & HIS FEAR OF TIRE EXPLODING. HE OFFERED TO SELL NEW TIRES. CALLING SAME SHOP TODAY FOR TIRE OPTIONS & PRICE QUOTES ANOTHER EMPLOYEE REFERRED/ CONNECTED CALL TO THEIR EVANS TIRE CENTER FOR TIRE OPTIONS & PRICES, WHERE YET ANOTHER EMPLOYEE OFFERED TO SELL NEW CAPITAL ( SP. CAPITOL?)TIRES, QUOTING PRICE DESCRIBED AS"....AT THEIR (EVANS' )COST..." PLEASE RESPOND AND RELAY A COPY OF THIS COMPLAINT TO ALL APPROPRIATE FEDERAL AND CALIFORNIA STATE CONSUMER AND AUTO REPAIR, TIRE SALE REGULATORY &LICENSING AGENCIES . THANK YOU. *TR

THERE IS CURRENTLY A COMPLAINT FOR THE 2500 DODGE SPRINTERS, FOR VALVE STEM FAILURE. WHAT ABOUT THE 3500? I'VE HAD THREE VALVE STEM FAILURES SO FAR AND NO RECOURSE. WHY IS THE 2500 DIFFERENT THAN THE 3,500? TWO HAPPENED ON THE HIGHWAY AND ONE JUST LET GO WHILE PARKED. LUCKILY TWO WERE ON THE REAR DUALS AND I HAD THE OTHER TIRE TO BEAR THE WEIGHT. *TR

THERE IS A SAFETY RECALL ID # 07V299000 - INTERIOR LIGHTING ON THE MAKE AND MODEL OF MY VEHICLE AND MY VEHICLE HAS THE SAME SYMPTOMS YET IS NOT PART OF THE RECALL. DODGE HAS ORDERED THE PARTS TO BE REPLACED AND IS CHARGING $277.67. PLEASE LET ME KNOW HOW TO CORRECT THIS ISSUE. *TR

DT: THE CONTACT STATED 2004 SPRINTER 2500 DRAINED THE BATTERY AND NEEDED TO BE RECHARGED ABOUT EVERY THREE WEEKS. THE DEALERSHIP STATED THERE WAS A TSB , BUT THEY REFUSED TO FIX IT. *AK

IN MAY OF 2005 I PURCHASED A NEW DODGE (MERCEDES BENZ) SPRINTER 2500 PASSENGER VAN. WITHIN THE FIRST 3 MONTHS AND 7,500 MILES OF DATE OF PURCHASE THE VEHICLE BEGAN TO SHOW SIGNS OF PREMATURE RUSTING AND LEAKAGE OVER THE ENTIRE VEHICLE. I PURSUED REMEDY THRU ALL AUTHORIZED SPRINTER DEALERSHIPS ADHERING TO CHRYSLER PROTOCOLS AND RECOMMENDATIONS. NO REMEDY WAS EVER FORTHCOMING, I REPEATEDLY AND CONTINUE TO CHALLENGE CHRYSLER, THEIR REFUSAL TO PROVIDE WARRANTY SERVICE FOR THE ENTIRE TIME I HAVE OWED THIS VEHICLE IS DOCUMENTED AND TOO EXTENSIVE TO PROVIDE HERE. I HAVE FILED BBB COMPLAINTS IN DENVER CO. I HAVE SPOKEN TO EXECUTIVE LEVEL CHRYSLER CUSTOMER SERVICE REPS. AND NONE HAVE OFFERED A VIABLE SOLUTION. THEY HAVE ESSENTIALLY WASHED THEIR HANDS OF A PROBLEM THAT I HAVE BEEN PURSUING FOR 4 YEARS. I HAVE BROUGHT THIS ISSUE TO THE ATTENTION OF SO MANY CHRYSLER CUSTOMER SERVICE PEOPLE THAT THEY NOW AVOID MY EMAILS AND INQUIRIES. I BELIEVE THIS TO BE A RECALL ISSUE AS I HAVE FOUND NUMEROUS REFERENCES ON THE NET TO SIMILAR ISSUES. THE AFFECTED VEHICLES ALL SHOW SIGN OF PREMATURE RUST ,LEAKAGE OF ROOF SEAMS AND RUST PENETRATION AROUND THE WINDSHIELD FRAME. I HAVE SOUGHT REPAIRS WELL WITHIN THE RUST THRU WARRANTY PERIOD AND HAVE MET WITH NOTHING BUT LIP SERVICE. CHRYSLER REFUSES TO ADDRESS A VERY SERIOUS ISSUE AND HAS DELAYED OFFERING A REMEDY UNTIL NOW THE WARRANTY PERIOD HAS EXPIRED. I CAN PROVIDE EXPLICIT WORK ORDERS AND CUSTOMER SERVICE REF NO, WITHIN CHRYSLERS SYSTEM. I AM NOW CONSIDERING PURSUING LEGAL OPTIONS BUT LITTLE RESOLUTION IS AVAILABLE. BODY SHOPS REFUSE TO PERFORM REPAIR WORK BECAUSE THEY UNIVERSALLY STATE THAT RUST IS A NONFIXABLE ISSUE. ON ONLY ONE OCCASION DID CHRYSLER AUTHORIZE A SUPERFICIAL ATTEMPT TO PAINT OVER PROBLEM, THEY THEN REFUSED TO HONOR THEIR RUST THRU PERFORATION WARRANTY WHEN THE PROBLEM RESURFACED WITH 35,000 MILES. I AM NOW LEFT WITH A VEHICLE THAT IS RUSTING EXTENSIVELY IN AREAS WHERE I ORIGINALLY DOCUMENTED THE PROBLEM. *TR

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

UPON COMPLETION OF THE T21 RECALL, THE CHECK ENGINE LIGHT (ERROR CODE U0423) CAME ON. THE INSTRUMENT CLUSTER LIGHT CONTINUED TO ILLUMINATE AFTER THE VEHICLE'S IGNITION WAS OFF, DRAINING THE BATTERY.

2004 DODGE SPRINTER FUEL HOSE DISCONNECTED WHICH CAUSED THE ENGINE TO STOP OPERATING WHILE IN MOTION.*MR THERE WAS ALSO A WIRING ISSUE WHICH CAUSED THE BATTERY TO DRAIN AND THE ENGINE FAULT LIGHT WAS ILLUMINATED DUE TO THE LOOSE CONNECTION IN THE FUEL TANK. *TT

THE SLIDING DOOR WHICH IS THE ONLY EGRESS FOR PASSENGERS IN THE BACK OF THE VAN WILL NOT OPEN. I HAVE HAD IT FIXED 4 TIMES AND IT CONTINUOUSLY FAILS. I HAVE TALKED TO OTHER SPRINTER OWNERS AND THEY HAVE THE SAME PROBLEM. SHOULD THERE BE AN INCIDENT THAT REQUIRED THE QUICK EVACUATION OF THE VAN BY PASSENGERS IN THE REAR OF THE VAN THEY COULD BE VERY SERIOUSLY HARMED. THIS IS A VERY SERIOUS DEFECT THAT CHRYSLER WILL NOT ACKNOWLEDGE. *TR

IN MAY OF 2005 I PURCHASED A NEW DODGE (MERCEDES BENZ) SPRINTER 2500 PASSENGER VAN. WITHIN THE FIRST 3 MONTHS AND 7,500 MILES OF DATE OF PURCHASE THE VEHICLE BEGAN TO SHOW SIGNS OF PREMATURE RUSTING AND LEAKAGE OVER THE ENTIRE VEHICLE. I PURSUED REMEDY THRU ALL AUTHORIZED SPRINTER DEALERSHIPS ADHERING TO CHRYSLER PROTOCOLS AND RECOMMENDATIONS. NO REMEDY WAS EVER FORTHCOMING, I REPEATEDLY AND CONTINUE TO CHALLENGE CHRYSLER, THEIR REFUSAL TO PROVIDE WARRANTY SERVICE FOR THE ENTIRE TIME I HAVE OWED THIS VEHICLE IS DOCUMENTED AND TOO EXTENSIVE TO PROVIDE HERE. I HAVE FILED BBB COMPLAINTS IN DENVER CO. I HAVE SPOKEN TO EXECUTIVE LEVEL CHRYSLER CUSTOMER SERVICE REPS. AND NONE HAVE OFFERED A VIABLE SOLUTION. THEY HAVE ESSENTIALLY WASHED THEIR HANDS OF A PROBLEM THAT I HAVE BEEN PURSUING FOR 4 YEARS. I HAVE BROUGHT THIS ISSUE TO THE ATTENTION OF SO MANY CHRYSLER CUSTOMER SERVICE PEOPLE THAT THEY NOW AVOID MY EMAILS AND INQUIRIES. I BELIEVE THIS TO BE A RECALL ISSUE AS I HAVE FOUND NUMEROUS REFERENCES ON THE NET TO SIMILAR ISSUES. THE AFFECTED VEHICLES ALL SHOW SIGN OF PREMATURE RUST ,LEAKAGE OF ROOF SEAMS AND RUST PENETRATION AROUND THE WINDSHIELD FRAME. I HAVE SOUGHT REPAIRS WELL WITHIN THE RUST THRU WARRANTY PERIOD AND HAVE MET WITH NOTHING BUT LIP SERVICE. CHRYSLER REFUSES TO ADDRESS A VERY SERIOUS ISSUE AND HAS DELAYED OFFERING A REMEDY UNTIL NOW THE WARRANTY PERIOD HAS EXPIRED. I CAN PROVIDE EXPLICIT WORK ORDERS AND CUSTOMER SERVICE REF NO, WITHIN CHRYSLERS SYSTEM. I AM NOW CONSIDERING PURSUING LEGAL OPTIONS BUT LITTLE RESOLUTION IS AVAILABLE. BODY SHOPS REFUSE TO PERFORM REPAIR WORK BECAUSE THEY UNIVERSALLY STATE THAT RUST IS A NONFIXABLE ISSUE. ON ONLY ONE OCCASION DID CHRYSLER AUTHORIZE A SUPERFICIAL ATTEMPT TO PAINT OVER PROBLEM, THEY THEN REFUSED TO HONOR THEIR RUST THRU PERFORATION WARRANTY WHEN THE PROBLEM RESURFACED WITH 35,000 MILES. I AM NOW LEFT WITH A VEHICLE THAT IS RUSTING EXTENSIVELY IN AREAS WHERE I ORIGINALLY DOCUMENTED THE PROBLEM. *TR

2004 DODGE SPRINTER - THE BRAKING SYSTEM STIFFENS UP (POWER BRAKE) IF I PUSH THE PEDAL HARD ESPECIALLY WHEN I BACK UP THE VEHICLE. IT'S LIKE THE BOOSTER HAS FROZEN SOLID AND THE BRAKE PEDAL CAN'T TRAVEL ALL THE WAY DOWN. IF I LET THE VEHICLE SIT FOR A WHILE (1 HR) IT WILL GET BACK TO NORMAL. THIS IS A REPEAT INCIDENT AND STARTED IN THE FIRST YEAR BUT I DID NOT PAY TOO MUCH ATTENTION SINCE I DID NOT UNDERSTAND WHAT HAPPENED AND THE PROBLEM DISAPPEARED FOR A WHILE. BUT LATELY IS REAPPEARING MORE FREQUENTLY. NO ACCIDENT YET. NOTHING HAS BEEN DONE TO CORRECT THE FAILURE. THE VEHICLE IS OUT OF WARRANTY BY NOW 66,000 MILES. I WONDER IF THERE ARE MORE PEOPLE EXPERIENCING THE SAME. *TR

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

WE OWN TWO DODGE SPRINTERS 2500. YEARS 2004 AND 2006. WE HAVE OWNED BOTH FOR A LITTLE MORE THAN A YEAR. WE HAVE BROKEN SIX WINSHIELDS. WE HAVE LOOKED FOR STRONGER WINDSHIELDS NONE ARE MADE.{ PER PPG} WE HAVE HAD INSTALLS DONE BY FACTORY AND PRIVATE. THE WINDOW FAMES HAVE BEEN INSPECTED FOR DEFECTS AND NONE WERE FOUND. WE FEEL THAT THIS UNACCEPTABLE AND NEEDS TO BE FIXED. I HAVE CONTACTED DODGE AND THEY SAID THAT THEY WILL DO AN INTERNAL REVIEWBUT WE WILL NOT BE NOTIFIED. CURRENTLY THIS IS A GREAT HAZARD AND COST.

DRIVER SIDE MIRROR WON'T ADJUST HIGH ENOUGH TO BE ABLE TO SEE CARS BEHIND VEHICLE. CHRYSLER'S ANSWER IS THAT IT IS OPERATING AS DESIGNED AND NOT COVERED UNDER WARRANTY. *AK

IN MAY OF 2005 I PURCHASED A NEW DODGE (MERCEDES BENZ) SPRINTER 2500 PASSENGER VAN. WITHIN THE FIRST 3 MONTHS AND 7,500 MILES OF DATE OF PURCHASE THE VEHICLE BEGAN TO SHOW SIGNS OF PREMATURE RUSTING AND LEAKAGE OVER THE ENTIRE VEHICLE. I PURSUED REMEDY THRU ALL AUTHORIZED SPRINTER DEALERSHIPS ADHERING TO CHRYSLER PROTOCOLS AND RECOMMENDATIONS. NO REMEDY WAS EVER FORTHCOMING, I REPEATEDLY AND CONTINUE TO CHALLENGE CHRYSLER, THEIR REFUSAL TO PROVIDE WARRANTY SERVICE FOR THE ENTIRE TIME I HAVE OWED THIS VEHICLE IS DOCUMENTED AND TOO EXTENSIVE TO PROVIDE HERE. I HAVE FILED BBB COMPLAINTS IN DENVER CO. I HAVE SPOKEN TO EXECUTIVE LEVEL CHRYSLER CUSTOMER SERVICE REPS. AND NONE HAVE OFFERED A VIABLE SOLUTION. THEY HAVE ESSENTIALLY WASHED THEIR HANDS OF A PROBLEM THAT I HAVE BEEN PURSUING FOR 4 YEARS. I HAVE BROUGHT THIS ISSUE TO THE ATTENTION OF SO MANY CHRYSLER CUSTOMER SERVICE PEOPLE THAT THEY NOW AVOID MY EMAILS AND INQUIRIES. I BELIEVE THIS TO BE A RECALL ISSUE AS I HAVE FOUND NUMEROUS REFERENCES ON THE NET TO SIMILAR ISSUES. THE AFFECTED VEHICLES ALL SHOW SIGN OF PREMATURE RUST ,LEAKAGE OF ROOF SEAMS AND RUST PENETRATION AROUND THE WINDSHIELD FRAME. I HAVE SOUGHT REPAIRS WELL WITHIN THE RUST THRU WARRANTY PERIOD AND HAVE MET WITH NOTHING BUT LIP SERVICE. CHRYSLER REFUSES TO ADDRESS A VERY SERIOUS ISSUE AND HAS DELAYED OFFERING A REMEDY UNTIL NOW THE WARRANTY PERIOD HAS EXPIRED. I CAN PROVIDE EXPLICIT WORK ORDERS AND CUSTOMER SERVICE REF NO, WITHIN CHRYSLERS SYSTEM. I AM NOW CONSIDERING PURSUING LEGAL OPTIONS BUT LITTLE RESOLUTION IS AVAILABLE. BODY SHOPS REFUSE TO PERFORM REPAIR WORK BECAUSE THEY UNIVERSALLY STATE THAT RUST IS A NONFIXABLE ISSUE. ON ONLY ONE OCCASION DID CHRYSLER AUTHORIZE A SUPERFICIAL ATTEMPT TO PAINT OVER PROBLEM, THEY THEN REFUSED TO HONOR THEIR RUST THRU PERFORATION WARRANTY WHEN THE PROBLEM RESURFACED WITH 35,000 MILES. I AM NOW LEFT WITH A VEHICLE THAT IS RUSTING EXTENSIVELY IN AREAS WHERE I ORIGINALLY DOCUMENTED THE PROBLEM. *TR

ORIGINAL EQUIPMENT STEEL WHEEL ON 2004 DODGE SPRINTER BROKE ALONG "SPOKES". THIS COULD BE A LIFE THREATENING CONDITION AT HIGHWAY SPEEDS OR IN A LOADED VAN. I NOTICED A NOISE COMING FROM THE WHEEL AND TOOK IT TO A SHOP WHERE THEY COULD FIND NOTHING WRONG BECAUSE THE CRACKS IN THE WHEEL ARE VERY DIFFICULT TO DETECT UNLESS INSPECTED VERY CLOSELY. THE WHEEL THAT FAILED WAS NEVER ABUSED OR MISTREATED IN ANY WAY PRIOR TO FAILURE. I STILL HAVE THE BROKEN WHEEL IF YOU WISH TO INSPECT IT. I AM NOW RUNNING ON THE SPARE. SHOULD I REPLACE ALL 4 WHEELS ON THIS VAN? WILL THE OTHERS ALSO FAIL? ARE ALL 2004 SPRINTER WHEELS THIS DANGEROUS? *TR

RACK AND PINION WAS REPLACED AFTER LEAKAGE OCCURED AT 27000 MILES. IT IS LEAKING AGAIN BUT NOT COVERED UNDER DRIVE TRAIN WARRENTY AND DODGE REFUSES TO REPLACE IT. HOWEVER IF THIS IS A REOCCURING PROBLEM YOU SHOULD INSIST THAT DODGE MODIFY THE DESIGN AND EFFECT A RECALL.

THERE IS A SAFETY RECALL ID # 07V299000 - INTERIOR LIGHTING ON THE MAKE AND MODEL OF MY VEHICLE AND MY VEHICLE HAS THE SAME SYMPTOMS YET IS NOT PART OF THE RECALL. DODGE HAS ORDERED THE PARTS TO BE REPLACED AND IS CHARGING $277.67. PLEASE LET ME KNOW HOW TO CORRECT THIS ISSUE. *TR