2006 Ducati Sport Classic Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Ducati Sport Classic, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system7491.4%
- Body & structure44.9%
- Electrical22.5%
- Other / unspecified11.2%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
I WAS SENDING IN A COMPLAINT DUE TO THE FACT THAT I HAVE READ THAT THERE WAS LAWSUIT REGARDING THE GAS TANKS EXPANDING ON DUCATI'S. I WANTED INFORMATION ON HOW TO GO ABOUT GETTING MINE REPLACED. *TR
THE GAS TANK HAS EXPANDED TO THE POINT THAT IT DOES NOT STAY IN THE HOLDING BRACKETS. THE TANK IS LOOSE AND IS A DANGEROUS DRIVING HAZARD. DUCATI IS REPLACING THE TANK WITH THE EXACT SAME MATERIAL WHICH DOES NOT SOLVE THE PROBLEM. A TANK MADE OUT OF THE SAME MATERIAL WILL RESULT IN THE SAME PROBLEM ALL OVER AGAIN. A PERMANENT SOLUTION SHOULD REQUIRE A CHANGE IN THE GAS TANK MATERIAL USED. *TR
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
2006 DUCATI SPORT CLASSIC; RE: DEFECTIVE GAS TANK, SWELLS AND DEFORMS UNTIL IT EFFECTS STEERING (ACTUALLY GETS IN WAY OF HANDLE BAR AND COMES OFF FRONT MOUNTS LEAVING ONLY ONE BOLT HOLDING DOWN THE REAR). SEEMS TO BE A MANUFACTURING PROBLEM AS MANY OWNERS OF THIS MODEL ARE COMPLAINING ABOUT THE SAME THING ON ONLINE FORUMS. DUCATI WILL REPLACE A TANK ONCE IT SWELLS OR DEFORMS TO A CERTAIN LEVEL BUT THE REPLACEMENT WILL SOON START TO DO THE SAME. *TR
FUEL TANK OF MOTORCYCLE DEFORMS IN SUCH A MANNER TO BECOME UNSECURED FROM THE VEHICLE FRAME AND BE UNSAFE TO OPERATE. MANUFACTURER HAS ADMITTED NO DEFECT IN THE CONSTRUCTION OF THE TANK AND ONLY OFFERS TO REPLACE THE TANK WITH ANOTHER DEFECTIVE TANK THAT WILL ONLY DEFORM IN THE FUTURE AS WELL. I AM CURRENTLY DUE FOR MY 3RD TANK IN 3 YEARS OF OWNERSHIP. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
GAS TANK WARPING AND REGULATOR FAILURE. UNDER 3000 MILES GAS TANK WAS WARPING AND COMING OFF TANK MOUNTS. AT 7,546 MILES REGULATOR FAILED. BOTH WERE REPLACED. *TR
SPEEDOMETER QUIT WORKING PROPERLY. SPEEDO AND TACHOMETER ARE SUPPOSED TO PERFORM A FULL SWEEP AFTER TURNING KEY TO START. HOWEVER, SPEEDOMETER MOVES ERRATICALLY AFTER KEY IS TURNED ON AND STOPS IN ARBITRARY POSITION, NEVER RETURNING TO 0 MPH. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
MOTORCYCLE: 2006 DUCATI SPORT CLASSIC 1000-GAS TANK GETS LOOSE AND NO LONGER FITS BRACKETS. THE GAS TANK IS NOT HOLDING ITS MOLDED SHAPE AND CONTINUES TO GET WORSE, WHILE SPREADING AWAY FROM ITS MOUNTING BUSHINGS AND BRACKETS UNDER THE FRONT OF GAS TANK. THIS CAN CAUSE PAINT BUBBLING, POSSIBLE LEAKAGE OF FUEL AND A FUEL TANK THAT ULTIMATELY FALL OFF DURING RIDING. HIGHLY DANGEROUS. THE ORIGINAL GAS TANK HAS ALREADY BEEN REPLACED UNDER WARRANTY WITH THE SAME PROBLEM 2 YEARS AGO. NOW IM SEEING THE SAME PROBLEM AGAIN AND FEAR OF REPLACING AGAIN, SINCE MY WARRANTY HAS EXPIRED AND A NEW GAS TANK COST ABOUT $1700. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .